2016 Kia Sorento Electrical System Problems

All tail lights of suv go in an out randomly.

The contact owns a 2016 Kia Sorento. The contact stated that while driving at 50 MPH and depressing the accelerator pedal, the vehicle speed decreased. The contact was able to pull into a parking lot safely. The contact attempted to restart the vehicle, but the vehicle failed to restart as intended. An independent mechanic and a dealer were contacted. The vehicle was towed to the dealer, where it was diagnosed that the engine starter needed to be replaced. The vehicle was then towed to an independent mechanic, where it was diagnosed that the engine needed to be replaced. The vehicle was not repaired. The manufacturer was not notified of the failure. The approximate failure mileage was 83,000.

Vehicle: 2016 Kia Sorento, VIN [XXX] Incident Date: November 13, 2025 Incident Location: Durham, NC (3828 Guess Rd) Cause of Loss: Engine Fire, confirmed by Durham Fire Department Report (Incident #253663) as "originated from under the hood." TECHNICAL NARRATIVE & SYMPTOMS (CRITICAL FOR LIABILITY): I am filing this complaint to report a catastrophic vehicle fire that I believe is directly linked to multiple acknowledged manufacturing defects that create a fire risk in Kia vehicles. ABS/Traction Control Light Warning (Direct Fire Risk Symptom): Immediately prior to the loss, the ABS and Traction Control warning lights were constantly illuminated. This is a known precursor symptom for the defective Hydraulic Electronic Control Unit (HECU) or ABS Module short-circuit, which has been cited in numerous Kia fire recalls (e.g., NHTSA 20V019, 20V519). The fire's origin under the hood is consistent with this component failure. Prior Engine Failures (Systemic Defect History): This vehicle has a history of catastrophic manufacturing defects: The engine assembly was replaced in 2023 due to the known Theta II Rod Bearing Failure. The knock sensor was replaced in September 2025 as part of the KSDS Product Improvement Campaign, demonstrating the vehicle was still under active service for critical engine monitoring defects just weeks before the fire. Potential Tow Hitch Wiring Fire Risk: The vehicle was fully engulfed, but the fire may also be linked to the defect cited in NHTSA Recall 22V703 (tow hitch wiring harness short circuit, which also poses a fire risk). I require a full investigation into this defect leading to compensation for the total loss of the vehicle and consequential damages. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The car was running as normal and then randomly it started kind of rough and seemed like maybe just cold. But I had my mechanic take a look, and he said that when he started it, which was the next day that it made a loud knocking sound upon start. On the 30th I had it towed out to West Hills Kia in Bremerton. And they reported back that the engine needed full repair. I only owned this car one year and before me it was reportedly well maintained. I maintained it well also! Kia is denying all recall, but it’s a 2016 Kia sorento. It’s within the one or two years that the recall doesn’t cover??? The brake lights also work and always one of them is not working. It is not exclusively one or the other but the bulbs keep burning out. I need to know what to do to get this engine fixed, and it should fall under the bad engines that Kia’s have!

My headlights flicker when the left turn signal is used. I have taken this vehicle to the dealership previously for headlight flickering issues. I have owned it since 2019. When the lights flicker at night driving at highway speeds, it is dangerous for me and other drivers around me. The Ray Skillman Kia dealer has confirmed these issues and offered fixes that have not lasted. the most recent flickering did not come with warnings or messages prior to malfunctioning.

Odometer Fraud. The contact purchased a 2016 Kia Sorento. The contact stated that while attempting to register the vehicle, it was discovered that there was a mileage discrepancy. The vehicle was a private sale. At the time of purchase, the vehicle mileage was 97,000, and at the time of registration, it was discovered that the mileage was 167,000.

Vehicle stuck in park. Able to use emergency procedure to drive. Repair of fault would have cost 1600.00 if not covered by my extended warranty. There is a similar recall for not requiring brake to be applied before the shifter can select a gear. This is caused by the BCM body control module. I believe that most of these units are failure prone and they control a number of functions that are related to safety.

This scenerio happened and fire resulted with total loss. Fuel system, gasoline: Delivery: Hoses, lines/piping, and fittings Recall date 2018-12-18 Recall no. 18V907000 Kia Motors America (Kia) is recalling certain 2011-2017 Optima, 2012-2017 Sorento and 2011-2018 Sportage vehicles that previously received an engine replacement under recall number 17V-224, warranty, or the Knock Sensor Detection System (KSDS) Product Improvement Campaign. The high pressure fuel pipe that connects to the fuel pump outlet may have been damaged, misaligned or improperly torqued during the engine replacement procedure, possibly causing a fuel leak. Hide details Recall consequence A fuel leak in the presence of an ignition source can increase the risk of a fire. Recall action Kia has notified owners, and dealers will inspect and replace the fuel pipe, as necessary, free of charge. The recall began January 17, 2019. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC172.

While I am driving it can be jerking anytime and also the slippery light come on the dashboard.Sometimes the engine light come on too.

Engine blew. Getting on interstate, vehicle blew when accelerating on interstate and died right before getting on. Could have been very dangerous if it had made it on the interstate itself. No warning lights or indication ther was a problem. It was maintained regularly. It had 125000 miles on it. A/c fan quit working due to electrical issues. Drivers side brake light blew several times. It was life changing and not for the good. There have also been a few other minor problems.

The instrument cluster blacks out in the middle of a drive or will not come on when initially started. Seems to work when it wants to. Yes, vehicle is available for inspection and we have a video of this defect. Yes, this is a safety issue because no other warning lights or warning system can work. Sometimes the speedometer shows 60mph while sitting still or 0mph while driving. This glitch makes it impossible to verify the speed, if lights and signals are working, airbags active, etc The dealership was advised but nothing done and was told no recalls so can't help without having to come out of pocket. At first it would flicker and get lines like a broken TV screen. We bought car in 2023 about 6 months in is when flickering started. It stopped for awhile. It is on more than off but presents a safety issue for my 18 yr old daughter who it was purchased for.

The rear camera on my 2016 Kia Sorento no longer works. Over the past year, the camera images have been getting blurry and smaller. Now, there is no indication or warning of cars or people behind my vehicle, which is a safety concern. I found online that there is a recall on the rear camera for this model, but the dealership claims they haven't been informed. I'm worried about the safety risks this presents.

UNKNOWN

The contact owns a 2016 Kia Sorento. The contact stated that either while driving or while parked, the body control module failed to respond as designed while depressing the brake pedal. The vehicle was taking to an independent mechanic where it was diagnosed that the body control module needed to be replaced. The vehicle was not repaired. The manufacturer was not made aware of the failure. The approximate failure mileage was 135,000.

my car is completely in good working order but i want to send it to tyro and they say i have a problem with it SC249F TOW HH INSPECT/REPLACE +FUSE: DIO (NHTSA #22V703)

While driving on the parkway, the vehicle would not accelerate and would stall. After pulling over, vehicle would restart but repeated the pattern. Made it to Advanced Auto who ran codes and had the camshaft modulator changed. Vehicle made it back onto parkway. 40 miles from home, the vehicle began to shake, loose power, made loud sound and died. Towed home. Mechanic said out of oil but I had oil changed less than 1000 miles ago when vehicle purchased. New codes showed crankshaft position sensor. Changed part. Replaced starter and a new battery. Still nothing. Stating probable engine failure. I've only owned this vehicle for 2 months!

I am having an issue with my Kia headlights when on dim. The lights are so dim I am afraid to drive the car at night because I am scared I will hit a person, animal or object. I am replacing light bulbs frequently. Cars are flashing their lights at me (when I need to drive at night) because of the dimness. I took my car to a Kia dealer and they could not diagnosis the problem. They advised to replace the entire headlight assembly with a cost of $2,600.00. I am on Social Security and can't afford to have the repair made. I have read a lot of complaints of other Kia lighting issues. I feel a recall should be made immediately due to the seriousness of the issue.

The contact owns a 2016 Kia Sorento. The contact stated while driving 60 MPH, the vehicle lost motive power. There were no warning lights illuminated. The vehicle failed to restart and was towed to the contact’s place of employment. The dealer was not contacted. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 98,000. The VIN was not available.

My 2016 Kia seronto was fine wasn’t throwing any codes not even the code that tells me my oil is low. But always kept it changed and maintained never had a problem with it only the code that says 02 sensor then I started having an exhaust leak near my engine it was getting so hot to the point it was catching my carpet inside my car on fire so I had to pull up the carpet that never bother me or made an issue for the car I was driving and it started knocking like a rod knock I check the oil and there’s oil in it with no metal shavings or a creamy color to it. Car still starts gets louder when the rpms go up so I’m just a bit confused to what happened when I kept my oil changed and my car never warned me of any problems and only thru a code for the o2 sensor I seen the recall for different Kia for the rod knock sensor detection so could that have happened to my Kia since it just messed up without any time of warning please let me know at [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

I keep having problems with the brake lights and all of the back lights, have fixed or replaced them 7 to 8 times in the last 2 years, and my passenger door will not lock, know another person that has a Kia that has the same problem