2018 Kia Sorento Engine Problems

I have less than 100,000 miles on my 2018 Kia sorento. When I reached probably 50,000 miles this car went DOWN HILL. I feel like I’ve replaced everything on this car. Now every oil change was saying no oil on the dip stick, so I take it to the Kia dealership. They tell me that I need an ENTIRE engine. My car is less than 100,000 miles. I saw something that said if it was under that threshold, it could be covered but they said they couldn’t find anything. This car has been failing me. I still owe HALF of the car, what it’s not even worth on carfax anymore. AND the engine cost is exactly 50% of what I owe on this car. I don’t know what to do, but never buy a Kia again. This is a hazard for everyone around me the gas it is putting into the air. I don’t know what else to do. I even paid them to do an oil change and the oil light lit up as SOON as I left the parking lot. There are no leaks whatsoever. I even had someone from the Kia engine settlement verify my VIN # and told me that it was eligible and she told me that everything would be taken care of at the dealership without charge. She then told me to wait for the dealership to call and let me know because I was on hold while they were talking. But right after I received a call asking how I was going to pay for it because they could not find anyway to cover it. I don’t know how to ask for a second opinion. Kia is never available to speak with or try to resolve the issue. This has just been a nightmare.

On January 30, 2026, I was driving with my daughter from Kansas City to Platte City when the vehicle experienced a sudden and catastrophic mechanical failure. As we approached our exit, the engine unexpectedly revved and the vehicle rapidly decelerated to approximately 30 mph. When I attempted to accelerate, the vehicle was unable to properly gain speed. Upon reaching the top of a hill at an intersection, the engine completely shut off and the vehicle became disabled in the roadway. The vehicle was towed and inspected by two independent repair facilities. Both repair facilities confirmed catastrophic internal engine failure. A bore scope inspection identified a broken valve in cylinder 4, along with severe internal engine damage. The first repair facility estimated the cost of engine replacement at $9,600. The second repair facility confirmed the same diagnosis and recommended full replacement of the long block assembly. Copies of the inspection reports and repair estimates are attached. Due to the extent of the internal damage and the high cost of repair, the vehicle is considered mechanically inoperable and beyond reasonable repair. The cost of repair is substantial and exceeds our ability to proceed with repairs. At the time of the mechanical failure, approximately two years remained on the finance agreement, with an outstanding loan balance of approximately $12,000. As a result of this catastrophic mechanical failure, the vehicle is unusable, and a financial deficiency remains on the loan. Although the engine carried a warranty, we were informed that the specific failure was caused by internal component failure and material shedding, which is not covered under the warranty terms. Supporting documentation, including diagnostic findings, repair estimates, and photographs of the failed engine components, are attached. Due to the sudden and catastrophic mechanical failure, the vehicle has sustained a total mechanical loss and is no longer operable.

Noticed excessive oil consumption that turned into burning oil when the exhaust turned back of car black. Engine started knocking due to gummed up spark plugs. Replaced the spark plugs but within weeks the new plugs where gummed up as well. Took to Kia for diagnosis and potential repair for theta 2 class action. Mechanic confirmed damaged spark plugs, piston issues and needs for new engine.

Excessive oil consumption

The engine suddenly failed while I was driving on the highway. The vehicle lost power without warning, which created a dangerous situation. I had to pull over and have the vehicle towed.

Engine is burning oil at a rate of almost one quart per week. The engine can be felt shaking when driving. The engine light came on and states there is a P0303 Cylinder 3 misfired detected.

Started the car and heard a knocking sound. No check engine or low oil light on the dash. Dealership said the bearing clearance test was too great, causing the connecting rod to knock inside the engine. Dealership said I need an engine replacement. Engine is 3.3L Lambda II engine which has been reported to have this issue.

My car for the last 2 years has had multiple malfunctions with misfiring and replacement of head gaskets, pistons and more. Not to mention consistence oil concerns. On two occasions my family and I had to have the vehicle towed home over 200 miles because the car was not driving well. I have a [XXX] ghter who was with us at the time. The only warning lamp that ever triggered was the check engine. In October is when I was informed about a recall that was on my vehicle from KIA the corporation and I was told to have it towed to Kia in [XX [XXX] ey would replace my engine if the rod barring failed; and it did. Kia refused to pay for the engine and reported that I was misinformed. In December of 2025 I went through the Attorney General for mitigation to try and fix the engine- However, Kia reported because the engine manufacturer recall was not updated prior to October 30th or 2020 it was considered failure on the consumers part for not updating their address. However, I have documentation that the vehicle was sign for by myself on December 2nd of 2020. I have the car fax reporting that the car was surrendered by the previous owner on October 28th, 2020. Therefore, I was not the own when this manufacturer warrantee recall was in place or when it expired. So, I do not feel since i did not own the car when this was to be completed, that I should be responsible. Not to mention I am paying on the loan that financed this vehicle for the last 7 months while it has sat at KIA in [XXX] [XXX] ION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6) INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

KIA Sorento 2018 The vehicle experienced engine failure due to piston ring damage at approximately 111,500 miles. A Kia dealer diagnosed the issue with codes P0301 and P0304 and confirmed the engine requires full replacement. This creates serious safety concerns, including engine misfires, loss of power, and risk of stalling while driving.

My Vehicle’s Problems Excessive Oil Consumption My engine kept losing oil far more rapidly than normal. I was regularly checking and had to top off the oil, even though mileage suggested it should not be that frequent. However, there was no “check engine” warning light or low-oil warning light even when the oil level was dangerously low. Despite the oil being burned or lost, none of the sensors ever alerted me. Eventually, before my next scheduled service, the extreme oil loss culminated in catastrophic failure: the engine seized, and the car is now completely undrivable. Engine Failure / Seizure The engine’s seizure was sudden and without any prior warning. There was no indication via “check engine” light, oil light, or other dashboard warnings. I have obtained an estimate for replacing the engine, and regrettably, the cost of a new engine exceeds the current value of the vehicle. This is deeply unfair, given that the root cause appears to be excessive oil consumption, not misuse or accident. Lack of Responsiveness / Remediation I feel that despite my efforts to maintain the car and monitor oil levels, I was left to fix a major and very expensive defect. I request that Kia take full responsibility: cover the engine replacement (or provide a buyback / repurchase option), reimburse me for costs, or find another equitable remedy.

The contact owns a 2018 Kia Sorento. The contact stated that upon starting the vehicle, the vehicle made an abnormal knocking sound. Additionally, the contact stated that while driving and depressing the accelerator pedal all the way to the floorboard, the vehicle failed to exceed 18 MPH. The check engine warning light was illuminated. The vehicle was taken to an independent mechanic, where it was diagnosed, and the failure was linked to the knock sensor detection system(KSDS). The vehicle was not repaired. The local dealer was unreachable. The manufacturer was not notified of the failure. The failure mileage was 85,798.

I was driving and the vehicle shut off. All electric still on lights, radio, dash, etc. No issues or noises indicating that the engine was having faliure. Did not overheat, had oil and gas. Just bought car used 6 months ago with 140k miles. Had it towed to Mechanic and was told the engine was locked. Engine repair is my only option that is going to cost 5-8k. Vehicle has been maintained regularly with only one previous owner and no major repairs ever needed to be done.

The contact owns a 2018 Kia Sorento. The contact stated that while driving at various speeds, the engine was making an abnormal knocking sound. The contact stated that while slowing for a traffic sign or stop lights, the vehicle was shaking and vibrating abnormally. The contact stated that while depressing the accelerator pedal, the vehicle started making the knocking sound again. The check engine warning light illuminated and was now constantly illuminated. The contact stated that prior to the sounds and check engine warning light being illuminated, the contact was constantly adding engine oil, even after an oil change. The contact had taken the vehicle to a dealer, who diagnosed the vehicle and informed the contact that the engine was failing and needed to be replaced. The vehicle was not repaired. The contact stated that the engine was replaced in 2019 by the same dealer. The dealer requested that the engine be replaced; however, the manufacturer later informed the contact that the request was denied. The manufacturer was contacted, and the contact requested an escalation to review the engine replacement and was informed that the escalation had been denied. The failure mileage was approximately 178,000.

Excessive oil consumption, 4 quarts in 2000 miles

Engine oil is always law. Engine eats lots of oil.

The contact owns a 2018 Kia Sorento. The contact stated while driving at an undisclosed speed, the vehicle lost motive power. The check engine warning light was illuminated. The vehicle failed to restart and was towed to an unknown dealer. The vehicle was not diagnosed or repaired. The manufacturer was made aware of the failure and a case was filed. The failure mileage was approximately 89,000.

The contact owns a 2018 Kia Sorento. The contact stated while driving at an undisclosed speed, the contact heard an abnormal knocking sound coming from the engine before the vehicle lost motive power, with the check engine and oil warning lights illuminated. The vehicle was towed to the dealer but was not diagnosed or repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 115,000.

Was driving car it lost power, pulled over and had tow truck bring car to dealership. Dealership states a new engine is needed due to a malfunction in the engine block, however warranty is out on car just by 9,000 miles and car is still financed! Maintenance has been kept up on car. Kia wants $10,000 to replace engine.

Started with check engine light coming on then having problems with engine knocking last winter. During oil change and oil filter change there were gold "sparkles" throughout the old oil and the filter was completely covered. It appears some component of the engine is being "chewed" up and destroying our engine. It is now undrivable. I was told by our local mechanic shop to contact KIA or NHTSA regarding a special extended warranty from KIA specifically for engine issues. I am not finding anything specific online, so wanted to reach out. I am waiting to hear back from local KIA dealership service department as well.

My 2018 Kia Sorento has developed excessive oil consumption consistent with the known engine defects affecting Kia’s Theta II engines. The vehicle began consuming oil rapidly without warning, despite regular maintenance. This issue did not appear until after 100,000 miles, which is common for this defect. The sudden loss of oil creates a serious safety hazard, including engine stalling or failure while driving. Kia dealerships have acknowledged the symptoms but stated that because my vehicle is outside the warranty, I must pay for the oil consumption test and would be responsible for the full cost of an engine replacement. Kia has issued multiple Technical Service Bulletins related to excessive oil consumption in these engines, and many owners have experienced the same problem. This is a manufacturer‑related defect that develops over time and poses a safety risk to drivers and passengers.