2006 Lincoln Zephyr Tires & Wheels Problems

THE PLATING ON ALL FOUR OF MY WHEELS ARE PEELING MAKING THE TIRES NOT SEAL PROPERLY CAUSING AIR TO LEAK FROM THE TIRES. I HAVE HAD FOUR BLOWOUTS AND SEVERAL FLAT TIRES. I HAVE TO AIR UP THE TIRES EVERY 2 OR 3 DAYS. I HAVE TAKEN THEM TO SEVERAL PLACES TO GET THEM FIXED AND WAS TOLD THAT THEY CAN NOT DO ANYTHING ABOUT THEM OTHER THAN TRY AND PUT A SEALANT ON THE TIRE TO KEEP IT FROM HAPPENING. THIS HAS NOT FIXED THE PROBLEM AND I STILL HAVE TO CONTINUE TO AIR THE TIRE EVERY COUPLE OF DAYS.

TIRES LOSE AIR ALL THE TIME. I EVEN BOUGHT BRAND NEW TIRES AND IT STILL HAPPENS. CURRENT MECHANIC ADVISE ITS THE WHEELS. THEY ARE ORIGINAL TO THE CAR AND I AM BEING TOLD ITS DUE TO THE WHEELS. NOW I AM SPENDING MONEY TO "CLEAN" THEM. NOT SURE IF IT WILL HELP BUT THIS SEEMS TO BE A WIDE SPREAD PROBLEM.

THE WHEELS ON MY CAR ARE CORRODED AND AS A RESULT THE TIRES WILL NOT HOLD AIR PRESSURE I HAVE HAD TWO SETS OF TIRES WITH THE SAME PROBLEM CAR HAS 85000 MILES TIRES WERE REPAIRED BUT PROBLEM REMAINED THE METAL SHOWS FLAKING CAR HAS NEVER BEEN HIT AND SHOWS NO OTHER SIGNS OF A PROBLEM TIRES LOSE 20 POUNDS OF AIR PRESSURE EVERY THREE DAYS.

2006 LINCOLN ZEPHYR. CONSUMER WRITES IN REGARDS TO A DEFECTIVE TIRE AND REIMBURSEMENT FOR REPAIRS. *LD *JS

I HAVE A 2006 LINCOLN ZEPHYR AND I HAVE NOTICED THE CHROME ON MY RIMS IS PEELING OFF AND THE RIMS ARE BECOMING VERY CORRODED. THE TIRE KEEP DEFLATING DUE TO THIS PROBLEM EVEN AFTER YOU AIR THE TIRES UP THEY SLOWLY LEAK AIR. I HAVE SEEN MANY COMPLAINTS ABOUT THIS HAPPENING TO THESE RIMS AND IT COULD CAUSE A BLOW OUT DUE TO UNDER INFLATION AS THE TIRE SPECIFICALLY SAYS ON THE SIDE OF THE TIRE. THIS NEEDS TO BE ADDRESSED. *TR

WHILE DRIVING I FELT THE CAR PULLING TO THE LEFT, AFTER EXAMINATION I NOTICED THAT THE PASSENGER LEFT SIDE TIRE WAS FLAT. I MANAGED TO GET TO A GAS STATION, BUT WAS UNABLE TO INFLATE THE TIRE. THESE TIRES WERE PURCHASED IN NEW IN MAY 2014. I HAVE DRIVEN FEW MILES BETWEEN MAY AND NOVEMBER, THE MILEAGE CAN BE VERIFIED WITH DEALERSHIP. THIS IS THE FOURTH TIME THAT I HAVE PURCHASED TIRES FOR THIS VEHICLE. THE FIRST TIME WAS VERY SOON AFTER PURCHASE WHILE TRAVELING OUT OF STATE. I PURCHASED A NEW TIRE THEN THAT WAS VERY HARD TO FIND BECAUSE OF THE YEAR AND MAKE OF CAR. THE TIRES CONTINUED TO LOSE PRESSURE NEVER REALLY REMAINING INFLATED. I PURCHASED A AIR PUMP THAT I USED TO INFLATE THE TIRES, BECAUSE THE TIRES WOULD LITERALLY DEFLATE TO THE RIM. I AGAIN PURCHASED A FULL SET, BUT THE PROBLEM REMAINED. 2014 AGAIN PURCHASED A FULL SET, THEN 2014 PURCHASED ANOTHER TIRE. AS YOU CAN SEE THIS VEHICLE WITH ONE OWNER HAS VERY FEW MILES, BUT SEVERAL TIRE PURCHASES. LINCOLN/FORD NEEDS TO CLOSELY MONITOR THIS COMPLAINT. IT IS GETTING TO COSTLY TO CONTINUE BUYING TIRES FOR SOME REASON OTHER THAN THE DEFECTIVE RIM WHEEL. MY FAMILY SAFETY IS AT STAKE. *TR

TIRES CONTINUALLY LOOSING AIR PRESSURE. MECHANICS SHOWED FLAKING AND CRACKING CHROME PLATING ON WHEELS THAT CREATE AIR LEAKAGE PATH AT BEAD/RIM CONTACT AREA. DAMAGE TO TIRES DUE TO REPEATED LOSS OF AIR PRESSURE. MECHANICS AT BELLE TIRE SAY THIS IS A VERY COMMON PROBLEM WITH THE 2006 LINCOLN ZEPHYR WHEELS. WHY NO RECALL? REPLACEMENT WHEELS ARE APPROX $1,600! *TR

I HAVE HAD MY 2006 LINCOLN ZEPHYR FOR 1 1/2 YEARS. I NOTICED WITHIN ALMOST A MONTH THAT MY FRONT DRIVER TIRE WAS HAVING A SLOW LEAK. SHORTLY AFTER ALL MY TIRES WERE SLOWLY LEAKING AND I WOULD FILL THE TIRES TO 33PSI'S AS RECOMMENDED, BUT BY TWO DAYS THE PSI'S WOULD BE DOWN TO 8PSI. MY FIRST INCIDENT THAT OCCURRED WAS DRIVING ON THE INTERSTATE AND MY BACK PASSENGER TIRE BLEW OUT. I HAVE BOUGHT ALL NEW TIRES AND WITHIN ALMOST 3 MONTHS THE SLOW LEAK OCCURRED AGAIN IN ALL THE TIRES. I HAVE HAD MY TIRES RESEALED NUMEROUS TIMES ( THE RESEAL HOLDS FOR ALMOST 3 MONTHS) AND THE LEAK IS COMING FROM THE BACK OF THE RIM WHERE THE RIM AND TIRE MEETS. I HAVE BEEN TOLD BY MECHANICS THAT THE LEAKS ARE DAMAGING THE WALLS OF MY TIRE AND THE MECHANIC HAS PUT NEW VALVES ON AND THE TIRES STILL LEAKS. I HAVE INVESTED IN A AIR PUMP THAT PLUGS UP TO THE CIGARETTE LIGHTER BECAUSE I NEVER KNOW WHEN THE TIRES MIGHT BE FLAT. I HAVE CONTACTED LINCOLN/FORD AND THERE IS NO RECALL ON THIS VEHICLE. I HAVE DONE RESEARCH ON THE INTERNET AND FOUND SEVERAL ARTICLES/PAGES WITH SIMILAR PEOPLE TO MY SITUATION. I DO NOT FEEL SAFE, BECAUSE I NEVER WHEN A TIRE BLOW OUT MAY OCCUR AND WITH THE LEAK DAMAGING MY TIRES, IT LOOKS LIKE I MIGHT BE BUYING NEW TIRES QUIT OFTEN. WILL YOU PLEASE HELP MY AND OTHER 2006 LINCOLN ZEPHYR OWNERS. THANKS *TR

2006 LINCOLN ZEPHYR. CONSUMER WRITES IN REGARDS TO DEFECTIVE WHEEL RIMS. *SMD THE CONSUMER STATED FOR THE LAST YEAR-AND-A-HALF, HE HAS BEEN LOSING AIR IN AT LEAST ONE OF HIS TIRES. APPROXIMATELY SIX MONTHS AGO, HE NOTICED HE HAD BEEN LOSING AIR IN THREE TIRES. AN INDEPENDENT DEALER INFORM HIM THAT THE LOSS OF AIR WAS DUE TO CORROSION AND CHROME FLAKING OFF THE WHEEL RIM. HE RECOMMENDED THAT THE CONSUMER REPLACE ALL FOUR OF THE WHEELS RIMS. BECAUSE OF THE HIGH COST OF THE WHEEL RIMS, THE CONSUMER DECIDED TO MONITOR THE AIR LOSS AND ADD AIR AS NEEDED. OVER THE LAST FEW MONTHS, IN THREE TIRES, HE BEGAN LOSING BETWEEN 10-20 POUNDS OF AIR OVER A FOUR OR FIVE DAY PERIOD. THE OTHER TIRE MAINTAINED AIR PRESSURE. THE MANUFACTURER AGREED TO REPLACE TWO OF THE RIMS. *JB

THE 2006 LINCOLN ZEPHYR WAS TRAVELING AT A SPEED OF 40 AND THE REAR PASSENGER TIRE SUDDENLY BLEW UP. THE MECHANIC INSPECTED THE CAUSE AND CONCLUDED THAT THE ORIGINAL ALUMINUM LINCOLN-FACTORY WHEEL WAS DEFECTIVE. THE MECHANIC ALSO INSPECTED THE OTHER THREE WHEELS AND THE SAME PROBLEM IS CONTINUING TO OCCUR WITH ALL THE 2006 LINCOLN ZEPHYR WHEELS. THE MANUFACTURING DEFECT WAS DESCRIBED BY THE MECHANIC AS FOLLOWS: THE CHROME IS PEELING OFF THE WHEEL, WHICH PREVENTS A GOOD SEAL BETWEEN THE WHEEL AND THE TIRE, RESULTING IN THE LOSS OF AIR PRESSURE. THE SUDDEN LOSS OF AIR PRESSURE MAY CAUSE SERIOUS INJURY OR DEATH. *TR

WAS TRAVELING SOUTHBOUND ON I-39 WHEN TIRE BLEW OUT. HAVE HAD TO REPLACE TIRES SEVERAL TIMES AND TOLD BY DEALERSHIP AND 2 AUTO SERVICE CENTERS THAT THE RIMS ARE SO CORRODED THEY DO NOT HOLD AIR PROPERLY AND NEED TO BE REPLACED. ALL WHEELS HAVE CHROME FLAKING OFF. CAR CURRENTLY HAS LESS THAN 75K MILES. IN THE 2.5 YEARS I HAVE OWNED IT, PROBABLY HAVE HAD TO HAVE THE TIRES REPAIRED/REPLACED 10-15 TIMES. *TR

THE WHEELS HAVE STOPPED HOLDING AIR FOR ANY AMOUNT OF TIME. REGARDLESS OF TEMPERATURE, SPEED, MILEAGE. MECHANICS HAVE REPORTED THAT BECAUSE OF THE FLAKING CHROME WHEELS, THEY WILL NOT HOLD AIR CORRECTLY FOR ANY AMOUNT OF TIME. HAVE PAID OVER $20 ON SEVERAL OCCASIONS TO HAVE BEAD SEAL, WHICH MAY OR MAY NOT HELP UNTIL THE TIRES HAVE TO BE REPLACED BECAUSE OF UNUSUAL WEAR BECAUSE OF UNDER INFLATION. TIRES HAVE BEEN REPLACED AT AN UNUSUALLY HIGH RATE UNTIL IT IS NOT WORTH BUYING NEW TIRES AS THEY ARE TRASHED IN SHORT ORDER. NOW MY MOTHER DRIVES AROUND ON USED TIRES AND SHE HAS TO STOP IN INSTANT OIL CHANGE TO HAVE HER TIRE PRESSURE CHECKED ALMOST EVERY MORNING. THERE ARE SEVERAL COMPLAINTS ABOUT THIS PROBLEM AND THESE WHEELS SPECIFICALLY. WHY IS THERE NO RECALL REGARDING THIS? THIS IS AN OUTRAGE THAT SO MANY PEOPLE HAVE HAD THIS PROBLEM. THIS IS A MORE THAN $1500 FIX TO HAVE PEACE OF MIND. PLEASE DO SOMETHING SO THAT I CAN QUIT WORRYING ABOUT MY MOTHERS CAR, TIRES, HER LIFE! *TR

HAD A FLAT TIRE GOING DOWN THE HIGHWAY. DIDN'T THINK MUCH ABOUT IT...IT HAPPENS. GOT A COUPLE OF NEW TIRES PUT ON AND A FEW MONTHS LATER IT HAPPENS AGAIN. RUINING THE $250 TIRE AGAIN. MY MECHANIC SAYS THE CHROME IS PEELING OFF MY RIMS AND THAT IS WHAT IS CAUSING ME TO LOSE AIR PRESSURE IN THE TIRE,AND THAT I SHOULD REPLACE THE RIMS. THEY ARE ABOUT $550 A PIECE SO THATS NOT GOING TO HAPPEN. THESE CARS THAT HAVE LOW PROFILE TIRES NEED TO HAVE TIRE PRESSURE MONITORING SYSTEMS BECAUSE YOU CAN'T LOOK AT THE TIRE AND TELL ITS LOW. IF FORD DOESN'T FEEL THIS IS A SAFETY ISSUE THEY ARE WRONG.I WORK AT A FORD DEALERSHIP AND I SEE STUPID RECALLS FOR THINGS THAT MIGHT HAPPEN ONE TIME IN A THOUSAND. BUT I BET THIS IS HAPPENING TO ALL THE ZEPHYR,FUSIONS,MILANS, OR ANYTHING THEY ARE PUTTING THESE JUNK RIMS ON. *TR

DRIVING AT APPROX 30MPH MY TIRE BLEW OUT AFTER JUST REPLACING ALL 4 TIRES 3K MILES BEFORE. TOOK THE TIRE BACK TO THE MERCHANT AND THEY REPLACED IT BECAUSE I HAD A HAZARD PROTECTION PLAN WITH TIRES. REPLACED ALL 4 TIRES IN SEPT OF 2014 DUE TO NORMAL WEAR AND I HAVE HAD TO REPLACE 3 TIRES DUE TO TIRE COMING OFF OF THE RIM WHILE DRIVING AND LOSING AIR PRESSURE, SLOW LEAK THAT RESULTED IN FLAT AND A BLOWOUT WHILE DRIVING AT 40MPH AND LANDED ME INTO A DITCH. THE TIRE MERCHANT INFORMED ME THAT THE WHEELS ARE DEFECTIVE DUE TO THE CHROME ON RIM PEELING AND DAMAGING TIRE AS WELL AS PREVENTING A SEAL BETWEEN TIRE AND RIM TO KEEP TIRE INFLATED. REPLACING THE WHEELS WITH MANUFACTURER WHEELS WILL RESULT IN SAME PROBLEM BEING THAT IT IS A DEFECT IN THE PRODUCT. I FEEL FORD NEEDS TO TAKE RESPONSIBILITY FOR THIS DEFECT AND REIMBURSE CUSTOMERS FOR NEW WHEELS. *TR

I HAVE A 2006 LINCOLN ZEPHYR THE CHROME IS PEELING OF THE WHEELS CAUSING THE TIRES TO LOOSE AIR PRESSURE THE CAR WAS PURCHASED NEW AND CURRENTLY HAS 9,000 MILES WE PURCHASED AN EXTENDED WARRANTY BUT WAS TOLD THIS IS NOT A SAFETY ISSUE I BEG TO DIFFER. *TR

AFTER HAVING MULTIPLE FLAT TIRES - WHICH I INCORRECTLY ATTRIBUTED TO BAD LUCK - I DISCOVERED THE PROBLEM WAS NOT MY TIRES AT ALL, BUT WAS INSTEAD, THE CHROME PEELING ON THE INNER RIM OF THE WHEELS, WHICH NOT ONLY CREATED AN AIR LEAK FROM THE SEAL NOT HOLDING, BUT ALSO DAMAGED THE VERY-EXPENSIVE-TO-REPLACE TIRES. I LEARNED THIS WHEN I TRIED TO PUT 4 NEW TIRES ON THE CAR, THINKING MAYBE ALL THE FLATS WERE DUE TO THE BRAND OF TIRES, AND COSTCO SHOWED ME THE PEELING CHROME PROBLEM AND TOLD ME NOT TO WASTE MY MONEY ON NEW TIRES UNTIL THE WHEELS WERE REPLACED. WAS INFORMED THIS MANUFACTURING DEFECT WITH THE CHROME PLATING IS NOT A PROBLEM FORD WILL FIX AT THEIR EXPENSE AND THE COST FOR PUTTING NEW NON-CHROME WHEELS ON THE CAR WOULD ALL BE MINE. APPARENTLY SUDDEN FLATS DUE TO DEFECTIVE CHROME IS NOT REGARDED AS A SAFETY ISSUE BY FORD. *TR

2006 LINCOLN ZEPHYR. 22K MILES. ALL 4 RIMS CORRODE CAUSING TIRES TO LOOSE AIR. TIRE SHOP BROKE DOWN TIRES AND CLEANED RIMS. APPLIED SEALANT AROUND LIP AND REMOUNTED TIRES. TIRE SHOP OWNER INDICATED HE HAS CLEANED AND RESEALED A NUMBER OF 2006 LINCOLN ZEPHYR ALUMINUM WHEELS. AT 35K MILES ALL 4 TIRES WERE REPLACED AT LINCOLN DEALER. TWO WEEKS AFTER NEW TIRES INSTALLED FRONT DRIVER SIDE TIRE CAME OFF RIM DUE TO LOW AIR PRESSURE. I COMPLAINED TO DEALER THAT THE TIRES ARE LEAKING AIR. DEALER ACKNOWLEDGED PROBLEM WITH RIMS AND REPLACED TIRE FREE OF CHARGE. DEALER ALSO INDICATED ALL FOUR RIMS WERE CLEANED AND RESEALED. *TR

TL*THE CONTACT OWNS A 2006 LINCOLN ZEPHYR EQUIPPED WITH MICHELIN ENERGY TIRES, SIZE P225/50/R17. WHILE THE VEHICLE WAS BEING SERVICED, THE CONTACT WAS INFORMED THAT ALL FOUR TIRES (ORIGINAL) NEEDED TO BE REPLACED DUE TO DRY ROTTING. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER WHO CONFIRMED. THE TIRES HAD NOT BEEN REPLACED. THE FAILURE MILEAGE WAS APPROXIMATELY 20,000 AND THE CURRENT MILEAGE WAS 20,320. UPDATED 03/16/11 *BF UPDATED 11/16/11

TL* THE CONTACT OWNS A 2006 LINCOLN ZEPHYR. THE CONTACT STATED ALL FOUR CHROME RIMS FLAKED AND THE TIRE PRESSURE DECREASED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC FOR DIAGNOSIS WHERE IT WAS STATED THAT THE TIRES WERE LOSING PRESSURE. THE VEHICLE WAS REPAIRED AND THE MANUFACTURER WAS NOTIFIED. THE APPROXIMATE FAILURE MILEAGE WAS 40,000. *TR

TL* THE CONTACT OWNS A 2006 LINCOLN ZEPHYR. THE CONTACT STATED THAT THE TIRES WERE CONSTANTLY BECOMING FLAT. THE VEHICLE WAS TAKEN TO THE DEALER FOR INSPECTION WHERE THEY STATED THAT THE RIMS WERE CORRODED. THE VEHICLE WAS REPAIRED BUT THE FAILURE RECURRED. THE MANUFACTURER WAS NOTIFIED AND STATED THAT THE CONTACT NEEDED TO GO TO THE DEALER FOR FURTHER REPAIRS. THE FAILURE MILEAGE WAS 58,000.