2002 Mazda Protege Engine Problems

TL* THE CONTACT OWNS A 2002 MAZDA PROTEGE. THE CONTACT ATTEMPTED TO START THE VEHICLE BUT THE ENGINE FAILED TO START ACCOMPANIED BY AN ABNORMAL KNOCKING FROM THE ENGINE. THE CONTACT ALSO MENTIONED THAT THE FAILURE OCCURRED MORE OFTEN WHEN THE ENGINE WAS COLD. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED. THE FAILURE MILEAGE WAS 880. UPDATED 05/28/14*LJ THE CONSUMER STATED MODEL YEAR 2003 VEHICLES HAVE BEEN REPAIRED FOR THE SAME FAILURE BY THE MANUFACTURER. BUT THE MANUFACTURER REFUSES TO REPAIR MODEL YEARS 2001-2002. THE CONSUMER STATED THIS CONDITION DOES NOT KEEP THE ENGINE FROM STARTING. IT CAN AND HAS CAUSED CATASTROPHIC ENGINE FAILURE, WHICH SHUTS DOWN THE POWER STEERING AND BRAKES WHILE THE VEHICLE IS MOVING. UPDATED 05/29/2014 *JS

THE CAR BEGAN TO SHUTTER AND DROPPED FROM 50 TO 25 IN SECONDS. THE CHECK ENGINE LIGHT (CIL) STARTING FLASHING AND THE CAR BEGAN TO STUTTER LIKE IT WAS GOING TO DIE, I PULLED TO THE SIDE OF THE ROAD AND THE CAR DIED. STARTED CAR AGAIN THE CIL CONTINUED TO FLASH, IT ONLY WOULD ACCELERATE TO 25 MILES AN HOURS EVEN WITH MY FOOT ALL THE WAY DOWN ON THE GAS. I TOOK IT TO THE A MECHANIC AND THE CODES WERE P0421, 171, 300. THE MECHANIC DID EVERYTHING FROM ENGINE FLUSH, SPARK PLUGS, OIL, AIR FILTERS AND INSTALLED A NEW CATALYTIC CONVERTER BUT THE PROBLEM PERSISTS. ITS NOW A YEAR LATER AND THE CAR IS DOING THE EXACT SAME THING. *TR

I HAVE A 2002 MAZDA PROTEGE. WERE THE UPPER PASSENGER SIDE MOTOR MOUNT ATTACHES TO THE CAR BODY, THE CAR BODY METAL IS SEVERELY RUSTED AND STARTING TO SEPARATE ON THE INSIDE OF THE ENGINE COMPARTMENT. I DID TAKE THE CAR TO A MAZDA BODY SHOP AND THEY QUOTED ME IN THE AREA OF $1,000.00 TO FIX THE ISSUE. I DO NOT FEEL IT IS MY RESPONSIBILITY TO PAY FOR THE FIX AS THIS IS AN AREA HIGH IN THE ENGINE COMPARTMENT NOT SUBJECT TO THE ELEMENTS. BASICALLY MAZDA HAS SOME PROBLEM WITH THE METAL, THE ANTI CORROSION TREATMENT OR THE FINISH TREATMENT TO THE METAL. THIS IS IN A PROTECTED AREA AND IF PROPERLY MADE SHOULD NEVER RUST. NEEDLESS TO SAY, A GOOD SOLID MOTOR MOUNT IS A CRITICAL ITEM. I FIRST NOTICED THIS PROBLEM ABOUT JUNE 1ST 2010. *TR

I HAVE BEEN WORKING ON THIS CAR FOR MAYBE 2 YEARS AND THE LAST FEW MONTHS IT HAS BEEN MISFIRING ON CYLINDER 3. IT SEEMS THAT MANY OTHER PEOPLE HAVE HAD THIS PROBLEM BUT CANT SEEM TO FIGURE IT OUT. I HAVE REPLACED EVERYTHING THAT HAD TO DO WITH ELECTRICAL AND NOW I THINK IT MIGHT BE SOMETHING TO DO WITH THE FUEL INJECTORS. ALSO THE SEAT BELT WOULD STAY LOCKED FOR ABOUT 10 MINUTES OR SO. *TR

DT*: THE CONTACT STATED WHILE TRAVELING 60 MPH, THE CHECK ENGINE LIGHT ILLUMINATED AND THE VEHICLE LOST POWER. AFTER A FEW SECONDS, THE ENGINE REGAINED POWER BUT THE LIGHT REMAINED ILLUMINATED. THE VEHICLE WAS TAKEN TO THE DEALERSHIP, WHERE THE EGR VALVE AND CATALYTIC CONVERTER WERE REPLACED, BUT THE PROBLEM PERSISTED.

CONSUMER STATES ENGINE MAKES A RATTLING NOISE WHEN STARTED. NOISE IS ALSO HEARD WHEN ACCELERATING AFTER VEHICLE HAS COME TO A COMPLETE STOP. VEHICLE HAS BEEN CHECKED BY DEALER WHO ADVISED A "VALVE" IN THE ENGINE IS CAUSING NOISE AND THAT MAZDA ENGINEERS ARE INVESTIGATING TO FIND A SOLUTION. CONSUMER IS VERY CONCERNED THAT ISSUE COULD COMPROMISE HER SAFETY WHEN DRIVING VEHICLE. TS

MECHANICAL ENGINE RATTLES AT 2800 RPMS WHEN COLD. DEALER CONFIRMS PROBLEM, BUT CANNOT FIX. MAZDA CONFIRMS PROBLEM BUT CLAIMS TO NOT HAVE A SOLUTION. PROBLEM IS EVIDENT ON A LEAST 50% OF PROTEGE SEDANS AND WAGONS PRODUCED FOR 2002.*AK

ENGINE RATTLE WHEN COLD AT ABOUT 2500RPMS. MAZDA HAS NOT REPAIRED OR INDICATED THAT PROBLEM EXISTS. *AK