2002 Mercedes-Benz C-Class Complaint Log

TL* THE CONTACT OWNS A 2002 MERCEDES BENZ C320. THE CONTACT STATED THAT HE NOTICED THAT CORROSION WAS DEVELOPING ON THE LOWER PANEL OF THE VEHICLE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC. THE TECHNICIAN STATED THAT THE ENTIRE BODY OF THE VEHICLE WAS CORRODED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 40,000 AND THE CURRENT MILEAGE IS 51,000. UPDATED 12/30/13*CN THE CONSUMER STATED THE VEHICLE WAS ALWAYS GARAGED AND WELL MAINTAINED, YET THE DOORS AND UNDER PANELS SHOWED EXTENSIVE CORROSION. THERE WERE SEVERAL PRONOUNCED PAINT BUBBLING AND RUST SPOTS THAT HAVE PERMEATED THROUGHOUT THE BODY.

ON JUNE 9, 2011 I DROVE TO SACRAMENTO, CALIFORNIA TO VISIT MY COUSIN WHEN I GOT THERE I WENT TO LOCK MY DOORS BUT THE LOCK KEPT JUMPING UP AND DOWN. IT FINALLY LOCKED AFTER 12 ATTEMPTS. I TOOK IT TO THE DEALER AND THEY QUOTED ME A PRICE OF $3500.00 TO REPLACE THE REGULATOR. THE SECOND INCIDENT OCCURRED ON JULY 18, 2011 WITH MY BRAKES.THE BREAK WARNING LIGHT CAME ON. I TOOK IT TO THE DEALER AND $795.00 THEY CLAIMED I NEEDED FOR BOTH BRAKES AND ROTORS WHICH I COULD NOT UNDERSTAND SINCE 6 MONTHS PRIOR THE ROTORS HAD BEEN REPLACED. I AGAIN HAD TO HAVE THE ROTORS AND BREAKS REPLACED IN JULY 2012 AS WELL AS THE BACK BREAKS BUT THIS TIME I TOOK IT TO ANOTHER PLACE OTHER THAN THE DEALER AND HERE IT IS 2014 AND THEY ARE STILL HOLDING AND THE COST WAS $495.00 FOR BOTH FRONT AND BACK AS WELL 4 NEW MICHELIN TIRES THE DEALER WANTED TO CHARGE ME $495.00 FOR THE BACK ALONE. THE THIRD INCIDENT OCCURRED IN LAS VEGAS I WAS IN HEAVY TRAFFIC AND THE CAR SHUT OFF. IT STARTED BACK RIGHT AWAY BUT I HAD A TEN HOUR DRIVE TO MAKE IT HOME AND THIS WORRIED ME. THE FOURTH INCIDENT WAS WITH THE SUNROOF I WENT TO THE CAR WASH AND THE WAX THAT WAS USED CAUSED THE SUNROOF TO STICK AFTER IT DRIED AND LATER THE MOTOR WENT OUT BECAUSE OF MULTIPLE ATTEMPTS TO OPEN THE ROOF, THE DEALER QUOTED ME A PRICE OF $5000.00 TO REPAIR IT. LAST BUT NOT LEAST THE SRS LIGHT CAME ON, I TOOK IT TO THE DEALER AND I WAS TOLD THAT THE DRIVERS SEATBELT AND BACK SEATBELT ON DRIVERS SIDE WERE DEFECTIVE AND IF I HAD AN ACCIDENT THE AIR BAGS MIGHT NOT DEPLOY AND THE SEATBELTS MIGHT NOT HOLD, THIS WILL COST ME $700.00 TO HAVE FIXED. I DON'T HAVE A MONEY TREE GROWING IN MY YARD. ALSO MY REAR TAILLIGHT KEPT GOING OUT AND WHAT WE FOUND WAS THAT THE ENTIRE CASING HAD CAUGHT ON FIRE AND BURNED. THE ENTIRE UNIT HAD TO BE REPLACED. I HAVE PAID MORE IN REPAIRS ON THIS CARS THAN I PAID IN GROCERIES OVER THE PASS FIVE YEARS. *TR

MERCEDES 2002 C320. POWER SEAT CONTROL MODULE FOR BOTH DRIVER AND PASSENGER DRAIN THE BATTERY TO A EXTENT THAT CAR CAN NOT BE STARTED UP. ONLY SOLUTION IS BUY A NEW ($500.00 PLUS LABOR) CONTROL MODULE. I'VE DONE A RESEARCH IN DIFFERENT MERCEDES FORUMS AND IT SEEMS TO BE A COMMON PROBLEM AMONG THESE MODELS. MB DESPITE OF ALL THE PEOPLE HAVING THE SAME PROBLEM HAS NOT ISSUED ANY RECALL. *TR

MERCEDES BENZ C240 ECU FAILURE. ALSO THE TRANSMISSION SHIFTS ARE SOMETIMES RANDOM AT BEST AND SOMETIMES SHUTS OFF. THE CARS INSTRUMENT CLUSTER ALSO SOMETIMES DOESN'T WORK, THE POWER STEERING LEAKS INTERMITTENTLY THE REAR COIL SPRING BROKE ON LEFT SIDE OF VEHICLE . THE ALTERNATOR WAS REPLACED SO WAS THE COIL PACK AND OTHER ITEMS BY MERCEDES BUT THEY ALWAYS TRIED TO JUSTIFY THAT PROBLEM WAS NORMAL WEAR AND TEAR WHICH IS NOT TRUE. *TR

BATTERY DIES. AFTER DIAGNOSTIC, FOUND THAT DRIVER SEAT CONTROL UNIT DRAINED BATTERY. REPLACED BATTERY AND EVENTUALLY ALL CONTROLS FAIL ON THE SEAT AND STEERING WHEEL. I AM ONE OF MANY MANY PEOPLE WITH THE SAME PROBLEM. NO SOLUTION FOUND AND NO RECALL TO REPAIR. *TR

I JUST HAD THE CONVERSATION WITH MY MB DEALER ABOUT REPLACING A MALFUNCTIONING YAW RATE SENSOR ON MY 2000 C230K. THE PROBLEM IS THAT THIS IS CAUSING A DANGEROUS SITUATION BECAUSE IT IS RANDOMLY ENGAGING MY BRAKES AT ALL SPEEDS WHEN IT THINKS THE CAR IS OUT OF CONTROL. *TR

TL* THE CONTACT OWNS A 2002 MERCEDES BENZ C320. THE CONTACT STATED THAT THE BATTERY CONTINUED TO FAIL EACH TIME THE VEHICLE WAS STARTED. THE VEHICLE WAS TAKEN TO THE DEALER WHO ADVISED THAT THE SEAT MODULE WAS DRAINING THE BATTERY THAT WAS LOCATED UNDER THE FRONT DRIVER AND PASSENGER SEATS. THE CONTACT STATED THAT HE HAD TO PURCHASE TWO BATTERIES WITHIN FOUR MONTHS DUE TO THE RECURRING FAILURE. THE MANUFACTURER WAS NOT CONTACTED IN REGARDS TO THE FAILURE. THE FAILURE MILEAGE WAS 97,000.

I PURCHASED A 2002 C240 MERCEDES IN 2006. THE CAR HAS NEVER GIVEN ME ANY MAJOR PROBLEMS UNTIL HERE RECENTLY. THE CAR BEGAN TO NOT START AND COMPLETELY SHUT DOWN. I HAD TO HAVE THE CAR TOWED THREE TIMES TO THE MECHANICS (DON ALLEN SERVICE CENTER ON ALLENTOWN ROAD, FORT WASHINGTON, MD). WAS TOLD I NEEDED A FUEL PUMP. I PAID $1,500 TO HAVE A NEW FUEL PUMP INSTALLED. PROBLEM NOT SOLVED. WHEN I TRIED TO START THE CAR. IT HESITATES FOR ABOUT 10-15 SECONDS BEFORE IT TURNS OVER. I TOOK IT BACK TO THE MECHANICS AND WAS TOLD IT NEEDED TO FUEL FILTER CHANGED AGAIN. PROBLEM NOT SOLVED. NOW THE CAR MAKES THIS LOUD WHINING NOISE FROM THE BACK OF THE CAR. NOW I HAVE TO TAKE TIME OFF FROM WORK TO TAKE THE CAR BACK TO THE MECHANICS TO HAVE HIM TO REPLACE THE FUEL FILTER AGAIN. THIS IS WHAT I'M BEING TOLD IS THE PROBLEM WITH THE CAR. THE FUEL FILTER IS NOT WORKING PROPERLY. THIS WILL BE THE THIRD TIME IN ONE WEEK THAT THE FUEL FILTER HAD TO BE CHANGED. I WAS TOLD THAT ONCE THE FUEL PUMP GOES BAD, THE CAR WILL NEVER RUN THE SAME AGAIN. I BELIEVE THIS TO BE TRUE CONSIDERING THE PROBLEMS I'VE ENCOUNTERED AFTER HAVING THE FUEL PUMP INSTALLED ON MY CAR. HAVING A MERCEDES HAS BEEN A HEADACHE WITH THE COST OF JUST MAINTAINING THE SCHEDULED MAINTENANCE WHICH IS COSTLY. I PLAN ON GOING BACK TO A LEXUS AFTER ALL IS SAID AND DONE! THOROUGHLY DISAPPOINTED WITH MERCEDES. THESE VEHICLES SHOULD BE RECALLED TO FIX THE FAULTY FUEL SYSTEM/PUMP/FILTER. I PLAN ON REPORTING THIS COMPLAINT TO MY STATES ATTORNEY OFFICE IN THE STATE OF MARYLAND, PRINCE GEORGES COUNTY. *TR

UNPREDICTABLE APPLICATION OF ESP IN 2002 MERCEDES C-320 RESULTING IN SUDDEN AND UNPREDICTABLE BRAKING AND ENGINE THROTTLE DOWN. *TR

I HAVE A 2002 MERCEDES C-320 CAR THAT THE BATTERY WILL NOT HOLD A CHARGE! I HAD THE MERCEDES DEALER COME TO MY HOME AND PUT IN A NEW BATTERY. AFTER SPENDING $300 AND 2 DAYS LATER THE NEW BATTERY WAS DEAD. I WAS TOLD IT COULD BE THE ALTERNATOR/REGULATOR BY THE MB DEALER AND THE COST WOULD BE $1,200. I TOOK IT TO MY LOCAL MECHANIC, WHO WORKS ON FOR. CARS, AND THEY REPLACED THE ALTERNATOR/REG. FOR $512 OUT THE DOOR. 2 DAYS LATER THE BATTERY WAS DEAD AGAIN. I WAS TOLD MY NEW MERC. BATTERY WAS NOT GOOD AND THEY REPLACED IT. 7 DAYS LATER MY BATTERY DIED AGAIN. MY LOCAL MECH. TOLD ME TO TAKE IT BACK TO THE MB DEALER AS THERE SEEMS TO BE A PROBLEM WITH THEIR MODULE AND THEY SHOULD REPLACE IT FOR FREE AS THROUGH HIS RESEARCH MANY INDIVIDUALS ARE HAVING THE SAME PROBLEM. CLEARLY A DEFECT PART BY MERCEDES AS THROUGH MY AND MY MECH. RESEARCH, THE MB MECH ARE REPLACING THE OLD MODULES WITH A NEW AND IMPROVED ONE TO FIX THE PROBLEM. I NOW HAVE NOW HAD AAA TO COME AND CHARGE MY BATTERY ONCE AGAIN AND I WILL TAKE IT TO THE MB DEALER. I HOPE THEY A WILL DO THE RIGHT THING. *TR

TL* THE CONTACT OWNS A 2002 MERCEDES BENZ C 230. THE CONTACT WAS DRIVING 30 MPH WHEN THE VEHICLE STALLED WITHOUT WARNING. THE VEHICLE WAS TOWED TO A LOCAL REPAIR FACILITY WHERE THE MECHANIC ADVISED THAT THE FUEL PUMP WIRING AND SEVERAL OTHER WIRES WERE BURNED. THE MECHANIC ADVISED THAT IF THE FUEL TANK HAD BEEN FULL OF GASOLINE, THE VEHICLE WOULD HAVE CAUGHT ON FIRE. THE MECHANIC WAS UNABLE TO DETERMINE THE CAUSE OF THE FAILURE. THE MANUFACTURER ADVISED THE FAILURE WAS NOT CONSIDERED A SAFETY ISSUE AND WOULD NOT PROVIDE ANY ASSISTANCE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 99,000.

THIS 2002 MERCEDES C32 IS A DEATHTRAP! THE ELECTRONIC COMPONENTS, REAR & FORWARD SAM, FUEL PUMP, ETC, FAIL AT AN UNUSUALLY HIGH RATE. THE MOST RECENT INCIDENT INVOLVED A FAULT IN THE PRIMARY FUEL PUMP. THE MERCEDES DEALER IDENTIFIED THE FAULT AS A FAULTY PLASTIC POWER CONNECTOR ON THE PUMP AND A FAILED FUEL PRESSURE SENSOR. THEY THEN PROCEEDED TO TELL ME THAT MERCEDES BENZ NORTH AMERICA WOULD NOT SELL ME A REPLACEMENT PUMP; INSTEAD, THEY INSISTED THAT I PURCHASE AN ENTIRE NEW FUEL TANK AND WIRING HARNESS FOR $3200 PARTS AND THOUSANDS OF DOLLARS MORE FRO LABOR. MERCEDES BENZ IS AWARE OF A SERIOUS DESIGN FLAW ON THIS YEAR AND MODEL, YET, REFUSES TO ACKNOWLEDGE A VOLUNTARY RECALL. MOREOVER, THE DESIGN AND PLACEMENT OF THE TANK--A SADDLE TYPE, SITUATED UNDER THE REAR SEATS--ALLOWS DIRT, SMALL PEBBLES AND OTHER DEBRIS TO ACCUMULATE IN THE AREA (A TYPE OF WELL) OF THE FUEL PUMP(S)--THERE ARE TWO. EVERY TIME I'VE HAD THE CAR SERVICED THE TECHNICIAN HAD TO VACUUM OUT ALL THE ACCUMULATED DEBRIS. I'VE NOTICED ON THIS SITE THAT OTHERS HAVE COMPLAINED ABOUT FUEL PUMP PROBLEMS, INCLUDING SERIOUS FUEL LEAKS WITH THEIR ASSOCIATED FUEL LINE FAULTS. REGARDLESS OF THE AGE OF THE VEHICLE, THESE FAILURES SHOULD NEVER TAKE PLACE! MOREOVER, I AM COUNTING ON YOUR OFFICE TO INVESTIGATE THIS MATTER THOROUGHLY. IN RECENT DAYS IT HAS COME TO LIGHT THAT THE AUTO INDUSTRY HAS BEEN CRIMINALLY NEGLECTFUL WITH RESPECT TO ADDRESSING FAULTY DESIGN ISSUES. I THINK MY CIRCUMSTANCE IS YET ANOTHER EXAMPLE OF THIS PHENOMENON. MERCEDES BENZ OF NORTH AMERICA MUST BE HELD TO ACCOUNT FOR PLACING A SERIOUSLY FLAWED PRODUCT INTO THE MARKETPLACE! *JS

WE HAVE A 2002 MERCEDES C320 WAGON. THE AUTOMATIC DRIVER AND PASSENGER SEATS DRAINED THE BATTERY COMPLETELY WHERE THE CAR WILL NOT START. WE HAVE DISCONNECTED THE MODULE SEATS SO THAT IT WILL STOP DRAINING THE BATTERY. THE REPLACEMENT FOR EACH MODULE SYSTEM FOR THE SEAT IS ABOUT $500 OR MORE. I BELIEVE THIS IS A MANUFACTURER'S DEFECTS AS IT IS DANGEROUS IF OWNERS ARE NOT AWARE OF THE SITUATION AND LEAVE THEIR CAR PARK FOR A PERIOD OF TIME WILL CAUSE THE OWNERS NOT ABLE TO START THEIR CAR, ESPECIALLY IN AN EMERGENCY SITUATION. *JB

ON 1/14/2012 CAR WONT START BATTERY DEAD, CALL AAA TOW TRUCK. JUMP BATTERY OK USED CARED NEXT DAY AND ON FAUL COME UP ON MY CARS TROULBE SCREEN TO INDICATED THAT I HAD ANY OTHER TROUBLE IN ANY SYSTEM IT THE CAR, WE WHEN TO FL ON THE ON THE 16 OF JANUARY CAR WAS HOME (IN NY) SON WAS GOING TO TAKE OF HOUSE AND START CAR ONCE A WEEK. RECEIVED PHONE CALL FROM MY SON ON 1/17/2012 CAR WONT START,BATTERY DEAD, AND KEY WONT TURN. ON 4/21/2012 COME HOME FROM FL FROUND DEAD CAR AND TRANSMISTION LEAKING.CALLED MERCEDES BENZ FOR A TOE TO THE SHOP.THIS IS THR THIRED BATTERY SINCE A HAVE THIS CAR.BATTERY WAS UNDER WARRANTY.IT WAS CHANEG LEST THEN A YEAR AGO. M/B SHOP INFORMED ME BATTERY WAS DEAD. CAUSE MY SEAT MODULES SHORTED, TO REPLACE MODULES WAS COST $1200. I FEEL THAT THE BATTERY CAUSE THIS TROUBLE AND THE THE MODULES SHOULD BE REPLACED BY B/M AT NO COST TO ME. *TR

ON JAN 2, 2010, WHILE DRIVING HOME FROM A MOVIE IN MY 2002 MERCEDES C230, THE CAR SUDDENLY AND VIOLENTLY BEGAN PULLING TO THE RIGHT. I FIRST THOUGHT I HAD A BLOW OUT. I WAS DRIVING ON A FREEWAY AND AM NOT AWARE OF HITTING ANY THING THAT MIGHT HAVE CAUSED THE FAILURE. WHEN I STOPPED, I FOUND THE RIGHT FRONT TIRE WAS FLAT. THE FOLLOWING DAY I TOOK THE FLAT TO MY TIRE SHOP WHO INFORMED ME THE RIM HAD A CRACK IN IT, AND THAT CAUSED THE TIRE TO DEFLATE. I ORDERED A NEW WHEEL FROM THE LOCAL MERCEDES DEALER, WHO TOLD ME IT IS NOT UNCOMMON FOR WHEELS ON THIS MODEL TO FAIL. MERCEDES REFUSED WARRANTY. I CONSIDER THIS A SIGNIFICANT SAFETY FAILURE AND ASKED THE SERVICE MANAGER WITH THE LOCAL DEALER, KIMBALL MOTORS, TO PRESENT IT TO MERCEDES FOR WARRANTY AND/OR SAFETY REPLACEMENT. THE CAR IS BEYOND THE NORMAL WARRANTY PERIOD. MERCEDES REFUSED TO TAKE ANY ACTION. BOTH THE PEOPLE WHO REPLACED THE TIRE, BIG BRAND TIRE, AND THE PARTS PEOPLE AT THE DEALER, KIMBALL MOTORS, TOLD ME THEY SEE "SEVERAL FAILURES LIKE THIS" EACH YEAR. IN MY 50 PLUS YEARS OF DRIVING FOR PLEASURE AND COMMERCIALLY, I NEVER EXPERIENCED A CRACKED WHEEL AND SUBSEQUENT TIRE FAILURE. I WAS DISAPPOINTED THAT MERCEDES FAILED TO TAKE AN INTEREST IN THE FAILURE. I HAVE THE WHEEL, AND HAVE A DIGITAL PHOTO OF THE FAILURE IF THAT WILL BE OF ASSISTANCE. *TR

AT 45,000 MILES FRONT PASSENGER SEAT STARTED DRAINING THE BATTERY. DEALER TOLD BAD CONTROL UNIT. BECAUSE OF HIGH COST OF REPAIR ($900.), IT HAS BEEN DISCONNECTED. THE CONTROL UNIT WAS LEAST UTILIZED FOR THE PASSENGERS SEAT. THIS SHOULD NOT HAVE FAILED UNDER 45000 MILES USE. *TR

CAR STALLED IN THE MIDDLE OF THE ROAD AND ALMOST CAUSED AN ACCIDENT. AFTER 15 MINUTES, CAR STARTED BACK. I HAD IT DIAGNOSED AND A MODULE WAS REPLACED. 2 MONTHS LATER, THE BATTERY STARTED DRAINING. I HAD THE ALTERNATOR REPLACED AND THE BATTERY TWICE. CAR WILL WORK FOR A DAY OR TWO AND DIES AGAIN. SO MANY OTHER MERCEDES OWNERS OF C320 ARE HAVING THE SAME PROBLEM. BATTERY DYING AND CAR STALLING. *TR

I BOUGHT A CAR AND THE CHECK ENGINE LIGHT WENT ON, ITS A 2002 C230 KOMPRESSOR 2 DOOR, AND THE DEALER SAID ITS A SENSOR FROM THE SUPERCHARGER. *TR

SEAT CONTROL UNITS DRAINING THE BATTERY IF CAR IS PARKED. CAR WILL NOT START IF PARKED FOR MORE THEN 24H. DRAIN AMPS BETWEEN 1.2 AND 1.4 AMPS. HAD TO DISCONNECT THE SEAT MODULES, NOW SEATS CAN'T BE ADJUSTED. *TR

BATTERY DRAINING, OFFICIAL DEALERSHIP IS UNABLE TO IDENTIFY WHAT IS CAUSING DRAIN. *TR

DEFECTIVE SEAT CONTROLLER MODULES ( DRIVER AND PASSENGER ) CAUSE THE BATTERY TO DRAIN COMPLETELY WITHIN 24 HOURS. THIS LEAVES ME STRANDED AND UNABLE TO DRIVE MY VEHICLE. A SEARCH ONLINE REVEALS MULTIPLE OTHER WITH THE SAME ISSUES...INDICATING AN OBVIOUS SAFETY ISSUE THAT IS WELL KNOWN TO THE MANUFACTURER WITH NO RESOLUTION TO THIS PROBLEM FROM THE MANUFACTURER OTHER THAN PAYING $1000 FOR A KNOWN DEFECTIVE ISSUE/PART. *TR

DRIVERS OUTSIDE REARVIEW MIRROR HAS BECOME DISCOLORED AND IS NOW VERY DIFFICULT TO SEE IMAGES PARTICULARLY AT NIGHT. DEALER QUOTED $800 FOR MIRROR GLASS ONLY! *TR

BATTERY GOES DEAD AFTER A FEW DAYS: MAJOR CAUSE IS ELECTRICAL POWER DRAIN DUE TO FAULTY UNITS, MAJOR CAUSE BUT NOT ONLY CAUSE IS THE SEAT CONTROL MODULE UNIT. QUICK FIX IS TO DISCONNECT TO ELIMINATE POWER DRAIN BUT THIS CAUSES OTHER SAFETY FEATURES TO GO DORMANT. I HAVE READ MORE THAN 100 REPORTS ON BENZWORLD.ORG ON THE VERY SAME ISSUE WITH LITTLE OR NO SOLUTION FROM DEALERSHIPS. ITS A MAJOR AND COMMON PROBLEM AND SHOULD BE RECALLED BEFORE PEOPLE GET HURT. *TR

POWER SEAT CONTROLLER BECOMES DEFECTIVE AND FAILS TO SHUT DOWN WHEN CAR IS OFF AND LOCKED, AND THUS DRAINS THE BATTERY. *TR

SEAT CONTROLLER MODULES, THEY CONSTANTLY DRAIN THE BATTERY WHEN THE CAR IS OFF. THIS IS A VERY VERY COMMON PROBLEM WITH MERCEDES C CLASS. THE CONTROLLER DRAINS THE CAR BATTERY TO THE POINT WERE THE CAR CANNOT START, AND CONTINUES TO DO THIS IF THE CAR IS NOT DRIVEN EVERYDAY. OBVIOUSLY HAVING A CAR BATTERY GET SUCKED BELOW 3V IS NOT HEALTHY FOR THE BATTERY, AND IN THE END EVERYONE WITH THIS PROBLEM HAS TO REPLACE THEIR BATTERY MANY MANY TIMES. *TR

DOOR LOCK MALFUNCTION - WHILE DRIVING, I HEARD SOMETHING COME FROM THE LEFT/DRIVER SIDE...IT SOUNDED LIKE A BOX OR SOMETHING FELL FROM MY REAR SEAT, ONTO THE FLOOR AND UNDER MY SEAT. *TR I SAT IN THE CAR, UNLOCKING/LOCKING, AND IT CONTINUED TO GO NUTS...EVEN THE CENTRAL LOCKING BUTTON ON THE DASH FAILED TO WORK A FEW TIMES... LOOKS LIKE A DOOR LOCK ACTUATOR PROBLEM THAT COSTS ABOUT $400 TO FIX. *TR

SEAT CONTROL MODULE ON PASSENGER SIDE DRAINS THE BATTERY. *TR

TL*THE CONTACT OWNS A 2002 MERCEDES BENZ C230. ON OCTOBER 15, 2008, WHILE DRIVING 65 MPH, THE VEHICLE SUDDENLY DECELERATED TO 15 MPH ON ITS OWN. THE VEHICLE WAS TOWED TO THE GARAGE. IT WAS DIAGNOSED THAT THE RADIATOR FAILED AND COOLANT FLUID PENETRATED THE TRANSMISSION RESERVED FLUID. THE MECHANIC REPLACED THE RADIATOR AND CLEANED THE TRANSMISSION AT THE COST OF $5,000. THE MECHANIC STATED THAT THE TRANSMISSION WILL EVENTUALLY ALSO NEED TO BE REPLACED. THE FAILURE MILEAGE WAS 56,146 AND CURRENT MILEAGE IS 59,000. UPDATED 02/24/09. *LJ UPDATED 02/25/09. *JB

FAULTY SEAT CONTROLLER OF A MERCEDES C32 AMG, DRAINS CAR BATTERY OVERNIGHT, CAUSES NEW BATTERY REPLACEMENT AND CONTROLLER REPLACEMENT (NOT CHEAP - APPR $400). NO NEW CONTROLLER PURCHASED FROM MB USA, JUST DISCONNECTED PLUG (MOVING SEAT IS INOPERABLE). I NOTICED ALMOST ALL US MERCEDES BENZ VEHICLES WITH THAT BODY STYLE (W203) HAVE THAT ISSUE. SOURCES: BAY AREA DEALERSHIPS, A REPAIR SHOP AND ONLINE FORUMS. *TR

TL*THE CONTACT OWNS A 2002 MERCEDES BENZ C CLASS. WHILE DRIVING 35 MPH OR HIGHER, THE ESP INDICATOR LIGHT ILLUMINATED. THE VEHICLE HAD BEEN TAKEN TO THE DEALER AND REPAIRED ONCE BEFORE FOR THE SAME FAILURE. THE FAILURE OCCURS INTERMITTENTLY WHILE DRIVING 35 MPH. THE DEALER STATED THAT THEY WILL NOT ORDER THE PARTS AND MAKE THE REPAIR AGAIN. THE FAILURE MILEAGE WAS 110,000. UPDATED 09/23/08 *BF THE CONSUMER STATED THE VEHICLE STALLED IN BRAKING MODE.

CAR BATTERY DRAINS DUE TO A SHORT IN THE POWER SEAT CONTROL UNITS IN MY 2002 MERCEDES BENZ C320. REPLACED BATTERY, RECHARGED BATTERY NUMEROUS TIMES. EVERY OTHER OWNER OF THIS MAKE / MODEL COMPLAINS OF SAME PROBLEM. *TR

2002 MERCEDES BENZ C320 STATION WAGON: FAILURE TO KEEP A CHARGE IN THE BATTERY, AND APPARENTLY THE SOLUTION IS TO DISCONNECT THE POWER SEATS AND THEN RECHARGE THE BATTERY. BUT THEN THE POWER SEATS ARE INOPERABLE, UNLESS YOU GET THESE REPLACED. APPARENTLY, THIS IS A COMMON PROBLEM. *TR

I OWN A 2002 MERCEDES BENZ C230, WHICH HAS NOW HAD 2 SEVERE ISSUES WITH IT. THE FIRST ISSUE IS THE ELECTRICAL SYSTEM - THE SEAT CONTROL MODULES GO FAULTY AND START DRAINING THE BATTERY EVEN WHEN THE CAR IS TURNED OFF. IF YOU HAVE A BATTERY DRAIN, THIS IS THE LIKELY CULPRIT. I HAVE REPLACED THE SEAT CONTROL MODULES A TOTAL OF 3 TIMES. THIS IS A COMMON PROBLEM ACCORDING TO INTERNET BOARDS. THE 2ND PROBLEM IS THAT OIL STARTED TO LEAK ALL OVER THE WIRES. AGAIN ANOTHER COMMON PROBLEM ACCORDING TO THE INTERNET BOARDS. *TR

TL*THE CONTACT OWNS A 2002 MERCEDES BENZ C-230. THE CONTACT'S CHILD WRAPPED THE NEAREST REAR SEAT BELT AROUND HER NECK, WHILE SEATED IN HER CHILD SEAT. WHILE THE SEAT BELT WAS AROUND THE CHILD'S NECK, IT WOULD NOT LOOSEN AND WAS EXTENDED TO THE POINT THAT THE SEAT BELT COULD ONLY RETRACT. THE CONTACT CALLED THE POLICE AND THEY CUT THE SEAT BELT FROM AROUND THE CHILD'S NECK. SHE WAS UNINJURED FROM THE SEAT BELT FAILURE. THE VEHICLE HAS NOT BEEN DIAGNOSED BY THE DEALER. THE CURRENT AND FAILURE MILEAGES WERE 60,000.

2002 C320 MERCEDES BENZ ELECTRICAL SEATS DRAINING BATTERY. *TR

THE BATTERY IN MY 2002 MERCEDES BENZ C320 DIED IN LATE FEBRUARY 2008. DIAGNOSTICS WERE DONE AND THE BATTERY WAS REPLACED BY BY CHANDLER MERCEDES BENZ VIA ROADSIDE SERVICE. IN LATE MARCH I GOT INTO THE CAR TO GO TO WORK AND THE BATTERY WAS DEAD; CALLED ROADSIDE SERVICE. CHANDLER MB ARRIVED AND JUMP-STARTED THE CAR. MAY 5TH I GOT IN MY CAR TO GO TO WORK AND AGAIN, THE BATTERY WAS DEAD. CHANDLER MB ROADSIDE SERVICE AGAIN JUMP-STARTED THE CAR WHICH WAS THEN DELIVERED TO THEIR SERVICE DEPARTMENT. THE BATTERY WAS CHECKED AND THERE WAS NOTHING WRONG WITH IT. FURTHER DIAGNOSTICS REVEALED THAT THE DRIVER'S SIDE POWER SEAT MODULE WAS DRAINING THE BATTERY. I REQUESTED A BATTERY THAT COULD POWER THE CAR. WAS TOLD THERE IS NO BATTERY THAT WILL POWER THE CAR, THE POWER SEAT MODULE MUST BE REPLACED TO THE TUNE OF $398.00 PLUS LABOR. I DID FURTHER RESEARCH AND DISCOVERED THAT THIS IS A VERY WIDESPREAD PROBLEM IN THE MERCEDES C320, IN FACT MERCEDES BENZ IS NOW INSTALLING A DIFFERENT MODULE IN THE 2002 C320'S DUE TO THE EXTENT OF THE PROBLEM. IT SEEMS TO ME THAT WHEN I BUY A MERCEDES BENZ WITH A MERCEDES BENZ BATTERY AND A MERCEDES BENZ INSTALLED POWER SEAT MODULE, THERE SHOULD BE SUFFICIENT POWER TO DRIVE MY CAR. ASKING ME TO PAY OVER $400 TO REPLACE THEIR OWN PART BECAUSE IT DRAWS TOO MUCH POWER FROM THEIR OWN BATTERY AND THEN NOT MANUFACTURING A BATTERY THAT WILL PROVIDE THE REQUIRED POWER, IS VERY CONVENIENT FOR MERCEDES BENZ AND A GREAT WAY TO MAKE SOME VERY EASY MONEY, BUT WHEN I PAY $35,000 IN CONSIDERATION FOR A CAR AND THEY PROVIDE ME A CAR THAT DOES NOT HAVE ENOUGH POWER TO RUN, I BELIEVE THERE IS SOME FRAUD GOING ON AND FROM MY RESEARCH IT APPEARS THAT IT IS ON A VERY WIDESPREAD BASIS. JUST THE FACT THAT MERCEDES HAS ACKNOWLEDGED THE PROBLEM BY SWITCHING TO A DIFFERENT MODULE, INDICATES THEY ARE AWARE THAT THEIR ORIGINAL PART IS DEFECTIVE AND I BELIEVE IT'S THEIR RESPONSIBILITY TO BEAR THE COST TO REPLACE IT WITH THEIR REPLACEMENT MODULE. *TR

WE PURCHASED A NEW SET OF MICHELIN PILOT SPORT 2 TIRES AT COSTCO IN POWAY, CA ON 10/8/07 FOR MY WIFE'S MERCEDES. AFTER JUST LESS THAN SIX MONTHS AND UNDER 6,800 MILES, WE NOTICED HER LEFT TIRE WAS LOW. SUSPECTING SHE HAD PICKED UP A NAIL OR SUCH, WE FULLY INFLATED THE TIRE AND DROVE THE THREE MILES TO COSTCO. THE REPRESENTATIVE THERE, PATRICK, CALLED ME TO SAY IT WAS A NAIL BUT IT HAD DAMAGED THE SIDEWALL AND THE TIRE COULD NOT BE REPAIRED. WHEN I WENT BACK TO THE TIRE CENTER, PATRICK'S SUPERVISOR, WILLIAM KENNISON, INSISTED THAT SIX MONTHS AND 6800 MILES WERE PERFECTLY NORMAL LIFE EXPECTANCY NUMBERS FOR HIGH PERFORMANCE TIRES. HE INFORMED ME THERE WAS OVER 75% OF THE TREAD ON THE FRONT TIRES (DIFFERENT SIZE THAN THE REARS 225/45R17 VS. 245/40R17) BUT ONLY 38% ON THE LEFT REAR AND 0% ON THE RIGHT REAR. I NEVER SAW THE RIGHT REAR TIRE. HIS MANAGER, HERB, WAS OFF DUTY BUT WAS SUPPOSED TO CALL ME ON MONDAY TO DISCUSS MY DISSATISFACTION. HE NEVER CALLED. I PAID $379 AND CHANGE AND LEFT WITH A NEW PAIR OF REAR TIRES. MY WIFE WILL BE 56 NEXT WEEK. SHE IS A NURSE PRACTITIONER AND PRIMARILY DRIVES THIS CAR TO WORK AND OUR DAUGHTER'S SCHOOL. IT HAS BEEN ON THREE ROAD TRIPS TO UCLA FROM SAN DIEGO SINCE WE BOUGHT NEW TIRES IN OCTOBER. THERE IS NOTHING UNUSUAL OR AGGRESSIVE IN MY WIFE'S DRIVING STYLE AND THE FACTORY TIRES LASTED 40,075 MILES. CLEARLY, THESE TIRES CAME FROM A BAD BATCH AND SHOULD HAVE BEEN RECALLED. HAD WE NOT HAD A LOW TIRE THE CONSEQUENCES MIGHT HAVE BEEN MUCH WORSE. I HAVE NOTIFIED COSTCO AND MICHELIN. COSTCO INVOICE #007750053220 DATED 10/08/2007. MEMBERSHIP #111760783421. BARRY LOVELL. *TR

2002 MERCEDES C320 BATTERY DIES EVERY 2-3 DAYS. NEEDS JUMP START EVERY 2-3 DAYS. *TR

I HAVE A 2002 MERCEDES BENZ C240 SEDAN WITH 78,000 MILES ON IT. UPON LEAVING WORK TWO WEEKS AGO DRIVING DOWN THE PARKING LOT IN SECOND GEAR THE CAR STARTED TO MAKE THE WORST ENGINE NOISE I EVER HEARD. I SHUT THE CAR OFF AND HAD IT TOWED TO A DEALER AND THEY TELL ME THE TIMING CHAIN BROKE. IF I WAS TRAVELING DOWN AN INTERSTATE AND THIS BROKE AND THE ENGINE LOST POWER WHO KNOWS WHAT WOULD HAVE HAPPENED. THIS IN NOT THE FIRST PROBLEM I HAD WITH THE CAR I HAVE A SERVICE FILE FULL OF PROBLEMS AND SPENT A LOT OF TIME AND MONEY ON THINGS LIKE FRONT COIL SPRINGS WHICH ALSO COULD BE VERY DANGEROUS WHEN THEY BREAK AND I LOSE CONTROL OF THE CAR. *TR

I OWN A MERCEDES BENZ C320 AND LATELY I'VE BEEN EXPERIENCING SOME PROBLEMS, FEW WEEKS AGO, MY CAR WOULDN'T START ALL OF A SUDDEN. I JUMP STARTED AND I NOTICED 2 FAULTS .. ESP WARNING LIGHT AND LIGHT SENSOR ,FOR SOME REASONS SOMETHING WAS DRAINING MY BATTERY, I WENT AND PURCHASED A BRAND NEW BATTERY AND 2 DAYS LATER IT DID THE SAME THING AGAIN, I WAS TOLD THAT IT WAS A SEAT SENSOR THAT CAUSED IT,S O WE UNPLUGGED THE SEATS, EVERYTING SEAMED FINE FOR LIKE 4 TO 5 DAYS,WHILE I WAS DRIVING,THE CAR JUST CAME TO A COMPLETE STOP WOULD NOT MOVE,THE ENGINE LIGHT CAME ON, I'VE COME TO REALIZE THAT I'M NOT THE ONLY ONE WITH THIS PROBLEM, I HOPE THE GOVERNMENT WOULD DO THE RIGHT THING BY RECALLING THOSE VEHICLES. *TR

ON MY MERCEDES BENZ C320, IF THE CAR IS NOT STARTED AT LEAST EVERY 12 HOURS, THE CAR WILL NOT START AND IT NEEDS A JUMP. THE CAR IS A 2002 AND HAS 51K MILES. *TR

WHILE DRIVING ON HIGHWAY OUT OF STATE AT APPROX. 60MPH CAR SUDDENLY BUCKED AND ALL POWER CUT OUT, ALL LIGHTS ON CONTROL PANEL LIT UP- HIT CLUTCH AND GAS, VEHICLE RESTARTED. NEAREST DEALER WOULD NOT SEE ME FOR 2 WEEKS, DEALER IN ANOTHER STATE DID DIAGNOSTIC ESTIMATED REPAIR AT CLOSE TO $4,000; ALREADY GAVE OVER $1800 AS DOWNPAYMENT TOWARD PARTS. REPAIR ? SCHEDULED FOR NEXT WEEK. READ OTHER COMPLAINTS, BELIEVE MANUFACTURER SHOULD TAKE SOME RESPONSIBILITY HERE, AND WANT REASSURANCE IF REPAIR DOES NOT WORK I WILL NOT BE CONTINUOUSLY CHARGED WHILE THEY REPLACE EVERYTHING UNTIL THE GET IT RIGHT. SAID COMPUTER DID NOT READ A DEFECT. CAR HAS BEEN SERVICED BY DEALERS ONLY AT EVERY RECOMMENDED SERVICE MILESTONE. *TR

MERCEDES BENZ 2002, C320 *STEERING WHEEL MALFUNCTION *SRS WARNING *SEATS MALFUNCTION *BRAKE AND OIL FLUID MISLEADING INFO *BATTERY DRAIN *TURNING SIGNALS REQUIRING NEW HARNESS THAT COST A LOT $$$. *TR

THE CAR PARKED IN THE GARAGE OVERNIGHT AND THE MORNING I HAD AN EMERGENCY AT THE BUSINESS AND COULD NOT START THE CAR. THE BATTERY WAS TOTALLY DRAINED. HAD IT TOWED TO THE SHOP TO BE DIAGNOSED THAT IT WAS THE FRONT DRIVER SIDE POWER SEAT THAT HAS DRAINED ALL THE ENERGY FROM THE BATTERY EVEN WHEN THE CAR IS NOT RUNNING. THE POWER SEAT IS NOW CONTINUOUSLY EXCESSIVELY DRAIN THE BATTERY EVEN WHEN THE CAR IS NOT RUNNING. THE CONSEQUENCES ARE THAT THE CAR IS NOT TRUSTED TO BE ABLE TO START IN AN EMERGENCY SITUATION WHEN THE CAR IS NEEDED FOR TRANSPORTATION. THE CAR HAS VERY LOW MILEAGE ON IT. THE POWER SEAT HAS BEEN RARELY USED AND IT SHOULD NOT FAIL FOR HAVING BEEN IDLE/NOT USED FOR THE LENGTH OF TIME THAT I HAVE OWN THE CAR. I AM THE ORIGINAL FIRST TIME OWNER OF THE CAR AND I HARDLY HAVE TO ADJUST THE POWER SEAT. I BELIEVE THAT THE POWER SEAT IS A MANUFACTURE DEFECT AND COULD BE A DANGEROUS IMPEDIMENT IN AN EMERGENCY SITUATION. THE ARE LOTS OF MERCEDES OWNER WHO HAVE EXPERIENCING THE SAME MALFUNCTION IN THEIR POWER SEATS. I FEEL THAT WITH THESE MANY PEOPLE, IT WARRANTS A RECALL BY MERCEDES FOR ALL THE POWER SEATS. *TR

I HAVE MERCEDES C230 2002, WITH OEM MICHELIN MXV4 PLUS 205/55 R16. ONE TIRE WAS BLOWN AND REPLACED 3 YEARS AGO. NOW ALL TIRES DEVELOP HUGE CRACKS ON THE EDGE OF TREAD AND SIDEWALL AS WELL AS INSIDE OF TREAD. TIRES ARE IN BETWEEN 5/32ND AND 7/32ND TREAD WITH 40K MILES, AND WOULD BE GOOD TO GO FOR ANOTHER 2 YEARS EASILY. BUT, ACCORDING TO MERCEDES AND MICHELIN DEALERS (LES SCHWAB) TIRES UNSAFE TO DRIVE! I CALLED MICHELIN 866-866-6605 NOVEMBER 03-07, AFTER 30 MIN CONVERSATION WITH LES SCHWAB MANAGER INVOLVED, MICHELIN ADMIT MANUFACTURING DEFECT, AND OFFERED 45% OFF NEW TIRES PURCHASE. HERE IS WHAT MICHELIN OFFER ACTUALLY MEANS: 1) 45% DISCOUNT APPLY ONLY TO MICHELIN AND SAME MXV4 PLUS IS $205/EA AND IT MEANS $820 X0.55 = $451 TO PAY. 2) I MUST PAY DISMOUNT + MOUNT + BALANCE + DISPOSAL FEES, WHICH IS $20 PER TIRE X4 = $80, SO TOTAL OUT OF MY POCKET BECOMES $531 +TAX! *JB

THE LIGHTS ON MY DASH BOARD FLICKER AND DIM , MAKING IT DIFFICULT TO SEE THE SPEEDOMETER AND OTHER INSTRUMENTS. *TR

MY VEHICLE WOULD NOT START, SO I RECEIVED A JUMP, TWO DAYS LATER WHEN I DID NOT DRIVE THE CAR IT WOULD NOT START RECEIVED ANOTHER JUMP AND REPLACED THE BATTERY. DID NOT DRIVE THE CAR FROM 7-4 TO 7-8-07 AND CAR WOULD START. WENT TO MERCEDES DEALERSHIP ON 7-9-07 AND WAS TOLD THAT IT WAS A COMMON PROBLEM ON MY CAR THAT THE SEAT MODULES DO NOT POWER DOWN WHEN THE CAR IS OFF AND THAT IT IS DRAINING THE BATTERY. WENT TO SEVERAL MERCEDES-BENZ FORUM WEBSITES AND FOUND THAT THERE WERE HUNDREDS OF PEOPLE HAVING THE SAME PROBLEM. ONCE THE SEAT MODULE ARE REPLACED FOR $1200.00 THAT THE SEAT MODULES WOULD CONTINUE TO DRAIN THE BATTERY AND WOULD HAVE TO BE REPLACED AGAIN AND THIS BECAME A CYCLE. PLEASE VISIT WEBSITES WWW.BENZWORLD.ORG/FORUMS OR M-BENZFORUM.COM OR TYPE IN GOOGLE OR YAHOO MERCERDES BENZ FORUM AND CONNECT. HERE YOU WILL SEE A LIST OF PEOPLE WITH THE SAME PROBLEM. *AK

I CAME OUT AND MY BATTERY WAS DEAD WITHOUT WARNING. I TOOK THE VEHICLE TO DOWNTOWN LA MOTORS(MERCEDES BENZ) DEALER, WHERE THEY EXPLAINED THAT THE SEAT CONTROL MODULES WERE STAYING ON AND CAUSING THE BATTERY TO DRAIN. I SUBSEQUENTLY HAD TO UNHOOK THE SEAT CONTROLS AND NOW I AM UNABLE TO MOVE MY SEATS OR STEERING WHEEL. THEY ESTIMATED THAT THE REPAIR WOULD COST AROUND 1500. NUMEROUS CUSTOMERS HAVE THE SAME ISSUE ON THE SAME VEHICLE, IT IS OBVIOUS THAT THIS IS A MANUFACTURER DEFECT AND NOT THE FAULT OF MERCEDES BENZ CONSUMERS. *TR

THE INSIDE FRONT DOOR HANDLE OF C-CLASS (YEAR2002 OR SIMILAR) IS NO GOOD, IF YOU PARK THE CAR ON THE DOWN SLOPE STREET, AND CLOSE THE FRONT DOOR FROM WIDE OPEN POSITION, THE DOOR HANDLE WILL GIVE AWAY AND BROKEN APART AT THE TOP END WHICH IS ATTACHED TO THE INSIDE DOOR PANEL ONLY WITH A SMALL PLASTIC STUD. I SENT THE COMPLAINT LETTERS TO MERCEDES BENZ USA AS WELL AS MERCEDES BENZ OF SAN FRANCISCO, THEY NEVER RESPONSE. I BELIEVE THE FAILURE OF THE DOOR HANDLE TO PERFORM PROPERLY BECAUSE OF FAULTY DESIGN AND THE MANUFACTURE HAS TO BEAR RESPONSIBLE BY RECALLING THIS TYPE OF DOOR HANDLE. *TR

LEFT AND RIGHT ELECTRONIC SEAT MODULES WHICH ALSO CONTROLS THE STEERING WHEEL AND OTHERS FAILED AND MB DID NOT WANT TO ACCEPT THE RESPONSIBILITY PART NUMBERS ARE: 2118704626 2118704726. *TR