There are 5 owner-reported engine complaints for the 2021 Mercedes-Benz C-Classin NHTSA's database. These are unverified consumer reports and may not reflect confirmed defects.
The contact owns a 2021 Mercedes-Benz C300. The contact stated that while driving at an undisclosed speed, the vehicle stalled and failed to exceed 30 MPH, with the check engine warning light illuminated. The vehicle did not require a restart. The contact also stated that while stopped at a traffic light, the vehicle was shaking abnormally. The vehicle was taken to an independent mechanic, where it was diagnosed and determined that there was a misfire in cylinder #2. The contact was informed that the cylinder head needed to be replaced. The vehicle was not repaired. The vehicle was then taken to the dealer, where the same diagnostic information was provided, and the contact was informed that the cylinder head needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure. The approximate failure mileage was 86,078.
2021 Mercedes-Benz C300 with M254 2.0L turbo engine experienced sudden cylinder head failure at 44,000 miles due to manufacturing porosity in the cylinder head and camshaft bore scoring. Dealer confirmed defect. This is a known, recurring issue on 2021–2023 M254 engines with multiple documented failures under 50k miles. Sudden loss of compression and misfires create a safety risk of engine failure or fire while driving. TSB NUMBER LI07.16-P-074000 (February 2023, updated multiple times). This is a known production/early break-in issue with the M254 engine, not the result of owner misuse or delayed maintenance.
Cylinder head needed to be replaced on the M264 engine at 35,000 miles. The replacement part is also known to be defective for the same reasons. This is a common defect known to the manufacturer and they have not issued a recall. My concern is that of a roadside breakdown that would endanger my wife and myself. Thank you for your consideration.
the check Engine light fault code P012D12 The pressure sensor upstream of the turbocharger had a short circuit to positive. Found Kink wire on upstream pressure sensor. A short circuit to positive. Electrical Wire replaced.
Piston Connecting Rod broke and left the engine making holes in both sides of the block; Mercedes Benz rejected any responsibility because the car has a branded title. Currently a new engine (brand new) is being installed, my concern is that what will happen if the new engine has the same defective part and blew up again.
Complaints are unverified consumer reports submitted to NHTSA. A high complaint count may reflect vehicle popularity, not defect severity. Data sourced from NHTSA public records.
Data synced from NHTSA on Apr 25, 2026