There are 12 stored owner reports matching the electrical system leading-label group for the 2002 MINI Cooper in our NHTSA-sourced dataset. These are unverified consumer reports and may not reflect confirmed defects.
This group counts stored reports whose component label starts with one of this site's matching prefixes, ignoring case. Each matching report counts once within the group. Components mentioned later in the label or only in the narrative are not searched. How component counts work
Loaded 12 of 12 matching reports.
Open the full vehicle complaint log (all categories)Driverside headlight assembly flickers everytime when you turn the key to position 1 with selector on off or auto. Flickers multiple times but doesn'tturn on unless I cycle the key on off until headlight does. This annoyance would reoccur the very next morning. Passenger headlight assembly doesn't have any issues.
I purchased the vehicle used with airbag light showing on the speedometer gauge cluster. Searched with vin for recalls but showed 0 unrepaired recalls. Tried clearing the light with my Launch CREADER BMW V2 scan tool. Light flashes a few times and goes away but immediately appears on the speedometer gauge cluster. This would happen everytime. Wires are intact with no signs of damages to all 3 wire connectors under the seat.
I TURNED THE SEAT HEATER ON AND IT MELTED A HOLE IN THE LEATHER SEAT AND THE FOAM PADDING STARTED TO BURN. *TR
LOSS OF POWER WHEN GOING 60 MPH IN THE HIGH SPEED LEFT LANE OF FOUR LANE HIGHWAY. CAR WENT INTO "LIMP MODE" AND UNABLE TO ACCELERATE. CAR WOULD ONLY GO 5 TO 10 MPH WITH LARGE TRUCK BEHIND AND BEARING DOWN ON ME. EML AND SERVICE ENGINE LIGHTS ON DASH. WAS ABLE TO PULL INTO A CONSTRUCTION LANE THAT HAPPENED TO BE RIGHT THERE. OTHERWISE WOULD HAVE BEEN UNABLE TO GET CAR OUT OF THE WAY. CAR NEEDED TO BE TOWED. FAULT CODES LIST THROTTLE BODY AND WIRING HARNESS AS PROBLEMS AND RECOMMENDATION IS TO REPLACE BOTH. FROM MY RESEARCH, THE PROBLEM IS WELL KNOWN AND RELATES TO POOR CONNECTOR BETWEEN THROTTLE BODY AND WIRING HARNESS. MINI HAS SINCE REDESIGNED THE ANGLE OF THIS CONNECTOR TO FIX THIS PROBLEM. SUCH A LOSS OF POWER WHILE DRIVING IS EXTREMELY DANGEROUS. SHOULD BE RECALL ITEM. *TR
THIS CAR GOES INTO LIMP MODE AT VERY IN OPPORTUNE TIMES, BEFORE THIS LATEST TIME (AGAIN TO THE SHOP) IT NEARLY GOT ME T-BONED IN AN INTERSECTION, THIS CAR HAS BEEN IN THE SHOP NUMEROUS TIMES FOR ENGINE ELECTRICAL PROBLEM, THIS IS A KNOW DEFECT WITH THE WIRING HARNESS-I BELIEVE THIS SHOULD BE COVERED IN A RECALL FOR A VERY UNSAFE SITUATION. *TR
TL* THE CONTACT OWNS A 2002 MINI COOPER. THE CONTACT STATED THAT THE HEADLIGHTS AND CABIN LIGHTS WOULD REMAIN ILLUMINATED AFTER THE VEHICLE WAS SHUT OFF. IN ADDITION, THE CONTACT STATED THAT HE WOULD OFTEN BECOME LOCKED INSIDE OR OUTSIDE OF THE VEHICLE INTERMITTENTLY. THE VEHICLE WAS INSPECTED BY A DEALER AND THEY ADVISED HIM THAT THE CONTROL MODULE WOULD NEED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS CONTACTED AND THEY OFFERED NO ASSISTANCE. THE FAILURE MILEAGE WAS APPROXIMATELY 60,000.
I WAS DRIVING MY 2002 MINI COOPER. I HAD DRIVEN 1/4 MILE AND THOUGHT I HEARD SOMETHING CRACK OR SPARK UNDER THE DASHBOARD ON THE PASSENGER SIDE OF THE VEHICLE. THEN I SAW SMOKE, PULLED OVER, GOT OUT, AND THE WHOLE CAR WENT UP IN FLAMES. *TR
SIGNIFICANT AND REPEATED ELECTRICAL FAILURES CAUSED THE CAR TO RANDOMLY SWITCH INTO EML MODE, REDUCING ENGINE OUTPUT CRITICALLY. WHEN THIS HAPPENED ON A HIGHWAY THERE WAS NOT ENOUGH POWER TO REMOVE THE CAR FROM THE ROAD SAFELY. AFTER SEVERAL INEFFECTUAL REPAIRS, THE WIRING HARNESS WAS REPLACED. SHORTLY AFTER THE REPAIR, THE CAR WAS PARKED, EMERGENCY BRAKE SET, MANUAL TRANSMISSION SET IN FIRST GEAR. UNATTENDED, TURNED OFF WITH NO KEY IN THE IGNITION, THE CAR MOVED ITSELF SEVERAL FEET, HITTING ANOTHER CAR, BURNING OUT THE STARTER AND DRAINING THE BATTERY. THE CAR WAS MOVED TO A REPAIR SHOP WHERE THE STARTER WAS REPLACED. OVERNIGHT, WITH THE CAR PARKING INSIDE THE LOCKED SHOP, THE CAR MOVED ITSELF ACROSS THE SHOP. MECHANICS ARE NOW INVESTIGATING THE PROBLEM. *TR
WENT OUT TO DINNER WITH MY PARENTS - GONE APPROXIMATELY 2 HOURS - CAME BACK TO FIND THE CAR COMPLETELY BURNED. FIRE DEPARTMENT WAS CALLED BY A NEIGHBOR. THERE WAS NO INDICATION AT ALL THAT THERE WAS ANYTHING WRONG WHEN WE PARKED THE CAR. HAVE FOUND OTHER CASES (VIA THE INTERNET) IN THE UK THAT THIS HAS HAPPENED. *JB
THE VEHICLES REAR HATCH IS ELECTRONIC AND IF THE VEHICLES BATTERY DIED THERE WOULD BE NOT WAY TO INTO THE BATTERY COMPARTMENT. THE DEALER WAS NOTIFIED. *NLM
2003 MINI COOPER CVT. VEHICLE STALLS IN TRAFFIC CONDITIONS. BOGGS DOWN, LUNGES UPON ACCELERATION. POWER FAILURE. NO INDICATOR LIGHTS ON DASH WARN OF PROBLEM. VEHICLE HAS BEEN SERVICED ON THREE OCCASIONS FOR SAME PROBLEMS. BOGGS DOWN AND LUNGES CORRECTED BY REPROGRAMMING ON FIRST SERVICE. AFTER FIRST SERVICE VEHICLE STALLED AGAIN IN TRAFFIC CONDITIONS. RETURNED TO SERVICE DEPT. WHO WERE UNABLE TO REPLICATE STALLING AFTER 400 MILES OF TEST DRIVING IT. CONTACTED MINI DIVISION OF BMW OF AMERICA. THEY SENT TECHNICAL SPECIALIST WHO CHECKED THE ELECTRICAL SYSTEM, NO APPARENT CAUSE. MINI REPRESENTATIVE IS CURRENTLY HAVING ELECTRICAL HARNESS REPLACED. VEHICLE OUT OF SERVICE FOR 6 WEEKS AND COUNTING. MAJOR SAFETY CONCERN. *NLM
THE HEAD LIGHT FAILED TWICE, THE DEALER REPLACED THE MODULE AND THEN THE COMPUTER CHIP. *JB
Complaints are unverified consumer reports submitted to NHTSA. A high complaint count may reflect vehicle popularity, not defect severity. Data sourced from NHTSA public records.
NHTSA source checks for this vehicle year
Checks are recorded separately for each dataset, not for the whole page. Dates use UTC. A missing check date does not mean no records exist.
Vehicle import recorded: Apr 28, 2026. This is the stored import date, not confirmation that every source was successfully refreshed.