2008 MINI Cooper Complaint Log

AS SOON AS CAR BEGINS TO MOVE THE DSC ERROR APPEARS AND THE DSC NO LONGER WORKS. I HAVE BEEN TOLD THAT THE SZL MODULE THAT CONTROLS THIS HAS FAILED AND APPARENTLY DOES THIS WITH OTHER MINI'S AS WELL.

MY CAR HAS 114,000 MILE ON IT. THE HIGH PRESSURE FUEL PUMP WAS REPLACED PER RECALL. THE ENGINE HAS FAILED WITH BAD INJECTORS, CYLINDERS AND RINGS. MECHANIC SAID THIS FAILURE IS PERVASIVE IN 2002 TO 2008 MODELS DO TO POOR DESIGN. THE COST TO REPAIR IS TOO HIGH.

CVT TRANSMISSION STUCK IN FIRST GEAR WHILE DRIVING ON A HIGHWAY AND WOULD NOT GO MORE THAN 30MPH AND CARS HAD TO SWERVE FROM BEHIND ME IN ORDER TO PREVENT AN ACCIDENT. THE DEALER WANTS TO REPLACE THE TRANSMISSION FOR $8,000.00 WHICH IS RIDICULOUS. I COULD HAVE BEEN KILLED ON HIGHWAY ALONG WITH MY DAUGHTER..

I WAS IN A BAD CAR ACCIDENT IN WHICH MY CAR WAS REAR ENDED. I WAS IN THE VERY MOST RIGHT HAND LANE ON THE HIGHWAY, AT A STOP IN STOP AND GO TRAFFIC. THE VEHICLE BEHIND ME DID NOT STOP, HITTING ME AT APPROXIMATELY 75 MPH. AS A RESULT, MY CAR SPUN OUT TO THE RIGHT AND HIT THE GUARD RAIL ON THE SIDE OF THE HIGHWAY HEAD ON. THE CAR THEN BOUNCED OFF OF THE GUARD RAIL, AND SPUN ABOUT 180 DEGREES TO THE LEFT, WHERE THE REAR END OF THE CAR THEN HIT THE SAME GUARD RAIL AND FINALLY STOPPED. WHEN THE CAR CRASHED INTO THE GUARD RAIL HEAD ON, THE AIR BAG DID NOT DEPLOY AND I HIT MY HEAD AND MY CHEST AGAINST THE STEERING WHEEL. I SUSTAINED A FRACTURE IN MY T2 VERTEBRAE AND BAD CHEST BRUISING.

TL* THE CONTACT OWNS A 2008 MINI COOPER S. THE CONTACT WAS INCLUDED IN NHTSA CAMPAIGN NUMBER: 08V657000 (ENGINE AND ENGINE COOLING), BUT THE REPAIR WAS NOT COMPLETED BEFORE THE CONTACT OWNED THE VEHICLE. IN ADDITION, THE CONTACT EXPERIENCED A FAILURE CONCERNING NHTSA CAMPAIGN NUMBER: 12V008000 (ENGINE AND ENGINE COOLING). THE VEHICLE WAS TAKEN TO A REPAIR SHOP WHO PROVIDED AN OIL CHANGE AND CLEARED A DTC. THE CONTACT LATER EXPERIENCED EXTREME SMOKE EMITTING ON THE OUTSIDE OF THE VEHICLE TO THE INSIDE OF THE VEHICLE. THE VEHICLE WAS COASTED OVER TO THE SIDE OF THE ROAD AND TOWED TO A REPAIR SHOP. THE MECHANIC DIAGNOSED THAT THE WATER PUMP LEAKED, THE ENGINE OVER HEATED, THE CYLINDER HEAD WAS WARPED, AND THE OIL FILTER HOUSING GASKET WAS LEAKY. THE MECHANIC DIAGNOSED THAT THE ENGINE NEEDED TO BE REPLACED. THE CONTACT WAS UNCERTAIN IF THE VEHICLE WOULD BE REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 76,000.

TL* THE CONTACT OWNS A 2008 MINI COOPER. WHILE DRIVING 40 MPH, THE VEHICLE LOST ALL POWER AND ALL THE WARNING INDICATORS ILLUMINATED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT SOMETHING WAS LOOSE IN THE ENGINE AND THAT THE ENGINE NEEDED REPLACEMENT. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 60,000.

THE TURBO OIL FEED LINE IS INHERENTLY FLAWED AND PREMATURELY FAILS BECAUSE OF A BAD DESIGN. THIS FAILURE CAUSES HOT OIL TO LEAK ALL OVER A HOT TURBO. I WAS LUCKY ENOUGH TO NOT HAVE MY ENGINE CATCH FIRE WITH THE FAILED O-RING ON MINE. I WAS DRIVING ON THE HIGHWAY WHEN LARGE CLOUDS OF SMOKE BEGIN TO FLOW FROM THE ENGINE COMPARTMENT. I WAS FORCED TO PULL OVER AND GET TOWED HOME. I WAS OUT OF WARRANTY BUT STILL VERY LOW MILEAGE (48K) WHEN MINE FAILED. *TR

PRISTINE CONDITION, LOW MILEAGE, DEALER SERVICED MINI COOPER S (OWNED SINCE NEW) BEGAN EXHIBITING A RATTLING NOISE FROM ENGINE AT 34K MILES. DEALER DIAGNOSED IT AS A TIMING CHAIN DEFECT AND TIMING CHAIN TENSIONER DEFECT. THIS IS A KNOWN ENGINE DEFECT. REFERENCE CLASS ACTION SUIT AND SETTLEMENT 338403. THIS SETTLEMENT BY BMW/MINI USA COVERS THIS FLAW AND BMW/MINI KNOWS THAT VEHICLES PRODUCED WITHIN THE 2007-2010 TIMEFRAME HAVE THIS FLAW. THIS FLAW CAN RESULT IN CATASTROPHIC ENGINE FAILURE. IN MY CASE, IT WAS NOISY UNDER ACCELERATION, AND WAS INTO THE DEALER FOR SERVICE WITHIN DAYS OF FIRST ISSUE. THIS IS A KNOWN FLAW. HOWEVER, BMW/MINI SETTLED THE CLASS ACTION LAWSUIT AND SET ASIDE MILLIONS OF DOLLARS FOR CLAIMS....BUT THOSE CLAIMS MUST BE FILED BY 7/1/16. I DID NOT HAVE THE ISSUE BEFORE THAT DATE, I HAD IT HAPPEN IN SEPTEMBER 2016 - TWO MONTHS LATER. I HAVE REQUESTED SOME ACCOMMODATION FROM BMW/MINI, HOWEVER THEY ARE REFUSING TO PARTICIPATE AT ANY LEVEL, EVEN THOUGH THEY KNOW THIS WAS A FLAWED PART AND COULD HAVE CAUSED SIGNIFICANT DAMAGE. I AM NOT EXPECTING FULL REIMBURSEMENT, BUT IF THEY KNOW THE CAR HAS A MAJOR FLAW, THEY SHOULD HAVE SOME COVERAGE IN PLACE FOR ANY OF THESE VEHICLES WITH THE FLAW. THUS FAR THE REGIONAL SERVICE MANAGER AND MINI USA HAVE INDICATED BECAUSE THIS HAPPENED AFTER 7/1/16 THEY WILL NOT ACCOMMODATE.

FUEL SMELL STARTED TO GET STRONGER IN THE CABIN AND OUTSIDE OF THE VEHICLE, BUT DID NOT SEE ANY LEAKS ON THE FLOOR TILL TODAY. I ALSO NOTICE THE GREEN TEMPERATURE NOTIFICATION COME ON TODAY. I HAD MY OIL CHANGED AT THE BMW/MINI DEALER IN ONTARIO LAST MONTH.

"TAMARA RECALL" TIMING CHAIN.

IN SEPTEMBER, 2013, MY 2008 MINI COOPER HARDTOP, WITH THE N12 ENGINE, HAD THE TIMING CHAIN FAIL UNDER OPERATION. THIS CAUSED THE ENGINE TO STOP, AT HIGHWAY SPEED, AFFECTING STEERING, BRAKING AND ALL ABILITY TO MANEUVER THE VEHICLE OUT OF TRAFFIC. TWO VEHICLES BARELY AVOIDED MY DISABLED VEHICLE. I CONTACTED MINI USA AND THEY REFUSED TO ACKNOWLEDGE THE FACTORY DEFECT IN THE TIMING-CHAIN TENSIONER THAT CAUSES THE TIMING CHAIN TO FAIL. I PAID OVER $8000 FOR A REPLACEMENT N12 ENGINE. WITH LESS THAN 10,000 MILES ON THE REPLACEMENT ENGINE, IN JULY, 2016, THE TIMING CHAIN FAILED AGAIN. THIS TIME THE VEHICLE WAS CROSSING A BRIDGE AND THERE WAS NO PLACE TO TRY TO PULL OFF. THE SITUATION WAS VERY DANGEROUS AND LEFT MY FAMILY VULNERABLE TO ONCOMING TRAFFIC. I CONTACTED MINI USA AGAIN, AND ALTHOUGH THEY HAVE ADMITTED TO THE TIMING CHAIN DEFECT ON THEIR N14 ENGINE, IN THE S SERIES VEHICLE, THEY STILL REFUSE TO ISSUE A RECALL FOR THE N12 ENGINES IN WHICH THE TIMING CHAIN FAILURES ARE MORE NUMEROUS. THIS DEFECT CAUSES THE VEHICLE TO BECOME INOPERABLE AT SPEED WHICH IS UNSAFE IN THE EXTREME. MINI USA NEEDS TO ISSUE A SAFETY RECALL FOR EVERY VEHICLE EQUIPPED WITH THE N12 ENGINES.

AIRBAG SENSOR MAT DOES NOT RECOGNIZE WHETHER A PERSON IS SITTING ON THE PASSENGER SIDE THEREBY NOT ACTIVATING THE AIRBAG; THIS HAS BEEN HAPPENING ON & OFF FOR MONTHS; PASSENGER AIRBAG LIGHT COMES ON IMMEDIATELY DESPITE OCCUPANCY WHILE PARKED AND DURING DRIVING (ALL CONDITIONS-HIGHWAY, CITY STREET, TURNING; ETC. STARTED APPROXIMATELY FROM 75K MILES; NOW CONSTANT FROM 85K ON

AT 55000 MILES STARTED TO HEAR ENGINE RATTLE AND ROUGH RUNNING AT IDLE. TOOK TO DEALER FOR SERVICE AND THEY SAID THE ENGINE HAS MULTIPLE OIL LEAKS, A FAULTY CAMSHAFT ADJUSTMENT SOLENOID AND FAULTY TIMING BELT. THE TIMING BELT HAS CAUSED THE OIL LEAKS AND FAULTY SOLENOID. THIS WILL CAUSE CATASTROPHIC ENGINE FAILURE. MINI WILL NOT COVER EVEN THOUGH THIS HAS BEEN REPORTED AND IS AN OBVIOUS DEFECT.

WE TOOK OUR 2008 MINI COOPER TO A MINI DEALER BECAUSE OF A WARNING LIGHT AND IT WAS DIAGNOSED WITH A SHORT IN THE SENSOR THAT DETECTS THE NEED FOR PASSENGER SIDE AIRBAG. THIS MEANS THAT AT TIMES THE PASSENGER SIDE AIRBAG WILL NOT DEPLOY, MAKING POSSIBLE A POTENTIALLY DEADLY CRASH.

MY 2008 MINI COOPER WAS IN ACCIDENT IN JAN 2016. THE (PASSENGER) LIGHT CAME ON AND IT WAS IMMEDIATELY TAKE TO AUTOBODY SHOP. THE PASSENGER AIRBAG WARNING LIGHT WAS EVALUATED AND ADDED TO REPAIRS. THE SEAT MAP SENSOR IS THE CHIEF PROBLEM. THE CAR IS UNDRIVABLE. THE DEALERSHIP IN STERLING INDICATED THAT IT WOULD TAKE 15-30 DAY TO RECEIVED THE PART. THE PART WAS DELAYED UNTIL MARCH 24,2016. THREE DAYS PRIOR TO DELIVERY IT WAS UPDATED TO JUL 13, 2016. AT THIS POINT MY RENTAL CAR FROM THE INSURANCE COMPANY RAN OUT. I CONTACTED CUSTOMER CARE BUT WAS NOT ABLE TO RECEIVE A DATE NOR ASSISTANCE ABOUT MY PART AND LOST OF VEHICLE. AFTER CONVERSATION WITH LIBERTY MUTUAL, AUTO SHOP AND DEALERSHIP, WE WERE TOLD THAT THE VEHICLE WAS SAFE TO DRIVE WITHOUT A PASSENGER IN THE SEAT. NO RESOLUTION HAS BEEN MADE, MANY INDIVIDUALS ( CONSUMER, INSURANCE COMPANY AND AUTO SHOP) INVOLVED IN THE SITUATION STATED IT WAS NOT SAFE NOR COULD LOSS BE GUARANTEED. AS OF THE 4/18/2016, THE PART HAS BEEN PUT ON INDEFINITE BACK ORDER. CURRENTLY THERE IS NO KNOWN TIME FRAME RETURN OF VEHICLE. I AM WITHOUT TRANSPORTATION AND I WILL NEED TO PURCHASE ANOTHER CAR. ADDITIONALLY I HAVE HEARD FROM OTHER REPAIR FACILITIES, MINI'S PASSENGER SEAT OCCUPANCY SENSOR AFFECTS FAR MORE MODEL YEARS THAN THOSE FOR WHICH BMW HAS ALREADY ANNOUNCED RECALLS. I AM ALSO AWARE THAT MORE THAN 60 MINI OWNERS ARE WAITING ON THIS PART AS WELL.

TAKATA RECALL: MY 2008 MINI COOPER S HARDTOP BEGAN EXPERIENCING ISSUES WITH THE "PASSENGER AIR BAG OFF" LIGHT STAYING LITE WHETHER OR NOT A PASSENGER IS IN THE CAR. ON APRIL 28, 2016, I TOOK MY CAR TO A MINI COOPER DEALERSHIP TO HAVE THE ISSUE DIAGNOSED (AT A COST OF $53.95). THE DIAGNOSIS STATES "FAULT PASSENGER SIDE SEAT MAT SENSOR" (INVOICE COPY ATTACHED). I DON'T UNDERSTAND WHY MY VEHICLE THAT MEETS THE CRITERIA FOR THE APRIL 2015 AIR-BAG RECALL EXCEPT IT IS A HARDTOP INSTEAD OF A CONVERTIBLE IS NOT INCLUDED IN THE RECALL. TO FIX THIS ITEM WILL BE OVER 1300. MY CAR ONLY HAS 14,000 MILES ON IT. DUE TO THE COST, AT THIS POINT I DO NOT PLAN ON HAVING IT FIXED AND WILL SAY MY PRAYERS EVERY TIME I TRAVEL WITH A PASSENGER IN THE VEHICLE.

MY CAR ONLY HAS 47,000 MILES ON IT AND HAS THE SAME PASSENGER SIDE AIRBAG ISSUE. IT STARTED OFF AT TIMES HAVING THE PROBLEM, NOW IS ON ALL THE TIME. MINI WANTS $125 TO DIAGNOSE THE PROBLEM, WHICH SEEMS EVIDENT. ALSO PAID $425 TO FIX ELECTRICAL WIRING THAT CORRODED AND $1,700 2 MONTHS EARLIER THIS YEAR WHEN WHEEL SENSOR WENT BAD AND 3 LIGHTS WENT OFF IN THE CAR.

SRS COMPUTER AND SENSORS ARE FAILING. NO ACCIDENT, NO FLOODING JUST FAILING SENSORS AND COMPUTER. MINI CLAIMS THIS IS A "MAINTENANCE" ITEM, YET THERE IS NO DOCUMENTED MAINTENANCE PROTOCOL FOR THESE ITEMS. VEHICLE HAS LESS THAN 100K MILES AND AIR BAG SYSTEM COMPONENTS ARE FAILING. HENCE WE DON'T KNOW IF THE SYSTEM WILL WORK OR NOT AND THE VEHICLE WILL NOT PASS OUR STATE INSPECTION.

I OWN A 2008 MINI COOPER S AND IT HAS 62000 MILES ON IT. AS MANY OTHER MINI OWNERS, I HAVE " RATTLE NOISE" ISSUE WHEN COLD START AND POPPED UP "ENGINE OIL PRESSURE TOO LOW" WARNING YESTERDAY WHEN DROVE HOME ON CITY STREET. THIS VEHICLE HAS HAD THE TIMING CHAIN TENSIONER/GUIDE CHANGED ONCE BEFORE AT 18,942 BY A MINI DEALER.

TL* THE CONTACT OWNED A 2008 MINI COOPER S. WHILE DRIVING APPROXIMATELY 70 MPH, AN ABNORMAL NOISE WAS HEARD AND THE CONTACT NOTICED THICK, GREY SMOKE COMING FROM THE FRONT OF THE VEHICLE. THE OIL WARNING LIGHT ILLUMINATED. THE CONTACT OPENED THE HOOD AND NOTICED FLAMES IN THE ENGINE COMPARTMENT. THE FIRE DEPARTMENT EXTINGUISHED THE FIRE. A POLICE REPORT AND A FIRE REPORT WERE FILED. THE VEHICLE WAS DESTROYED. THE VEHICLE WAS TOWED. THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 12V008000 (ENGINE AND ENGINE COOLING). THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 85,777.

I PURCHASED MY 2008 MINI COOPER 3 YEARS AGO AND IT'S CURRENTLY AROUND 78K MY CAR WAS DIAGNOSED WITH TIMING CHAIN STRETCHED AND POSSIBLY ENGINE DAMAGE. HOWEVER MINI COOPER USA DOESN'T WANT TO REIMBURSE THE MONEY I'D PAY OUT OF POCKET MYSELF.

DRIVERS FOOT WELL GETS SO HOT THAT YOU CAN NOT TOUCH THE PLASTIC BY THE ACCELERATOR AND YOUR FOOT STARTS COOKING AFTER 20 MINUTES OR SO.

I PURCHASED A NEW 2008 MINI COOPER FROM AUTOHAUS WEST/MINI OF ST LOUIS. THE MINI COOPER WAS DESIGNED, MANUFACTURED, ASSEMBLED, DISTRIBUTED AND SOLD BY BMW OF NORTH AMERICA, BMW (U.S.) HOLDING CORP., AND BAYERISCHE MOTOREN WERKE AKTIENGELLSCHAFT. I EXPERIENCED A PROGRESSIVE FAILURE OF THE TIMING CHAIN, TIMING CHAIN TENSIONER AND RELATED TENSIONER RAIL, GUIDE RAIL AND SUPPORT RAIL. THE TIMING CHAIN HAD PREVIOUSLY BEEN REPRESENTED TO HAVE A USEFUL LIFE EQUAL TO THE LIFE OF THE CAR. THE TIMING CHAIN IS LOCATED WITHIN THE ENGINE, CONSISTS OF A METAL CHAIN, AND IS NOT SUBJECT TO ADJUSTMENT OR ROUTINE MAINTENANCE. I EXPERIENCED A PROGRESSIVE FAILURE OF THE TIMING CHAIN AS FOLLOWS: (A) DEATH RATTLE OR DIESEL NOISE FROM ENGINE UPON START UP & AT LOW SPEEDS, (B) ROUGH IDLING AFTER HIGHWAY DRIVING, (C) POWER LOSS & ENGINE STALLS ON HIGHWAY EXIT RAMPS, (D) POWER LOSS & ENGINE STALLS ON HIGHWAY, & (E) CATASTROPHIC ENGINE FAILURE. THE MINI COOPER WAS SERVICED BY AUTOHAUS WEST ON THREE SEPARATE OCCASIONS WITH REPAIRS//REPLACEMENT OF SPARK PLUGS, BATTERY, IGNITER COILS, THERMOSTAT COVER AND OTHER ITEMS TOTALING OVER $3,000. AUTOHAUS WEST FAILED TO IDENTIFY THE TIMING CHANGE AS A PROBLEM. AUTOHAUS WEST, BMW OF NORTH AMERICA, LLC, BMW (U.S.) HOLDING CORP., AND BAYERISCHE MOTOREN WERKE AKTIENGELLSCHAFT HAVE KNOWN ABOUT THE TIMING CHAIN TENSIONER DEFECT SINCE 2007 AND HAVE FAILED TO WARN CONSUMERS, ISSUE A RECALL OR PROVIDE EXTENDED WARRANTY COVERAGE.THE LOSS OF POWER & ENGINE STALLS ARE SERIOUS SAFETY HAZARDS & WILL EVENTUALLY LEAD TO ACCIDENTS, INJURIES & EVEN DEATH. TECHNICAL SERVICE BULLETIN M110207 WAS ISSUED IN JANUARY, 2008. HOWEVER, IT IS NOT WIDELY KNOWN TO CONSUMERS AND FAILS TO GIVE CONSUMERS ADEQUATE WARNING. BMW SETTLED CLASS ACTION RE N14 ENGINE USED IN MINI COOPER S. HOWEVER, IT HAS IGNORED SAME PROBLEM WITH N12 ENGINE USED IN MINI COOPER. SAME ISSUES.

PASSENGER SIDE AIR BAG SENSOR MAT FAULTY. SAME ISSUE AS OTHER MINI COOPERS THAT HAVE BEEN RECALLED. WAS TOLD I HAVE TO REPLACE ENTIRE SEAT. $1,000. WAS TOLD THERE IS A NATION WIDE BACK ORDER FOR THE SEAT. THIS REPAIR SHOULD BE COVERED BY MINI (BMW).

TL* THE CONTACT OWNS A 2008 MINI COOPER S. WHILE DRIVING VARIOUS SPEEDS, THE FRONT PASSENGER SIDE AIR BAG WARNING INDICATOR ILLUMINATED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE SEAT OCCUPANCY MAT WOULD NEED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 63,000.

FAULTY SEAT OCCUPANCY DETECTOR IN PASSENGER SEAT. THERE HAS BEEN A RECALL ON THIS IN SEVERAL MODELS, BUT THEY DO NOT CURRENTLY INCLUDE THIS MODEL/YEAR. FAILURE OF THE SEAT SENSOR PREVENTS DEPLOYMENT OF THE PASSENGER AIRBAG AND CAN ONLY BE FIXED BY REPLACING THE ENTIRE SEAT (EXPENSIVE). NO USER-SPECIFIC ACTIONS HAVE CAUSED THIS DEFECT, IT'S A WELL KNOWN PROBLEM. THE ISSUE WAS ORIGINALLY DIAGNOSED IN 2014, RE-DIAGNOSED 1/3/2016. THE BEST RESOLUTION WE HAVE BEEN OFFERED IS 10% OFF REPAIR COSTS.

AIR BAG WARNING LIGHT ON. PASSENGER AIRBAG OFF DESPITE SOMEONE SITTING IN THAT SEAT

TIMING CHAIN & TENSIONER MY VEHICLE ONLY HAS 85,000 MILES AND I HAVE HAD TO SPEND $3500.00 TO CHANGE THE TIMING CHAIN THAT IS SUPPOSED TO BE MAINTENANCE FREE, AND LAST TEN YEARS AS PER THE OWNERS MANUAL AND SERVICE MANUAL. CAR STOPPED SUDDENLY ON THE NEW JERSEY TURNPIKE, VERY DANGEROUS SITUATION. THIS IS NOT RIGHT THAT I HAD TO PAY OUT OF POCKET FOR A CAR THAT ONLY HAS 85,000 MILES, AND WAS SERVICED REGULARLY. HUGE SAFETY ISSUE

ENGINE RATTLE UPON STARTUP. NEXT THING I KNOW IS THE TIMING CHAIN GUIDES BROKE AND THE VALVES BENT. THOUSANDS IN REPAIR AND MINI WON'T COVER A THING.

TL* THE CONTACT OWNS A 2008 MINI COOPER. WHEN SHIFTING INTO FIRST GEAR, THE VEHICLE EASILY SWITCHED INTO THE REVERSE POSITION. THE CONTACT WAS INVOLVED IN A CRASH. THE AIR BAGS FAILED TO DEPLOY. THERE WERE NO INJURIES AND A POLICE REPORT WAS NOT FILED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE ISSUE. THE FAILURE MILEAGE WAS 46,000.

AFTER MINI/BMW REPAIRED THE TIMING CHAIN TENSIONER AND THE TIMING CHAIN, MY TURBO OIL SUPPLY LINE DEVELOPED A SIGNIFICANT LEAK (WITHIN A WEEK/ WITHIN 200 MILES OF MINI SERVICE) CAUSING SMOKE TO ESCAPE FROM THE BONNET, OIL TO COVER THE FRONT ENGINE/TURBO/EXHAUST. OIL NOW PUDDLES BENEATH THE CAR WHEN PARKED. THE CAR HAS 89,XXX MILES. I FIRST NOTICED THE SMELL OF BURNING OIL WHEN DRIVING ACROSS TOWN AT A SPEED OF 40MPH. WHEN PARKING THE VEHICLE, UPON IDLE THE SMOKE BILLOWED FROM THE BONNET OF THE CAR. ACCORDING TO MINI FORUMS, THIS PROBLEM OF A FAILED O-RING IN THE TURBO OIL SUPPLY LINE IS A KNOWN PROBLEM RESULTING IN NUMEROUS FAILURES THAT CAN LEAD TO CATASTROHIC DAMAGE TO THE TURBO, CATALYTIC CONVERTER, AND ENGINE.

AS MANY OTHERS HAVE POSTED HERE, MY ENGINE BEGAN RATTLING LOUDLY WHEN I WOULD START IT UP. TO ALLEVIATE THIS, I WOULD TOP OFF THE OIL AND GET FREQUENT OIL CHANGES, IN FACT, MORE OFTEN THAN MINI/BMW SUGGESTED IT SHOULD GET AN OIL CHANGE. THIS WOULD USUALLY TAKE CARE OF THE RATTLE. ONE NIGHT, THE ENGINE RATTLE KEPT INCREASING AND SUDDENLY THE CAR STOPPED IN THE MIDDLE OF A BUSY STREET JUST 20 FEET FROM RAILROAD TRACKS WITHOUT ANY WARNING LIGHTS OR INDICATIONS WHATSOEVER. I HAD IT TOWED TO A NEARBY MECHANICS SHOP I TRUST (NOT THE DEALERSHIP). THE TIMING CHAIN HAD BROKEN AND BENT THE VALVES AND I'M IN THE PROCESS OF HAVING A NEW ENGINE PUT IN (WITH THE SAME FAULTY TIMING CHAIN) TO THE TUNE OF $6,500. I CALLED MINI/BMW USA BECAUSE MY MECHANIC SAID HE'S SEEN THIS PROBLEM FREQUENTLY IN MY MODEL. MINI SAID THEY WOULD NOT DO ANYTHING FOR ME UNLESS THE CAR WAS DIAGNOSED BY THE MINI DEALERSHIP, AND EVEN THEN THERE WOULD BE NO GUARANTEE THEY WOULD COVER ANYTHING BECAUSE OF "MY VEHICLE'S AGE." MINI/BMW USA WOULDN'T EVEN ACKNOWLEDGE THAT THERE HAVE BEEN FREQUENT REPORTS OF TIMING TENSIONER/CHAINS HAVING PROBLEMS. I'M EVEN MORE SURPRISED HOW FREQUENT THIS PROBLEM IS NOW THAT I'M LOOKING ON THE NHTSA WEBSITE. THIS NEEDS TO BE A RECALL AND SOMETHING THAT MINI/BMW SHOULD COVER AND RESPOND TO, SINCE THERE HAVE BEEN SEVERAL CLASS ACTION LAWSUITS AGAINST THE COMPANY BECAUSE OF THIS.

AIR BAG WARNING WITH THE FAULT CODE 93C3 WHICH HAS CAUSED A RECALL OF 91 THOUSAND VEHICLES... MY MINI S IS NOT A RECALL CAR. (ON THE SAME GRID AS THE RECALLED MINI'S...SAME OEM REPAIR PARTS) MINI USA REPRESENTATIVE [JAMIE] SUGGESTED I REMOVE THE AIR BAG AND PUT A SIGN UP IN THE DASH INDICATING 'NO AIR BAG" IF I DID NOT WANT TO PAY THE $1500.00+ IN REPAIIR COST... AND THAT WILL ALLOW ME TO PASS THE STATE INSPECTION.

ON 15 AUG 2015 I PURCHASED A 2008 MINI COOPER 2D HATC WITH 122,629 MILES FOR $6,325 WITH NO WARRANTY IN STANFORD, NC FROM KARAS AUTO SALES, INC. ON 27 OCT 2015 THE MINI COOPER BROKE DOWN WHILE DRIVING AND PULLED IT OVER BESIDE THE ROAD. THE WRECKER SERVICE TOOK THE MINI TO A MECHANIC. THE MECHANIC STATED THE TIMING CHAIN HAD BROKE AND THERE WAS MAJOR ENGINE DAMAGE AND THE REPAIR BILL WILL BE FROM 8K TO 10K IN REPAIR COST. MINI HAD APPROXIMATELY 125K MILES ON IT. I'VE HEARD OF A LOT OF COMPLAINTS WITH THOSE MINIS WITH THOSE SAME ISSUES HAPPENING ANYWHERE FROM 30K MILES TO OVER 100K MILES FROM 2007-2010 MODELS. NOTHING ELSE HAS BEEN SPENT ON THE CAR FOR REPAIR. I'M NOT WASTING ANYMORE MONEY ON THAT JUNK MINI COOPER. IT'S TO LATE FOR THE LEMON LAW TO BE APPLIED. CAN ANYTHING GET DONE SO THAT I CAN IMPLEMENT A LAWSUIT AND RECEIVE ANY MONEY FOR THAT FROM BMW OR AND THE DEALER OR IS IT A WASTE OF TIME? THANK YOU IN ADVANCE.

IN THE SPRING 2014 I PURCHASED A 2008 MINI COOPER 2D HATCH WITH AROUND 98,0000 MILES FOR $14,000 WITH WARRANTY IN IVRINGTON, NJ FROM SPRINGFIELD AUTO GROUP AUTO SALES. IN JANUARY 2015 I HAD A TUNE UP DONE AND THE MECHANIC REPORTED TO ME AFTER DOING A ENGINE DIAGNOSTIC TEST THAT THERE WAS A PROBLEM WITH MY IMMEDIATELY REPORTED THE PROBLEM TO MY WARRANTY COMPANY THAT WAS PROVIDED THROUGH MY THE CAR LOAN COMPANY CREDIT ACCEPTANCE. THE WARRANTY COMPANY REFUSED TO PAY FOR ENGINE TO BE DROPPED OUT OF THE CAR TO FIND OUT WHAT THE PROBLEM WAS. THEY ADVISE ME THAT I WOULD HAVE TO PAY FOR THE ENGINE TO BE DROPPED OUT OF THE CAR TO BE AND CHECKED OUT BEFORE THEY PAY FOR ANYTHING. IN OCTOBER 2015 THE MINI COOPER ENGINE FINALLY BROKE DOWN WHILE DRIVING I HAD TO PULLED IT OVER WHILE DRIVING UP ROUTE 280. THE WRECKER SERVICE TOOK THE MINI TO A MECHANIC. THE MECHANIC STATED THE TIMING CHAIN HAD BROKE AND THERE WAS MAJOR ENGINE DAMAGE AND THE REPAIR BILL WILL BE FROM 2K TO REBUILD THE ENGINE AND 8K FOR A NEW ONE AND I STILL OWN 11K TO BANK FOR THE CAR. THE CAR HAS APPROXIMATELY 106K MILES ON IT. I'VE HEARD OF A LOT OF COMPLAINTS WITH THOSE MINIS WITH THOSE SAME ISSUES HAPPENING ANYWHERE FROM 30K MILES TO OVER 100K MILES FROM 2007-2010 MODELS. NOTHING ELSE HAS BEEN SPENT ON THE CAR FOR REPAIR. I'M NOT WASTING ANYMORE MONEY ON THAT JUNK MINI COOPER. IT'S TO LATE FOR THE LEMON LAW TO BE APPLIED. CAN ANYTHING GET DONE SO THAT I CAN IMPLEMENT A LAWSUIT AND RECEIVE ANY MONEY FOR THAT FROM BMW OR AND THE DEALER OR IS IT A WASTE OF TIME? THANK YOU IN ADVANCE. *TR

THE SEAT OCCUPANCY SENSOR MALFUNCTIONS. THE PASSENGER SIDE AIRBAG MAY NOT DEPLOY EVEN IF THE PASSENGER SIDE SEAT IS OCCUPIED. THE AIRBAG LIGHT SOMETIMES STAYS ON, WHILE SOMETIMES GOES AWAY. MINI HAS RECALLED SEVERAL CARS FOR SEAT OCCUPANCY SENSOR MAT FAULT BUT MY CAR ISN'T ON THE LIST. THE LIGHT STAYS ON WHEN VEHICLE IS STATIONARY AND ALSO WHILE RUNNING. I'M UNABLE TO USE THE PASSENGER SEAT FOR SAFETY CONCERN. THE AIRBAG LIGHT GOES AWAY ON ITS OWN AS WELL BUT TURNS BACK ON WITHIN A FEW MILES.

I BOUGHT THIS CAR USED WITH 86,100 MILES ON IT. WHEN DRIVING WITHIN THE FIRST 500 MILES, THE AIRBAG LIGHT AND SEAT BELT RESTRAINT SYSTEM INDICATED ON MY DASH (BOTH THE TACHOMETER AND THE SPEEDOMETER). AN ALERT FOR THE AIRBAG APPEARS AS AN ICON ON THE TACHOMETER. I TOOK THE CAR TO THE DEALERSHIP WHO INDICATED THE AUTO GOT WET WHICH CAUSED THE AIR BAG MODULE TO FAIL, WHICH NOW NEEDS REPLACEMENT AT A RIDICULOUSLY HIGH COST.

THE MILEAGE ON THE VEHICLE 16600MILES. THE WARNING LIGHT FOR THE FRONT PASSENGER AIRBAG GOES ON INTERMITTENTLY. THE LIGHT FOR THE FRONT PASSENGER AIRBAG ILLUMINATES "OFF". TOOK TO DEALERSHIP AND FOUND THE PASSENGER SEAT MAT FAULTY. STARTED FLICKERING WHILE DRIVING BUT NOW THE LIGHT IS ON CONSTANTLY WHEN START CAR AND DRIVING. I HAVE READ THAT THERE IS A RECALL FOR THIS PROBLEM FOR VEHICLES MANUFACTURED UP TO JULY 2008. MY MINI S SHOWS A PRODUCTION DATE 8/01/08. I HAD THIS CAR BUILT TO MY SPECIFICATION IN JULY 2008. I HAVE PAID FOR THE PART BECAUSE I BELIEVE THIS IS FOR THE SAFETY FOR WHOM EVER RIDES WITH ME BUT THE PART IS ON BACKORDER AND WE ARE WAITING FOR IT TO ARRIVE FROM GERMANY. BMW/MINI HAVE NOT RESOLVED THE ISSUE IF IT IS STILL HAPPENING. THE COST TO REPAIR IS APPROX.$ 2153.00. IF I WAIT TILL I GET A RECALL AND THERE IS A FATALITY.....? IF AT A LATER DATE A RECALL IS MADE FOR MY VEHICLE CAN I GET THE FULL COST REIMBURSED?

PURCHASED AT 61,000 MILES 9/9/14; HAD SYNTHETIC OIL CHANGE 5/15; 9/29/15 CAR BEGAN TO HAVE A RATTLE BUT UNSURE IF IT WAS FRONT OF CAR OR BACK OF CAR. RATTLING STOPPED ON ACCELERATION. NO WARNING LIGHTS CAME ON. 10/4/15 CAR DIED AT 69,362 MILES WHILE DRIVING ON A TWO LANE ROAD ON A CURVE. WAS ABLE TO COAST TO GETTING HALF THE CAR OFF THE ROAD. BYPASSERS PUSHED ME OFF THE REST OF THE WAY. TOWED TO MECHANIC WHO SAID IT WAS THE TIMING CHAIN GUARD THAT SPLIT OFF. CALLED MINI THEY SAID THEIR DEALERSHIP SERVICE DEPT HAD TO LOOK AT IT. HAD IT TOWED TO OH 70 MILES AWAY. THEY TOLD ME I HAD AN OIL LEAK WHICH CAUSED THE FOLLOWING TO BE DAMAGED - CRANK SHAFT, HARMONIC BALANCER, CYLINDER HEAD, TIMING CHAIN AND GUARD AND MAYBE OTHER STUFF BUT THEY COULDN'T TELL WITHOUT FURTHER EXAMINATION. TOLD $5,000 PLUS TO FIX, BUT I SEE MINI ESTIMATE STATES $3,500-4,500. MY LOCAL MECHANIC FOUND NO EVIDENCE OF AN OIL LEAK CAUSING THE TROUBLE, NOR DID I HAVE AN OIL SPOT WHERE I PARKED MY CAR IN THE GARAGE OR WORK PARKING LOT. NO OIL OR ENGINE LIGHT CAME ON.

I WANT TO KNOW WHEN RECALL 15V-205 IS GOING TO BE IMPLEMENTED. MY CAR IS AFFECTED BY THIS RECALL AND I WAS NOTIFIED BY MINI USA IN JUNE. MY AIRBAG LIGHT HAS BEEN ON FOR 5 MONTHS AND MINI SAYS IT STILL DOES NOT HAVE THE PARTS TO FIX THE PROBLEM. I CONSIDER THIS TO BE A REASONABLE PERIOD OF IME.

TL* THE CONTACT OWNS A 2008 MINI COOPER S. THE CONTACT STATED THAT WHILE PARKED, THERE WAS AN ABNORMAL BURNING OIL ODOR FROM THE VEHICLE. THE FAILURE RECURRED CONSTANTLY. THE CONTACT PARKED THE VEHICLE AND NOTICED OIL LEAKING ONTO THE GROUND. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS MADE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 59,000.

PASSENGER AIRBAG LIGHT SAY LITE EVEN THOUGH NO ONE IS SEATED IN THE PASSENGER SEAT. DEALER SAID KNOWN ISSUE BUT NOT PART OF RECALL. QUOTED A VERY HIGH PRICE TO HAVE REPAIRED.

TAKATA RECALL?? THE SEAT OCCUPANCY SENSOR MALFUNCTIONS - 3 WARNING LIGHTS - ALWAYS ON. TOOK MINI INTO DEALERSHIP FOR THIS PROBLEM ON 9/17/15. THEY DIAGNOSED: J# 1 511MZOTHERDIAG GENERAL DIAGNOSIS VEHICLE NEEDS RIGHT SEAT WEIGHT SENSOR REPLACED. PART NEEDS TO BE ORDERED - $1493.47 PART COST - CUSTOMER ADVISED. NEITHER BMW/MINI CORPORATE OR THE DEALERSHIP CAN SAY WHEN THE REPLACEMENT PART WILL BE AVAILABLE - NOR CAN THEY GUARANTEE OCCUPANT SAFETY - AIRBAGS MAY NOT DEPLOY THERE IS AN ACCIDENT. THE MILEAGE ON THE MINI IS 26,959. WHEN IS THIS VEHICLE TO BE INCLUDED IN THE RECALL? AND WHEN WILL THE PARTS BE AVAILABLE TO FIX IT?

TL* THE CONTACT OWNS A 2008 MINI COOPER. THE CONTACT STARTED THE VEHICLE AND THE FRONT PASSENGER'S SIDE AIR BAG WARNING INDICATOR ILLUMINATED CONTINUOUSLY. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC, WHO CONFIRMED THAT THE AIR BAG SENSOR WOULD NEED TO BE REPLACED. THE MANUFACTURER AND DEALER WERE NOTIFIED AND THEY WERE UNABLE TO PROVIDE AN EXPECTED DATE FOR THE PART TO BECOME AVAILABLE. THE APPROXIMATE FAILURE MILEAGE WAS 52,000. THE VIN WAS UNAVAILABLE.

AIRBAG PASSENGER SIDE LIGHT ON W ONLY 25000 MILES ON IT, MECHANIC TOLD ME IT'S A SHORT IN THE WIRING CAUSED BY SUNROOF SLICING INTO IT. SAID HE COULD FIX IT BUT HEADLINER HAS TO COME DOWN AND HE DOESN'T DO THAT KIND OF WORK. CONTACTED MINI USA AND WAS TOLD IT'S OUT OF WARRANTY AND DEALER PROB WON'T FIX IT WITHOUT CHARGE. WHEN SOMEONE GETS KILLED OR MAMED, MAYBE THEY'LL RECALL. COST TO REPAIR ABOUT $5K...

WITHOUT BEING INVOLVED IN ANY INCIDENT, THE AIRBAG AND SEAT BELT WARNING LIGHTS STAY ON. THERE ARE THOUSANDS OF COMPLAINTS ONLINE ON MINIS AND BMWS AROUND A FAULTY AIRBAG/PASSENGER SEAT SENSOR AND IT APPEARS TO BE A MANUFACTURING DEFECT THAT COULD BE RISKING MANY LIVES. MINI NEEDS TO DIAGNOSE/INVESTIGATE AND EXTEND RECALLS TO ALL VEHICLES THAT HAVE FAULTY MANUFACTURING.

WHILE SITTING AT A RED LIGHT THE ENGINE SHUT OFF AND WOULD NOT START, CAR HAD TO BE TOWED. A FEW DAYS LATER IT WAS FOUND THAT THE TIMING CHAIN HAD BROKE. WITH ONLY 69,000 MILES IT IS UNHEARD OF THAT A TIMING CHAIN BREAKS. THE REPAIR COST WAS $5159.60.

MY AIRBAG LIGHT CAME ON SO I SCHEDULED AN APPOINTMENT WITH MINI DEALER. THEY INFORMED ME THAT THE PASSENGER SIDE OC3 MAT SENSOR NEEDED REPLACED. THEY INFORMED ME THAT THERE IS NO RECALL FOR IT AND MY CAR IS NO LONGER UNDER WARRANTY. THE COST TO REPLACE IS GOING TO BE $1,454.52. AFTER LOOKING ONLINE AT VARIOUS FORUMS, I HAVE FOUND HUNDREDS OF OTHERS WHO ARE EXPERIENCING THE SAME PROBLEM AT RANDOM MILEAGES, ANYWHERE FROM 30,000 - 150,000 MILES. IF THIS SENSOR, WHICH IS A MAJOR SAFETY ISSUE, KEEPS FAILING ON HUNDREDS OF VEHICLES, THIS PART SHOULD BE RECALLED AND FIXED AT THE MANUFACTURES EXPENSE. HOW CAN THEY EXPECT A CUSTOMER TO PAY OVER $1,400 TO REPLACE A SENSOR THAT IS JUST GOING TO FAIL AGAIN IN A SHORT TIME, NOT TO MENTION PUTTING LIVES AT RISK? THIS ISSUE HAS BEEN GOING ON FOR SEVERAL YEARS NOW WITHOUT CORRECTION. PLEASE RECALL THIS PART.

WHEN STARTING CAR, I GET A GRINDING, RATTLING NOISE FROM THE ENGINE. I HAVE BEEN TOLD THIS IS THE CHAIN TENSIONER ON THE CAR

TL* THE CONTACT OWNS A 2008 MINI COOPER S. WHILE DRIVING APPROXIMATELY 70 MPH, THE VEHICLE BEGAN TO DECELERATE AFTER THE CHECK ENGINE WARNING INDICATOR ILLUMINATED. THE CONTACT COASTED THE VEHICLE TO THE SIDE OF THE ROAD. THE VEHICLE WAS POWERED OFF AND BACK ON AND WAS ABLE TO BE DRIVEN; HOWEVER, THE VEHICLE WOULD NOT ACCELERATE PAST 55 MPH ON A 70 MPH HIGHWAY. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO DIAGNOSED THAT ONE OF THE CYLINDERS FAILED AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 62,000.