2011 MINI Cooper Engine Problems

There are no open recalls on my car. I am needing physical proof/documentation that the recall part has been replaced. The car is having issues stalling/losing power while driving. The dealership claims there is nothing wrong with the car and if they can't recreate failure then the car is deemed fine to drive. This car was purchased for my 16yr old son as a daily driver. After multiple weeks of the car being at The Mini of Tempe Dealership, they released the car back to me because there is "nothing wrong" with the car. I took it to another specialized Mini mechanic in the area for a second opinion. This mechanic states the cause of intermittent failure is from the Auxillary Coolant Pump for the Turbo. This is the same part that was a safety recall for potential fire. I have no record of this part ever being replaced. As described in the recall, the car is at risk of fire. Recall campaign #[XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Changed out the battery and now my windows and lights and locks are not working

EXHAUST VANOS SOLENOID FAILURE 06/12/2019. THIS IS A COMMON ISSUE TO MINI'S AND BMW'S THAT OCCURS ON A REGULAR BASIS WHICH INTERRUPTS THE POLLUTION CONTROL SYSTEM. BMW WHO MANUFACTURES THE PART HAS EXTENDED THE WARRANTY FOR THIS PART ON BMW'S TO 10 YEARS BUT HAS NOT YET ADDRESSED ALL THE ISSUES THAT MINI OWNERS HAVE HAD WITH THE PARTICULAR PART. THERE ARE TWO IN THE ENGINE AND THEY ARE IDENTICAL (INTAKE/EXHAUST) COST TO REPLACE IS OVER $500. WHY DOES BMW GET A REPLACEMENT AND MINI OWNERS HAVE TO PAY. THE CAR GOES INTO A LIMP MODE WHEN FAILURE OCCURS, SO STILL DRIVABLE BUT AT REDUCED POWER. THIS IS A COMMON ISSUE AND PREVALENT IN BOTH MINI FORUMS AND BMW FORUMS. THE WARRANTY SHOULD BE EXTENDED FOR MINI OWNERS PART # 11-36-8-610-388. IT IS A DEFECTIVE DESIGN BY THE MANUFACTURER.

THERMOSTAT & HOUSING PLUS WATER PUMP HAVE BEEN REPLACED. CAR STILL RUNS TEMPS IN EXCESS OF 230 BEFORE FAN WILL COME ON. I AM FEARFUL THE ENGINE MAY GET ON FIRE DUE TO HEAT AND THEREFORE, I AM NOT DRIVING IT. TOOK IT TO THE DEALER AND THEY REMOVED 2 RELAYS, ONE OF WHICH CONTROLLED THE ENGINE FAN. I REPLACED THE RELAY.

2011 MINI COOPER. CONSUMER WRITES IN REGARDS TO ELECTRIC COOLANT PUMP SAFETY RECALL. *LD *JS

WHILE DRIVING ON THE HIGHWAY, THE TIMING CHAIN TENSIONER BROKE, CAUSING NUMEROUS AND SEVERAL THOUSAND DOLLARS IN REPAIR COSTS.

HALF ENGINE LIGHT COME ON DURING DRIVING WHILE CHANGE LANE ON THE FREEWAY, AND GOING UP HELL. NOT LOSING POWER TURBO WORKING FINE. DEALER REPLACE VACUUM PUMP BUT NOT FIX THE PROBLEM. HALF ENGINE LIGHT COME OFF WHEN YOU DRIVE FROM PARK WHILE PRESSING THE GAS PEDAL INCREASING RPM TO 15OO, ON THE FREEWAY OR UP ON THE HELL THE HALF LIGHT COME BACK ON. DEALER CAN NOT DIAGNOSE THE PROBLEM.

TL* THE CONTACT OWNS A 2011 MINI COOPER. THE CONTACT STATED THAT THE VEHICLE STALLED INTERMITTENTLY. THE CHECK ENGINE INDICATOR ILLUMINATED BEFORE AND AFTER THE FAILURE. THE DEALER AND MANUFACTURER WERE NOT NOTIFIED OF THE FAILURE. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 56,000. THE VIN WAS NOT AVAILABLE.

TIMING CHAIN ISSUE LEAD TO OIL LEAK IN ENGINE. 2008-2010 MODELS HAVE BEEN RECALLED AFTER A CLASS ACTION LAWSUIT WAS FILED FOR THE SAME ISSUE. MY MODEL IS ONE YEAR OUTSIDE THE OFFICIAL BMW RECALL. I TOOK MY CAR IN FOR ROUTINE MAINTENANCE. THAT'S WHEN THE DEALERSHIP INFORMED ME I COULDN'T DRIVE MY CAR WITHOUT THE REPAIRS. THE COST OF THE REPAIR WAS NEARLY $2000 SINCE I AM ALSO OUTSIDE OF MY WARRANTEE PERIOD. I HAVE READ THAT IF THIS ISSUE WASN'T FOUND, IT COULD LEAD TO ENGINE FAILURE EITHER WHEN IDLE OR DRIVING. I AM LUCKY NOT TO HAVE SUSTAINED INJURIES OR INCUR FURTHER COSTS. OTHER 2011 MINI COOPER DRIVERS SHOULD BE MADE AWARE SINCE THERE HAS BEEN NO OFFICIAL WARNING FROM BMW. BMW SHOULD BE HELD ACCOUNTABLE.

THERE IS A LOUD CLANGING COMING FROM THE MOTOR, THE ENGINE LOST OIL, IT IS BEING TOWED TO A MECHANIC - THE DIAGNOSIS IS A BAD TIMING CHAIN TENSIONER, THE CAR HAS ABOUT 65,000 MILES, THERE WAS A RECALL FOR 2008 - 2010 MINIS FOR THIS PROBLEM

LETTER FROM SENATOR FLAKE ON BEHALF OF CONSTITUENT RE 2011 MINI COOPER. (PLEASE RESPOND BY FAX OR ELECTRONIC MAIL: BOB_BRUBAKER@FLAKE.SENATE.GOV). *SMD THE CONSUMER RECEIVED EXTREMELY, PAINFUL , SCARING BURNS FROM THE HOT EXHAUST PIPE WHILE LEANING OVER TO RETRIEVE ITEMS FROM THE TRUNK. THE CONSUMER STATED IF ONE IS FACING THE CENTER TRUNK, THE HOT EXHAUST PIPE IS LOCATED DIRECTLY TO THE RIGHT, APPROXIMATELY 10 INCHES OFF THE GROUND. THE METAL IS NOT COATED TO OFFER PROTECTION. *JB UPDATED 03/07/16.*JB UPDATED 04/11/16.*JB

MINI COOPER 2011 OVERHEATED AND BLEW OFF RADIATOR HOSES WHILE DRIVING ON FWY- ENGINE DAMAGE AND HEAD REPLACEMENT.. DEALER IS SAYING BOTTOM RADIATOR HOSE MUST HAVE COME OFF AND LEAKED COOLANT. JUST HAD IT SERVICED. *TR

TL* THE CONTACT OWNS A 2011 MINI COOPER. THE CONTACT STATED THAT WHILE ATTEMPTING TO REVERSE FROM A RESIDENTIAL GARAGE, BLACK SMOKE EMITTED FROM UNDER THE HOOD. THE CONTACT WAS ABLE TO PUT THE FIRE OUT UNDER THE HOOD WITH A GARDEN HOSE. THE FIRE DEPARTMENT WAS NOT CONTACTED AND NO INJURIES WERE REPORTED. THE VEHICLE WAS TOWED TO THE DEALER WHO WAS UNABLE TO DIAGNOSE THE FAILURE. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE VIN WAS NOT AVAILABLE. THE FAILURE AND THE CURRENT MILEAGE WAS 3,000.

I HAVE BEEN HAVING PROBLEMS WITH MY 2011 MINI COUNTRYMAN S ALL4 IN REGARDS TO CHECK ENGINE INDICATOR. I HAVE TAKEN MY CAR FOR SERVICE OF THE CHECK ENGINE INDICATOR 4 TIMES NOW. EACH TIME IT HAS BEEN CAUSED BY FUEL IN THE CHARCOAL FILTER SYSTEM. EACH TIME I HAVE BEEN TOLD IT IS FROM OVERFILLING THE FUEL TANK, WHICH I DO NOT DO. I AM CAREFUL TO STOP FUELING THE FIRST TIME THE PUMP KICKS OFF, ESPECIALLY AFTER THE FIRST TIME THIS HAPPENED. THE FIRST 2 TIMES THE DEALER CHANGED THE CHARCOAL FILTER AT NO COST. THE 3RD TIME THEY CHANGED THE FUEL TANK AT NO CHARGE. I HAD NO PROBLEMS FOR ABOUT A YEAR, AND THE CHECK ENGINE INDICATOR CAME ON AGAIN ON 12/18/13, I SCHEDULED SERVICE AS SOON AS POSSIBLE. TURNS OUT THAT FOR THE 4TH TIME FUEL WAS IN THE CHARCOAL FILTER. THE DEALER CAN'T SEEM TO FIND THE SOURCE OF THE PROBLEM AND THIS IS VERY ANNOYING TO SAY THE LEAST. WOULD LIKE TO TURN IN THE CAR NOW, LEASE ENDS IN 7 MONTHS, AND STAY AWAY FROM BMW AND MINI FROM NOW ON!! *TR

TL* THE CONTACT OWNS A BMW 2011 MINI COOPER. THE CONTACT WAS DRIVING 50 MPH WHEN THE VEHICLE EXHIBITED A LOUD CLUNKING NOISE WITH THE ILLUMINATION OF ALL OF THE WARNING LIGHTS. THE VEHICLE BEGIN SMOKING AS HE PULLED TO THE SIDE OF THE ROAD. THE CONTACT WAS ABLE TO EXIT THE VEHICLE JUST AS IT IGNITED INTO FLAMES, FOLLOWED BY AN EXPLOSION. THE POLICE WERE CALLED AND A REPORT WAS FILED. THERE WERE NO INJURIES FROM THE EXPLOSION. THE VEHICLE WAS THEN TOWED BY THE STATE. THE MANUFACTURER WAS CONTACTED AND THEY ADVISED HIM THAT THEY WOULD GET BACK TO HIM AT A LATER DATE. THE FAILURE MILEAGE WAS APPROXIMATELY 120.

2011 MINI COOPER. CONSUMER STATES VEHICLE BROKE DOWN WHILE TRAVELING *TGW THE CONSUMER STATED THE ENGINE FAILED WHICH CAUSED OIL TO LEAK UNDER THE HOOD. BMW REFUSED ANY ASSISTANCE ON THE GROUNDS THE VEHICLE HAD AN OVER REV-MISSED SHIFT THAT WAS AN AFTER MARKET PART THE CONSUMER HAD INSTALLED. AN INSPECTION SHOWED A BORE SCOPE WAS USED TO VERIFY THAT THERE WAS DAMAGE TO THE CROWN OF ONE PISTON INDICATING THAT DURING THE OVER REV, A VALVE HAD COME IN CONTACT WITH THE PISTON. *JB