2021 Nissan Leaf Electrical System Problems

I own a 2021 Nissan Leaf subject to open recall R25C8 (NHTSA Campaign 25V655) for fire risk during Level 3 DC fast charging. The recall was issued October 2025. Nissan’s stated remedy target was late March 2026. As of today, April 6, 2026, no remedy has been provided. The affected component is the lithium-ion battery pack and its charging system. The vehicle is equipped with a CHAdeMO DC fast charging port, which I cannot safely use due to the documented fire risk. I am not avoiding this feature by choice – I am avoiding it because Nissan’s own recall identified it as a safety hazard. On April 6, 2026, I encountered a DC fast charging station and chose not to attempt charging due to the active recall warning, and due to reports that charging networks have begun refusing sessions on recalled vehicles. Diagnostic software shows my battery’s internal resistance index (Hx) at 71%, disproportionately low relative to State of Health at 87.5%. The vehicle is also consuming battery charge at an accelerated rate during highway driving, with approximately 50% of charge depleted over 30 to 40 miles. I am concerned that a software-only remedy will be inadequate for a battery with this level of internal resistance degradation, as software cannot compensate for the absence of active thermal management hardware. No dealer has confirmed the condition. I am filing to document loss of vehicle functionality, Nissan’s missed remedy deadline, and concern about remedy adequacy.

I want to be clear about why I opened this case. Per Nissan’s own recall documents, the software update does not repair the defective battery cells, it only detects the issue and may disable the vehicle to prevent a thermal event. Level 3 charging remains unusable, and the underlying defect is still present. Because of this, I am requesting a repurchase or a replacement vehicle. If they say the software will “fully correct the condition”

See attached document for complaint. I purchased a certified pre-owned Nissan Leaf SV Plus on [XXX] specifically for the larger battery capacity and the ability to use a DC fast charger, as this would allow me to drive my electric vehicle wherever I needed to go, including regular trips to Seattle from Mount Vernon. I was notified by Nissan in September 2024 that, due to the possibility that the battery could catch fire while using a DC fast charger, that my vehicle’s battery had been recalled and was instructed not to use a DC charger. They stated a remedy would be available in October 2024. When the date came and went, I contacted Nissan about the issue and the date was pushed to November 2024. Then December 2024, then spring 2025, then fall 2025. After numerous contact attempts to replace my battery, I initiated a buyback with Nissan on 10/16/25. I unexpectedly required medical treatment in October and contacted the Nissan rep on 10/28/25 to inform them of my medical issue and asked they contact my husband. My husband also attempted to contact the rep w/ no response. After coming back home, I found out that my claim was closed—Nissan said I failed to respond. Now, my doctors want me to receive further medical treatments in Seattle 3-5 times per week. At this time, my vehicle cannot transport me to the required appointments since I cannot use the fast charger. My medical treatment is delayed until Nissan resolves this! INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

*High Voltage Battery defect/failure - this is what was believed to be the issue when it was towed to the dealership. What is left of it is available for inspection at the dealership for now, however the insurance may take it to a salvage yard since the fire department finished their investigation. *While at the dealership after they spent the day trying to recreate what happened they parked it and planned to try again the next day, then someone walked by and saw smoke coming from the car and called 911. They called it a thermal runaway and it burned for hours before being moved to a safer, emptier lot where it was covered in thousands of pounds of sand. The night before the mileage range dropped roughly 70%, unaware of the recall in our mail that hadn't been opened we stopped to try to charge so we could get home. Thankfully none of the chargers worked since the recall was for a potential fire if plugged into a level 3 charger. We tried to drive home only to end up on the side of the road in total system failure. Police sent incident management to get us to safety. If we had made it home we are told this could have caught our home on fire and would likely have blown up our house and taken neighbors houses out as well. It could hurt more people or structures while they tried to recreate the problem. I understand the dealership had $20K in damages from the fire on top of which my car is clearly a total loss. Homes & Businesses nearby had to be evacuated. *Yes, what is left of the car has been inspected by the county fire marshall, insurance co. Police were called, but no investigation. When I called consumer affairs at Nissan, I spoke to 3 different people who said there was nothing they could do. *We had one other time 3 weeks earlier that the range dropped significant, we got home plugged it in and it seemed fine. The only warnings said we were low on miles and to stop to charge which would have made things worse, could have killed us if they had worked.

I can’t charge the car. I live in a city without a garage. I 100% need level 3 ChadEMO charging to use this car. Please pressure the automaker to fix it or buy back the vehicle as I cannot use the car. This is unacceptable from Nissan. Lemon!

The battery has had a recall since October 2025 with no repair update at all. The battery degeneration has cause serious issues and has almost left me stranded multiple times. I haven’t been able to charge at most charging stations due to the limiting of fast chargers and it is very time consuming when I do.

As described in recall 25V-655, lithium deposited have accumulated in the HV battery of my 2021 Nissan Leaf. I haven't used L3 charging since I received the recall notice, but the car often won't charge even on L1 charging. The state of health of the HV battery is still 86% but the internal resistance of the HV battery is down to 44% due to the lithium deposits. The local Nissan dealership won't touch it because Nissan hasn't provided a remedy. It has been over 5 months since I received the recall notice. That doesn't seem very timely.

Nissan has yet to effectively respond to NHTSA recall 25V-655 concerning a fire hazard when fast charging particular Leaf models including the 2021 model year that I own. As a temporary solution Nissan strongly recommends not to fast charge (Level 3 charge) until a solution is provided (anticipated by Dec. 31 2025). Nissan Customer Service has been unable to respond to my query for a revised date and therefore the safety issue is ongoing for an indeterminable time. Meanwhile the safety issue continues leaving my car in a diminished state of use.

Vehicle battery drains significantly after being charged, passenger wiper will not work impairing visibility, back up camera blurs and fails, bright lights would not turn on, I was in a huge rain storm unable to see. Inability to use level 3 charger is disallowing me to be able to use vehicle due to amount of time to charge and battery drain has caused me to be broken down requiring a tow twice due to inaccurate mileage readings, leaving me stranded at night without access to phone service, placing me in an unsafe area/situation.

I currently have a recall on my Nissan 2021 Leaf SV Plus. There is an issue with the level 3 charging which can result in fire to the vehicle. As a result, I’m unable to rapid charge. Nissan has failed to remedy the issue or offer any attempts to fix this recall. I’m unable to charge my vehicle at this time.

The contact owns a 2021 Nissan Leaf. The contact received notification of NHTSA Campaign Number: 25V655000 (Electrical System); however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The dealer was not made aware of the issue. The manufacturer was not made aware of the issue. The contact had not experienced a failure.

The high-voltage battery on my 2021 Nissan LEAF is subject to Recall 25V-655/R25C8. The recall notice states that the battery cells can develop excessive lithium deposits, which increase electrical resistance and can cause rapid battery heating during Level 3 fast charging. Nissan instructs owners not to use Level 3 charging at all until a “remedy” is available. I have attempted to have the car fixed at two local dealerships, with both stating that they do not have a fix available. The documented "fix" is a software update that slows or disables Level 3 charging, which does not resolve the issue, and only disables the vehicle's intended use.

The contact owns a 2021 Nissan Leaf. The contact received notification of NHTSA Campaign Number: 25V655000 (Electrical System); however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not informed of the failure. The contact had not experienced a failure; however, due to the recall, the vehicle was unable to be fully charged using the fast charger.

Took car to dealership to charge. Got home and an hour later the battery ignited into a fire. Car was engulfed with smoke ,fire in front of our house. After 4 hours with fire dept trying to put out the fire within battery... it still continued to smoke. Hazmat team came out as well. Total loss after having car less than 30 days that I purchased as dealership.

The contact owns a 2021 Nissan Leaf. The vehicle was taken to a charging station, and while driving at 5 MPH, entering the driveway, the battery burst into flames. There were no warning lights illuminated. The contact stated that the failure was similar to NHTSA Campaign Number: 24V700000 (Electrical System). The police department was on the scene. The fire department attempted to extinguish the fire, but the battery continued to ignite. The fire marshal from Minnesota was contacted for assistance to resolve the matter, and the fire department had taken the battery to a gravel pit. The local dealer was not contacted. The vehicle was not diagnosed or repaired. The manufacturer was not notified of the failure. The approximate failure mileage was 60,000.

The contact owns a 2021 Nissan Leaf. The contact stated that while driving at an undisclosed speed, the vehicle shut off. The contact was able to pull over to the side of the road. The vehicle was towed to the nearest dealer, where it remained for a month. The dealer replaced an unknown battery component. The vehicle was repaired. Additionally, the contact stated that the vehicle was seldom driven for short distances after the incident, due to safety concerns. The contact later received notification of NHTSA Campaign Number: 25V655000 (Electrical System); however, the part to do the recall repair was not yet available. Nucar Nissan of Norwood (525 Boston Providence Hwy, Norwood, MA 02062) and Quirk Nissan (600 Southern Artery, Quincy, MA 02169) were contacted and confirmed that the recall remedy was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was notified of the failure. The failure mileage was approximately 25,000.

My 2021 Nissan Leaf battery does not hold charge for more than 80 miles. Its has a chademo charger and my daughter could not get to next charger. The car battery has a system issue. The car main battery cells keep dying. Nissan replaced 4 cells last year and now more cells need replacement. These cars are becoming hazards on road as they loose charge state and its not possible to get to the next charging point even on a 230 mile journey. Nissan is aware of the issue but not willing to help proactively. I have been sold a lemon. I know of atleast 4 other families who have same model year cars and all have faced issue with the battery. I would request you all to please look into the matter and make sure the manufacturer is held accountable for not taking action proactively. They are cheating the consumers.

The contact owns a 2021 Nissan Leaf. The contact received notification of NHTSA Campaign Number: 25V655000 (Electrical System); however, the part to do the recall repair was not yet available. The contact stated that occasionally, while driving at various speeds, the vehicle shifted in Turtle Mode, preventing the vehicle from exceeding 30 MPH. The contact stated that there was a message for the EV Battery failure and to take the vehicle to the dealer for further analysis. The Turtle Mode warning light was illuminated. The vehicle was taken to a local dealer, where it was diagnosed; however, the failure was not identified or replicated. The vehicle was not repaired. The manufacturer was possibly notified by the local dealer about the failure. The failure mileage was approximately 40,000.

From time to time the BCM (body control module) is stuck in a mode which disables the electric door locking and unlocking as well as the electric window lifters. This state can be fixed by disconnecting and reconnecting the vehicle battery. This issue happened two times recently. It appears to be a SW related issue as other functions of the BCM are still operational. E.g., the electric rear view mirror adjustment was still operational. The risk of this issue is that the door locks will not be unlocked automatically in case of a crash. Also the windows cannot be opened as an alternative escape opening in case the doors are blocked after an accident.

The contact owns a 2021 Nissan Leaf. The contact stated that while charging the Lithium battery, the message that the battery had overheated was displayed. While driving on the freeway, the battery rapidly lost charge without warning. The vehicle decelerated to 5 MPH before stalling in the middle of the road. The contact ran across a four-lane highway to safety. The vehicle was later towed to the local dealer. The contact received information about NHTSA Campaign Number: 25V655000 (ELECTRICAL SYSTEM) and was informed that parts were not yet available. The vehicle was charged at the dealer and driven to the residence the following day. The contact indicated that the vehicle had experienced the failure listed in the recall. The failure mileage was 30,000.