2001 Nissan Xterra Fuel System Problems

THE TERMINAL STRIP ARE CORRODE AND CAN'T BE REPLACED BECAUSE THE PUMP GOT DAMAGE BY THE CORROSION OF THE TERMINAL, NOW NISSAN DO NOT WANT TO REPLACE THE PUMP. IS NOT MY FAULT THAT THEY USING PARTS THAT CAUSING THOSE TYPE OF PROBLEM. I CAN'T AFFORT TO PAY FOR THE PUMP PLUS LABOR.

TL* THE CONTACT OWNS A 2001 NISSAN XTERRA. THE CONTACT STATED WHILE DRIVING APPROXIMATELY 30 MPH, THE ENGINE STALLED WITHOUT ANY WARNING. THE VEHICLE FAILED TO RESTART AND WAS TOWED TO AN INDEPENDENT MECHANIC. THE TECHNICIAN DIAGNOSED THAT THE FUEL PUMP SENDING UNIT WAS CORRODED AND NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE DEALER WAS CONTACTED WHO REFUSED TO PROVIDE ANY ASSISTANCE SINCE THE VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN ID NUMBER 04V230000 (FUEL SYSTEM, GASOLINE). THE MANUFACTURER WAS NOTIFIED OF THE PROBLEM. THE APPROXIMATE FAILURE MILEAGE WAS 140,000.

TL* THE CONTACT OWNS A 2001 NISSAN XTERRA. THE CONTACT STATED THAT WHILE DRIVING 65 MPH, THE VEHICLE STALLED WITHOUT WARNING. THE CONTACT WAS ABLE TO COAST ONTO THE SHOULDER WHERE IT WAS TOWED TO THE DEALER. A DIAGNOSTIC WAS PERFORMED WHICH LOCATED THE FAILURE AT THE FUEL SENDING UNIT. THE CONTACT ALSO STATED THAT NHTSA CAMPAIGN ID NUMBER: 04V230000 (FUEL SYSTEM, GASOLINE), WAS PERFORMED ON THE VEHICLE BUT THE REPAIR DID NOT CORRECT THE FAILURE. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE VEHICLE WAS TAKEN BACK TO THE DEALER, WHO SEALED THE FUEL SENDING UNIT AS A REMEDY. THE FAILURE MILEAGE WAS 87,128 AND THE APPROXIMATE CURRENT MILEAGE WAS 87,130. ..UPDATED 06/28/13 *BF THE CONSUMER STATED THE RECALL REPAIR FAILED . THE VEHICLE WAS TOWED BACK TO THE DEALER AFTER THE FAILURE, THEN THE PART WAS REPLACED. THE MANUFACTURER REFUSED TO ASSIST WITH THE COST. UPDATED 07/2/2013 *JS

MY 2001 NISSAN XTERRA SHUTS OFF WHILE IN MOTION. ALSO, WILL NOT START AT TIMES. OVERALL, CAR HAS SHUT OFF OR NOT STARTED PROBABLY ABOUT 10 OR SO TIMES. ACCORDING TO NISSAN THE RECALL ON THIS PART WAS ALREADY FIXED BEFORE I OWNED THE CAR (I BOUGHT IT PREOWNED)....BUT OBVIOUSLY IT IS THE SAME PROBLEM AGAIN THEREFORE THEY HAVE NOT CORRECTED THE PROBLEM AT ALL. HOWEVER, SINCE THEY REPAIRED IT ONCE THEY HAVE WASHED THEIR HANDS OF IT. *TR

TL*THE CONTACT OWNS A 2001 NISSAN XTERRA. THE VEHICLE WAS TAKEN TO BE REPAIRED UNDER A RECALL. THE REMEDY WAS PERFORMED BY SILICONE SPRAY BEING SPRAYED OVER THE STRAP SENDING UNIT, WHICH RESTS ON THE FUEL PUMP AND INDICATES HOW MUCH FUEL THE VEHICLE IS USING. AFTER HAVING THE VEHICLE REPAIRED, WHILE DRIVING APPROXIMATELY 65 MPH, THE VEHICLE SUDDENLY STOPPED. THE CONTACT FEELS THAT THIS IS A SAFETY ISSUE BECAUSE A CRASH COULD HAVE OCCURRED. HE FEELS THAT THE REPAIR WAS NOT FIXED PROPERLY, BUT COVERED UP INSTEAD. HE WOULD LIKE THE REPAIR WORK INVESTIGATED. THE NHTSA CAMPAIGN ID NUMBER WAS UNKNOWN. THE CURRENT AND FAILURE MILEAGES WERE 92,000.

FUEL SENDING UNIT THAT WAS REPLACED ON 4/25/2005 DUE TO RECALL OF POSSIBLE CORROSION FAILURE FAILED DUE TO CORROSION. *NM

04 V 230 000/FUEL SENDING UNIT: THE MANUFACTURER REFUSED TO SEND THE DEALER THE RECALL PART BECAUSE THE CONSUMER MOVED TO FLORIDA. *JB NISSAN DENIED THE CONSUMER THE REPLACEMENT OF THE FUEL SENDING UNIT. *SC

WHILE DRIVING,THE VEHICLE STALLED THE DRIVER TRIED TO RESTART,BUT WAS UNABLE TO DO SO. THE DRIVER HAD THE VEHICLE TOWED TO THE DEALER FOR INSPECTION. THE MECHANIC INFORMED THE DRIVER THAT THE FUEL PUMP NEEDED REPLACEMENT DUE TO CORROSION. PLEASE FILL IN ADDITIONAL INFORMATION.

WHILE PUMPING GASOLINE AT THE GAS STATION GASOLINE SPLASHED ON THE DRIVER. CONSUMER DROVE THE VEHICLE TO THE DEALER FOR INSPECTION. HOWEVER, MECHANIC WAS NOT ABLE TO DUPLICATE THE PROBLEM. *AK

COMPLAINT CONCERNS THE FUEL TANK SENDING UNIT. MY VEHICLE WENT DEAD ON HWY 131S AT 6:00 IN THE MORNING. ALONE AND OUT OF TOWN. HAD TO BE TOWED ON FLATBED. WHEN TALKING WITH THE LOCAL DEALERSHIP THEY STATED THEY HAVE HAD TO REPLACE THIS PART ON NUMEROUS OCCASIONS. I THEN CALLED MY PRIVATE, USUAL DEALERSHIP I HAVE SERVICE AT AND THEY STATED THEY HAD REPLACED THREE OF THESE IN THE LAST MONTH. THIS NEEDS RECALLED!!*AK

2001 NISSAN XTERRA - I WAS JUST GETTING OFF A BUSY RT. 95 AND MY CAR JUST TURNED OFF - NO POWER STEERING,ETC. I WAS LUCKILY ABLE TO COAST TO THE SIDE OF THE ROAD WITHOUT CAUSING AN ACCIDENT WHERE I HAD TO LEAVE IT OVERNIGHT. CALLED TWO NISSAN DEALERSHIPS THE NEXT DAY AND THEY WERE UNABLE TO FIT ME IN FOR TWO DAYS, SO I NEEDED MY XTERRA FIXED SO I TOOK IT TO AN INDEPENDENT AUTO SHOP. THEY SAID MY FUEL PUMP SENDING UNIT SHORTED OUT WHICH IN EFFECT SHORTED OUT MY FUEL PUMP, BOTH WERE REPLACED - $962 LATER.....I TOOK IT TO THE DEALERSHIP AND THEY WERE WELL AWARE OF THE PROBLEM (I SHOWED THEM THE NISSAN FAULTY PART) AND THEY REFERRED ME TO NISSAN CONSUMER AFFAIRS. I SPOKE WITH SOMEONE THERE AND SHE INVESTIGATED THE PROBLEM AND SAID THEY WEREN'T IN THE POSITION TO REIMBURSE ME B/C THE WORK WASN'T DONE AT THE NISSAN DEALERSHIP, SHE DIDN'T KNOW WHEN THERE WOULD BE A RECALL....I WOULD'VE HAD A GREATER CHANCE OF GETTING MY MONEY BACK IF I TOOK IT TO THE DEALERSHIP. REGARDLESS, IN THE END I PAID $962 FOR A FAULTY NISSAN PART WHICH HASN'T BEEN RECALLED AND HAS THE POTENTIAL TO CAUSE MANY FATAL ACCIDENTS - GO FIGURE!!

FUEL SYSTEM SENDING UNIT FAILED. AS A RESULT, THE VEHICLE BECAME INOPERATIVE. *AK

THE CONSUMER STATED THE FUEL PUMP HANGER/SENDER UNIT HAD A SHORTAGE WITHIN THE FUEL TANK. THE REPAIR WAS MADE BY AN AUTO REPAIR SHOP. PLEASE FEEL FREE TO PROVIDE ANY FURTHER INFORMATION. *JB

FUEL TANK SENDING UNIT FAILED AT 38,800 MILES (OUT OF WARRANTY). A CRACK FORMS IN THE UNIT AND EVENTUALLY CORROSION SETS IN CAUSING A SHORT IN THE WIRING. WHEN THIS OCCURS, THE TRUCK STALLS AND YOU LOSE MOST OF YOUR STEERING AND BRAKING ABILITY. THIS IS A PROBLEM THAT HAS BEEN REPORTED SINCE THE 1999 NISSAN FRONTIER ACCORDING TO YOUR WEB SITE, SO THIS APPEARS TO BE A COMMON ISSUE WITH NISSAN TRUCKS. IT'S TIME FOR AN INVESTIGATION AND RECALL!*AK

VEHICLE STALLED WHILE MAKING A LEFT TURN FROM A STOP OUT OF A PARKING LOT AND WOULD NOT RESTART.

MY GAS TANK NEVER SHOWS FULL WHEN IT IS FILLED. WHEN FILL MY XTERRA WITH GAS, IT OVERFLOWS EVERYTIME UNLESS I MANUALLY STOP THE PROCESS BY GUESSING HOW MANY GALLONS I HAVE PUT IN. AT THAT POINT THE GAS SPLASHES OUT AND OVERFLOWS. THEN WHEN I START MY CAR. THE GAS GAUGE ONLY SHOWS 3/4 TANK FULL, NEVER COMPLETELY FILLED. WHEN I FIRST BOUT THIS VEHICLE IN OCTOBER OF 2000, THIS PROBLEM WAS PRESENT BUT THE DEALERSHIP COULD NOT FIX IT. THEN I READ ABOUT THE RECALL 2 YEARS LATER ON THE INTERNET AND DECIDED TO TAKE IT IN AGAIN. THE SECOND TIME, I TOOK MY XTERRA TO A LOCAL NISSAN DEALERSHIP ABOUT THE RECAL ISSUED BY NHTSA IN 2002 BUT THEYSAID MY VEHICLE WAS NOT PART OF RECALL DUE TO VIN. *AK

I WAS DRIVING MY 2001 XTERRA ON INTERSTATE 495 WHEN THE CAR ABRUPTLY LOST POWER AND STALLED WHILE TRAVELING 65 MPH. AFTER REPEATED ATTEMPTS TO START THE CAR, IT STARTED AFTER 20 MINUTES. I LET THE CAR RUN FOR ABOUT 15 MINUTES BEFORE REENTERING THE HIGHWAY. ABOUT TWO MILES DOWN THE ROAD THE CAR SUDDENLY LOST POWER, STALLED AND WOULD NOT RESTART. I HAD THE CAR TOWED AND A BAD FUEL PUMP/FUEL SENDING UNIT WAS DIAGNOSED. THE FUEL INJECTORS WERE DRY, AS IF THE CAR HAD RUN OUT OF GAS, BUT I HAD THREE QUARTERS OF A TANK. IT IS WELL DOCUMENTED ON THE INTERNET ON NISSAN OWNER'S SITES THAT THE NISSAN FRONTIER AND XTERRAS EXPERIENCE PROBLEMS WITH THE FUEL PUMP SENDING UNITS. THE RESULT OF SUCH FAILURES IS NO GAS DELIVERY TO THE ENGINE, AS IF THE VEHICLE HAS RUN OUT OF GAS. THE FAILURE COMES WITHOUT WARNING AND DOES NOT SEEM TO BE RELATED TO MODEL YEAR. IT IS APPARENT THAT SUCH FAILURES IN A GAS DELIVERY SYSTEM IS A MAJOR SAFETY HAZARD. I BELIEVE NISSAN IS AWARE OF THE PROBLEM BECAUSE IN JANUARY OF THIS YEAR THERE WAS A NATIONAL BACKORDER FOR THIS PART. *NLM

I WAS ON MY WAY HOME FROM WORK AND ON RT17 WHICH IS VERY BUSY AROUND RUSH HOUR WITH TRACTOR TRAILERS AND PLENTY OF CARS, ALL OF A SUDDEN MY 2001 XTERRA STALLED OUT AT THE STOP LIGHT, THEN WOULD NEVER START AGAIN, IT TOOK 30 MINUTES TO GET THE TRUCK OF THE ROAD BECAUSE THERE WAS SO MUCH TRAFFIC, I HAD IT TOWED TO RADLEY CHEVROLET BECAUSE I CALLED NISSAN, AND THEY ADVISED ME MY WARRANTY RAN OUT AND IT WOULD BE AT LEAST 200.00 BEFORE THEY COULD EVEN LOOK AT IT? ONCE TO THE DEALER WHICH MY WARRANTY JUST RAN OUT, AND THEY SAID THERE WAS NOTHING WRONG WITH IT, SO I PAID THE TOW BILL AND TOOK MY CAR, NO MORE THAN AN HOUR LATER I WAS BROKE DOWN AGAIN ON THE ROAD, AND HAD TO PAY ANOTHER TOW BILL, COME TO FIND OUT MY FUEL PUMP WAS MALFUNCTIONING AND THAT WAS THE PROBLEM, $500.00 LATER I AM BACK ON THE ROAD, I COULD NOT UNDER STAND ON SUCH A NEW VEHICLE WITH ONLY 37000 MILES THE FUEL PUMP WOULD GO BAD?????????? *NLM

VEHICLE STOPPED RUNNING ON I-287N NEAR MAHWAH, NJ., POST PRESIDENT'S DAY BLIZZARD. CONDITIONS WERE VERY DANGEROUS DUE TO SEMI TRUCK TRAFFIC AND SNOW/ICE PACK IN EMERGENCY LANE WHICH PREVENTED PULLING VEHICLE ALL THE WAY OFF THE HIGHWAY. STRANDED ON SIDE OF THE HIGHWAY FOR SEVERAL HOURS IN BELOW FREEZING COLD UNTIL NJ STATE POLICE SENT TOW TRUCK. TOWED TO NISSAN DEALER, DIAGNOSED FUEL SENDING UNIT FAILURE PART #250604S415. TEN DAYS LATER, PART IS STILL ON BACK ORDER WITH NO IDEA WHEN IT WILL BE AVAILABLE. *JB

WHEN PUMPING GAS IT WILL NOT CUT OFF, INDICATING THAT TANK IS FULL. HOWER, CAUSING GAS TO OVERFLOW.DEALER CONTACTED.*AK