2005 Saturn Vue Brakes Problems

I HAD JUST RETURNED HOME FROM SHOPPING WHEN I EXPERIENCED A COMPLETE BRAKE FAILURE. FORTUNATELY THE INCIDENT HAPPENED ON MY DRIVEWAY AS I WAS DRIVING UP TO THE FRONT OF MY GARAGE. SINCE I WAS MOVING VERY SLOW I WAS ABLE TO STOP BY SHIFTING THE TRANS INTO "PARK". I LOOKED UNDER THE VEHICLE AND SAW A PUDDLE OF BREAK FLUID ON THE DRIVEWAY AT EACH REAR WHEEL. THE VEHICLE WAS PICKED UP BY A TOWING SERVICE AND DELIVERED TO AUTO-LAB OF TROY, MI 48084. THEIR INSPECTION FOUND THAT BOTH BRAKE LINES AT THE REAR WHEEL CYLINDERS WERE COMPLETELY RUSTED THROUGH WHICH ALLOWED THE FLUID TO SPAY OUT OF THEM WHEN THE BRAKE PEDAL WAS APPLIED.

I WAS DRIVING ON A BUSY HIGHWAY, BRAKING REGULARLY WITH THE STOP AND GO TRAFFIC, MY BRAKES SUDDENLY LOCKED UP ON ME AND I WAS BARELY ABLE TO GET BACK UP TO 50 MPH. EVENTUALLY I WAS CLOSE TO HIGHWAY SPEEDS, BUT THE CAR WASN'T SHIFTING CORRECTLY. THIS HAPPENED A FEW TIMES, AND WE BEGAN REPLACING PARTS ON THE BRAKES. THEN, WHILE DRIVING AGAIN, THE BRAKES LOCKED DOWN AND STOPPED THE VEHICLE. ONCE LOCKED, THE BRAKES DID NOT RELEASE, OR DO NOT RELEASE COMPLETELY. AND WE DISCOVERED - ULTIMATELY, ONCE THIS HAPPENS YOU SIMPLY CAN'T FIX IT. THE FIRST THING THAT WE DID IS WE REPLACED THE BRAKE PADS, ROTORS, TIE ROD ENDS AND BOOTS, BECAUSE WE THOUGHT THE PADS WERE GOING BAD AND THE ROTOR WAS WARPED (THE FRONT END HAD STARTED HAVING A SHIMMY AT HIGHER SPEEDS SOMETIMES ALSO). THAT SEEMED TO FIX ALL BUT THE SHIMMY SO WE THEN REPLACED THE TWO FRONT TIRES AND HAD THEM REBALANCED AND REALIGNED. AFTER THAT THE BRAKES SUDDENLY LOCKED UP RATHER HARD. I MANAGED TO GET OFF THE HIGHWAY SAFELY, BUT THE VEHICLE WOULD BARELY DO 10 MPH BECAUSE OF THE BRAKES LOCKING DOWN. WE TOOK IT IN AND REPLACED PARTS FOR ALL OF THE BRAKE SYSTEM. WE REPLACED THE PADS, ROTORS, CALIPERS, HOSES, MASTER CYLINDER AND THE ABS UNIT (ONLY FOUND IN JUNKYARDS NOW). THEN THE BRAKES LOCKED ONCE AGAIN AND CAUGHT FIRE! WE PUT IT OUT, BUT THIS WAS A KNOWN PROBLEM, ESPECIALLY WHEN ATTEMPTING TO REPLACE BRAKE PARTS ON THIS MODEL. WE FOUND NUMEROUS REPORTS ONLINE THAT THIS WAS A COMMON PROBLEM FOR THIS MODEL, AND NOT JUST FOR 2005.

AT 24,000 MILES THIS 2005 SATURN VUE NEEDED THE ENTIRE BRAKE SYSTEM REPLACED. THEN WHEN BACKING UP AND THEN PUTTING THE CAR IN DRIVE IT WOULD NOT SPEED UP. I HAD TO STOP, PUT IT IN PARK, PUT IT IN DRIVE AGAIN BEFORE IT WOULD MOVE. THIS WAS AT 28,300 MILES, TURNS OUT THE TRANSMISSION WENT AND HAD TO BE REPLACED. NOW AT 35,533 THE DRIVE SHAFT IS RUSTED AND CENTER SUPPORT IS BLOWN OUT. I ASKED SATURN WHAT THE LIFE EXPECTANCY OF THIS VEHICLE IS AND RECEIVED NO RESPONSE. THERE WERE NO ACCIDENTS RELATED TO THESE FAILURES BECAUSE I REALIZED SOMETHING WAS WRONG AND TOOK IT IN FOR SERVICE IMMEDIATELY. HOWEVER, THIS VEHICLE HAS HAD MORE SERIOUS AND COSTLY REPAIRS AT 35,533 MILES THAN VEHICLES WITH OVER 100,000 MILES. DRIVING IT IS VERY STRESSFUL AS I NEVER KNOW WHAT WILL HAPPEN NEXT. *TR

THE VEHICLE HAS MAJOR WIND NOISE...YOU CAN NOT EVEN HEAR THE RADIO OR CONVERSATIONS IN THE VEHICLE DUE TO THIS NOISE. THE CAR ALSO HAS A RATTLING COMING FROM THE DRIVER AND PASSENGER SIDE OF THE CAR, WE CAN NOT IDENTIFY THE SOURCE. THE VEHICLE ALSO ROLLS BACK ON A HILL WHEN IN DRIVE. THE BRAKES ALSO SQUEAL AND THE DEALERSHIP SAYS THEY ARE FINE, BUT WE DO NOT BELIEVE THEY ARE. THESE PROBLEMS HAVE BEEN GOING ON SINCE MAY 2005 AND TILL NOW (1/18/06) SATURN HAS NOT FIXED ANY OF THEM. *JB