2009 Subaru Forester Engine Problems

TRAVELING ON AN INTERSTATE AT 70MPH, CAR CHECK ENGINE LIGHT CAME ON AND CAR LOST ALL POWER. WAS ABLE TO LIMP OFF THE ROAD AND WAIT 3 HOURS FOR A TOW TO DEALERSHIP. DIAGNOSIS; STAGE 4 BLOWN HEAD GASKET. THERE WAS NO PRIOR WARNING OR SYMPTOMS AND COULD HAVE BEEN A GREATER DANGER IF HEAVIER TRAFFIC. HEAD GASKET PROBLEMS KNOW ON EARLY MODEL SUBARU'S.

TURBO FAILURE CAUSED BY DESIGN FLAWS IN LUBRICATION DELIVERY SYSTEM IDENTIFIED BY MULTIPLE TSB WVF-16, TSB#02-103-07, TSB # 02-97-05. MANUFACTURE REFUSES TO ACKNOWLEDGE TSB AND CLASS ACTION LAW SUIT ABOUT 2.5 LITER TURBO CAR. LEADING $3500.00 REPAIR BEING FORCED ON CONSUMERS IN SPITE OF THIS CONDITION BEING A ENGINEERING DEFECT.MY CAR HAD THE TURBO REPLACED BY DEALERSHIP AT 50,000 MILES NAD NOW 50,000 MILES LATER THE TURBO HAS FAILED AGAIN. CONTACTED SUBARU OF AMERICA, WHO STATED THAT SOA WOULD NOT BE ASSISTING IN REPAIRS OF THE SAME FAILURE.

TL* THE CONTACT OWNS A 2009 SUBARU FORESTER. WHILE DRIVING 60 MPH, THE ENGINE STALLED AND THE CHECK ENGINE AND TRACTION CONTROL INDICATORS ILLUMINATED. THE LOCAL DEALER WAS NOT CONTACTED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS CONTACTED AND DID NOT ASSIST. THE FAILURE MILEAGE WAS 108,000.

FAIRLY RECENTLY I HAD MY RADIATOR REPLACED DUE TO A LEAK. COUPLE WEEKS INTO MY NEW ONE, I WENT TO START MY CAR AND A PROOF OF WHITE SMOKE SHOT OUT THE EXHAUSTS WHICH I NEW WAS NOT OK. I PUT THE CAR IN REVERSE AND ALL OF THE SUDDEN IT FELT LIKE IT WAS IN LIMO MODE AND THE CHECK ENGINE, TRACTION CONTROL, AND CRUISE CONTROL LIGHTS ALL STARTED BLINKING - THEY WEREN'T ON BEFORE. SO I SHUT MY CAR OFF AND TOOK MY MOM'S TO WORK. I LATER FOUND OUT THAT I HAD NO COOLANT, BUT THERE WAS NO WARNING OR INDICATION THAT I WAS LOW. FROM THAT DAY ON MY CAR HAS BEEN GOING THROUGH FULL RESERVOIRS OF COOLANT BY THE DAY WITH NO VISIBLE LEAKS, HEATING+COOLING, FAND A ULL RADIATOR UP TO THE BRIM. I'M ASSUMING MY ISSUE IS A HEAD GASKET LEAK AT ONLY 86,000 MILES...THAT IS TERRIBLE PRODUCT QUALITY - I CAN'T JUST GO AROUND AND PAY $2000 IN REPAIRS FOR A CAR I RELIED ON AND HAVE ONLY DRIVEN FOR 10K MILES. THAT'S JUST RIDICULOUS AND THERES NOTHING I CAN DO ABOUT IT WITHOUT $2000 TO SPEND BUT SELL IT AND SCREW SOMEONE ELSE OVER.

ENGINE AND VEHICHLE CAUGHT ON FIRE. DRIVING HIGHWAY FOR ABOUT 3.5 HOURS. HAD JUST REFILLED WITH FUEL ABOUT 15 MINUTES PRIOR TO CHECK ENGINE LIGHT COMING ON. PROCEEDED TO NEXT EXIT. CHECK OIL LIGHT CAME ON AND CAR WAS ON FIRE. VEHICLE DESTROYED.

HEAD GASKETS FAIL AROUND 125,000 MILES. SEEMS TO BE A COMMON PROBLEM WITH THIS VEHICLE. DID NOT CAUSE AN ACCIDENT IN MY CASE.

VEHICLE WAS IN MOTION ON THE FREEWAY WHEN ENGINE LIGHT TURNED ON AND IMMEDIATELY BRAKES STOPPED WORKING AND ENGINE STOPPED AS WELL. FIRE AND SMOKE CAME OUT OF THE ENGINE AND FILLED THE CABIN. DRIVER AND PASSENGERS HAD TO ESCAPE AND THE CAR WITHIN MINUTES WAS ENGULFED IN FLAMES.

TL* THE CONTACT OWNS A 2009 SUBARU FORESTER. WHILE THE VEHICLE WAS UNDERGOING ROUTINE MAINTENANCE AT COMPETITION SUBARU OF SMITHTOWN (601 MIDDLE COUNTRY RD, ST JAMES, NY 11780, (631) 361-4500), IT WAS DIAGNOSED THAT ANTIFREEZE WAS LEAKING AND THE HEAD GASKET NEEDED TO BE REPAIRED. THE VEHICLE HAD NOT BEEN REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED. THE FAILURE MILEAGE WAS 54,000. *TT*JB CONSUMER STATED IT WAS THE 3RD COMPLAINT.*JB

HEAD GASKETS FAIL AROUND 100,000 MILES. SEEMS TO BE A COMMON PROBLEM WITH THIS VEHICLE. DID NOT CAUSE AN ACCIDENT IN MY CASE.

SUDDEN ACCELERATION CAUSED A SERIOUS ACCIDENT. UPON PULLING INTO A PARKING SPACE THE VEHICLE SUDDENLY ACCELERATION AND CRASHED INTO A BUILDING. THIS IS THE SECOND TIME THIS HAS HAPPENED WITH THIS VEHICLE.

THIS PAST APRIL, I PURCHASED A 2009 SUBARU FORESTER FROM BYERS SUBARU AND EAGERLY ANTICIPATED THE OWNERSHIP EXPERIENCE SUBARU PROMISES AND PROUDLY BASES ITS REPUTATION. CONTRARY TO THE SUBARU PROMISE, MY EXPERIENCE OVER THE FIRST 3 MONTHS HAS BEEN A NIGHTMARE. PRIOR TO THE PURCHASE, I HAD COMMITTED TO HAVING THE SCHEDULED MAINTENANCE PERFORMED BY THE DEALER AND DID. THE FIRST SERVICE WAS PERFORMED WITHIN A FEW WEEKS OF PURCHASE ($700). A MONTH LATER THE VEHICLE STOPPED RUNNING AND REQUIRED A TOW TO A TEXAS SUBARU DEALERSHIP. INITIAL THOUGHTS WERE A TIMING BELT FAILURE. $600 DOLLARS LATER, I WAS TOLD THAT THE TIMING BELT PULLEY HAD FAILED AND WOULD REQUIRE EXTENSIVE ENGINE REPAIRS OR AN ENGINE REPLACEMENT ($2500 TO $6000). THE TIMING BELT WAS NOT DUE TO BE REPLACED FOR ANOTHER 10,000 MILES. DUE TO THE HIGH REPAIR COST AND THE FACT THAT THE DAMAGE OCCURRED WITHIN A SHORT PERIOD OF TIME AFTER PURCHASE, I REACHED OUT TO SUBARU AMERICA FOR ASSISTANCE WITH THE REPAIR. SUBARU COMMITTED TO 50% REIMBURSEMENT OF THE INITIAL $600 DEALER CHARGE. I APPROACHED BYERS SUBARU WITH THE SAME REQUEST FOR THE SAME REASON AND WAS INFORMED BY A MANAGER, THAT IT WAS NOT THEIR PROBLEM AND THAT I HAD AN OPPORTUNITY TO PURCHASE AN EXTENDED WARRANTY.

THEIR WAS A CLUNK AND DRIVER CAR PULLED OVER AND OFF HIGHWAY . HAD IT TOWED TO OUR INDEPENDENT GARAGE. THE ENGINE FAILED. THE CHECK ENGINE LIGHT NEVER WENT ON NOR DID THE LOW OIL PRESSURE LIGHT GO ON. *TR

TL* THE CONTACT OWNS A 2009 SUBARU FORESTER. THE CONTACT STATED THAT WHILE TRAVELING 40 MPH, HE HEARD A LOUD BANG AS THE VEHICLE LOST ACCELERATION POWER. THE VEHICLE WAS TAKEN TO THE DEALER WHERE THE FAILURE COULD NOT BE DIAGNOSED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS CONTACTED ABOUT THE FAILURE. THE FAILURE MILEAGE WAS 92,000.

UPON RETURNING FROM A SHORT DRIVE WE PULLED INTO MY DRIVEWAY AND NOTICED SMOKE COMING FROM THE ENGINE COMPARTMENT. I ASSUMED THIS WOULD HAVE BEEN POSSIBLY SOME TYPE OF OVERHEATING ISSUE, BUT UPON INSPECTION I DISCOVERED IT WAS ENGINE OIL DRIPPING ONTO THE EXHAUST HEAT SHIELDS AND WAS BURNING OFF. I WAS STUNNED BY THIS AS I AM VERY PARTICULAR ABOUT THE MAINTENANCE ON THIS VEHICLE. I TOOK TO THE DEALERSHIP A FEW DAYS LATER AS IT WAS GOING IN ANYWAY FOR A RECALLED CAT CONVERTER. THEY THEN ADVISED ME THAT THE ENGINE HAD A BLOWN HEAD GASKET. THIS NEEDS TO BE REPAIRED IMMEDIATELY AS THIS IS A POTENTIAL FIRE HAZARD IF NOT REPAIRED. THIS VEHICLE ONLY HAS 73,000 MILES AND I AM NOW FACED WITH AM ALMOST $2000.00 REPAIR. I AM SPEECHLESS AND BESIDE MYSELF AS I BOUGHT THIS CAR SPECIFICALLY TO GET A QUALITY VEHICLE THAT IDEALLY WOULD AVOID ISSUES OF THIS NATURE. I AM PURSUING A COMPLAINT WITH SUBARU OF AMERICA AND WANTED THE NHTSA TO BE AWARE AS WELL. THANK YOU. *TR

TL* THE CONTACT OWNS A 2009 SUBARU FORESTER. THE CONTACT STATED THAT DURING ROUTINE MAINTENANCE, THE MECHANIC NOTICED THAT THE CYLINDER HEAD-SIDE OIL SUPPLY PIPE WAS LEAKING OIL. THE CONTACT WAS INFORMED OF A RECALL UNDER NHTSA CAMPAIGN NUMBER: 08V460000 (ENGINE AND ENGINE COOLING). THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND INFORMED THE CONTACT THAT THE VIN WAS NOT INCLUDED IN THE RECALL. THE VEHICLE WAS SCHEDULED TO BE REPAIRED. THE MILEAGE WAS UNKNOWN.

LOUD KNOCKING SOUND NOTED COMING FORM ENGINE WHILE DRIVING ON HIGHWAY. PULLED OFF OF HIGHWAY THEN ALL THE WARNING LIGHTS ON DASHBOARD FLICKERED ON AND ENGINE DIED. HAD TO TOW TO DEALER. INFORMED THAT A ROD HAD KNOCKED LOOSE RELATED TO FAULTY BEARINGS HAD TO HAVE ENGINE REPLACED. *TR

I WAS DRIVING TO WORK, AND THE CAR WOULDN'T ACCELERATE, IT ALSO HANDLED ROUGHLY. THE CHECK ENGINE LIGHT, CRUISE CONTROL LIGHT WAS FLASHING, ALONG WITH VEHICLE DYNAMICS CONTROL WARNING LIGHT. I HAD MY CAR TOWED, AS IT WASN'T DRIVABLE. MY LOCAL GARAGE REPAIRED MY CAR, I RECEIVED 4 NEW SPARK PLUGS, AND AN AIR FILTER. 9 DAYS LATER THE CHECK ENGINE LIGHT CAME ON, AS WELL AS THE CRUISE CONTROL LIGHT, AND THE VEHICLE DYNAMICS WARNING LIGHT, AGAIN IT WAS REPAIRED, THIS HAD TO DO WITH THE CATALYTIC CONVERTER MESSAGE, BUT ALL MY LOCAL GARAGE COULD FIND WAS A SMALL LEAK NEAR THE MANIFOLD THAT THEY REPAIRED. 2 DAYS LATER THE CHECK ENGINE LIGHT WENT ON AGAIN, I NOW CALLED MY SUBARU DEALERSHIP, THEY REPLACED A FAULTY CATALYST CONVERTER, AND AF SENSOR, THE ALSO CHANGED MY OIL, AS IT WAS DUE, AND SUGGESTED I HAVE A TRANSMISSION FLUID FLUSH AND REFILL, AND THAT MY REAR AND FRONT DIFFERENTIALS, NEEDED A DRAIN AND REFILL. 5 DAYS PASSED ANOTHER CHECK ENGINE LIGHT, THIS TIME IT WAS FLASHING, I HAD TO HAVE MY CAR TOWED, THE SUBARU DEALERSHIP DISCOVERED THE WRONG SPARK PLUGS WERE PUT IN INITIALLY, AND REPLACED THEM WITH PLATINUM TIP SPARK PLUGS THAT MY MODEL TAKES. 4 DAYS PASSED ANOTHER CHECK ENGINE LIGHT, WITH BEING UNABLE TO ACCELERATE, I WAS GOING UP HILL, SO I CONTINUED ON, TO REACH A PARKING LOT, I COULD STOP IN BUT SUDDENLY, IT FELT LIKE SOMETHING UNBLOCKED, THIS MADE THE CHECK ENGINE LIGHT GO AWAY, UNTIL 2 DAYS LATER, ANOTHER CHECK ENGINE LIGHT, I ONCE AGAIN BROUGHT MY CAR BACK TO THE DEALERSHIP, THE MENTIONED SOMETHING ABOUT THE CATALYST CONVERTER, BUT SAID IT WAS 'TOO SOON" SO THEY LEFT THE WORK ORDER OPEN , IN CASE IT OCCURRED AGAIN,AND GAVE ME THIS LECTURE ABOUT THE GRADE OF GAS I AM BUYING. 4 DAYS LATER THE CHECK ENGINE LIGHT RETURNED, THIS TIME SUBARU DISCOVERED THE MY OTHER O2 SENSOR WAS FAULTY, AND THEY WOULD REPLACE IT, WHEN THE PART COMES IN. *TR

FOR SOME ODD REASON ON MONDAY, APRIL 23 MY CHECK ENGINE LIGHT CAME ON, MY AWD INDICATOR, AND THE CRUISE CONTROL LIGHT STARTED FLASHING ALL AT ONCE. I CAME INTO WORK AND GOOGLED THE ABOVE ITEMS ALONG WITH MY MAKE AND MODEL OF THE CAR...MUCH TO MY SURPRISE MULTIPLE LINKS, ITEMS, AND THREADS APPEARED. SO I READ MOST OF THEM AND THIS APPEARS TO BE A SYSTEMIC PROBLEM WITH SUBARU'S THROUGHOUT THE UNITED STATES AND CANADA. I BECAME CONCERNED BECAUSE NO RECALL WAS ISSUED AND IT SEEMS MORE THAN COINCIDENCE THAT MANY PEOPLE ARE HAVING THE SAME ISSUE. PLEASE ADVISE SINCE I CALLED THE SUBARU DEALER AND THEY COULD HAVE CARED LESS. *TR

STOPPED TO FILL UP CAR WITH GAS ON WAY TO WORK AND WHEN I RESTARTED THE ENGINE I HEARD A REAL LOUD KNOCKING NOISE. AS I PULLED AWAY THE CAR WAS VERY SLUGGISH AND THE NOISE FROM THE ENGINE STARTED GETTING LOUDER. I WENT TO GET OFF THE ROAD AND TURN INTO A PARKING LOT AND THE CAR DIED AND I NARROWLY MISSED HITTING A BALTIMORE CITY WORK TRUCK AS THE POWER STEERING AND POWER BRAKES WERE NON RESPONSIVE BECAUSE THE ENGINE HAD CUT OFF. I WAS VERY LUCKY TO NOT CRASH INTO THE WORK TRUCK. I HAD THE CAR TOWED TO VALLEY MOTORS SUBARU IN COCKEYSVILLE AND THEY CALLED TO INFORM ME THAT I NEED A NEW AT LEAST A NEW LOWER BLOCK IF NOT A WHOLE ENGINE REPLACEMENT. I LOOKED ONLINE FOR SOME INFORMATION ON ANY KNOWN ISSUES WITH STYLE OF CAR AND ENGINE AND WAS SHOCKED TO SEE THAT IN APRIL 2008 A " STOP SALE" WAS ISSUED BY SUBARU OF AMERICA ON MY EXACT CAR. LEGACY VEHICLES HAVE BEEN ADDED TO THE STOP SALE WE REGRET TO INFORM YOU THAT WE MUST PLACE AN IMMEDIATE STOP SALE ORDER ON ALL OF THE 2008/2009 SUBARU IMPREZA, FORESTER AND LEGACY VEHICLES EQUIPPED WITH A 2.5L TURBO ENGINE PRODUCED WITH THE BEGINNING CHASSIS NUMBER AND LATER AS SHOWN BELOW. MODEL BODY TYPE CHASSIS NUMBER PRODUCTION DATE FORESTER WAGON 701045 OR LATER 2008/01/08 OR LATER THE REASON FOR THIS IMMEDIATE QUALITY ASSURANCE ACTION IS THAT THERE HAVE BEEN SEVERAL REPORTS OF "ENGINE KNOCKING NOISE" FROM OTHER MARKETS ON VEHICLES PRODUCED AFTER THE PRODUCTION DATES LISTED. INITIAL INVESTIGATION CONFIRMS AN INTERNAL WEAR ISSUE ON THE FAILED UNITS. I BOUGHT MY CAR IN OCTOBER 2009 AND YOU CAN SEE THE VIN # IS PRETTY CLOSE IN THE RANGE AND I HAVE READ IN FORUMS OF PEOPLE WITH ALMOST IDENTICAL VIN'S AS MINE OF HAVING THE SAME EXACT ISSUE. *TR

2009 SUBARU FORESTER. PRODUCTION DATE: 02-14-08. INITIAL DIAGNOSIS IS INTERNAL TURBO FAILURE. THE CAR HAS 34,000 MILES ON IT AND OIL AND FILTERS ARE MAINTAINED. MY WIFE WAS DRIVING WITH OUR 2YR. OLD IN THE CAR WHEN IT STARTED MAKING A HORRIBLE GRINDING SOUND. SHE DESCRIBED IT AS IT SOUNDED AND FELT LIKE SHE WAS DRAGGING SOMETHING. SHE LIMPS HOME WITH THE CAR AND I TAKE IT FOR A TEST DRIVE. IT SOUNDED FINE AT START UP. NO TAPPING OR GRINDING. AS SOON AS I START UP THE ROAD I COULD FEEL THERE WAS NO ACCELERATION. LIKE I WAS DRIVING IN MUD. THE CHECK ENGINE LIGHT, THE TRACTION CONTROL LIGHT AND THE CRUISE CONTROL LIGHT ALL STUCK ON. I HAVE READ MANY CASES OF THIS SAME THING HAPPENING WITH OTHER 2.5 TURBO ENGINES. THERE WAS A STOP SALE AND A RECALL BUT, ACCORDING TO SUBARU MY CAR WAS NOT AFFECTED. THE REPORTS I'VE READ INDICATE OTHERWISE. THE PRODUCTION DATE AND THE VIN# FALL INTO THE RANGE OF THE STOP SALE. I AM VERY WORRIED ABOUT THE OUTCOME AS THE DEALERSHIP I BOUGHT THE CAR FROM AND SOA HAVE NOT BEEN HELPFUL. I HAD TO CALL SUBARU MYSELF TO GET THEM TO RESPOND TO THE DEALERSHIPS CASE CONCERNING MY CAR. IT'S BEEN A WEEK NOW AND JUST TODAY I GOT A CALL FROM SUBARU REQUESTING PERMISSION TO TEAR DOWN THE ENGINE TO FIND THE SOURCE. A WEEK AND IT'S JUST SITTING THERE. NO OFFER OF A RENTAL. NOTHING. THIS ISSUE IS NOT RESOLVED YET AND I HOPE SUBARU DOES THE RIGHT THING AND LIVES UP TO ITS REPUTATION OF BEING A RELIABLE, LONG LASTING CAR. *TR