2025 Tesla Cybertruck Complaint Log

Front body panel of hood came unglued

One to two times per month upon starting my Cybertruck I receive multiple notifications for systems not working including "Driver Assistance - Automatic Emergency Braking is unavailable" and "Steering & Braking - Adaptive ride control degraded/Ride comfort may be reduced." These alerts cause the disablement of the regenerative braking, auto-hold (braking), emergency braking, adaptive ride control, traction control, and the self drive features. While the vehicle is still drivable, my ability to control the vehicle is greatly diminished, as is the safety of the vehicle without any of the accident avoidance and stability systems working. After driving in this condition, if I park the vehicle, exit it, and let it sit for at least 10 minutes, all systems are normal upon reentry. On 1/5 I experienced this issue and opened a service request for warranty work and Tesla demanded that I agree to a $200 charge before they would even look at it and said if they were unable to see the issue then it would not be considered as warranty. Since I cannot reproduce this issue on demand I cancelled the service request as I do not want to pay them $200 to say they couldn't reproduce the issue. Internet searches have revealed that this is a common issue among Cybertrucks and despite multiple software updates since owning my vehicle, it has not gotten any better.

HTSA Safety Complaint Description The 2025 Tesla Cybertruck exhibits a persistent and recurring air suspension system defect that impairs safe vehicle operation. From the moment of delivery, the air suspension failed to raise or lower properly, displaying a fault message indicating potential restoration on the next drive. This did not occur. The issue included repeated overheating warnings, multiple system failure alerts, excessive compressor noise/knocking, steam and water discharge from the undercarriage, and the vehicle remaining stuck in a lowered ride height, causing scraping damage to underbody trim and mud flaps. The vehicle underwent a major warranty repair where the air suspension compressor was replaced due to a stuck exhaust valve and damaged air line, followed by recalibration. Despite this, suspension overheating warnings and intermittent system failure notifications continued to appear. On December 23, 2025, while driving at moderate speed in clear conditions, the vehicle suddenly and uncorrectably migrated off the roadway. Adaptive steering correction, braking intervention, and lane assist failed to engage. At the time of the incident, the display actively showed service notifications indicating suspension system failure and overheating. The vehicle veered into a ditch, resulting in a significant drop and requiring specialized heavy-duty extraction. This defect has impaired the vehicle’s handling, stability, and safety from delivery onward, with no resolution after attempted repair. The recurring nature and active failure alerts during the loss-of-control event suggest a serious safety risk.

Brand-new 2025 Cybertruck developed moisture inside sealed HV battery pack with no submersion, off-roading, or flooding. Service photos show only trace condensation and crystallized residue—no mud, corrosion, or contaminants. Tesla denying warranty and quoting $37k replacement. Suspected manufacturing defect in pack lid gasket (known issue in early VINs). Safety risk if unaddressed.

The contact owns a 2025 Tesla Cybertruck. The contact stated that while the vehicle was parked, the contact exited the vehicle and the front driver-side door independently closed and slammed his right hand in the door, injuring three of his fingers. The contact sought medical attention and was informed that he had sustained internal bleeding and was prescribed anti-inflammatory medicine and instructed the contact to try not to move his fingers in order to avoid disturbing the healing process. The contact stated he also sustained emotional distress and described the incident as traumatic. The vehicle was taken back to the residence and was not diagnosed. A dealer was not contacted, and the vehicle was not repaired. The manufacturer was notified of the failure, and the contact stated that the manufacturer said they would send an email after the call; however, the manufacturer did not send an email and refused to provide a manufacturer case number. The failure mileage was approximately 7,857.

windshield crack spontaneously while using defrost function TESLA refused cover it with warranty

Tesla sold me a 2025 Cybertruck RWD without disclosing that no compatible bed cover exists at all for this model. We test-drove the vehicle at Tesla Clermont and took delivery at Tesla Tallahassee. At neither location were we told that the RWD trim cannot use the powered hard tonneau cover OR the soft tonneau cover. After delivery, Tesla confirmed in writing that the only cover associated with this model is out of stock with no ETA, and they “cannot speculate on availability.” No third-party manufacturer offers a compatible cover. This means the vehicle’s truck bed cannot be covered or secured in any manner. As a result, we experienced two serious safety incidents. Both times, the vehicle was operating in SFD (self-drive) mode at speeds below the posted speed limit, with items properly tied down using rope. Even under safe, controlled conditions, items flew out of the truck bed twice, nearly causing a collision behind us. Vehicles had to brake and swerve to avoid debris. These incidents created a direct hazard to us and the surrounding traffic. The Cybertruck RWD cannot safely retain cargo under normal driving conditions without a cover, and no cover exists or can be purchased. Tesla buried a clause in a 45-page contract saying they may “remove parts from commerce,” but this does NOT excuse failing to disclose that no safe cargo-retention solution exists for the RWD configuration. A pickup truck that cannot keep cargo from ejecting onto the roadway presents a serious safety defect. I am reporting this because the inability to secure a load is a safety hazard for both occupants and other drivers, and Tesla has no remedy available. Thank you

The contact owns a 2025 Tesla Cybertruck. The contact stated that while driving at various speeds, the rear middle row seat felt loose and failed to remain in place as intended. The vehicle was taken to a local dealer, where it was diagnosed with a loose rear middle row seat. The vehicle was repaired; however, the failure reoccurred. The manufacturer was made aware of the failure. The failure mileage was approximately 978.

When on full self driving on the freeway if the road starts curving the car does not stay in the lane and start hitting the bump on the road or in situation getting to close to another car or the center diver

There is a defect in the stainless-steel exterior trim panel called the “cant rail,” which detached from the vehicle while driving, posing a safety risk as road debris and hazard to other motorists. There was a recall issued for this exact same thing for previous models earlier this year but it still happened with the new 2025 model. This August 2025 model was not included as a recalled vehicle.

I’ve had a model 3,model y and now a cybertruck, can’t speak on the rest of the fleet but didn’t had this problem with those cars or any my other cars in the pass, but the passenger side seat belt keeps locking up, if you have to reach down to get an item or reach back it locks up, even if you go a few inches over it locks up which which needs constant taking the seat belt off and resetting it which become a safety issues while driving for the passenger, I took it to the dealership and they said it’s normal, I feel like the seat belt is short which makes it lock up as it should or other defect, I tasted on another cybertruck and didn’t had that problem, tesla customer service didn’t wanted to help me and push me away, I google the problem and there a forum and people having the same problem

Since purchasing my Cybertruck with Full Self-Driving in July 2025, I have experienced a repeated safety issue whenever Autopilot/FSD is engaged on highways. The vehicle will consistently pull toward the left side of the lane, positioning itself directly on the left lane line. This feels extremely unsafe, especially when another vehicle is traveling in the lane beside me. This behavior happens at highway speeds and creates a significant safety concern because it reduces the buffer between my vehicle and adjacent traffic. The issue has occurred repeatedly over several months in different locations and conditions. I have brought the vehicle to Tesla service multiple times, and the issue has not been resolved. Tesla acknowledged the concern happened to multiple vehicles in the past two months, but was unable to fix it. They are now performing another inspection for my vehicle, and starting a buyback request that is under review. There are no warning messages before or during the behavior. This appears to be a malfunction with the vehicle’s lane-keeping or Autopilot/FSD behavior that puts my safety and the safety of others at risk.

Driving the cybertruck on a road going straight no set destination on the cars navigation with autopilot on so it should have continued straight for the most part…. but the car decided to make an abrupt illegal right turn from a straight only lane after passing the appropriate right merge lane. After which the car swerved illegally into 2 oncoming traffic lanes before briefly missing an oncoming car then me driver manually pulled back into the correct lane. By the way my 12 pound dog which sits in the passenger seat was swung so hard hard by the abrupt turn that she literally ended up in the driver foot well by my ankles. This has never ever happened from my regular driving! I’m not so upset about my dog so much as I am trying to convey the amount of abrupt rough turn the car did. Very last minute and doing anything but let the car do the turn may have resulted in me crashing into oncoming traffic had there been any. A terrible illegal scary occurrence by Tesla autopilot. I was left very stunned. Please contact me for additional information I did record the dashcam footage and would like to share that.