There are 142 stored owner reports matching the electrical system leading-label group for the 2018 Tesla Model 3 in our NHTSA-sourced dataset. These are unverified consumer reports and may not reflect confirmed defects.
This group counts stored reports whose component label starts with one of this site's matching prefixes, ignoring case. Each matching report counts once within the group. Components mentioned later in the label or only in the narrative are not searched. How component counts work
Loaded 50 of 142 matching reports. This is a limited sample of up to 50 reports, ordered by incident date when available, not the complete group. The list controls page through the loaded reports only.
Open the full vehicle complaint log (all categories)After downloading Tesla’s update (no. 2025.44.25.4) software my heater (with the window defrost functionality) in winter stopped operating. I made my update while at my nearest Tesla service compound (location verifiable per system location log) on 01/25/26 when that same day software began throwing HVAC error codes with blowing cold air, when previously my heat ran well. This is not coincidental; this is system design failure.
The contact owns a 2018 Tesla Model 3. The contact stated that there was a feature in the vehicle that allowed the front driver’s seat to automatically adjust according to the saved driver's profile. The contact stated that the driver’s seat back and forth movement to adjust to each driver's profile might have caused loose wire connection, resulting in error code: RCM_a021 (Front Left Safety Restraint System Fault) being displayed. The contact stated that the error message had been displayed intermittently. Upon investigating the failure online, the contact related the failure to the seat adjustment feature. The failure was reported to the manufacturer through the Tesla App; however, the contact had not yet received a response. The vehicle was not diagnosed or repaired after the failure. The failure mileage was approximately 55,000.
Description of the Defect: While driving with Full Self-Driving (FSD) engaged, the vehicle's primary computer shuts down and reboots, causing a sudden loss of all safety features, including Blind Spot Monitoring, Lane Departure Warning, Forward Collision Warning, and the driving visualization. The cameras go black while the vehicle is in motion. The Trigger: The failure is triggered by high electrical load. If the Cabin Heater (HVAC) and Seat Heaters are active while FSD is fully computing, the 12V power supply to the computer drops below critical voltage, causing a "Turbo A" processor lockup and system crash. Evidence of Defect: Service Center diagnostics confirmed the specific error code APS_w169_TurboA_SCS_LKUP (Computer Crash) occurred at the exact same timestamp as VCLEFT_a302_blowerGeneralFault (HVAC Blower Failure). This proves a common-mode voltage drop affecting multiple critical systems simultaneously. Manufacturer Response: The manufacturer (Tesla) acknowledged the logs but refused to inspect the wiring harness or ground connections, instead recommending a replacement of the computer unit. However, the failure can be mitigated by unplugging external cameras to reduce load, proving the root cause is an insufficient power delivery design (Wiring/Grounding) rather than a component failure. The computer is running at full load with the newest FSD software and it can no longer keep up with additional loads. Safety Risk: This defect causes a sudden, uncommanded loss of driver assistance and situational awareness tools (cameras/visualization) while the vehicle is maneuvering in traffic. The vehicle’s power distribution system appears insufficient to support the electrical load of the software (FSD) and the hardware (HVAC) simultaneously.
The center display (Vehicle Pad) on my 2018 Tesla Model 3 went completely blank while driving. This eliminated access to all vital driving information including the speedometer, gear selection, and safety indicators. Safety Concern: Without visible speed data and wipers the vehicle cannot be operated safely or legally. I attempted to reboot the system and power cycle the vehicle but the screen still failed.
The contact owns a 2018 Tesla Model 3. The contact stated that when the vehicle was started, the GPS failed to function as intended. In addition, the “Unable to Charge” warning light was illuminated. The contact stated that the GPS provided incorrect directions. The contact attempted to recharge the battery; however, the battery failed to charge. The contact stated that the failure had occurred the following day after an over-the-air software update was performed. The dealer was made aware of the failure. The contact was informed that the battery needed to be replaced. The vehicle was not repaired. The vehicle was not diagnosed or repaired by an independent mechanic or dealer. In addition, the contact referenced a document that stated that the battery life should last 200,000 to 300,000 miles. The manufacturer was made aware of the failure but provided no assistance. The failure mileage was approximately 106,884.
Main incident: Time: 2025-08-28 ~12:41 PM PST What happened: After searching for a parking space, the driver was preparing to reverse into the spot, the driver pressed up the stalk to shift the gear into reverse, a sound was heard and something showed up on the screen, the vehicle once again started accelerating and running forward suddenly and sharply (3 mph to 28 mph in 3 secs), driver tried to steer the vehicle away from cars and buildings to minimize danger, the car rushed onto a concrete curb, hit one blue Tesla, then hit the side of a concrete utility pole, and ran over a plant and last crashed into the chain-link french before it finally stops Injuries: * Spine pain for one passenger Damages: ** All tires blown out, tire falls off ** Severe damages throughout the vehicle body * One Tesla parked on the parking lot was severely damaged * The utility pole's base box was scraped and deformed * One plant was knocked down Similar case 3 few mins ago: Time: 2025-08-28 ~12:38 PM PST What happened: The driver entered a oneway parking lot, but found no available spot and was trying to back up, the vehicle suddenly accelerated on its own. The driver performed an emergency brake and stopped the vehicle. At the time the vehicle stopped, it was only about 20 inches away from two cars in front of it Injuries and damages: None What component or system failed or malfunctioned, and is it available for inspection upon request? Malfunctioning of the electronic control or braking system leading to abnormal acceleration Conflicting gear shifting and autopilot engagement design The right stalk is used to both shift gears and engage autopilot features, this design makes it very easy for the system to confuse the two actions Autopilot feature safety issues Autopilot features (whether its FSD or cruise control) should not be allowed to initiate abrupt acceleration to a dangerous speed in a low speed area (for example parking lot) Insurance claim filed, number: 25-647243342
The contact owns a 2018 Tesla Model 3. The contact stated that while driving 60 MPH with the Self Driving feature activated, the vehicle failed to slow down while approaching oncoming traffic. The vehicle accelerated and drove around the traffic. The contact depressed the brake pedal and touched the steering wheel to disable the Self Driving feature, but the vehicle failed to respond. The contact stated that once the vehicle passed through traffic, the brake pedal was depressed again, and the Self Driving feature was deactivated. The vehicle was not diagnosed or repaired by an independent mechanic or the dealer. The manufacturer was not made aware of the failure. The failure mileage was 55,866.
No warning messages at all, all cameras/sensors stopped working all at once while driving, full self drive stopped working, lane assist, safety features of full self drive was degraded by this. Car software v12 (2024.44.25.2 288ce84bb43e), according to the dealership the computer fried randomly.
I believe my car should be included in the recall for trunk harness recall. My alert and issue is the rear camera being off due to rear trunk ruining the wiring harness that has affected many cars. This is already a recall but I believe my car missed being involved.
This is a large scale problem with Tesla due to their "easy entry" which automatically moves the front seats to fit the drivers saved positions. Due to Tesla not properly securing the wires under the seat, they get crimped over time causing an error of "safety restraint system issue." There have been thousands of reported Teslas with a simple Google search. The service center also stated to me this is a large scale issue but a recall has not been issued. This is very dangerous as this disables the airbags due to a seat belt or wire crimp under the seat issue. Please investigate and issue a mandatory recall for the safety issue as Tesla wants $1000 to rectify the issue. Many have reported this issue to be fixed by the service center multiple times only to come back months later.
Tesla failed to properly diagnose a high-voltage battery isolation fault in my 2018 Model 3. Despite safety-critical BMS_a027 and BMS_a142 faults indicating multiple isolation failures, they skipped required insulation resistance testing, falsely blamed sand in a connector, and charged me $174.95. After the issue returned, they reversed course, replaced an internal battery contactor, and reduced the $1,173 estimate to $356—admitting fault without owning it. Days later, a diagnostic showed dangerously low isolation resistance (380kΩ, far below Tesla's 1,000kΩ safety threshold), yet they took no further action. On July 12, the car again went into limp mode. Tesla’s repeated failure to follow safety protocols, diagnose accurately, and honor warranty obligations has left me with a vehicle in an unsafe state and no corporate accountability. I've contacted their Resolutions team three times (7/2, 7/7, 7/10) with zero response.
My brake lines began to leak. When I took the car to the Tesla Service center they repaired the brake lines, but in the process they found that the brake fluid had leaked in/on the battery compartment. Furthermore, they found a coolant leak that also leaked on/in the battery compartment. This cause a hole to develop into the battery compartment. Having the coolant and brake lines in a place that could affect the batteries is a significant design flaw of the Model 3. According to the technician from Tesla, my car/batteries, were a ticking time bomb and could have ignited at any point. I am very fortunate that a fire was not started with myself or my family in the car. I believe Tesla needs to make all Model 3 owners aware of this possibility and come up with a way to remedy this flaw before someone looses a life. If the brake lines on my car hadn't sprung a leak, I'm not sure I would have know about the coolant leak until it was too late.
The contact owns a 2018 Tesla Model 3. The contact stated that while opening the doors of the vehicle, the driver's side seat back unintendedly reclined and pressed down on the rear seat, causing the cushion to become deformed. The contact manually used the seat controls to return the seat to an upright position. There was no warning light illuminated. The contact stated that the failure was intermittent and only occurred while the doors were opened. A Tesla service center was contacted; however, an appointment was not scheduled for diagnostic test. The contact was provided an estimate for the repair. The vehicle was not diagnosed or repaired. The failure mileage was approximately 95,000.
RCM_a021 alert: Front left safety restraint system fault. Seems like an issue caused by seat movement back & forth.
My 2018 Model 3 recently started experiencing issues during AC charging where I’m only able to use 16A out of the 48A available from my Tesla mobile connector charger at home. The specific error warning and error I’m seeing says “PCS_a019 Power grid or vehicle issue limiting AC charging Unplug and retry/ Try different charging location”. Before this started happening I’ve been charging with the same charging setup at home since 2019 and have been getting 32A consistently. I’ve tried the following options to diagnose the issue: 1. I’ve unplug and replug mobile charger from the connector. (the end plug to the mobile charger), I’ve also plug and unplug connector to the nema 14-50 receptacle. 1. The mobile connector exterior shows a constant flowing of green color on the “TESLA” letters outside the charger 2. I also separately own a second 2023 Model Y Performance, my Model Y is able to use the same Tesla mobile charger connector/receptacle at my home. It it getting AC charging at 32A 3. I’ve also tried charging the 2018 Model 3 (w/ the issue) at another separate AC charging station from a friend’s house that can normally deliver 48A, but I’m still also only getting 16A out of the possible 48A After sending the above to Tesla service center, they remotely diagnose and stated that it was an partial failure/issue with the " Power Conversion System" on the vehicle. However, Tesla mentions that is is not covered by their "HV Battery Warranty" and only covered by their 4 year 50k miles Basica vehicle warranty. My particular vehicle has only 37k miles on the odometer but it exceeded the 4 year period so I'm out of warranty. However I found that my vehicle fits the criteria for this outstanding NHTSA bulletin notice (SB-18-16-011) [XXX] , which also specifically mentioned "Replace Reworked Power Conversion System". My vehicle meets the criteria ( manufactured [XXX]) but Tesla refused to honor the bulletin. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Warning message appeared on center screen stating: "Front left safety restraint system fault". This appears to be a safety related problem , Tesla dealer wants $500 to repair because the vehicle is "out of warreanty" . This is the second Model 3 we have had. Previous version also experienced this fault. Is this a safety problem and if so should the car manufacturer be responsible to repair at no cost to owner? I have receoved a notice from NHTSA dated 5-31-2024 stating recall 24V376 may affect my vehicle - Seat Belt warning Sustem. I have not receoved a specific recall from tesla for this recall. Is it the same as the fault referenced above?
I’m not exactly sure what’s wrong, the screen keeps failing on my car. It’s been taken to Tesla to service this issue 4 times. With the most expensive repair costing $2,200. Its poses a safety hazard because when the screen fails. You can’t see anything, speed, gear. You can’t adjust windshield wipers, seat or mirror positions.
Passenger Safety Restraint system fault. Faulty wiring under the seat. Cost of repair is $1000. Passenger airbag requires replacement.
RECALL NEVER COMPLETED FOR MY CAR. WAS FROM 2021. WORRIED THAT REAR CAMERA MAY FAIL AND CREATE A DANGEROUS SITUATION.
Power Coversion System (PCS) failed on vehicle Causing issues with charging No User facing errors to alert of issues prior to problem (hidden in service menu) - preventing owners from claiming under basic 50k mile warranty. Stated as not part of HV Battery warranty and replacement is ~$2000 Advised to replace or could leave car unusable.
Showing 1-20 of 50 loaded complaints
Complaints are unverified consumer reports submitted to NHTSA. A high complaint count may reflect vehicle popularity, not defect severity. Data sourced from NHTSA public records.
NHTSA source checks for this vehicle year
Checks are recorded separately for each dataset, not for the whole page. Dates use UTC. A missing check date does not mean no records exist.
Vehicle import recorded: Apr 28, 2026. This is the stored import date, not confirmation that every source was successfully refreshed.