2022 Tesla Model Y Complaint Log

Tesla has failed to provide a software update to address both recalls, and has made it impossible for me to get support to have this rectified. They cancelled a service appointment I made and are no longer responding to my inquiries.

While driving on Intestate I-95 in the Express Lane at high speed in my 2022 Tesla Model Y, the hood (frunk) suddenly flew open, smashed into the windshield and remained in the upright position. Luckily I was able to slow down and ease blindly into the emergency lane without causing further damage to myself or others. I lost entire visibility at high speed and my windshield was smashed on the highway. This was a traumatic experience that could have caused serious damage to me personally and other motorists. The hood (frunk) latch failed to operate properly and was available for inspection immediately. Once the highway safety patrol officer forced the hood down and escorted me safely off the highway, we drove the vehicle to a Tesla dealership directly after the incident. The Tesla dealer initially took full responsibility for the incident and said they would repair at their expense. However, the story changed once they did a VIN search on my vehicle and discovered I had been hit (not my fault, driver ran red light) in the front quarter panel prior to this incident. Tesla said the fault was on the repair shop (Tesla recommended) who had fixed the vehicle prior to the incident. The repair facility claimed they were not at fault, and Tesla was responsible, as they did not touch the frunk latch as noted by the invoice for repair/parts and painting/lack of near the latch. This is a recurring incident as reported by recalls and my vehicle is listed as one of the possible vehicles for recall. The vehicle was inspected by insurance, and the same Tesla recommend repair facility we used before. There were no warning lamps, signals or symptoms to indicate anything was wrong or loose with the latch. In the end, we had to file the incident through our insurance provider and pay out of pocket for the repair in order to get the vehicle back on the road. I'm truly frustrated with the lack of ownership by Tesla over the incident, they are losing a brand loyal customer.

In the Tesla Full Self-Drive adaptive cruise control system the set speed arbitrarily and abruptly drops from the set speed to 40 mph on an interstate highway. In other words, if set to 70 it will drop instantly to 40 mph for no reason.

Unwanted Lane Assistance in Tesla Model Y made the car swerve to side. When I tried correcting it, the steering got hard to control and whole car swirled 360 degrees and hit shoulder rail. Brakes didn’t slow the car.

I was sideswiped by another vehicle which just joined our direction of traffic coming out of a cutout. As soon as I saw the vehicle moving fast from inside the cutout to join our direction and into my lane, I immediately decided to move to the lane next to me. I was at the leftmost lane at the time. Halfway into the lane I just felt the violent impact of the other vehicle hitting us. My wife and I were shaken so bad, we were shocked and terrified at what just happened and what else might happen to us. I felt like we were travelling on the front wheels with our rear end up in the air. Next thing we knew, the car stopped in front of a tree. Our iphones and the our car's phone called 911. We were pulled out of the car and taken immediately into an ambulance and Orange Global Hospital, where we stayed for about 2 days. X rays, CT Scan and MRI were taken. NOTE: A ROD STICKING OUT FROM THE FLOOR HIT MY WIFE during the accident. This rod was connected to the wheel and was not supposed to be stick out inside the car during an accident! I BELIEVE THAT A DEFAULT IN CAR DESIGN CAUSED THIS ROD TO HIT MY WIFE , WHICH CAUSED SO MUCH PAIN, DOCTORS COMPARED HER BRUISED RIBS TO BROKEN RIBS!!

I was using the Summon feature and the vehicle scraped another car. The safety features that keep the vehicle from hitting an object did not work.

The front license plate holder, which is attached to the vehicle with two strips of double-sided adhesive tape, became detached while driving on the highway. This occurred while driving on the highway without any prior collision or impact that could have caused such damage. The detachment resulted in damage to the vehicle’s paint on the bumper, dislodgement of the ultrasonic parking sensor, and the license plate holder itself flying off the vehicle. I have ordered a replacement plate at my expense. Safety Concerns: There was no prior warning or indication of instability of the license plate holder. Tesla’s provided literature does not include instructions for regular checks or maintenance of the plate frame, nor are there warnings against the potential risks of car washes on the adhesive’s integrity. Previous Incidents: Online forums and discussions among Tesla owners reveal multiple instances of similar occurrences, indicating a pattern that suggests a potential defect in the design or materials used for the license plate holder’s attachment. Response from Manufacturer: Upon contacting Tesla regarding the incident, I was informed that they consider this situation akin to a collision and hold me solely responsible for all repairs. Despite the availability of video footage and telemetry data from my vehicle that could confirm the absence of a collision, Tesla has declined to utilize these resources to investigate the incident further. Requested Action: I urge the NHTSA to consider the potential safety hazards posed by the detachment of the front license plate holder on Tesla vehicles. An investigation into the frequency and circumstances of these incidents could be warranted to ensure the safety of Tesla vehicle owners and the driving public.

I was using Autopilot (adaptive cruise control) in the toll lane. The toll lane has stretches with double white lines that separate that lane from the other, regular freeway lanes. Drivers are not supposed to cross those double white lines. In some parts of toll lane, there are sections where drivers can merge in or out of the toll lane/carpool line into or from the regular freeway lane. As I was using Autopilot in the toll lane/carpool lane, the car suddenly veered at high speed to merge into the regular freeway lane rather than staying straight in the toll lane. I had to take control of the wheel to keep the car from veering into the adjacent regular freeway lane.

Vehicle had a software update. After software update the car can see all speed limit signs while driving except for 65 mph sign. Traveling into a town car will register 45 mph, 35 mph, 25 mph signs and update the max speed to reflect the speed limit. However 65 mph signs are completely ignored. Resulting in the max speed being the speed of the last sign passed. Ie leaving a town where speed limit goes from 35 to 45 and then finally to 65 the speed on the car will only register the 45 sign and thus driver is unable to set the cruise or use autopilot at the correct speed. Contact was made with the service department but was told it was there was inconsistency between what the camera is seeing versus what is posted in the navigation maps package. It was submitted for review and will be fixed in the future but until then the only way to use cruise control at 65 is to get off onto a side road where no speed limit sign is posted turn around and get back onto the highway. I have since had 2 more software updates to the car and it is still broken.

Phantom braking while driving with Adaptive Cruise Control or on Autopilot.

Autopilot will suddenly start to slow down on highway and freeway speeds with no warning, this has happened more than 4 times. The last time that this happened me and my partner almost got rear-ended.

Tesla is using camera-only detection for Forward Collision Warning system and this leads to numerous false positive alerts. I'm filing a complaint because this did occur today (March 7, 2024), but this has happened countless times in my 2 years of ownership. This particular incident was triggered by cars parked along a curved street in my neighbor, while I was traveling approximately 20 mph with no other vehicles driving around me. These occur from simply driving next to parked cars or slowly approaching vehicles at a traffic light. When these faulty alerts occur, a loud audible beeping is heard and red alerts are displayed on the screen. These faulty alerts are dangerous distractions, causing panic, fear, and uncertainty in the driver, causing them to take their attention off of the road while they assess what just occurred. This is a critical flaw in the functionality of Tesla vehicles that the company has refused to address.

Tesla is using camera-only detection for Forward Collision Warning system and this leads to numerous false positive alerts. I'm filing a complaint because this did occur today (March 5, 2024), but this has happened countless times in my 2 years of ownership. This particular incident was triggered by cars parked along a curved street, while traveling approximately 20 mph with no other vehicles around. These occur from simply driving next to parked cars or slowly approaching vehicles at a traffic light. When these faulty alerts occur, a loud audible beeping is heard and red alerts are displayed on the screen. These faulty alerts are dangerous distractions, causing panic, fear, and uncertainty in the driver, causing them to take their attention off of the road while they assess what just occurred. This is a critical flaw in the functionality of Tesla vehicles that the company has refused to address.

A Tesla Model Y has one screen which is all instruments, warning indicators and reverse camera. On March 3rd, 2024 I had just completed about a 40 mile drive. I parked the vehicle for approximately three minutes and upon returning to the vehicle the screen failed to turn on. The vehicle ran and drove perfectly normally, but I had zero instrumentation or warning indicators. I drove home about two miles this way without incident. Upon exiting the car and closing the door (which is the equivalent to turning off the key in a traditional vehicle), the screen turned back on as normal and has since not repeated this issue. I contacted Tesla service about it and even sent them a video showing the vehicle operating with the screen not functioning and I was told to just reboot the car and they brushed it off and would not see the vehicle over this incident.

While using cruise control at highway speeds the car abruptly brakes for no reason. If another car was following too close it would have rear ended us. It happens at unexpected times and speeds. I has happened multiple times and I am to the point of not using it because of the danger it causes. It has not been inspected by any authority because of its randomness. No warnings were made prior or during the abrupt braking

Tesla is using camera-only detection for Forward Collision Warning system and this leads to numerous false positive alerts. This has happened from simply driving next to parked cars or slowly approaching vehicles at a traffic light. When these faulty alerts occur, a loud audible beeping is heard and red alerts are displayed on the screen. These faulty alerts are dangerous distractions, causing panic, fear, and uncertainty in the driver, causing them to take their attention off of the road while they assess what just occurred. This is a critical flaw in the functionality of Tesla vehicles that the company has refused to address.

I am using Full Self Driving (FSD). When i look at my screen to control the cars map it gives me a strike. I have 5 strikes it removes FSD but also removed auto pilot that has lane centering and ALSO removes the camera so if I were to have a stroke, Tonic-clonic Seizure, or heart attack or for any other issue the vehicle would not pull over like it would in FSD/Auto Pilot. THIS MAKES IT VERY UNSAFE and I could argue it violates the ADA act! For privacy I have had one of the previous issues and bought the Tesla with FSD just in case it ever happens again!!! Now i don't have that safety measure for a week and I DRIVE A LOT on two lane 75 mph highways. The basic lane assist will even shut off if i hug the lane !! How Dangerous is that???? Now i have absolutely no safety features!

turning on defrost vehicle has cracked windshield

The Automatic Windshield Mode does not function properly. On some Sunny days, the windshield wiper will automatically engage. Yet, during heavy downpours, the automatic windshield wipers will not engage or it will wipe very slowly. I have to press the stauk manual or press the manual setting while driving in the rain. Very unsafe due to distraction and poor visibility while driving.

Tail light assemblies on vehicle develop moisture inside of them when it rains. Tesla claims that this is normal and refuses to service the part. The concern is that the electronics inside the light assembly will be damaged by the moisture. This places the burden on the consumer to frequently test and inspect the tail light for an impending failure of the light which may inadvertently occur during driving and result in an accident. In certain instances the amount of moisture that may develop unbeknown to the driver while operating the vehicle, may decrease the light transmission through the light assembly, rendering the function of the tail light to fall out of NHTSA mandated standards for light transmission for the fixture.

Steering got locked stating that assistive driving was reduced. We were in front of our house and my wife was driving. She said that steering is basically unusable so we pulled back in the driveway. Normal restarts didn't fix it. We then did a hard restart of the car and that fixed it but it was scary and accident prone when locked "assistive driving reduced".

Driving in traffic this afternoon, I was turning right at a controlled intersection. I stopped my car during the turn before entering the stream of right-bound traffic. Abruptly my steering wheel was frozen: I was unable to turn the steering wheel and the car would not drive forward. There had been a dash warning light on with the message: 'Steering Assist Reduced!'. This message had been coming on intermittently during the past several weeks while driving, but without any noticeable change in the steering/handling of the car. I was blocking the traffic behind me. I called 911 and requested assistance. I got out of my car to open the "frunk" lid to alert drivers that my vehicle was disabled. I got back into the car. At some point during the 5-10 minutes that I was stopped, I re-entered my code and put the car back in drive mode and suddenly the steering wheel worked and I was able to drive home (about 2 miles). I contacted Tesla service and they suggested that I have it towed to the nearest service center, which I did.

Vehicle: 2022 Tesla Model Y VIN: [XXX] Mileage: 85,000 Complaint Description (Copy & Paste): I am filing this complaint due to serious and ongoing safety-related defects with my 2022 Tesla Model Y that remain unresolved despite multiple service visits. The vehicle experiences shuddering and vibration during regenerative braking, especially when driving downhill. In addition, the braking behavior is unpredictable, which compromises vehicle control and creates a risk of loss of control while driving. These issues occur during normal driving conditions and present a significant safety hazard to myself, my passengers, and other road users. I have taken the vehicle to Tesla for service three separate times for this issue. Despite these visits, the Tesla service department has stated they are unable to fix the problem, and the safety concern remains unresolved. I’m being having this issues since I bought the car new. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Since purchasing the car, I've had issues with the driver's side floor mat sliding and/or flapping. By sliding I mean it slides to the right and then interferes with the braking. By flapping, I mean the left separate portion/flap of the drivers side mat just randomly bends over - again causing interference with braking. I've tried to correct this issue multiple times by repositioning the floor mats. There is no way to secure the mats. I also added this concern to a pre-existing service request as it is quite annoying; however, I was told to just purchase new mats - even though my vehicle is under warranty.

The contact owns a 2022 Tesla Model Y. The contact stated that while driving at approximately 70 MPH with the Adaptive Cruise Control activated, the vehicle decelerated while driving at night in the rain. The contact was concerned about being rear-ended. There were no warning lights illuminated. The contact used the App to communicate with an unknown dealer, who responded and informed the contact that there were no hard wire issues. To contact took control of the vehicle and used the accelerator pedal to drive as needed. The failure might have been caused by false positive conditions in the surrounding area. The mechanic informed the contact to reboot the vehicle. The vehicle was not diagnosed or repaired. The contact stated that after the computer was rebooted, the Lane Departure Unavailable message was displayed. The manufacturer was not contacted. The failure mileage was approximately 23,000.

I was driving the car in a straight lane. I missed a speed bump but the car was still driving straight. After 100-150 feet driving ahead, the car suddenly steered the wheel completely towards the right side resulting in an accident where the car crashed into a wall.

By ~10:30PM, [XXX], my TESTLA Y 2022 lost power steering at the intersection of [XXX] . I was making left turn and found my car could only slightly turn left since the power steering was basically lost, almost being hit by a red sedan. There was a yellow sign on my TESTA computer: "Steering assist reduced. Steering may require increased effort". About midnight, [XXX], I called the Roadside Assistance of TESLA, informing them what went wrong. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

ALMOST POOPED MY PANTS - backed up into a parking spot to get food for family gathering. Took two family members with me to pick up the said food. Put collected food in trunk and we all got back in. Placed MYLR in “D” (drive) and sweet baby jesus it was going backwards! My family member in back yelled and I said that wasn’t me it’s in “D” look! And we all looked at each other puzzled. Then I tapped the “go” pedal one more time and sure enough backwards again. I put it in park and I was like “you all saw that right!?” We all agreed. Put it in “D” again and worked fine. Two family members said I had to watch some end of the world movie and they no longer want a Tesla after seeing that.

This is not a defect but rather something I consider could be dangerous. On slippery conditions example, during heavy snow fall, or when there is slush or if there is an icy surface, I find that the AWD system in my vehicle which is all controlled via software that the manufacturer wrote (because it is a dual electric motor setup, and there is no mechanical connection between the front and rear axle), tends to either send too much power or tried to regen too much to/from the front motor when the steering wheel is turned (something they can detect), and it tends to cause unexpected understeering which if you are not accustomed either to driving an electric car or Tesla’s AWD system could end up in a potential accident. I am writing to you because I know that my voice will go unheard since I do not have access to any of their feedback challenge. Again I do not consider that a potential dange, nothing imminent or defective with the vehicle. The fix in my opinion is a software update that could impliment road surface detection via their vision, in combination the steering angle sensor wheel slippage detection, to detect that the trajectory of the vehicle is not going as desired and mitigate that through multiple techniques of traction control, I know that with a RWD Tesla they do use the front brakes in certain conditions to force the wheels to dig in the snow and try to find traction from experience even though there is no front motor.

My vehicle was rear ended while parked on the side of the road. No one was in the car so there was no personal injury. The car was repaired but after the repair the rear tires were found to be wearing out at a rate of 4 times normal speed. Two repair facilities (one of them being a Tesla service center) measured the vehicles rear alignment and found the camber to be outside of manufacturers specifications but couldn't fix the issue as the vehicle has no way to adjust the camber on the rear wheels. The insurance company tried to have the alignment fixed but could not as Tesla would not give any instructions on how to make the repair and suggested that the problem be fixed by Tesla under a warranty repair. This determination was made because the vehicles frame was found to be fine, and the suspension was fine, but the alignment was off with no way to make an adjustment. When I tried to have Tesla repair the alignment, I was told I hit too many potholes and because the car is a performance car I drove the car to aggressively which caused the problem. I do not hit potholes and I do not drive aggressively. If I were to do either of these things the frame would show damage, and the suspension would show damage. Also, if I hit potholes the front wheels would sustain most of the damage and there no issues with the front wheel alignment. The photos in the files attached: "Rear Tire 4-2-2023" shows a rear tire after the car was repaired with no abnormal wear, "Rear Left Tire 10-4-2023" and "Rear Right Tire 10-4-2023" so abnormal wear just 6 months after repair.

Due to NHTSA Recall Number 23V-838, the car has become more dangerous than before. Often making me apply more force on the wheel when constantly alerting me which has inadvertently made me swerve into oncoming lanes. Not only has this mandatory recall made the autopilot experience much worse, but it seems highly politicized by the previous leader of nhsta and should be reinvestigated. This is such a failure of over regulation over biased leadership and should not be tolerated.

Ever since a recent update to my car, it has become far more difficult to keep the ADAS features active. It is incredibly intrusive, even just glancing at the screen to see what message it's telling me leads to the car threatening to cut off all driver assistance features. This is so dangerous. The car is a better driver on the highway than I am. It is better at holding speed, it never veers out of its lane, and it never misses someone attempting to impinge on my lane. I think something needs to be done to make this system more lenient. It used to be better but something changed in late December. People in other cars seem to be able to stare at their telephones with impunity while their car continues on without any issues. All I want is to be able to glance away from the road to see what the screen is trying to tell me.

The incident happened on 12/22/2024 8:30 am to 8:40am. Weather: heavy foggy. On freeway, no raining. Road was dry. Autopilot was off. I was trying to change lane to 2nd lane (I was in 3rd lane) and I saw a white pickup truck suddenly changed lane to the 2nd lane from 1st lane, so I turned my steering to left quickly (speed was 55-60 miles) and back to 3rd lane, and then suddenly the steering wheel was out of control, the steering wheel was turning right - left many times quicky and tilting the car. It just happened so quickly (not even a second) I wasn't able control the steering. After 3-5 seconds, it stopped. the steering was back to normal. I kept the car in 3rd lane. I almost got killed. I am glad I am still alive because it's Christmas holiday, not many cars on freeway in the early morning. Many cars behind me stayed away from me when they saw my car was out of control. I reported the incident to the Tesla manufacturer, they said they checked computer log remotely and nothing wrong, just something related to wheel slips and then cancelled my service request. I didn't know if there was any warning lamps or messages pop up because I was so scared at the moment and forgot to check.

To Whom It May Concern at the National Highway Traffic Safety Administration (NHTSA), I am writing to urgently express my concerns about the latest software update for the Tesla Model Y’s autopilot system, which, in my view, significantly compromises safety. As a Model Y owner for over two years, I have generally found the vehicle and its features to be reliable and safe. However, the recent update has introduced an overly stringent hands-on-wheel detection mechanism that is not only inconvenient but also potentially hazardous. The new update requires frequent and often forceful interaction with the steering wheel to assure the system of driver presence. This change is drastically different from my previous experience, where I received only one hands-on-wheel violation in two years. The current sensitivity of the system disrupts the smooth operation of the autopilot, leading to frequent and abrupt disengagements. I have found myself struggling to maintain the system’s activation, inadvertently causing the vehicle to exit autopilot mode multiple times. This issue goes beyond mere inconvenience; it actively detracts from driving safety. The need for constant and sometimes aggressive adjustments to satisfy the system’s requirements is distracting and can lead to erratic vehicle behavior. The irony is stark: a system designed to enhance driving safety and ease is now a source of potential danger and stress. The unpredictability and over-sensitivity of the updated system could lead to dangerous situations, especially on highways or in heavy traffic, where sudden disengagement of the autopilot can be particularly risky. As a driver, I now find myself more focused on keeping the autopilot engaged than on the actual driving conditions and surroundings, which is surely contrary to the feature’s intended purpose. I urge the NHTSA to investigate this situation and cancel the recall.

Subject: Safety Concerns Regarding Recent Model Y Autopilot Update To Whom It May Concern at the National Highway Traffic Safety Administration (NHTSA), I am writing to urgently express my concerns about the latest software update for the Tesla Model Y’s autopilot system, which, in my view, significantly compromises safety. As a Model Y owner for over two years, I have generally found the vehicle and its features to be reliable and safe. However, the recent update has introduced an overly stringent hands-on-wheel detection mechanism that is not only inconvenient but also potentially hazardous. The new update requires frequent and often forceful interaction with the steering wheel to assure the system of driver presence. This change is drastically different from my previous experience, where I received only one hands-on-wheel violation in two years. The current sensitivity of the system disrupts the smooth operation of the autopilot, leading to frequent and abrupt disengagements. I have found myself struggling to maintain the system’s activation, inadvertently causing the vehicle to exit autopilot mode multiple times. This issue goes beyond mere inconvenience; it actively detracts from driving safety. The need for constant and sometimes aggressive adjustments to satisfy the system’s requirements is distracting and can lead to erratic vehicle behavior. The irony is stark: a system designed to enhance driving safety and ease is now a source of potential danger and stress. The unpredictability and over-sensitivity of the updated system could lead to dangerous situations, especially on highways or in heavy traffic, where sudden disengagement of the autopilot can be particularly risky. As a driver, I now find myself more focused on keeping the autopilot engaged than on the actual driving conditions and surroundings, which is surely contrary to the feature’s intended purpose. I urge the NHTSA to investigate this and stop enforcing ridiculous changes to Tesla.

Subject: Safety Concerns Regarding Recent Model Y Autopilot Update To Whom It May Concern at the National Highway Traffic Safety Administration (NHTSA), I am writing to urgently express my concerns about the latest software update for the Tesla Model Y's autopilot system, which, in my view, significantly compromises safety. As a Model Y owner for over two years, I have generally found the vehicle and its features to be reliable and safe. However, the recent update has introduced an overly stringent hands-on-wheel detection mechanism that is not only inconvenient but also potentially hazardous. The new update requires frequent and often forceful interaction with the steering wheel to assure the system of driver presence. This change is drastically different from my previous experience, where I received only one hands-on-wheel violation in two years. The current sensitivity of the system disrupts the smooth operation of the autopilot, leading to frequent and abrupt disengagements. I have found myself struggling to maintain the system’s activation, inadvertently causing the vehicle to exit autopilot mode multiple times. This issue goes beyond mere inconvenience; it actively detracts from driving safety. The need for constant and sometimes aggressive adjustments to satisfy the system’s requirements is distracting and can lead to erratic vehicle behavior. The irony is stark: a system designed to enhance driving safety and ease is now a source of potential danger and stress. The unpredictability and over-sensitivity of the updated system could lead to dangerous situations, especially on highways or in heavy traffic, where sudden disengagement of the autopilot can be particularly risky. As a driver, I now find myself more focused on keeping the autopilot engaged than on the actual driving conditions and surroundings, which is surely contrary to the feature’s intended purpose. I urge the NHTSA to investigate this

The contact owns a 2022 Tesla Model Y. The contact stated that while her husband was driving at 60 MPH, a large plastic object was in the roadway causing the contact to crash into the object. The contact stated that there was no warning from the manufacturer's forward collision avoidance system or any other safety system, the cruise control was engaged at the time of the crash. The contact stated that her husband swerved to the left to avoid the object and the front passenger side bumper, passenger corner of the hood and headlight crashed into the plastic object and were fractured and crushed. The contact stated no warning light was illuminated and the air bags had not deployed. The contact stated that there were no injuries and that the police were on the scene and filed a report. The vehicle was drivable and the contact drove back to her residence with her husband. The vehicle was not diagnosed or repaired. The manufacturer was notified of the failure. The failure mileage was approximately 26,000.

The contact rented a 2022 Tesla Model Y. The contact stated that while driving 70 MPH with the Adaptive Cruise Control activated, the vehicle experienced Phantom Braking and abruptly decelerated. The contact stated that the failure had occurred twice during the trip; after de-activating the Adaptive Cruise Control, the vehicle operated normally. During the failure there were no other vehicles or objects nearby. The cause of the failure was not yet determined. The manufacturer, the local dealer, and the Rental Car Company were not yet notified of the failure. The failure mileage was 32,000. The VIN was not available.

Front passenger safety restraint system fault

"Phantom breaking" issue. When the vehicle is placed in cruise control the vehicle just randomly slams on the breaks; this typically happens when on the freeway/highway at speeds of 55 mph or greater. My wife and I have experienced this extremely dangerous issue from day 1 of taking possession of our Tesla over a year ago. I've reported it to Tesla and also spoken to the repair technicians that work on the Tesla vehicles. They're aware of the issue and haven't done anything to help or even offered to fix the issue. The technicians advised me that they are fully aware of the issue, and Tesla has no fix at this time. This is totally unacceptable and extremely dangerous. We've nearly gotten into a couple of major accidents because of this uncorrected issue.

The contact owned a 2022 Tesla Model Y. The contact stated while driving 60-70 MPH, she noticed a burning smell. There was no warning light illuminated. The contact then noticed sparks coming from the front passenger's side tire area. Another driver alerted the contact of an issue, and the contact immediately veered to the side of the road. The contact then noticed that the sparks coming from the front passenger's side tire area had become significant and had turned into flames. The front end of the vehicle caught on fire. The fire department extinguished the fire; however, a fire department report was not filed. There was no police report filed. The contact sustained minor bruises while exiting the vehicle. Additionally, the contact sustained an emotional trauma and intended to receive therapeutic assistance. The vehicle was towed to a tow lot. The insurance company then towed the vehicle to another tow lot, where it was totaled. The manufacturer was notified of the failure, but no assistance was provided. The failure mileage was 30,028.

Windshield of my car cracked spontaneously in two different occasions for no apparent reasons. First incident's occurred in June 2023 resulting in replacement of the windshield. Second incident occurred on December 4,2023 & vehicle is scheduled for replacement of the windshield. I thought the first event was due to rock hitting my car while driving on the highway but very likely it’s a spontaneous crack like the second.

The seat belt buckle not latching and keep popped out while driving

HVAC system in vehicle seemed to lack power since first use and now the HVAC system doesn’t operate (cold or hot).

Date: 12/1/2023 Time: Approximately 5:20 AM Location: Intersection of [XXX] and [XXX] Vehicle 1: Type: Tesla Model Y Mode: Full Self-Driving (FSD) Direction: Eastbound on XXX Avenue Speed: Approximately 30 MPH Vehicle 2: Type: Sedan (Make and Model Unknown) Direction: Southbound on XXXX Avenue, turning right Incident Description: While operating a Tesla Model Y in Full Self-Driving mode, I was traveling eastbound on XXX Avenue in Summit at around 30 MPH. The incident occurred at the intersection of XXX Avenue and XXX Avenue. At this intersection, the traffic light for XXX Avenue was flashing yellow, indicating caution, while the light for XXX Avenue was flashing red, signaling a stop requirement for vehicles on that road. As I approached the intersection, a sedan traveling southbound on XXX Avenue initiated a right turn onto XXX Avenue. Despite the flashing red light for the sedan's direction, the Tesla's FSD system, which was controlling the vehicle at the time, appeared to misinterpret the right-of-way. The Tesla continued at the same speed without reducing, shifting lanes, or showing any indication of yielding to the turning sedan. Recognizing the impending risk of collision, the sedan driver executed a sharp right turn, narrowly avoiding an accident but coming close to the curb in the process. Realizing the Tesla's FSD system was not responding appropriately to the traffic situation, I quickly disengaged the FSD mode and manually took control of the vehicle to avert a potential collision. Remarks: This incident highlights a concern regarding the current capabilities of the Full Self-Driving system in complex traffic scenarios, particularly at intersections with flashing traffic signals. It underscores the necessity for continuous driver attention and readiness to assume control, even when FSD is engaged. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Rear driver side seat belt won’t latch. Passenger cannot properly fasten seatbelt.

We bought a 2022 Tesla Y performance in August 2023. Love the car but customer service in the service center is and has been beyond horrible and frustrating. We had a back seat (driver side) panel that was not snapped in properly. In November 2023 we took it to a service center so they could fix it. They said they needed to order the part and they would send someone to come to our house to fix it. On 2 different occasions someone came to our house to fix it. The first service tech replaced the bottom piece but it wasn’t snapping in securely so he said they need to order the middle piece. The 2nd service tech came to the house and said they did not send him with the correct part and he will schedule an appt for us to come to the service center. We scheduled an appt to go to ant other service center (an hour away) and they had our car for a couple hours and gave us a loaner. When my husband went to pick it up they did not fix the panel and it was not snapped in correctly. We have a picture of it. They said they would have to order the part and schedule us to come back to fix it. We went back and they said it would be 2 hours and my husband was already waiting an hour. They did not fix it and we left. Very rude customer service.

On the highway I set my cruise control. It registers as the max speed on the tesla screen. Regularly the max speed changes very suddenly and the vehicle brakes. For my most recent trip drove on the highway and this happened 3 times. The max speed changed from 78 mph (the speed I set it at) to 40 mph. Another time it changed to 45 mph and a third time to 55 mph. Sometimes there are cars directly behind me when this happens. The sudden change in speed on a highway is very dangerous. I have also reported this to Tesla.

I was driving at 64 mph utilizing the Adaptive Cruise Control and Autosteer (Beta). I was in the first of a two lane divided highway with no vehicles within 1000 feet in front of me and several cars passing me on my left. Fortunately, I had both hands on the wheel at the 10 and 2 positions and have good arm strength. Suddenly, abruptly and violently the car took over the steering and braking swerving to the left about a foot or so then applying the brakes hard while simultaneously turning the front wheels about 65 degrees to the right. I believe another vehicle without the Tesla's low center of gravity would surly have rolled over. I was now heading across the breakdown lane towards the guardrail. With great effort I took over control of the steering just 1-2 feet from the guardrail pulling hard left and pressing down on the accelerator (to release the brakes) causing a second roll over feeling. I then turned right to straighten the car out and continued down the highway in the same lane without contacting any objects. I felt the violent nature of the swerving in my lower back and left arm. The car did not want to release the steering to me. I have no evidence other than the experience of my wife and me. I was coming off a white concrete bridge deck with a slight left curve without any lane markings. At the moment of the incident the bridge deck was covered with a large area of black tar. I believe these two factors caused the car to go into some kind of avoidance maneuver. I also believe a lesser capable driver may have been killed.

My Tesla model Y performance 2022 was purchased on September 26, 2022. I found that the left rear wheel was leaking in July 2023. After other tire repair shops failed to find the cause of the leak, I went to the Alhambra Tesla service center for further inspection. They found that my wheels rims had cracks that caused the tire to leak very slowly. These cracks are invisible to the naked eye (I still have this wheel rim at home). During my negotiation with this Tesla service center, they told me that it was my use that caused the wheels rims to crack, and they would not be responsible for the wheels rims. I disagreed with their decision and bought a new WHEEL RIM at my own expense. I use this car for work. I have never driven this car for strenuous exercise or to steep mountains. This is my vehicle usage scenario. In February 2024, the same situation occurred on my right rear wheel. My wheel began to leak slowly and I couldn't find the reason. After multiple inspections, Tesla service center found that there was a very small crack in the right rear wheel rim. The conclusion of TESLA SERVICE CENTER is still that my use caused the crack of the wheel rims. TESLA MODEL Y PERFORMANCE is a high-performance sports car. The wheels rims are specially made 22 inches and are produced by the original factory. There have been many cases of wheels rims cracking in 18 months. I hope to attract your attention and conduct product quality inspections, which is very important for safety.