2023 Tesla Model Y Steering Problems

On the evening of April 8th 2026, my wife was driving our 2023 Tesla Model Y home in San Francisco, CA when she noticed unusual noise coming from the front left wheel area. The vehicle was otherwise functioning normally aside from the noise. The following morning, I inspected the vehicle and found a large hex bolt (Class 10.9 grade) on the ground directly beneath the car. The front left wheel was binding and the vehicle was completely undrivable — the wheel felt stuck and made grinding/scraping noises when attempting to move. Based on the bolt size, grade, and location, this appears to be a front suspension lateral link fastener that detached from the subframe. This is the same defect described in NHTSA recalls 21V-835, 22V-895, and 23V-235, involving under-torqued or improperly secured front suspension fasteners on Tesla Model Y vehicles. The vehicle had 28,482 miles at the time of the incident. There was no prior collision, impact, or road hazard event. No warning or alert appeared on the Tesla touchscreen at any point. The vehicle displayed no diagnostic message despite having a compromised suspension component.

I was parking my vehicle in my driveway, turning left to park in front of my garage and heard a loud pop. I got out, looked underneath the car and didnt see anything unusual. I later investigated by moving the vehicle and noticed my steering wheel was turning without any driver input, and heard the tires scrubbing more than normal. I got out of the vehicle and noticed my tires were not aligned, having one tire pointing to the left, and the other tire pointing straight. Then I noticed a large bolt on the ground. I called Tesla and they told me my car was 2000 miles out of warranty and would have to pay for towing and the repair. I feel the steering should still be covered under warranty.

Catastrophic Axle Failure, I was driving out from my driveway when this happened. Just the day before my wife was driving on the highway, and I was driving with my two boys. I have video of the complete failure of the left driver's side axle. The vehicle was towed by the dealer and is at the dealer as we speak. There has been no inspection by the police or insurance representative. We had reported it to Tesla at our last appointment but they said they could not recreate the noise.

On February 23, 2026, I was driving my 2023 Tesla Model Y under normal city conditions. While parallel parking at very low speed, I suddenly heard a loud metallic bang from the driver’s side of the vehicle. Immediately afterward, the vehicle lost mobility and the steering wheel became unresponsive and would not turn. I exited the vehicle and observed a detached metal suspension component and a bolt on the ground underneath the driver’s side. The vehicle was not drivable and required towing. I contacted Tesla Roadside Assistance through the Tesla app, and the vehicle was towed to Tesla Service Center in Coral Gables, Florida. At the time of the incident, there had been no collision, no impact with a pothole, curb, or road debris, and no prior warning signs or noises indicating a developing issue. The failure occurred suddenly during a low-speed maneuver. Tesla Service initially indicated that the vehicle was under warranty and that repairs would be covered if no external impact was found. However, after inspection, Tesla attributed the failure to an alleged “external impact” and declined warranty coverage, providing an estimate of approximately $4,000. After involving my insurance company, the vehicle was inspected by a Tesla-certified repair facility, which found significantly more extensive damage to the suspension system, estimating repairs at approximately $11,000. This incident represents a sudden and complete failure of suspension components resulting in immediate loss of steering control. Such a failure poses a serious safety risk, particularly if it were to occur at higher speeds, as it could lead to loss of vehicle control and a crash. I am reporting this issue as a potential safety defect involving suspension component separation and steering loss in a 2023 Tesla Model Y.

like many have mentioned, the control arm bolt came off or broke. [XXX] / [XXX] / [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

While making a left turn at normal turning speed, the steering system became unresponsive. The steering wheel was able to move; however, there was no corresponding movement of the front tires/wheels. The front wheels appeared to remain stuck at approximately a 45-degree left position and did not return toward the straight-ahead position despite steering input. It is also possible that the steering wheel itself became locked or partially locked during this event. As a result, the vehicle could not be corrected and collided with the median and a pillar. The collision caused the airbags to deploy and resulted in severe front-end damage, with an estimated repair cost exceeding $40,000. This steering failure occurred without warning and resulted in a sudden loss of vehicle control, creating a serious safety hazard to the occupants and surrounding traffic. The vehicle was subsequently declared a total loss.

While traveling at highway speeds, the vehicle suddenly veered to the right without driver input. The Autopilot/FSD system was not engaged. It all happened in a matter of seconds. There was no system failure message on the screen. The vehicle airborne and hit a tree. All side airbag were deployed. Was able to open the door and walk away without any major injuries. Software update : 2025.44.25.5

All in the same day: 1) Odd sound from behind the pedal area of driver side front quarter (sounded like a styrofoam cooler top rubbing against the cooler is the best way to describe - faint though). 2)BANG when in a parking garage turning full right but still able to control without difficulty. Made it home without incident. 3)Later that day, just after getting off of I4 in Orlando I pulled into grocery parking lot and parked. When I returned to my car I again turned right and a loud BANG and the car jerked to a sudden halt. I was able to back into a parking spot but there were 2 large screws in the driving land and the left wheel was toed slightly to the left. Ultimately it was detached when we tried to tow it we had to remove tire and put on a device to allow us to move it. Per Tesla “I have updated that estimate! The vehicle has very heavy damage, and this is the start. Once we replace these components their (sic) could be more damage, and it also could potentially need to go to a body shop!” Thankfully this didn’t happen at speed with my daughter in the car on I4! This is unsafe and a simple internet search revealed it is not an uncommon parts failure at this mileage! This is dangerous. All of this at just 54,000 miles. (4k out of warranty)

I was driving on the highway at around 70mph, switched lanes and the steering wheel randomly locked up. Gladly, I was aware of the situation and avoided a HUGE car crash but the steering started to work a few seconds later. I am very nervous to drive the car now.

While driving approximately 5–10 mph and making a right turn on a local street, the vehicle suddenly produced a metallic pulling sound followed by a loud impact. The vehicle abruptly stopped and became undrivable. Upon exiting the vehicle, the left front wheel was visibly displaced from normal alignment and appeared to have shifted rearward into the wheel well. No collision, curb strike, pothole, or road debris was involved. The vehicle had exhibited a wire-tugging or metallic noise during turning in the days prior. The failure occurred without warning and resulted in a sudden loss of vehicle control at low speed. The vehicle was towed to Tesla, where the left front control arm was found to be disconnected/broken. Tesla has not yet provided a determination and is attempting to route the vehicle to a collision center despite no evidence of impact. This appears to be a suspension component failure that could have resulted in a serious accident at higher speeds. Safety Impact: Loss of steering control, risk of crash, inability to drive vehicle.

My Model Y experienced a sudden steering assist failure while driving. The wheel became extremely stiff/locked even though Autosteer was off. Multiple thermal system faults appeared: VCRIGHT_a271_THSSensorFault, VCRIGHT_a257_THSMIA, GTW_w043_THSVersionMismatch, and HVACSystemNotNominal This was very scary as I was driving and had no control of steering wheel because it locked.

Currently on the newest Tesla Full Self Driving software v14.1.4, it is phantom breaking as well as phantom swearing out of nowhere. It is swerving and using the breaks so hard it actually affects the steering wheel and self disengages it's self (without the big-loud safety alert to immediately take over control), it just does the soft disengage audio notification, like if you wanted to cancel FSD yourself. The serious problem is that the car does not stop like it should, instead it just continues it seems like it just neutrally rolls on its own drive and twice in the last week it would swerve directly into oncoming traffic. It is not supposed to be doing this at all, especially now that the "hands off" approval is enacted. I drive about 450 miles a week and this has happened about twice a week for the last two weeks. Thank god i was paying attention all four times, but I am so worried this is going to kill someone. I have tried to call TESLA but they purposely don't staff their phones and no one answers.

I am writing to file a complaint regarding a safety issue with my 2023 Model Y Performance Tesla vehicle. The steering wheel's faux leather covering is peeling and bubbling, causing the material to come off while driving. This poses a significant hazard as it compromises my grip and creates a distraction, potentially leading to loss of control. Additionally, Tesla does NOT want to repair this, even though I’m still under warranty.

Two days ago a warning popped up on the Tesla screen saying to schedule service for something the car had detected. It said the car could still be driven. I submitted a service request in the app, and in the meantime researched the error. Per Google, it said this was a potential issue with suspension / steering components that needed to be looked at. The next day, a Tesla technician called and asked what my appointment was for. I told him about the error and that I had found it said it was for a suspension or steering issue. He told me I was wrong, and that it was only for low tire pressure. The car did not have low tire pressure. He said the appointment wasn't needed, cancelled the appointment, and told me to drive 30-40 miles to clear the error. Literally 5 hours later, after my wife driving my kids down the freeway, when parking on the street in front go my house the car made a giant pop and the front left sank. We looked under the car and the front drivers side control arm had completely disconnected, popping straight down towards the road. More concerning, two bolts popped out, not broken, but just clearly loose and had finally unscrewed. You will see them on the ground in the pictures. If this had happened 5 minutes earlier while on the freeway I don't want to even think about what might have happened. These cars should be recalled, this is super dangerous. Not to mention the fact that Tesla explicitly canceled my appointment for this and told me not to bring the car in.

The contact owns a 2023 Tesla Model Y. The contact stated while driving at an undisclosed speed, there was an abnormal sound coming from the steering wheel, and the electronic power steering was not functioning properly, requiring an increased effort to maneuver the vehicle. No warning lights were illuminated. The vehicle was not taken to the dealer or an independent mechanic. The vehicle was not repaired. The manufacturer was notified of the failure, a case was opened, and the contact was referred to the NHTSA Hotline for assistance. The failure mileage was 20,000.

According to TESLA service, my two "lateral links" for the front wheels need to be replaced. They sent us photos of the issue and it looks like one of the fasteners for one of the lateral links was missing (1 of two fasteners) If the other fastener failed/fell out the car could easily steer out of control. The problem of the lateral links was confirmed by Tesla servicing. They are repairing it under warranty. It was only been inspected by the manufacturer, Tesla. There were no warning lamps. The only indication was the thumping sound during turns.

Making a right turn and heard a pop sound. Pulled into a parking lot immediately found the steering arm dropped and shortly after a large bolt fell out. There is supposed to be 2 bolts holding up each side, one bolt was already missing. Event occurred without incident. Normal street driving at a low speed turn.

The contact owns a 2023 Tesla Model Y. The contact stated while driving at an undisclosed speed and attempting to complete a left turn, the contact briefly heard an abnormal clicking sound coming from the front end of the vehicle, after which the steering wheel jerked abnormally. The vehicle quickly returned to normal functionality, but the failure became a regular occurrence. No warning lights were illuminated. The vehicle was taken to the dealer, who diagnosed a failure with the front-end suspension bushings. The contact was also informed that a bolt on the driver’s side control arm had loosened. The vehicle was repaired. The manufacturer was not notified of the failure. The failure mileage was 54,000.

The contact owned a 2023 Tesla Model Y. The contact stated that while driving approximately 45 - 50 MPH, the contact lost control of the vehicle. The contact stated that while attempting to regain control of the vehicle and attempting to correct the steering wheel, the vehicle kept going to the right and to the left independently. The contact was unable to regain control of the vehicle. The contact stated that the vehicle struck a railing and a concrete divider with the passenger’s side front bumper and then the rear passenger’s side quarter panel, and the vehicle spun around on the highway and came to a stop. The contact pressed the emergency latch to exit the vehicle out of fear that the vehicle might catch on fire. The contact stated that the rear passenger’s side tire was pushed back due to the impact. There were no warning lights illuminated. The contact stated that all the air bags deployed as designed. The vehicle was towed to a local Collision Center. A Police report was filed. The contact stated that the vehicle was deemed destroyed by the Insurance Provider. The contact sustained injuries to the upper back, left shoulder, right elbow, and neck; however, there were no broken bones reported. The contact received medical attention for the injuries sustained. The local dealer was not contacted, and the vehicle was not diagnosed or repaired. The manufacturer was not yet notified of the failure. The approximate failure mileage was 40,000.

UNKNOWN I was driving with no Advanced Driver Assistance Systems (ADAS). My vehicle took control of the steering wheel, swerving uncontrollably, almost hitting approaching cars, and a wooden electricity post. It was diffucult to keep the steering wheel steady. I struggled to pull the vehicle to the side of the road until I made a complete stop. A witness checked on me and was concerned that I had almost crashed.