2002 Toyota Highlander Speed Control & Cruise Problems

ACCELERATOR STICIKING. VEHICLE ACCELERATES AT 4000 TO 5000 RPMS HAD VEHICE TOWED TO TOYOTA OF BEDFORD 440-809-8399

WHILE DRIVING HOME THE CAR ACCELERATED ON IT,S OWN AND WAS UNABLE TO STOP WITHOUT REARENDING ANOTHER CAR WITHALL THE DAMAGE TO MY CAR AS A MECHANIC I REPAIRED THE BODY ON MY OWN AFTER MAKING REPAIRS I WAS ABLE TO DRIVE THE CAR FROM THE SHOP I WORK AT TO MY HOUSE THE CAR WAS IDLING A LITTLE HIGH .I RETURNED TOWARD WORK THE NEXT MORNING TO SCAN THE CAR FOR HIGH IDLE .THE CAR ACCELERATED TO OVER 100 MPH WITH MY FOOT OFF THE ACCELERATER AND BOTH FEET ON THE BRAKE PEDAL I HAD TO SHUT THE CAR OFF TOSTOP IT I HAD IT TOWED TO WORK I SCAN IT AND FOUND CODE C1203 WHICH IS A COMUNICATION FAULT FROM THE ECM TO THE VEHICLE SPEED CONTROLLER WHILE RESEARCHING THE CODE I FOUND THAT MY CAR FELL UNDER A CLASS ACTION LAW SUIT FOR THIS PROBLEM I NOTIFYED TOYOTA WHERE THEY SENT AN OUTSIDE ADJUSTER OUT TO EXAMINE THE CAR HE FILED A REPORT TO TOYOTA SAYING THERE WAS NO PROBLEM HE DID NOT MENTION THE CODE IN HIS REPORT I FILED AN APPEAL ON OCTOBER 2017 AND HAVE NOT HEARD OF ANYTHING WITH THIS PROBLEM I HAVE BEEN A MECHANIC FOR OVER 35 YEARS AND EXPLAIN THE PROBLEM TO THEM WITH NO SOLUTION THIS HAS BEEN GOING ON SINCE MAY2017 I JUST WANT A SOLUTION TO THE PROBLEM WITHOUT HAVING TO EXPLAIN A FIX TO TOYOTA FOR THIER CLASS ACTION SETTLEMENT IT SEEMS THAT THE INDEPENENT ASSESSOR IS WORKING FOR TOYOTA AND NOT THE CONSUMER

VEHICLE WAS IN MOTION ON A CITY STREET GOING STRAIGHT SLIGHTLY DOWNHILL AND THEN UPHILL. THE WEATHER WAS CLEAR. SPEED WAS ABOUT 15-25 MPH. I WAS BRAKING TO SLOW THE CAR DOWN BUT THE CAR ACCELERATED ON ITS OWN ( TOYOTA CALLS IT "UNINTENDED ACCELERATION"). THE CAR CONTINUED ACCELERATING EVEN THOUGH I WAS PRESSING THE BRAKES AS HARD AS I COULD AND IT WAS NOW GOING UPHILL.. TO AVOID CRASHING I PUT THE CAR IN NEUTRAL, AND ENGAGED THE EMERGENCY BRAKE AND HAZARDS. THE ENGINE RACED IN NEUTRAL AND THEN STOPPED RACING.. TOYOTA STARTED A CASE FILE AND INSPECTED IT. THEY SAID EVERYTHING IS WORKING PROPERLY NOW, CASE CLOSED AND I CAN COME GET THE CAR. I HAD IT TOWED THERE AND AM AFRAID TO DRIVE IT UNTIL SOMETHING IS FIXED. IT WAS A TERRIFYING EXPERIENCE. I AM CONCERNED IT COULD HAPPEN AGAIN OR TO OTHER CARS. I AM THOROUGHLY DISAPPOINTED IN TOYOTA'S NONCHALANT ATTITUDE; IT WAS-IS A POTENTIALLY FATAL SITUATION, AND IT SEEMS THAT ACCORDING TO TOYOTA IF SUCH AN ACCIDENT WAS INVESTIGATED NOTHING WOULD SHOW UP.

BOUGHT THIS VEHICLE IN 2002. A YEAR LATER NOTICED THAT THE IDLE CONTROLLER HAD PROBLEM. WHEN STARTED THE ENGINE IN THE MORNING, THE IDLE WENT DOWN VERY LOW AND THE ENGINE SHUT DOWN AUTOMATICALLY. AT FIRST IT HAPPENED NOT FREQUENTLY. PAST TWO YEARS I TOOK TO A DEALER FOR MAYOR TUNEUP, THE SYMPTOM STILL RESISTED. TOLD THE DEALER AND THERE WAS NO ACTIONS AT ALL. NOW IT HAPPENS MORE FREQUENTLY. USUALLY IF IT HAPPENS, STEP ON THE GAS PEDDLE ( OVER 2K RPM) FOR A FEW SECONDS. SOMETIMES THE IDLE RETURNS TO NORMAL; BUT MOST OF THE TIMES, THE IDLE SETS VERY LOW. I THINK THE IDLE CONTROL FOR THIS MODEL SHOULD BE RECALLED. *TR

ENGINE ACCELERATING WHEN BRAKES WERE DEPRESSED. *TR

TL* THE CONTACT OWNS A 2002 TOYOTA HIGHLANDER. THE CONTACT STATED WHILE DRIVING AT APPROXIMATELY 35MPH, THE ACCELERATOR CABLE DISCONNECTED CAUSING THE VEHICLE TO ACCELERATE. THE CONTACT MENTIONED THAT THE BRAKES WERE ENGAGED IN TO STOP THE VEHICLE FROM MOVING FORWARD. THE DEALER STATED THAT THE WRONG CABLE WAS PLACED IN VEHICLE. THE CONTACT STATED THAT THE TRANSMISSION BECAME DEFECTIVE AS A RESULT OF ENGAGING THE BRAKES WHILE THE VEHICLE WAS ACCELERATING. THE DEALER AND MANUFACTURER WERE MADE AWARE OF THE PROBLEM. THE FAILURE MILEAGE WAS 200,000.

TL* THE CONTACT OWNS A 2002 TOYOTA HIGHLANDER. THE CONTACT WAS DRIVING 60 MPH WHEN THE VEHICLE SUDDENLY ACCELERATED WITHOUT ANY WARNING. THE CONTACT DEPRESSED THE BRAKE PEDAL BUT THE VEHICLE FAILED TO STOP. THE CONTACT HAD TO COMPLETELY TURN OFF THE ENGINE IN ORDER TO GET THE VEHICLE TO STOP. THE VEHICLE WAS TOWED TO A DEALER WHO DIAGNOSED THAT THE ACCELERATOR CABLE WAS STUCK IN THE FORWARD POSITION AND NEEDED TO BE REPLACED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE WHO DID NOT OFFER ANY ASSISTANCE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND THE CURRENT MILEAGE WAS 210,000.

TL*THE CONTACT OWNS A 2002 TOYOTA HIGHLANDER LTD (N/A). WHILE DRIVING 60 MPH AND SPEEDING TO 70 MPH TO PASS ANOTHER VEHICLE, THE ACCELERATOR PEDAL STUCK AND WOULD NOT RELEASE. THE PASSENGER REMOVED THE FLOOR MATS BUT THE VEHICLE CONTINUED TO ACCELERATE RAPIDLY. THE CONTACT MANEUVERED THE VEHICLE TO THE SIDE OF THE ROAD BY DEPRESSING THE BRAKE PEDAL FIRMLY, SHIFTING INTO NEUTRAL AND TURNING THE ENGINE OFF. THE RPMS CONTINUED TO INCREASE EXCESSIVELY. THE VEHICLE WAS TOWED TO AN AUTHORIZED DEALER WHERE THE CONTACT WAS INFORMED THAT THE THROTTLE BODY HAD CARBON AND BUILT UP CORROSION WHICH CAUSED THE FAILURE. THE CONTACT CALLED THE MANUFACTURER WHO OFFERED NO ASSISTANCE AS THE VEHICLE WAS TOO OLD, TOO HIGH IN MILEAGE AND NO LONGER UNDER WARRANTY. THE VIN WAS UNAVAILABLE. THE FAILURE MILEAGE WAS APPROXIMATELY 218,000.

FROM A STOPPED POSITION ON A SIDE STREET, I PRESSED THE ACCELERATOR TO PULL ONTO A MAIN STREET. BECAUSE TRAFFIC ON THE MAIN STREET MOVES RATHER FAST, I ACCELERATED SOMEWHAT ABOVE NORMAL, BUT IN NO WAY EXCESSIVE. AFTER GETTING INTO MY LANE, I BACKED OFF THE ACCELERATOR, BUT THE ENGINE ACTED AS IF I WAS FLOORING IT AND THE CAR CONTINUED ACCELERATING. IT WAS SCARY. I PUSHED HARD ON THE BREAK. THE CAR STILL ACCELERATED. I STEPPED ON THE HAND BRAKE. IT CONTINUED TO ACCELERATE. FINALLY, I TOOK THE CAR OUT OF DRIVE AND INTO NEUTRAL. THE ENGINE CONTINUED TO SCREAM, BUT I WAS ABLE TO STOP AT THE SIDE OF THE ROAD. AT SOME POINT THE ENGINE DID COME DOWN TO NORMAL IDLE, BUT I WAS SO SHAKEN, I REALLY DON'T KNOW WHEN THAT HAPPENED. FORTUNATELY NO ONE WAS AHEAD OF ME, THE ROAD IS STRAIGHT AND LEVEL, ETC. ASIDE FROM SHATTERED NERVES, THERE WAS NO HARM DONE. BUT I CAN IMAGINE ALL KINDS OF HORRIBLE OUTCOMES HAD CONDITIONS BEEN DIFFERENT. THE CAR ACTED AS IF THE ACCELERATOR STUCK ALL THE WAY DOWN, HOWEVER I KNOW I DIDN'T PRESS IT DOWN THAT FAR. LATER MY HUSBAND DROVE THE CAR HOME FROM WHERE I STOPPED IT. WITH THE CAR OFF, MY HUSBAND INSPECTED THE ACCELERATOR PEDAL PRESSING IT WITH HIS HAND AND LETTING IT BACK UP. THERE IS A POINT ABOUT HALF WAY BACK UP WHERE THE MECHANISM IS NOT SMOOTH. THE PEDAL COMES ALL THE WAY BACK UP, BUT SOMETHING INSIDE CATCHES AND CAUSES LOTS OF GAS TO FLOW INTO THE ENGINE. AT LEAST ONE TIME HE WAS ABLE TO REPRODUCE THE PROBLEM WITH THE CAR IN PARK. I AM AFRAID TO EVER DRIVE IT AGAIN. THIS TIME I WAS LUCKY, BUT I SHUTTER TO THINK. IF SOMEONE HAD BEEN IN ONE OF THE CROSSWALKS. IF I HAD BEEN APPROACHING A RED LIGHT. WHEN MIGHT THIS HAPPEN AGAIN? *TR

TL* THE CONTACT OWNS A 2002 TOYOTA HIGHLANDER. THE CONTACT STATED WHILE DRIVING AT SPEEDS OF 70 MPH, THE VEHICLE ABNORMALLY ACCELERATED. THIS WAS THE THIRD INCIDENT OF UNINTENDED ACCELERATION IN THE VEHICLE. ON THE FIRST INCIDENT, THE CONTACT WAS ABLE TO STOP THE VEHICLE BY APPLYING CONSTANT, STEADY PRESSURE TO THE BRAKE PEDAL. ON THE SECOND INCIDENT, THE ACCELERATOR PEDAL BECAME STUCK IN THE OPEN THROTTLE POSITION AND HE WAS ABLE TO MANUALLY REMOVE THE PEDAL FROM THE STUCK POSITION. THE DEALER WAS UNABLE TO DUPLICATE THE FAILURE AND THERE WERE NO REPAIRS MADE TO THE VEHICLE. THE MANUFACTURER ADVISED THE VEHICLE WAS NOT UNDER RECALL AND WOULD NOT PROVIDE ANY ASSISTANCE. THE FAILURE MILEAGE WAS 114,000 AND THE CURRENT MILEAGE WAS 114,532.

TL*THE CONTACT OWNS A 2002 TOYOTA HIGHLANDER. WHILE STARTING THE VEHICLE HE HEARD A LOUD NOISE, AND THE RPMS RAPIDLY INCREASED FOR APPROXIMATELY 15 SECONDS BEFORE THE RPMS DECREASED. THE FAILURE OCCURRED ONE TIME AND DIDN'T RECUR WHEN THE CONTACT WAS DRIVING THE VEHICLE. THE DEALER STATED THAT THERE WERE NO RELATED RECALLS. THE FAILURE MILEAGE WAS 23,000. THE CURRENT MILEAGE IS 23,500. UPDATED 03/12/10. *LJ UPDATED 07/12/10*JB

TOYOTA HIGHLANDER 2005. PETERBORO , NH. 11 AM. DRIVER WAS REPORTED TO PASS VEHICLE ON RIGHT IN BREAK DOWN LANE, THEN TRIED TO PASS ANOTHER CAR BY GOING INTO LEFT LANE AND HIT ONCOMING VEHICLE. FOUR PEOPLE KILLED. DRIVER WAS VERY EXPERIENCED --EXCELLENT SAFETY RECORD. I HAD BEEN IN HIS CAR WITH HIM HUNDREDS OF TIMES. VERY SAFE DRIVER --NO COWBOY. BELIEVE CAR HAD UNCONTROLLED ACCELERATION. *CN UPDATED 05/10/10 *BF UPDATED 10/04/10 UPDATED 9/27/11*CW THE INVESTIGATING POLICE OFFICER INSPECTED THE INTERIOR OF THE TOYOTA AND NOTED THE DRIVER'S CARPETED FLOOR MAT WAS OUT OF POSITION FORWARD UNDER THE ACCELERATOR AND BRAKE PEDALS.

2002 TOYOTA HIGHLANDER ACCELERATOR STICKING IN THE FULL DOWN POSITION WHEN PASSING ANOTHER VEHICLE. FIRST HAPPENED SUMMER OF 2008. SECOND TIME THIS HAPPENED AUGUST 13, 2009. PUT ON FULL BRAKE AND TURNED IGNITION KEY OFF. AFTER VEHICLE STOPPED, ABOUT 5-10 SECONDS, PEDAL RELEASED. SERVICE APPOINTMENT WITH DEALERSHIP AUGUST 18, 2009 TO CORRECT PROBLEM. DEALERSHIP COULD NOT FIND ANYTHING WRONG WITH VEHICLE. SAID IT WAS THE FLOOR MAT THAT MADE THE ACCELERATOR STICK IN THE OPEN POSITION. DON'T THINK TOYOTA INFORMED OF THIS COMPLAINT. SINCE TOYOTA RECALL HAS TAKEN PLACE, I WANTED TO GET MY VEHICLE BACK IN THE DEALERSHIP TO CORRECT MY PROBLEM. APPOINTMENT MADE 2/09/10 AT 10:30 WITH DEALERSHIP. DEALERSHIP CHECKED THROTTLE BODY AND THROTTLE CABLE. SAID ALL OKAY. DEALERSHIP CONTINUES TO TELL ME RUBBER MAT COULD CATCH PEDAL AND CAUSE PROBLEM. I DISAGREE WITH THIS DIAGNOSIS. I ASKED DEALERSHIP TO PLEASE INFORM TOYOTA ABOUT THIS PROBLEM IN MY MODEL SINCE THE RECALL IS ONLY CORRECTING 2010 MODELS. THE ONLY WAY I WILL TRY AND PASS ANOTHER VEHICLE NOW, ESPECIALLY ON MOUNTAIN ROADS, IS PLACE THE CAR IN SECOND GEAR AND ACCELERATE. I DON'T TRUST PLACING THE PEDAL DOWN TO FLOORBOARD. I OFFER THIS AS ADDITIONAL INFORMATION REGARDING THIS DANGEROUS PROBLEM. I HOPE TOYOTA WILL CORRECT THIS SITUATION IN "ALL" MODELS OF THEIR CARS. *TR

ACCELERATOR DOES NOT RESPOND WHEN PUSHED,THE FAILURE OCCURS REGULARLY WHEN PASSING VEHICLE WONT ACCELERATE,THE DEALER ACKNOWLEDGE THIS IS A PROBLEM WITH THESE VEHICLES THAN CAN BE REPAIRED FOR $1200. *TR

TL*THE CONTACT OWNS A 2002 TOYOTA HIGHLANDER. THE DRIVER STATED THAT THE VEHICLE SUDDENLY ACCELERATED AND CRASHED INTO A WALL OF HIS GARAGE WHILE DRIVING APPROXIMATELY 5 MPH. THERE WERE NO INJURIES. A POLICE REPORT WAS NOT FILED. THE VEHICLE WAS TAKEN TO THE DEALERSHIP WHO WAS UNABLE TO DIAGNOSE THE FAILURE. THE MANUFACTURER WAS NOT NOTIFIED. THE CURRENT MILEAGE WAS APPROXIMATELY 48,690. THE FAILURE MILEAGE WAS APPROXIMATELY 38,000.

TL*THE CONTACT OWNS A 2002 TOYOTA HIGHLANDER. THE CONTACT WAS DRIVING 5 MPH INTO A PARKING GARAGE WHEN SUDDENLY, THE VEHICLE ACCELERATED. SHE ATTEMPTED TO ENGAGE THE BRAKE PEDAL TO STOP THE VEHICLE AND CRASHED INTO A TREE. THE CONTACT NOTIFIED THE INSURANCE COMPANY AND THEY COVERED THE REPAIR COST. THE CONTACT WAS SORE AFTER THE CRASH OCCURRED DUE TO MINOR INJURIES. THREE WEEKS AGO WHILE PARKING THE VEHICLE IT SURGED FORWARD AND HIT ANOTHER VEHICLE. THE MANUFACTURER WAS NOTIFIED AND STATED THAT THEY WOULD SEND SOMEONE TO INSPECT THE VEHICLE AND IF THERE WAS SOMETHING WRONG WITH THE VEHICLE THEY WOULD REIMBURSE HER IN 35 DAYS. THE CONTACT IS CONCERNED ABOUT THE SAFETY RISK AND CHOSE TO RENT A VEHICLE TO DRIVE. THE FAILURE MILEAGE WAS 62,000. THE CURRENT MILEAGE WAS 75,000.

I BOUGHT A 2002 TOYOTA HIGHLANDER LIMITED IN MAY 2008. THE CAR HAD JUST UNDER 60,000 MILES ON THE ODOMETER. THIS CAR IS MY SECOND CAR, MAINLY TO BE USED TO TOW MY HORSE TRAILER. WITHIN A MONTH OF OWNING THE CAR IT SHOWED THE SUDDEN UNEXPECTED ACCELERATION. THIS WAS NOT UNFAMILIAR TO ME BECAUSE I ALSO OWN A 2002 TOYOTA CAMRY. I HAVE OWNED THE HIGHLANDER NOW FOR 1 AND 3/4 YEAR AND THE CAR HAS SHOWED THE DESCRIBED BEHAVIOR OFF AND ON. IT HAPPENS MOSTLY ON THE FREEWAY AND MOSTLY WHEN I AM NOT TOWING. IT DOES NOT HAVE ANYTHING TO DO WITH FLOORMATS OR STICKY GASPEDALS. SINCE THE SAME BEHAVIOR HAPPENS IN BOTH TOYOTA'S I OWN, IT IS TIME THAT TOYOTA STARTS LOOKING AT SOMETHING ELSE THAN THE SILLY EXPLANATIONS OF FLOORMATS AND STICKY GASPEDALS. IT IS THE ENGINE WHICH RUNS AWAY, LEAVING THE DRIVER NO CONTROL OVER THE SPEED. I HAD NOT EXPECT THIS FROM TOYOTA. I BOUGHT TOYOTAS BECAUSE OF THEIR RELIABILITY AND BECAUSE I TRUSTED THE COMPANY (AS OPPOSED TO FORD, WHICH I ALSO OWNED AND EXPERIENCED A PROBLEM WHICH TURNED OUT THE COMPANY KNEW A LONG TIME ABOUT AND DID NOT DO ANYTHING ABOUT). I GUESS TOYOTA IS NOT DIFFERENT. ALSO, IT IS TIME THAT THE RECALL GOES FURTHER BACK THEN THE 3-4 YEARS. I EVEN HAVE A COPY OF A PROFESSIONAL CAR REVIEW OF THE CAMRY WHO EXPERIENCED THE PROBLEM IN 2002. *TR

I PULLED INTO MY GARAGE DURING EARLY AFTERNOON AND CAME TO THE USUAL STOP FACING THE WALL. MY FOOT WAS STILL ON THE BRAKE AND I HAD NOT YET PUT THE CAR INTO PARK. SUDDENLY THE CAR LURCHED FORWARD AND HIT THE WALL WITH GREAT ENOUGH FORCE TO DEPLOY THE AIR BAG. THE BAG FRACTURED MY STERNUM IN TWO PLACES. AT THE TIME I WAS NOT AWARE OF THE PREVALENCE OF UNINTENDED ACCELERATION PROBLEMS AND DID NOT REPORT IT. THERE HAVE BEEN NO EPISODES SINCE. *TR

DT*: THE CONTACT STATED WHILE PULLING INTO A PARKING SPACE AT 10 MPH, UPON APPLYING BRAKE PRESSURE, THE VEHICLE LURCHED FORWARD WITHOUT WARNING, AND CRASHED INTO A PARKED VEHICLE. THE CONTACT WAS WEARING A SEAT BELT, AND NO INJURIES WERE SUSTAINED. THERE WAS MODERATE DAMAGE TO THE FRONT OF THE VEHICLE. THE POLICE WERE ALERTED, BUT A REPORT WAS NOT TAKEN. THE VEHICLE WAS TOWED TO AN INDEPENDENT REPAIR SHOP FOR INSPECTION OF THE BODY DAMAGE. THE MANUFACTURER WAS ALERTED. UPDATED 12/12/06. *JB

2002 TOYOTA HIGHLANDER WITH UNEXPECTED ACCELERATION. CONSUMER STATED THAT THE VEHICLE SUDDENLY ACCELERATED WITHOUT WARNING. DRIVER HAD TO SLAM THE VEHICLE INTO PARK FOR THE VEHICLE TO STOP. *KB THE DEALER KEPT THE VEHICLE FOR 3 DAYS, RAN VARIOUS DIAGNOSTIC TESTS, BUT WAS UNABLE TO DUPLICATE THE PROBLEM. *JB