2006 Toyota Highlander Complaint Log

My 2006 Toyota Highlander Hybrid Limited has an ABS fault that has caused my vehicle to undergo several maintenance issues and poses a serious safety hazard. My vehicle has less than 150,000, and over the course of the last year, my ABS light, my emergency brake light, my TSC light, and my tire pressure sensor light have all come on and refuse to go away. Additionally, the maintenance light, along with a "CHECK VSC SYSTEM" message has been on my dash for months and will not reset. My ABS has been making an intermittent buzzing sound that cycles every ten seconds when my car is on. That has been going one since shortly before the lights. When the lights came on, I noticed a serious change in my braking. The pedal would become spongy one moment and rock solid the next, or my car would brake intensely with the lightest pressure or require my foot basically to the floor to stop it. This has caused a serious issue for the safety of myself and my family. After using and OBDII scanner with ABS capabilities, the codes I received point to the ABS assembly failing to retain pressure, hence the persistent cycling to compensate for it loosing pressure. This was confirmed after the battery voltage/connection, relays, fuses, and speed sensors had all been tested. After doing further research, several other owners of similar configurations to mine share the same issue. My dashboard even makes an incredibly distracting ringing noise that can only be stopped by removing all the fuses and relays to the ABS entirely. This has not been caused as a lack of proper maintenance as this vehicle has only been in my possession for the past 3 years, of which before it came from the Toyota dealership. The dealership wants over $3,000 to fix the issue, and the part alone is $1,850 since the part has been discontinued. This fix costs more than the car is worth given its age and mileage. During any inclement weather, or in traffic, the car is unpredictable in how hard it might brake.

I was on the interstate driving about 72 mph when the car just shut off all the dash lights came on and the dash it said check hybrid system I had no brakes or steering I got it off the road turned it off and back on again it started up and I drove it home but the dash still displayed check hybrid system , a week later I get in it to go to work and there’s an alarm that won’t cut off and the abs , traction control and brake light and warning light and tire pressure light are all on and the brakes are hard and there’s a weird noise coming from somewhere when u push on the brake and it says check VSC system on the dash now

Toyota’s part number 44050-48190 brake actuator assembly failed, as it has in other models and is very commonly doing in the Highlander model. It is triggering other warning lights issues in the vehicle. Vehicle safety is at risk. Many others have reported the same issue.

The vehicle suffers from an ABS module failure. I've been researching that this is common problem with the Toyota Highlander Hybrid and presents a danger of failing brakes while driving. My brakes partially failed with my [XXX] son in the car. When attempting to stop, I had no hydraulic pressure and luckily was able to get the vehicle stopped after the car had regained some pressure. The vehicle had been running for several minutes, so it wasn't related to a fresh start and the system not having time to pressurize, if that's a thing. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The brakes on my 06 Highlander hybrid AWD have been finicky at best since I’ve owned the vehicle. The car lunges forward when braking, all the way until a complete stop. While driving at around 55 MPH a medium sized dog ran out into the road. I braked hard but the brakes just lunging and trying to stop. At one point feels like it’s not braking anymore and just hope to veer out of the way. This can be fatal not only to the driver but to others driving as well. The fact that people are still having this issue, and Toyota hasn’t come up with a proper long term solution speaks to how much Toyota cares about its customer bases’ safety. It is honestly disgusting that people have had accidents and may have fatal and Toyota continues to not care. Please urge Toyota to look into this further and attempt to fix this permanently!

The driver's side sun visor does not stay up against the roof of the car and falls down obstructing the driver's view. It will not stay up and falls down immediately when pushed up against the roof. We have resorted to tying the visor up but then are unable to use the sun visor while driving.

Car is lunging forward while braking.I just had to put a new abs module and pump on the vehicle which was very expensive.Since I know there was a recall but I was not notified.Is there a way to get toyota to pay for the new pump and module ?

Two problems being reported are severe safety issues, and could result in injury, death, and/or property damage. Problem 1: While driving, the brake pedal suddenly went all the way to the floor, and the car would not stop. To avoid hitting the car in front at a stop sign, I had to turn the wheel, resulting in running through the stop sign and onto the grass and shoulder before the car finally stopped. Multiple dashboard warning lights appeared. After stopping, the brakes momentarily returned but failed again within 2-3 minutes. A loud, high-pitched, piercing whistle sound began, indicating a complete loss of brakes. The car had to be towed 200 miles back home. It is not safe to drive the car without functioning brakes. The OBD scan codes are: C1256 (accumulator low pressure), C1391 (abnormal leak of accumulator pressure), and C1256 (accumulator low pressure). Problem 2: When starting the car, the brakes are applied first, and then the car is placed in gear. The car involuntarily and immediately jumps forward or backward and continues to move, even though the brakes are being applied. Having the foot on the brakes has NO EFFECT on the car moving! The car should not move at all when the brakes are being applied. To stop the movement, I must quickly pump the brakes repeatedly. This occurs every time the car is placed into gear after starting the engine, causing it to jump forward or backward and continue moving despite brake application. Both problems are severe safety issues, and could result in injury, death, or property damage.

The ABS Module on the vehicle continually go bad. A newly never used one was purchased 2yrs 4 months ago. A genuine Toyota part ($1300) and it has already gone bad. This is causing safety issues as the brakes make a loud thumping sound when pressed. The car also starts rolling in reverse when turned on if the engine hasn’t started as yet.

The past couple months the Brakes have been acting up. Changed brakes and rotors to only find out that my brake pump or actuator are faulty and a known issue for highlanders yet my vehicle had no recalls

The Brake Actuator on many Toyota Hybdrid and Lexus Hybrid models fails prematurely leading to a unsafe situation with virtually no braking. Toyota extedend the warranty on the item however there are many cars which didn't qualify for the repalcement and are still failing. This should have been a recall rather a warranty extension. This Brake Actuator fails because of a design flaw, it has been since redesigned. The part istself is priced by Toyota at about $2000 in addition to installation labor that can run in thouands depending on the Toyota model.

When braking, apparently when the vehicle transitions from regenerative braking to hydraulic braking, there is a brief total loss of braking force and a noticeable sense of acceleration before the hydraulic brakes begin to grab and slow the vehicle resulting in an unanticipated increase in stopping distance and causing a near collision as my vehicle went several feet past the stop line into an active intersection due to this defect.

Power brakes stopped working while driving due to bad brake actuator. Vehicle shut down while driving due to power train system.

I can see many complaints similar to mine on line since the car was built in 2006. Driving on a 7hr trip when engine light came on and car overheated. We had to pull over on a busy highway and wait for car to cool down and light to go off. It was scary since I had my child in the car and traffic was moving at 60 mph. The next day I had the Toyota dealer charge me $160.00 to tell me coolant and oil were leaking from the head gasket and the bolt corroded and listed out causing a sealing issue. We just had the car in their shop doing thousands of dollars of maintenance and had a full inspection done in preparation for this trip. We also had fluid leaks from the engine twice before at 65819 miles and again at 84458 miles. No mention of this issue was ever brought up by dealer. I have full records and always did maint as suggested. so now the dealer says it will need a used engine at a cost of $9,000+. I am now without a car. This car should have been recalled and repaired, now it is totaled it. Thank goodness we were not injured or hit by another car on the interstate. sorry unable to send a copy of repair estimate done at Daytona Toyota 386-255-7475

My electric brake computer thu a code C1256 & C1391, ABS Brake Actuator Failure. Not regular maintenance item. No code ever thrown til this time. Major people killer when it fails. My experience was during a rain storm, lost all brakes for maybe 1-2 seconds. Felt like you were on ice. No control, No ABS. Then code and lights on dash lit up. I limped home worried I had no brakes or some brakes. Scared me and my family completely. Now car sits in driveway afraid to drive. I went to dealer, they read the codes and found 2 codes present. C1256 and C1391, ABS Brake Actuator FAILURE, needs to be replaced for SAFE Operation of car. Why isn’t this Brake Actuator under warranty? Excessive mileage? How would you know it was bad if you NEVER got the “CODE” as per Toyota Corporation.

Brake Actuator Assembly is a known issue with several Toyota models including my Hylander Hybrid. Toyota tried to address these actuator issues by extending the warranty coverage for the Brake Actuator Assembly on a limited basis, however; there is not an actual recall for this when there obviously should be. Thousands of customers are left with unknowingly driving vehicles that are not safe and for those that have had their brakes fail (and survive) are left with $3,000-$4,500 in repair bills to resolve these issues. In April 2021, I noticed odd purging-like sounds while stopped at stop signs or red lights when the brakes were engaged. This concerned me so, I had our local Toyota dealership check out our highlander but they said there was nothing wrong with the vehicle and we assumed they knew what they were talking about so we went about our business. Unfortunately, some months later while driving hundreds of miles from our home, the Check VSC light, ABS, Brake, and one other dash warning lights came on and the purging sound became much louder. Lucky for us, the brakes still worked enough to stop the vehicle. An official recall would have facilitated our local Toyota Dealer Service Dept in alerting us about these issues before we were put in a dangerous situation. Our Hylander is currently being worked on at our local Toyota Dealership. A guy in the service department is how we found out about the Toyota Customer Support Program that outlines the brake actuator shortcomings/failures. The service dept. manager's exact words were "it's like a recall but it's not an official recall". Here is a video I found on the Toyota Nation website where this gentleman's wife had her brakes fail and hit a car in a parking lot. Thank god she was not injured! https://youtu.be/mn_xs6k8_H4 Ultimately, all Toyota models with these faulty brake components should be recalled!!

While normally driving on the highway and without no warning the vehicle the power steering stops working , it just dies with no power and dash lights warning start to flash and Check Hybrid System turns on. I am not a mechanic nor a technician . The mechanic disconnected the ground cable after waiting about 5 minutes and it resets the system. He told me that it has something that may be caused by some electrical problem . He thinks that it has to do with a recall about some soldering electrical part in the inverter control. This has happened in 3 more occasion and I've been lucky and i have time to let it go to side of the road and i disconnect the ground wire for 5 minutes and connect it back and it resets and then starts to work normal. Since the vehicle stalls completely i fear that this could cause an accident or lost of life due to other vehicles coming behind at high speeds . Please i need help!

I was driving the car then as I hit the brakes it felt like they were not engaging until I applied more pressure. Then as I was almost home the abs and traction control lights came on. Took it to a specialist and they said that the abs module would have to be replaced. There are tons of people apparently with my same year and model with the same concern

The contact's client owned a 2006 Toyota Highlander. The contact stated while his client was driving at an unknown speed when the front passenger tire blowout and he crashed into a tree. The contact stated the front driver side air bag did deploy but the front passenger-side air bag failed to deploy causing the client's wife to have a fractured clavicle and spine, and internal injuries. The contact stated the wife was having a third surgery on 10/6/2021. The driver sustained 6 fractured ribs and did seek medical attention at a hospital. The contact also stated the client was traveling with a dog who was injured in the accident and decided to put down the dog due to the extended injuries. A police report was filed. The vehicle was not drivable. The vehicle was towed to towing lot. The contact called the local dealer and spoke to them about a possible air bag recall inquiry. The manufacturer had been informed of the failure. The failure mileage was approximately 120,000.

Sudden power steering failure. Hybrid vehicle with power assist steering.

In the last 4 weeks my 06 Highlander Hybrid has had malfunctions in the brakes and in the power steering. Both issues rendering the car inoperable. The first issue that was to arise was the brake actuator pump. I noticed it was failing when i got in the vehicle to move it out of the driveway and noticed after i put the car in gear that their was no power brake assist. When the car was shifted into drive the car began rolling even while i was pushing hard on the brakes. Luckily the brake assist resumed and i did not run into anything but the car unintentionally moved about 5 feet. I mentioned this to my wife, and she said while driving home one day the car made a high pitched buzz. She was close to home, so she made it home and parked the car and forgot about the noise. After the car was turned back on again no noise was made and no CEL or warnings were displayed. The actuator was replaced, and the car operated fine for about one week and probably 40 miles of driving. I want to mention I had noted a odd feeling in the brakes for years leading up the the failure. The brake pedal would continue to the floor while trying to maintain constant pressure on the brakes. I believe this is due to the actuator losing pressure, but it would cause an uneasy sensation of failing brakes, but no CEL's were ever triggered. The new actuator fixed this. After fixing the car we drove it on a few trips. Yesterday 8/24/21 my wife went to drive the car, and it wouldn't start. She tried about 10 times and it wouldn't turn on. I put a battery charger on the car and the battery looked okay. I tried to start it a few time probably 5 and finally got the READY light, so the car was ready to go, but all of a sudden the car would shut off and the READY light would go out and the P/S light would come on. This light is triggered when something is wrong with the power steering system, and the computer will disable the vehicle. The car immobile now. These are worth recalling.

Power window failure passenger window stopped working, back passenger window was always getting stuck either halfway down or all way down ( I had the POWER DISCONNECTED for the Bk passenger window). front driver window hesitates to work, can hear window rattling part way or all the way down - Yes car available for inspection. The safety for all persons in my vehicle are at risk I have not been in an accident yet, if I do I’m worried people won’t be able to escape through the windows if needed. Dealer looked at it- too expensive to fix. Obviously no warning light This has been going on since 2012. I complained to Toyota on 8/28/2012 my incident # 120828000209 asking them if they had complaints - NO complaints regarding window failure, 2 months later toyota had a recall due to power switch failure, sticky power window switch pretty much related to catching on fire-mine has not. This has to be investigated before people get hurt !!!! I have complained to you in the past, go to Toyotanation.com and look at all the vehicles with the same issues. The date below is incorrect disregard it

The dashboard on my Highlander Hybrid 2006 (AWD) had all its check lights on suddenly. I was not driving then. The car was in my parking lot for a few hours before which it had no signs on. The warning message said: Vehicle Stability Control (VSC). I took it to my nearest Toyota service center for diagnosing the issue. They reported that the ABS systems have started to fail. Specifically, the ABS actuator is losing pressure and should be replaced. They quoted a price of $2700 approx. which includes about $2000 for parts. Turns out that this same part had been replaced in 2016 during a recall - but they cannot attend to this again without charging the customer. What I was never told about was that a whirring sound - which has always been an issue with this car - was always from the ABS actuator. The same service center has checked and diagnosed this car multiple times - so I am surprised that they did not find the ABS actuator noise a problem on earlier occasions. I have been reading about this on this forum and Toyotanation and this seems to be a consistent issue with the older Toyota hybrid highlanders and other hybrids as well - with the same diagnosis and approximately the same price quoted by the service centers. I have not currently fixed this issue since I cannot afford this price. It also seems that I will be paying for manufacturer's or service center's negligence since this actuator seemed to be faulty all along and I was not warned about this.

The contact owns a 2006 Toyota Highlander. The contact stated while driving at various speeds, the brake pedal had to be pumped several times to stop the vehicle. The contact stated that the ABS warning light and several other unknown warning lights were illuminated. The vehicle was not diagnosed nor repaired. The manufacturer was informed of the failure but offered no assistance. The failure mileage was approximately 175,000.

3 accidents all rear end due to brakes ( brake pump/brake actuator failure) not safe.

ABS Control Module. Yes could be made available for review. A few years ago, a diagnostic showed the ABS Control Module as bad (it started buzzing is what made us get it checked). Toyota replaced it, but there was still buzzing after the service, from a NEW part!? I strongly expressed this to Toyota since it still seemed like an issue to me, but they told me nothing could be done unless the computer said it was bad or if there was a recall. The buzzing continued to get worse and does it almost all the time now, and finally the ABS light came on, sometimes it will make an alert noise, and the vehicle will not brake properly (with the brake pedal feeling very firm), so apparently now that the ABS light is on, a diagnostic showed it bad again. I have researched to find many other people experiencing this same issue with this part going bad AND continuing to quickly go bad even after replacing, and I have been advised the danger of this, for if it goes out while driving, you cannot brake like normal and cause an accident. If a brand new part was making the same buzzing noise when the previous part did not used to make that noise, then something seems very wrong! And this is very much a safety issue if your brakes suddenly stop working like they are supposed to! Please help! I appreciate your time. Thank you!

MY ABS, VSC, (I), AND EMERGENCY BRAKE DASH LIGHTS ARE ON CONTINUOUSLY. IT IS VERY HARD TO STOP THE CAR AS IT FEELS LIKE THE BRAKE ISN'T ENGAGING. WHEN IT DOES ENGAGE YOU ARE JERKED FORWARD.

THE VSC LIGHT, ABS LIGHT, CHECK ENGINE LIGHT AND SOUND IS ARE ON. THE CODE IS BACK AS WELL C1391 FOR THIS BRAKE ACTUATOR. IT IS A WELL KNOWN PROBLEM WITH TOYOTAS . THIS WAS FIXED ONCE ALREADY BY TOYOTA DEALER AND FAILED AFTER 40K MILES AGAIN. HOW CAN A PART HAS FAILED AGAIN IN SUCH A SHORT TIME AND MILES? THIS IS A COMMON PROBLEM AND WE CAN'T GET HELP FROM TOYOTA COMPANY OTHER THAN TO PAY FOR THEIR LACK OF QUALITY ON PARTS? I CAN'T AFFORD $4000 PLUST TO FIX A PART THAT ONLY LASTED 40,000 MILES. WHEN IS TOYOTA GOING TO DO A RECALL ON THIS PART AND FIX IT FOR GOOD?

THE VSC LIGHT, ABS LIGHT AND NOW THE CHECK ENGINE LIGHT IS ON. THE CODE COMES BACK TO C1391 WHICH IS THE BRAKE ACTUATOR. IT IS A KNOWN PROBLEM WITH TOYOTA THAT OCCURS @118,000 MILES. I WAS TOLD IT WAS GOING TO COST $4,000, BUT THEY FINALLY ONLY MADE ME PAY FOR THE LABOR AND TAX. HOWEVER, IT HAS NOW BEEN 30,000 MILES LATER AND THAT PART HAS FAILED AGAIN. I CAN'T AFFORD $2500-$4000 TO FIX A PART THAT ONLY LASTS 30,000 MILES. I HAVE SEEN THIS COMPLAINT OVER AND OVER. CAN WE GET SOME HELP??

TL* THE CONTACT OWNS A 2006 TOYOTA HIGHLANDER. THE CONTACT STATED WHILE DRIVING 25 MPH DOWN A HILL, WHILE DEPRESSING THE BRAKE PEDAL, THE BRAKE PEDAL WENT TO THE FLOOR AND THE VEHICLE HESITATED AND STARTED MAKING AN ABNORMAL SOUND. THE CONTACT STATED THAT THERE WAS NO WARNING LIGHT ILLUMINATED. THE CONTACT REGAINED CONTROL AND STOPPED THE VEHICLE. THE VEHICLE WAS TAKEN TO DCH WAPPINGERS FALLS TOYOTA (1349 U.S. 9, WAPPINGERS FALLS, NY 12590, (845) 288-0892) WHERE IT WAS DIAGNOSED WITH NEEDING THE BRAKE ACTUATOR TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS INFORMED OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 191,000.

LOUD CONTINUOUS BEEP BEGAN IN CAR WITH NO INDICATION AS TO WHAT IT WAS. WAS DRIVING AT 40 MPH, LET OFF GAS TO GET READY FOR TURN, HIT BRAKES AND THERE WEREN'T ANY. WAS ABLE TO SAFELY MERGE BACK INTO TRAFFIC AND DECELERATE ENOUGH TO TURN ONTO THE NEXT STREET. DIAGNOSED AS FAILED BRAKE ACTUATOR ASSEMBLY.

BRAKES ARE FAILING AND WHEN I BRAKE AT A STOP LIGHT, THE BRAKES SEEM LIKE THEY ARE NOT ACTIVATING AND ARE DANGEROUS BECAUSE I CANNOT STOP IN TIME. TOYOTA MUST REPLACE THIS OTHERWISE IT IS A HUGE SAFETY ISSUE IF BRAKES FAIL.

I WAS ON THE HIGHWAY DRIVING AND ALL THE DASH LIGHT CAME ON AND THE CAR STALLED WHILE I WAS GOING 60MPH.

VSC LIGHTS CAME ON. EVENTUALLY LOST ALL BRAKES. THE ABS ACTUATOR ASSEMBLY HAD FAILED. I WAS DRIVING SLOW ENOUGH TO BE ABLE TO PULL OVER SAFELY. THIS HAS BEEN REPORTED SO MANY TIMES HERE BY DIFFERENT PEOPLE, WHERE IS THE RECALL ON THIS PART?!?! TOYOTA HAD ISSUED AN EXTENDED WARRANTY COVERING THIS PART BECAUSE THEY KNEW THERE WERE PROBLEMS WITH IT. THANK GOD THERE WASN'T AN ACCIDENT, GRATEFUL NO ONE WAS HURT. SICKENED I WASTED MY MONEY ON THIS VEHICLE. NEVER BUYING ANOTHER TOYOTA.

THE BRAKE ACTUATOR IS FAILING AND IS MAKING LOUD NOISES. THE CAR DOES NOT BRAKE NORMALLY. I HAVE REPORTED BRAKING PROBLEMS SINCE I BOUGHT THE VEHICLE IN 2007. WHEN IT HITS A BUMP IT ACCELERATES AND I MUST STAND ON THE BRAKES SO I DO NOT HIT SOMEONE. IT LURCHES FORWARD WHEN IT HITS A POTHOLE OR SOME KIND OF OBSTRUCTION IN THE ROAD. WHEN I WORKED DOWN NEAR THE BUS STATION I WOULD HIT THE AREAS IN THE ROAD WHERE THE BUSES CREATED BUMPS IN THE ROADWAY AND IT WOULD LURCH FORWARD. I REPORTED THIS NUMEROUS TIMES AT NORTH BAKERSFIELD TOYOTA. I RECENTLY WENT IN TO REPORT THE NOISE I WAS HEARING AND THEY FINALLY FIGURED OUT THAT THE BRAKE ACTUATOR IS FAILING. I WAS TOLD THAT IT WAS NOT A HAZARD BUT THEY COULD NOT TELL ME WHEN IT WILL TOTALLY FAIL. I BELIEVE IT IS A SAFETY HAZARD AND THERE HAS BEEN A PROBLEM FROM DAY ONE

UNLIKE TRADITIONAL VEHICLES WHERE YOU STILL HAVE SOME STOPPING ABILITY WHEN POWER BRAKING FAILS THIS HYBRID HAS NO BRAKES. WHAT HAPPENED? THAT'S PRETTY SIMPLE I WAS DRIVING AND THEN I HAD NO BRAKES WHILE I WAS STILL MOVING. I WAS GOING 25 MILES AN HOUR AND ALL THE OTHER CARS WERE GOING 25 MILES PER HOUR. THE CAR IN FRONT OF ME STOPPED TO LOOK AT THE FLOWERS AND I LAID ON MY HORN LUCKILY THE ONCOMING CAR RECOGNIZED THE SITUATION AND PULLED OVER JUST ENOUGH TO ALLOW ME TO STRADDLE THE YELLOW LINE AND PASS THE STOPPED CAR WITHOUT CRASHING. THE PARKING BRAKE DIDN'T HELP MUCH BUT EVENTUALLY STOPPED ME ABOUT A QUARTER-MILE LATER DOWN A SLIGHT HILL. DEALER WANTS $3,500 TO REPLACE THE BRAKE ACTUATOR WHICH THEY HAD ORIGINALLY OFFERED TO REPLACE FREE AS AN EXTENDED WARRANTY BUT THE PROBLEM DIDN'T CREEP UP UNTIL THE EXTENDED WARRANTY EXPIRED. I HAVE NO DOUBT PEOPLE ARE DYING BECAUSE OF TOYOTA'S DESIGN FLAW.

TL* THE CONTACT OWNS A 2006 TOYOTA HIGHLANDER. THE CONTACT STATED THAT WHILE DRIVING AT AN UNDISCLOSED SPEED, THE VEHICLE LOSS MOTIVE POWER AND STALLED. THE CONTACT STATED THAT THE FORWARD GEARS WERE INOPERABLE HOWEVER, THE REVERSE GEAR WORKED AS DESIGNED. THE VEHICLE WAS TOWED TO MARK MCLARTY TOYOTA 4336 LANDERS RD, NORTH LITTLE ROCK, AR 72117 (501) 753-0400 BUT WAS NOT DIAGNOSED NOR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 150,000.

AFTER BEING DRIVEN OR IDLING FOR AWHILE, THE CAR STARTS CUTTING OUT. IT ACTS LIKE IT ISN'T GETTING GAS. I HAVE TO PUMP THE ACCELERATOR OR PUSH IT TO THE FLOOR. HILLS ESPECIALLY CAUSE IT TO STALL. IT WAS SO BAD, I HAD IT TOWED. THE SCAN SHOWED A OXYGEN SENSOR PROBLEM. HAD THAT REPLACED. IT DROVE OK FOR AWHILE. IT HAS RESUMED THE STALLING. WHEN I READ THE RECALL, IT SOUNDED LIKE MY CAR WOULD BE INCLUDED. THE VIN # SHOWS IT NOT BEING ON THE LIST. PLEASE VERIFY BECAUSE IT CUTS OUT, ACTING LIKE IT ISN'T GETTING FUEL. THE AREA I WAS IN WAS A COUNTRY ROAD WITH NO SHOULDERS TO PULL OFF ON. IT ALSO HAPPENED ON A 4 LANE HIGHWAY. IF IT IS NOT A RECALL, ANY SUGGESTION WILL BE APPRECIATED. THE EXACT DAYS IN SEPTEMBER ARE AN EDUCATED GUESS. THANK YOU.

ABS ACCUMATOR STOPPED WORKING

ABOUT A WEEK AGO, I WAS DRIVING MY TOYOTA HIGHLANDER 2006 AND EVERYTHING WAS PERFECT. ON MONDAY, OUT OF THE SUDDEN THE DASH TURNED TO A CHRISTMAS TREE LIGHTS + VSC SYSTEM. I WAS TERRIFIED SO I CALLED MY LOCAL TOYOTA DEALERSHIP AND TOOK AN APPOINTMENT. WENT THERE THE NEXT DAY AND THEY MADE ME WAIT 6 HOURS AND TOLD ME IT HAS BRAKE ACTUATOR ASSEMBLY PROBLEM AND TO GET IT FIXED, I HAVE TO PAY $2,246. AS A COLLEGE STUDENT THIS IS VERY PRICY. IT PUTS ME IN A MAJOR STRESS. AFTER I TOLD THEM I CAN'T OFFERED IT, I WAS TOLD IT'S SAFE TO DRIVE IT, NOTHING GOING TO HAPPENED BUT A A WEIRD FEELING ON THE BRAKE. AFTER RESEARCHING, I FOUND OUT IT'S VERY DANGEROUS TO DRIVE IT LIKE THAT. I FELT LIKE TOYOTA WANTED ME TO PUT MYSELF IN DANGER. I'M SCARED TO DRIVE THIS CAR RIGHT NOW. I LOST MY FATHER LAST WEEK AND WITH THIS PROBLEM, I FEEL VERY BAD. PLEASE HELP.

THE BRAKE ACCUMULATOR/ACTUATOR IS A DEFECTIVE PART AND TOYOTA HAS REFUSED TO HONOR THE REPAIR. THEY MANIPULATED OWNERS BY HAVING A WARRENTY SUPPORT PROGRAM WITH END DATES, INSTEAD OF HAVING A RECALL ON IT. WHICH IS WHY WHEN I RESEARCHED BEFORE I BOUGHT, IS NOT LISTED ON CAR FAX. THE WARRANTY SUPPORT WAS BEFORE I PURCHASED VEHICLE AND PREVIOUSLY IT WAS EITHER IGNORED OR MISSED BETWEEN OWNERS. THEY HAVE HAD MANY OF THESE AND GET AWAY WITH IT. RIGHT NOW THERE IS A CLASS ACTION FILED IN OHIO OVER THIS SAME ISSUE WITH OTHER CARS. IT IS A $3000 DOLLAR PART AND NOT A KNOB ON RADIO. IT IS A SAFETY ISSUE DUE TO IT BEING PART OF THE BRAKING SYSTEM. I'VE SEEN WHERE THE SUPPORT PROGRAM SAID MILES DIDN'T MATTER BUT WHEN TALKING TO TOYOTA THEY SAY 114,000 MILES. THE CAR IS A 2006, YEAH THAT'S REASONABLE, EVEN FOR 2017/18 LETTER. WHILE DRIVING THE VSC ALARM SYSTEM COMES ON AND THE BRAKING BECOMES DIFFICULT. THE PUMP HAS ALWAYS MADE A SOUND BUT WAS TOLD BY DEALER IT WAS THE SECURITY ALARM SYSTEM MAKING THE NOISE. IT HAPPENED IN 2019 ALSO, THE ALARM, BUT REPAIR SHOP SAID IT WAS CALIPERS, SO PAID $800 TO HAVE THEM REPLACED WITH PADS. ITS ALWAYS MADE NOISE BUT THE ALARM SYSTEM STARTED BACK UP AGAIN LAST MONTH. NOW WITH RESEARCH ON MY OWN, I KNOW EXACTLY WHAT IT IS BUT TOYOTA SAID THEY SENT LETTER TO PREVIOUS OWNER AND SORRY ABOUT MY LUCK! THIS HAS RENDERED THIS VEHICLE WORTH $5500, WORTHLESS. CANT TRADE IN A VEHICLE LIKE THIS AND LOST MY INCOME FROM DELIVERY WITH IT. I HAVE CHECKED OFF EVERYTHING THAT WOULD APPLY IF IT WAS A RECALL BUT SINCE THE SUPPORT PROGRAM HAS AN END DATE TO GET OUT OF TOYOTA EVER BEING RESPONSIBLE FOR THEIR DEFECTIVE PART, THEY PUSH IT OFF ON OWNERS. I'M JUST LUCKY, I HAVE A CDL AND GOOD DRIVER AND HAVE NOT HAD AN ACCIDENT WITH IT. I FILED A COMPLAINT WITH TOYOTA AND THEY JUST SWIPED ME AWAY AS ANOTHER POOR SUCKER THAT DIDN'T FIGURE IT OUT BEFORE I PURCHASED.

THE BRAKE ACTUATOR ASSEMBLY HAS GONE OUT AT 135000 MILES. IT INTERFERS WITH BRAKING. THE BRAKES LOCK UP FREQUENTLY AND CAR WILL ALMOST HOP TO A HALT. IT IS QUITE CONCERNING AND SCARY WHEN IT OCCURS.

THE ABS ACTUATOR MAKES LOUD NOISE ANYTIME YOU STEP ON BRAKES. MAKES SOUND STATIONARY OR IN MOTION.

Over 2 year ago our 2006 Highlander Hybrid began making a series of noises when depressing the brake pedal when in park and in motion. Dashboard screen are showing Check ABS, Check VSC System, Check Brake System and Brake Malfunction, and Errors. The noise would get louder and last longer and took longer distance to slow or stop. The shop asked for over $3000 that I don't have to fix so I drive it less and less. Please help if possible.

ONCE AFTER PARKING AND THEN TWICE WHILE DRIVING ON A HIGHWAY, THE CHECK HYBRID SYSTEM LIGHT, THE VSC LIGHT, THE CHECK ENGINE LIGHT, AND THE CAUTION LIGHT ALL ILLUMINATED AND THE VEHICLE LOST ALL POWER INCLUDING STEERING ASSISTANCE . EACH TIME REQUIRING MULTIPLE KEY TURNS TO RESTART THE VEHICLE INTO LIMP HOME MODE. THIS VEHICLE HAS BEEN REPAIRED ONCE BEFORE FOR A SIMILAR ISSUE WHICH OCCURRED WHILE DRIVING UP A HILL IN MODERATE TRAFFIC. THE TANK IS FULL OF FUEL, THE TIRES ARE LESS THAN A YEAR OLD, AND THE VEHICLE UNDERGOES REGULAR MAINTENANCE(WHICH INCLUDES A NEW BATTERY AS THE ONE BOUGHT FROM TOYOTA HAD A FEW DEAD CELLS AFTER ONLY A YEAR OR TWO). I'VE READ MULTIPLE COMPLAINTS ABOUT THIS ONLINE WHILE SEARCHING FOR THE UNDERLYING ISSUE AND THERE SEEMS TO BE A RELATED RECALL THAT DOESN'T INCLUDE MY VIN. *TR

TL* THE CONTACT OWNS A 2006 TOYOTA HIGHLANDER. THE CONTACT STATED THAT THE VEHICLE WAS VERY WELL KEPT AND THAT THE UNDERCARRIAGE OF THE VEHICLE WAS REGULARLY WASHED AND SERVICED HOWEVER, THE UNDERCARRIAGE BECAME VERY CORRODED. THE SUBFRAME AND FRONT SUSPENSION OF THE VEHICLE SHOWED AN EXCESSIVE AMOUNT OF RUST. NEITHER THE DEALER NOR THE MANUFACTURER WERE NOTIFIED OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 256,000.

MY 2006 HIGHLANDER HYBRID BRAKE LIGHTS CAME ON AND HAD NO BRAKES. TOOK TO A MECHANIC WHO CLEARED THE CODES AND AFTER 24 HOURS THEY CAME BACK ON. CALLED TOYOTA AND THEY SAID THE WARRANTY EXPIRED IN 2017 FOR THAT EXTENDED WARRANTY. I WAS QUOTED ALMOST $2500.00 TO GET IT FIXED. TOYOTA SAID THEY CAN'T DO ANYTHING ABOUT THE PRICE. NOW I HAVE A VEHICLE I AM MAKING PAYMENTS ON THAT ISN'T SAFE TO DRIVE CAUSE I HAVE NO BRAKES. *TR

WHEN DRIVING DOWN HIGHWAY AND NEEDING TO SUDDENLY BRAKE, ABS LIGHT AND CHECK VSC SYSTEM LIGHTS CAME ON, THE CAR DID BRAKE IN TIME. HOWEVER, SOON AFTERWARDS THE BRAKES DID NOT IMMEDIATELY ENGAGE WHEN REVERSING OUT OF PARKING SPACE OR ANYTIME WHEN PRESSING BRAKES WHILE REVERSING.

MY 2008 HIGHLANDER ONLY HAS 130,000 MILES, YET THE DRIVER'S SIDE VISOR DROPS AND FALLS UNEXPECTEDLY WHILE DRIVING, THUS CAUSING A DRIVING SAFETY HAZARDTHE VEHICLE IS ACCIDENT FREE. I HAVE CODES CHECK ENGINE, VSC AND TRAC OFF. GAS CAP WAS REPLACED WITH NEW OFFICIAL TOYOTA MATCHED PART & SYSTEM CHECKED BUT PROBLEM FOUND - THIS DISPLAY LIGHT COMBINATION IS COMMON ON TOYOTAS AROUND THIS TIME.. MY GAS MILEAGE & ACCELERATION PERFORMANCE IS NEGATIVELY AFFECTED. INABILITY TO PROPERLY ACCELERATE CREATES A DANGER FOR INABILITY TO AVOID COLLISIONS.

WHILE DRIVING MY VEHICLE ALL THE LIGHTS ON MY DASHBOARD ILLUMINATED. MY VEHICLE LOST POWER AND I HAD TO PULL OVER. IT DIED THERE. I WAS ON BELFIELD AVE AND GRATZ STREET IN PHILADELPHIA, PA . I SUBSEQUENTLY HAD IT TOWEDBACK TO MY RESIDENCE.