2020 Toyota Highlander Complaint Log

The contact owns a 2020 Toyota Highlander. The contact received notification of NHTSA Campaign Number: 23V865000 (Air Bags); however, the part to do the recall repair was unavailable. The dealer was contacted and confirmed that parts were not yet available. The manufacturer was not made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.

My 2020 Toyota Highlander Platinum started having the well-known "whining" sound at just under 60,000k. This is coming from the transmission. The vehicle is now just over 60,000k and I did not know that the noise was a cause for concern, let alone something that was an issue (I am not tech savvy - I'm just a regular person). I will not drive this vehicle again, as it is my only transportation for my children. Toyota issued a service bulletin about this issue for 2021 Highlanders ONLY, but as I am now experiencing this problem, I see that this is something well known as a problem.

All of the sudden around 70K miles, the transmission started to make a "whining" noise. It does not sound right and I'm afraid the transmission could fail while I'm driving. I took it to the dealer and they acknowledged that it's a known issue but that in my case the noise is not loud enough to warrant replacing the transmission. A quick research on the internet revels that this is a very common problem.

At approximately 75,000 miles the vehicle had a whining noise coming from the engine area. Took it to the dealer and they tested it, listened to it and determined that the transmission needed replaced. They confirmed the t-case oil is in good condition and level. No maintenance issues or concerns. Just that the transmission had gone bad. Toyota wants $8,000 to replace a transmission with low miles for a 2020 vehicle.

So there was a service bulletin put out by Toyota in December 2020, about its AC repair. Well no notice was given to Toyota owners about this. Well fast forward to yesterday May 21, 2025, my mechanic told me that the AC lines to the rear were leaking and needed to be replaced as it was leaking refrigerant into the environment. Well after reading reviews and other folks problems it seems Toyota knows there is a problem with the ac lines and the type of material they used. Toyota should be issuing a recall notice on these cars to replace the ac lines so it does not pose an environmental hazard inside or outside the vehicle.

Transmission making whining noise that increases with speed. Concerned about safety if transmission fails while driving Diagnostic done at Toyota and confirmed transmission is failing and needs new replacement. There are no warning lamps. Noise has increased intensity over short period of time

The contact owns a 2020 Toyota Highlander. The contact received notification of NHTSA Campaign Number: 23V865000 (Air Bags); however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The dealer was made aware of the issue and confirmed that parts were not yet available. The manufacturer was made aware of the issue and confirmed that parts were not yet available. The contact had not experienced a failure. VIN tool confirms parts not available.

My 2020 Toyota Highlander hybrid sometimes has a brake slipping or surging sensation when I apply my brakes while stopping. It happens periodically and not every time. I have not taken it to a Toyota service station for this specific reason but I mentioned it while in for a recent oil change. They checked for a recall but didn't find any. I have somewhat gotten accustomed to the issue and have been able to adjust. As I have stated, it doesn't happen every time I apply my brakes. My concern is if I allow someone else to borrow my car or even sell to a new owner. I believe I am the second owner.

8 speed automatic transmission started whining at 45k miles (purchased new), has been inspected, dealer confirmed transmission is bad and part is on back order (date keeps moving out),

The contact owns a 2020 Toyota Highlander. The contact received notification of NHTSA Campaign Number: 23V865000 (Air Bags); however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.

My 2020 Toyota Highlander is equipped with Toyota’s UA80 8‑speed transmission. At around 62, 000 miles, a loud whining noise developed. The dealership confirmed the transmission is defective. Toyota has issued multiple Technical Service Bulletins acknowledging this transmission defect across all 2020 Highlanders with the UA80, but they are refusing to cover my repair because I am slightly over the 60,000‑mile powertrain warranty. Impact: This is a confirmed design flaw that affects every 2020 Highlander with the UA80 transmission. I rely on this vehicle as my only means of commuting to work—if the transmission fails, I will lose my job.

TOYOTA HIGHLANDER 2020 less than 5 years 63,000 miles started making noise Dealer where i bought it; said my warranty expired with 60,000 miles , so i have to pay transmission replace close to $9,000 , obviously this is a Toyota fabrication problem they need to assume responsibility .

Known recall and Toyota is not correcting it.

Faulty Transmission that Toyota doesn’t want to cover fixing.

The contact owns a 2020 Toyota Highlander. The contact stated that while driving at 30 MPH, there was an abnormal whining sound coming from underneath the vehicle. No warning lights were illuminated. The vehicle was taken to the dealer, who diagnosed a failure with the transmission. The vehicle was not repaired. The manufacturer was notified of the failure, and a case was opened. The failure mileage was 78,000.

The transmission is making a whining noise at 104;368 miles. We own another 2020 Toyota Highlander and it had to have the transmission replaced for the same reason. It is available for inspection. It’s a safety hazard because it’s a bearings in the transmission that’s failing. The transmission will eventually stop working. The issue was confirmed by a Toyota dealer and one of our transmissions has already had to be replaced. Toyota has a service bulletin out for this known problem. There were no warning signs for the transmission noise.

It’s been a known issue that Toyota Highlander has transmission problems under 100k miles from 2016-2021 or later (social media sites confirmed such). My vehicle require a trans axle replacement as well as the struts are leaking oil and my vehicle has less than 62k miles and is only 5 years old. This is being covered under my extended warranty but parts are on back order After doing research many owners complain about a whining noise showing acceleration of vehicle . If left unfixed this leads to transmission gears slipping and eventually needing an entire replacement Some owners also complain about leaky struts. My car has an issue with leaky struts and is being fixed under warranty Some owners say they need an entire new transmission and after that is replaced the rear transaxle goes and needs replacement Toyota is not putting a recall on this but it’s a known issue. Owners are asking to have this put out as a recall by toy. All parts are on back order and takes several months before transmission can be repaired or replaced. This tells me there are hundreds if not thousands of Highlander’s having the same issue This is a Toyota problem and is related to building transmission in the factory..recall the older vehicles and do better in the factory

The contact owns a 2020 Toyota Highlander. The contact received notification of NHTSA Campaign Number: 23V865000 (Air Bags); however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.

Currently having issues for my active recall with no remedy available

1- Most of the time my rear hatch will not close unless you use the inside button - cost 1,198.10 to repair. 2- my car started making a whining noise on acceleration. Took it Toyota and they said that I need to replace my transmission that it has an internal failure. Of course my warranty was of no use b/c it stopped at 100,000 miles. At the time of the inspection I was at 104,000. To get a new transmission it will be 7,425.60 (not including the labor). I really wish the dealership could have been honest about this year model transmissions failing. I would have passed on this car.

Whining noise from the transmission after 66K miles - Change fluids still no improvement - Known issue with UA80 transmission . Dealers knew of the issue but still sold cars

Around 90,000 miles, the transmission has started to whine really bad. This seems to be a common problem with this 2018 to 2021 Highlanders, but 2020 has no recall or service bulletin. My mechanic priced a transmission from a dealership and was told it would be 3 months at least to get a reman transmission. There is a good chance of catastrophic failure before we can get a new transmission installed.

At around 61,000 miles, I noticed a whining sound in the vehicle when accelerating. I took the vehicle in to a Toyota dealer for diagnostics and their technicians indicated that my vehicle had transmission failure and it needed to be completely replaced - quoted at $8,000 to do the replacement. Diagnostic appointment also cost $174. Parts are on back order and no one could tell me when parts would come in - guess was one month. In reality, parts are now finally in (I'm about to take it in to be fixed) after 2 months. I was told by the dealership that I could drive it at my own risk of failure - if it were to fail, I would be stranded wherever that may be putting my family and those around me at risk due to the unknown nature of when that could happen. This failure is recorded for the same model and same UA80 transmission on several online forums: [XXX] The vehicle has been inspected by a Toyota dealer as I stated previously. Diagnostic report says "Internal component failure. Recommend transmission" No other warning lights or messages from the car to warn me of this problem even now. Just the whining sound from the failure itself. Keep in mind, Toyota's powertrain warranty period is 5 years or 60,000 miles - this vehicle just surpassed both of those limits as this problem came about. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

2020 Toyota Highlander l developed a whining noise and after extensively researching this sound it seems like its common on highlanders with the UA80 transmission and leads to transmission failure. There is a Toyota forum where owners have gathered about this issue not only for this year highlander but early models when the specific transmission above started being used. Quotes to replaced this transmission range from $6,000-$13,000 at the dealer. Toyota has been called and they have been of no help to anyone. Even worse it seems all places are backordered on these transmissions and owners are left without a car. To quote a toyota member who called to get hemp with the issue, this is what Toyotas response was: “ Toyota refuses any support stating that "we can't predict an average life expectancy for any specific part of component", This only means life expectancy on their parts does not exist? Shouldnt they have a target life expectancy on parts? A lot of dissatisfied toyota owners as toyota is hiding from this issue.

Transmission going out afraid it will come apart or lose power while driving. Toyota dealership told me that we could put new transmission in but it will be the same as the one that is in it and that problem with them has not been corrected and it probably won't hold up long either. Our vehicle only has 71000 miles and we bought it new.

Final drive failing in transmisssion

The contact owns a 2020 Toyota Highlander. The contact received notification of NHTSA Campaign Number: 23V865000 (AIR BAGS); however, the part to do the recall repair was unavailable. The local dealer was contacted, and it was confirmed that the part was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. Parts distribution disconnect.

At 76000 miles my 2020 Highlander water pump began to fail. 20 days after the water pump was replaced at Kings Toyota dealership, the transmission is now failing at 79000 miles. The warranty only covers repairs on each up to 60000 miles. This car has been maintained by the dealership and no engine light ever came on. The water pump was $1200 to repair and I’m being quoted $10K to repair the transmission. I also don’t trust that dealership didn’t accidentally cause the transmission to fail bc they surprisingly have a new transmission in stock the day I came in. If it truly failed today, then Toyota needs to recall this car for safety reasons. It went from fine to not fine in just a few days of driving.

The contact owns a 2020 Toyota Highlander. The contact stated that while depressing the accelerator pedal, the vehicle was making an abnormal whining sound. The contact stated that the failure occurred at various speeds. The contact stated no warning light was illuminated. The contact had taken the vehicle to a local dealer, where it was diagnosed and determined that the transmission had failed and needed to be replaced. The vehicle was not repaired. The contact researched online and related the failure to Technical Service Bulletin: T-SB-0008-21 Whine Or Grind Noise from Transmission (Power Train). The manufacturer was not informed of the failure. The failure mileage was approximately 98,000.

Complete transmission and transfer assembly failure at 72,000. Just outside manufacturer warranty. Toyota Dealership and Corporate refused to acknowledge responsibility, stating that the transmission and transfer assembly met warranty requirements, and that they would not entertain assistance.

The contact owns a 2020 Toyota Highlander. The contact stated while driving at undisclosed speeds, there was a whining sound coming from the transmission. There was no warning light illuminated. The vehicle was taken to a local dealer where the vehicle was diagnosed, and the contact was informed that the internal bearings had failed, and the transmission needed to be replaced. The vehicle was not repaired. The contact referenced Technical Service Bulletin: TSB-0008-21 as a possible cause for the failure. The manufacturer was notified of the failure. The approximate failure mileage was 99,000.

Toyota sent a letter in mid-2024 that there was a safety recall for airbag issue with 2020 Toyota Highlander. The letter stated that a remedy would be available by the third quarter of 2024. As of January 21, 2025, they still have not provided a remedy for the serious safety issue. I would like to file a complaint against Toyota for failing to remedy the defect within a reasonable time.

Around 92k miles my transmission started makining a whining noise while driving. Dealership diagnosed a transmission problem and it needed to be replaced. They said eventually the transmission will go bad and stop working, potentially leaving me stranded or causing an accident. Spoke with Toyota HQ who would not offer financial assistance or assist with getting a part. UA80F transmissions are on a nationwide backorder. They also would not acknowledge that there is a problem.

At about 85,000 miles, the transmission developed a whine noise, and two dealers and a transmission shop all state it needs replacement. However, the backlog for replacement is enormous and I risk the transmission failing catastrophically while driving.

Transmission failure- this affects the safety of others when the car decides it doesn’t want to accelerate and could potentially lead to car accidents when another vehicle runs into it. The transmission needs to be completely replaced. This issue started back in January and has been an ongoing problem since warranty and Toyota will not assist with issue of their faulty product.

The 8-speed automatic transmission was making a whirring, whining noise. Transmission could failed completely and stranded occupants including children. Vehicle has been serviced every 5,000 miles and no warning lights or indicators ever came on. Dealer inspected and diagnosed an internal component failure necessitating complete transmission replacement. Vehicle is 4 years and 2 months old with 65,000 miles on it.

I am not reporting any specific incident related to this defect. I am simply complaining to NHTSA that Toyota is taking far too long to provide a remedy for the OCS sensor issue, NHTSA recall number 23V865 (Manufacturer recall number 23TB15). This issue has been ongoing since late in 2023 and it seems that Toyota should have provided a remedy by now.

While driving on a highway, with little traffic around, our sunroof exploded, sending shards of glass down. It produced a sound of a gunshot and quite possibly could have resulted in such a distraction to cause a wreck. The vehicle has not been inspected but insurance agents has been contacted. There were no warnings at all.

The transmission started slipping without any warning and then went into neutral while driving and I am not able to drive it anymore. The dealership said the transmission is bad. I see many complaints online about 2020 Toyota Highlander transmissions going bad for no reason. This is a new car only 4.5 years of normal driving and the transmission goes, this is not normal for such a high rated vehicle.

The transmission in my 2020 Highlander XLE needs replacement at 64,000 miles.

Highlander transmission broke down around 80,000 miles

The transmission is starting to whine at 108,000 miles. Toyota service told me the only fix is a replacement and they have seen two failures within the same week. They also said this is a known issue with this model year. A Reddit thread shows many owners in the US and Canada with the same issue. If this is resulting in failures of the transmission in operation this is a safety issue and a reasonable recall being a known defect for this line of transmissions. The recommendation from the service department since this vehicle is paid off is to run it to failure.

The contact owns a 2020 Toyota Highlander. The contact received notification of NHTSA Campaign Number: 23V865000 (Air Bags); however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.

my wife was pulling into a driveway slowly approximately 5 mph when she went to stop the Toyota Highlander sped up to full speed and smash the tree while my wife was depressing the brake. All airbags were deployed and it looks like they are going to total the Toyota Highlander that has all the maintenance records Very lucky to not have somebody seriously injured.

Began hearing a high-pitched whining sound when I accelerated. Took it into the dealer and they casually told me that I needed a new transmission. My car was less than four years old, but had more than the 60,000 miles that would apply under a warranty. I am now reading online. This is a widespread problem involving Toyota Highlanders. Can’t get a new transmission for three months or more.

I was in a school line waiting for my children. I went to hit the gas to move and the car said “maintenance required” and then flashed other warning lights “low power steering fluid and engine light.” Then the car turned off and screens were flashing. I tried to restart the car but the steering column was locked and brake pedal was locked. I checked all fluids and they were full. I had someone jump the car and it turned back on. I figured maybe a bad battery. Had AAA come look at the car and all diagnostic testing was normal. Next day, car does it again in the middle of an intersection.

Vehicle produces a noticeable whining noise under acceleration. Shifting is completely normal and no other drivability issues are present. Issue matches the pattern described in TSB T-SB-0008-21 (UA80E/UA80F front carrier assembly pinion shaft bearing failure). Multiple owners report dealers are diagnosing this as requiring full transmission replacement at 8,000–12,000, with no partial repair or recall offered despite Toyota’s prior knowledge of this defect in earlier model years (ZJC Warranty Enhancement Program for 2017–2018). Requesting NHTSA investigation

While driving on the freeway in the evening about 10 minutes into the drive, a loud bang was heard like a shotgun and the front portion of the panoramic sunroof had shattered. Small shards of glass entered the cabin but fortunately no one was injured inside the vehicle. No sign of a rock hitting the vehicle or defect in the panoramic had occurred prior to this incidence. It appears to have occurred spontaneously. There was a large hole in the glass with an outward projection like the pressure inside the vehicle somehow blew out the sunroof. The passengers in the vehicle were at risk of being covered in small shards of glass including a small child in a rear facing carseat who was sitting behind the driver's side. The driver and front passenger would have been impacted as well if the glass gave away. This occurred at high speeds on a freeway where if the glass would have fallen inside the cabin could have caused the driver to be covered in glass, injured while driving at high speeds and caused a wreck. The incident was reported to the highway patrol who could not place a formal report because they said it was not a mechanic defect and the Toyota corporate office said that they could not report because it was a glass issue. Insurance has not been informed yet as we are waiting from the local dealership to see if they can assist. There were no warning messenger prior to this problem and it occurred spontaneously.

I have experienced ongoing transmission problems, including but not limited to rough shifting, delayed acceleration, jerking while driving, and abnormal noises. These issues have significantly affected the safety, reliability, and drivability of my vehicle. This transmission failure significantly undermines Toyota’s long-standing reputation for reliability and has substantially reduced the value of my vehicle.

Transmission whining around 38mph when accelerator is pressed. Goes away when foot is off pedal. No warning lights are on. I test drove 3 other 2020 - 2021 Highlanders in May before I purchased this one. All 3 of those had a very noticable transmission whine over 20mph. I opted for this Highlander because there were no noticeable issues/sounds. Just this month, I am noticing a more pronounced high pitch whine during acceleration. This certainly sounds like a much wider issue, especially calling around to multiple dealerships confirming they have other 2020-2021 Highlanders in getting transmission replacements (on 3+ months wait times for parts) This is absolutely a safety issue if a transmission fails while driving. There was a technical bulletin for this same issue with certain VINs, but I was told that my VIN fell outside of that range. To answer rest of questions: No confirmation from dealer on the whine, they are all charging $180 to diagnose the issue and I am not paying that. No further inspections by the above groups listed.