2020 Toyota Highlander Complaint Log

THE FUEL TANK CAPACITY LISTED AS 17.1 GALLONS BUT ONLY TAKE BETWEEN 12-12.5 GALLON WHEN FILLED UP, EVEN WHEN THE RESERVE HAS RAN DOWN WHERE MILE TO EMPTY IS NEAR ZERO. TOTAL MILES RANGE BETWEEN FILL UPS IS UNDER 500 MILES, FAR LESS THAN THE 616 MILES RANGE CLAIMED BY TOYOTA.

TOYOTA ADVERTISES AND REPRESENTS THAT THE HIGHLANDER HYBRID′S FUEL TANK CAPACITY IS 17.1 GALLONS, AND BASED ON ITS 35 MPG RATING, THE RANGE SHOULD BE ABOUT 600 MILES. HOWEVER, I AM NOT ABLE TO FILL THE TANK BY MORE THAN 12 GALLONS THUS REDUCING MY RANGE TO 420 MILES. I BELIEVE THERE IS A DEFECT IN THE NEWLY DESIGNED SADDLE TANK WHICH PROHIBITS THE TANK FROM BEING FILLED COMPLETELY THUS CHEATING ME OUT OF ABOUT 180 MILES OF DRIVING RANGE.

THE VEHICLE HESITATES, STALLS AND HAS BUCKING LEAPING FORWARD UNCONTROLLABLY, ON THE ROAD. THE VEHICLE ALSO HAS A VERY LOUD WHINING NOISE UPON SHIFTING THE CAR FROM PARK TO DRIVE AND BACK AGAIN FROM DRIVE TO PARK, AT A STAND STILL. THIS IS A MAJOR ISSUE WITH A NEE CAR, MY WIFE AND I DON'T FEEL SAFE WHILE DRIVING IN THIS CAR. *TR

FUEL GAUGE DOES NOT PROPERLY REGISTER FULL HYBRID FUEL TANK (DESIGN) AND/OR DEFECTIVE FUEL LEVEL SENDING UNIT. TOYOTA SERVICE REPORT (6032680/1- 25 SEP 2020); TOYOTA SERVICE REPORT (6046594/1- 21 JAN 2021).

AFTER LEAVING A SHOPPING CENTER ON FEBRUARY 29 2020, WE PULLED OUT ONTO A ROAD TO HEAD TOWARDS HOME. WE WERE DRIVING ABOUT 45 MILES PER HOUR IN TRAFFIC AND RECEIVED A NOTIFICATION ON THE SCREEN THAT SAID THE ENGINE WAS OFF, PUT CAR IN PARK. THERE WAS ALSO A WARNING LIGHT THAT CAME ON FOR THE ELECTRONIC STEERING ASSIST WITH AN EXCLAMATION POINT. WE WERE ABLE TO COAST TO THE SIDE OF THE ROAD TRYING TO MANEUVER THROUGH TRAFFIC OF 4 LANES. WE PUT THE CAR IN PARK AND ATTEMPTED TO START THE VEHICLE. IT WOULD TURN OVER, BUT NOT START. WE CALLED TOYOTA ROADSIDE ASSISTANCE AND TOLD THEM WHAT HAPPENED AND THEY SAID IT WOULD TAKE ABOUT AN HOUR TO GET TO US AND TOW THE VEHICLE. AFTER ABOUT 15 MINUTES WE DECIDED TO ATTEMPT TO START THE VEHICLE AGAIN. IT STARTED, AND THE VEHICLE STEERING WARNING LIGHT CAME ON, BUT THEN WENT OFF. WE CALLED ROADSIDE ASSISTANCE AND TOLD THEM WE WERE GOING TO ATTEMPT TO DRIVE TO THE DEALERSHIP WHERE WE PURCHASED THE VEHICLE WHICH WAS ONLY A FEW MILES AWAY. WE LEFT THE VEHICLE THERE TO BE CHECKED AND SO FAR THEY SAY NOTHING HAS BEEN FOUND BUT ARE CHECKING FURTHER AND TESTING THE VEHICLE BUT SO FAR HAVE BEEN UNABLE TO DUPLICATE THE OCCURRENCE. IT ONLY HAS 300 MILES ON THE ODOMETER.

The driver side mirror, yes available for inspection The mirror is shaking on higher speed makes it difficult to keep up with traffic around you No No No

THE VEHICLE SUSPENSION IS VERY TIGHT AND CABIN NOISE IS VERY LOUD.ICAN HIT 95 DECIBELS ON MY SOUND PRESSURE METER. HAVE TO TURN THE RADIO UP SO I DO NOT HEAR IT . CANNOT HEAR EMERGENCY VEHICLES. WONDER IT IS DOING TO MY HEARING. THIS A NEW VEHICLE TOOK IT TO TWO DEALERSHIPS AND THEY SAY IT IS NORMAL, THAT CAN NOT BE NORMAL IT SOUNDS LIKES TRUCK. *TR

SUSPENSION IS VERY LOUD AND TIGHT, THE CABIN NOISE IS VERY NOISY IT CAN HIT 95 DECIBELS ON SOUND PRESSURE LEVEL METER. THE NOISE IS SO BAD THAT I DO NOT WANT TO DRIVE THE VEHICLES ANY MORE UNLESS I TURN THE RADIO VOLUME UP AND I CAN NOT HEAR EMERGENCY VEHICLES.THE SERVICE PEOPLE SAID THAT IS NORMAL.THE VEHICLE NOISE CAN BE UNBEARABLE AT TIMES.IWONDER WHAT IT DOING TO MY HEARING.THE VEHICLE WAS LIKE THIS SINCE I BOUGHT NEW.

While driving my navigation system/screen/radio screen goes completely black! Which is dangerous when I’m using gps on the interstate! It does not come back on until I restart the car.

The contact owns a 2020 Toyota Highlander. The contact received notification of NHTSA Campaign Number: 23V72000 (Structure). The vehicle was taken to the dealer; however, the contact was informed that the recall could not be performed due to a damaged bumper clip. In addition, the contact stated that the vehicle was taken to the dealer several times, however the recall repair was not performed. The manufacturer was made aware of the failure and a case was filed. The manufacturer denied performing the recall repair.

Taken vehicle at least 6 times to dealer (Corwin Toyota), to enquire about the 23v-865 recall, and each time have been told the repair is not available. Most recently asked December 2025.