2008 Toyota RAV4 Suspension Problems

The contact owns a 2008 Toyota Rav4. The contact stated while driving at various speeds, the vehicle failed to drive in a straight line and would erroneously drift out of the lane. The vehicle was taken to the local dealer who diagnosed that the rear suspension was faulty and needed to be repaired. The contact indicated that the vehicle was previously repaired under NHTSA campaign number: 16V596000 (Suspension) however, the failure occurred. The vehicle was not repaired. The approximate failure mileage was 157,000.

I I HAVE BEEN HAVING A LOUD SOUND FROM THE PASSENGER SIDE REAR... I HAVE HAD THE CAR FOR 3 YEARS I HAD TO HAVE THE SWAY BARS REPLACED WITHIN THE PAST 6 MONTHS.. I AM HIGHLY AFRAID THAT THIS IS ASSOCIATED WITH RECALL THAT SUPERSEDE 13V-383 WHICH WAS PRIOR TO WHEN BOUGHT THE SUV.. IT'S HARD TO TELL IF THE SOUND GOES AWAY AFTER SOME TIME DRIVING BUT IS VERY NOTICEBLE AT LOW SPEED

WE DROPPED OFF OUR 08 RAV 4 AT THE DEALER DUE TO (FAULTY RECALL REAR TIE ROD REPAIRS DONE IN 2013.) I PUT A NEW SET OF EXPENSIVE TIRES. NOW AT APPROX 34,000 MILES NOW I NOTICES EXTREME WEARING PREMATURELY WITH POSSIBLE SAFETY CONCERNS. OUR REPAIR SHOP SAID THE (REAR SUSPENSION TIE RODS) CAN NOT BE ADJUSTED DUE TO TOYOTA'S (RECALL REAR TIE RODS EPOXY GLUE!) THIS MEANS WHEEL ALIGNMENT CAN NOT BE PROPERLY. HOWEVER, WHILE DRIVING ON CITY STREETS OR THE HIGHWAY YOU HEARD RUMBLING TIRE NOISES.

RECALL CSJ WAS PERFORMED 08/01/14. REAR TOE-IN SET AT 0.10. ON 08/28/19 DEALER FOUND REAR TOE AT 0.08 LEFT AND 0.25 RIGHT AND REPORTED IT AS "FAILED". THEN INFORMED US THAT ALIGNMENT CAN'T BE CORRECTED DUE TO RECALL CSJ AND WE SHOULD DRIVE THE VEHICLE "AS IS' OR PAY FOR REPLACEMENT REAR TIE RODS. RECALL GOV WAS NOT PERFORMED. THE VEHICLE HAS INCREASED STEERING SENSITIVITY..

REAR SUSPENSION ARM (TIE RODS) FIXED UNDER RECALL CAMPAIGN 13V 383000 HAVE BECOME LOOSE. AFTER SEVERAL CALLS TO THE MANUFACTURER AND TO TWO DIFFERENT DEALERS, TOYOTA HAS DENIED TO HELP WITH THE COST OF REPAIRS. OBVIOUSLY THEIR RECALL "FIX" HAS NOT WORKED AND I THINK THEY SHOULD BE HELD RESPONSIBLE FOR THE REPAIRS DUE TO THIS FACT.

TL* THE CONTACT OWNS A 2008 TOYOTA RAV 4. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 16V596000 (SUSPENSION). THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE DEALER WAS NOT CONTACTED. THE MANUFACTURER WAS MADE AWARE OF THE ISSUE AND WAS NOT ABLE TO CONFIRM WHEN THE PARTS WERE TO BECOME AVAILABLE. THE CONTACT HAD NOT EXPERIENCED A FAILURE. PARTS DISTRIBUTION DISCONNECT.

2008 TOYOTA RAV4. CONSUMER WRITES IN REGARDS TO SEVERELY RUSTED FRAME THAT WAS BEYOND REPAIR. *AS THE CONSUMER ALSO STATED THERE WAS A BROKEN FRONT SPRING THAT NEEDED TO BE REPLACED. *TR

WHILE MAKING A RIGHT TURN I HEARD A LOUD POP THEN A THUMP LIKE SOMETHING FALLING ON THE BACK FLOOR AND HITTING THE SIDE OF THE CAR. THOUGHT, AT FIRST IT WAS THE ITEMS IN MY BACK CARGO SPACE RISING UP AND FALLING AS IF I HIT A SPEED BUMP TOO FAST. I WAS ONLY TURNING ONTO ANOTHER ROAD WHEN I HEARD THE LOUD NOISE. I TOOK THE CAR TO A PLACE THAT GAVE FREE ESTIMATES AND THEY DISCOVERED THE DRIVERS SIDE SWAY BAR BOLT HAD BROKE OFF. THEY SAID IT WAS FROM RUSTING AND IT FINALLY GAVE. WAS RECOMMENDED TO REPLACE BOTH SIDES. NOT HAPPY AS I ALREADY PUT MUCH MONEY INTO THIS CAR AFTER I BOUGHT IT 3 YEARS AGO.

RECALL DATED AUG.10, 2016. UNABLE TO FIND ANY TOYOTA DEALER IN ATLANTA AREA WITH THE PART TO FIX THE PROBLEM. BEEN ACTIVELY ENGAGED WITH DEALERS FOR A YEAR TO GET RESOLUTION, BUT TO NO AVAIL. WANT TO SELL THE CAR BUT CAN'T AS LONG AS RECALL IS OUTSTANDING.

TL* THE CONTACT OWNS A 2008 TOYOTA RAV4. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 16V596000 (SUSPENSION) HOWEVER, THE PART FOR THE RECALL REPAIR WAS UNAVAILABLE. THE CONTACT STATED THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE CONTACT HAD NOT EXPERIENCED ANY FAILURE. THE CONTACT CONTACTED THE COURTESY TOYOTA DEALER WHO DESPITE HAVING AN APPOINTMENT FAILED TO HAVE ALL NECESSARY PARTS FOR THE REMEDY TO BE COMPLETED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. PARTS DISTRIBUTION DISCONNECT.

AFTER SECOND RECALL ON REAR SUSPENSION THAT OCCURRED IN NOVEMBER 2016, I HAD TO REPLACE MY TIRES ABOUT 20K MILES PREMATURELY BECAUSE OF EXCESSIVE WEAR ON INSIDE RIM. WHEN I WENT TO HAVE IT ALIGNED, I WAS TOLD THAT THE PARTS THAT WOULD HAVE BEEN ADJUSTED TO ALIGN THEM HAD STICKERS ON THEM IDENTIFYING THEM AS HAVING BEEN PART OF THE RECALL AND SAYING THAT THEY ARE NOW NON ADJUSTABLE. WHEN I CALLED TOYOTA, I WAS TOLD THAT IT WAS NOT THEIR PROBLEM BECAUSE I MUST HAVE DRIVEN OVER A CURB OR A POTHOLE BEFORE THE EPOXY HAD SET IN ORDER FOR THE CAR TO COME OUT OF ALIGNMENT. SO APPARENTLY NOW IF I DRIVE OVER A POTHOLE, INSTEAD OF A >$100 ALIGNMENT BILL, I WILL HAVE A $1000 BILL TO REPLACE THE REAR SUSPENSION. UNACCEPTABLE.

TL* THE CONTACT OWNS A 2008 TOYOTA RAV4. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBERS: 16V596000 (SUSPENSION) AND 16V096000 (SEAT BELTS); HOWEVER, THE PARTS FOR THE RECALL REPAIRS WERE UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIRS. THE MANUFACTURER WAS NOT MADE AWARE OF THE ISSUE. THE VIN WAS UNKNOWN. THE CONTACT HAD NOT EXPERIENCED A FAILURE. PARTS DISTRIBUTION DISCONNECT.

REAR LOWER SUSPENSION ARM ASSEMBLIES IN FALL 2016 I RECEIVED A SAFETY RECALL NOTICE FROM TOYOTA REGARDING THE REAR LOWER SUSPENSION ARM. THREE TIMES IN THE LAST SIX MONTHS I HAVE CONTACTED THE LOCAL TOYOTA DEALER TO SCHEDULE A SERVICE APPOINTMENT TO MAKE THE NECESSARY REPAIR. EACH TIME I WAS TOLD THAT I WOULD BE CONTACTED ONCE THE REPLACEMENT PARTS ARE AVAILABLE. IF THIS IS TRULY A SAFETY ISSUE WHY THE DELAY IN OBTAINING THE NECESSARY PARTS? TOYOTA SHOULD BE REQUIRED TO EXPEDITE THE REMEDIATION OF THIS SAFETY RECALL. THANK YOU,

TL* THE CONTACT OWNS A 2008 TOYOTA RAV4. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBERS: 16V596000 (SUSPENSION) AND 16V096000 (SEAT BELTS). THE PARTS TO DO THE REPAIR WERE UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE WESTERN SLOPE AUTO COMPANY IN GRAND JUNCTION, CO WAS CONTACTED AND CONFIRMED THAT THE PARTS WERE NOT AVAILABLE FOR THE RECALL REMEDY. THE MANUFACTURER WAS NOT MADE AWARE OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE. VIN TOOL CONFIRMS PARTS NOT AVAILABLE.

TL* THE CONTACT OWNS A 2008 TOYOTA RAV4. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 16V596000 (SUSPENSION). THE PART TO DO THE REPAIR WAS UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS NOT MADE AWARE OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE.

HAVE CALLED A FEW TOYOTA DEALERS IN THE AREA TO GET THIS URGENT RECALL TAKEN CARE OF. NOBODY HAS THE PARTS. WHY IS TOYOTA SAYING THIS IS AN "URGENT SAFETY RECALL" - QUOTE FROM FRONT OF NOTICE - YET NOT PROVIDING THE PARTS TO THE DEALERS? ONE DEALER SAID NO BOLTS. ANOTHER DEALER SAID NO SUSPENSION ARMS. I AM CURRENTLY #139 ON THEIR LIST, ONCE THE PARTS COME IN. CAN YOU REALLY ISSUE AN URGE NT SAFETY RECALL, YET NOT PROVIDE THE PARTS FOR REPAIR????

TOYOTA WANTS TO REPLACE MY REAR SUSPENSION ARMS, ALIGN MY WHEELS AND THE ENCASE ARMS IN EPOXY. THIS WILL PREVENT ANY FUTURE ALIGNMENTS TO MY CAR WITHOUT HAVING TO REPLACE THE SUSPENSION SYSTEM. SOMETHING THAT WAS DONE ON THE LAST RECALL OF THE FRONT END. HOWEVER THIS TIME THEY ARE REFUSING TO DO THE SAME THING. THIS IS NOT RETURNING THE CONDITION OF MY CAR TO THE CONDITION IT WAS IN WHEN I BOUGHT THE CAR. AND IT IS NOT ACCEPTABLE TO ME.

TL* THE CONTACT OWNS A 2008 TOYOTA RAV4. THE CONTACT RECEIVED A RECALL NOTIFICATION FOR NHTSA CAMPAIGN NUMBER: 16V596000 (SUSPENSION) AND STATED THAT THE PART NEEDED WAS UNAVAILABLE TO PERFORM THE RECALL REPAIR. THE MANUFACTURER WAS NOTIFIED OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE. PARTS DISTRIBUTION DISCONNECT.

TL* THE CONTACT OWNS A 2008 TOYOTA RAV4. WHILE DRIVING APPROXIMATELY 15 MPH, A POPPING NOISE WAS HEARD FROM THE REAR OF THE VEHICLE. WHILE INSPECTING THE VEHICLE, THE CONTACT DISCOVERED THAT THE REAR PASSENGER SIDE TIE ROD FRACTURED. THE CAUSE OF THE FAILURE WAS NOT DIAGNOSED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 75,000.

TL* THE CONTACT OWNS A 2008 TOYOTA RAV4. THE CONTACT RECEIVED A RECALL NOTIFICATION FOR NHTSA CAMPAIGN NUMBER: 16V596000 (SUSPENSION) AND STATED THAT THE PART NEEDED WAS UNAVAILABLE TO PERFORM THE RECALL REPAIR. THE MANUFACTURER WAS NOT NOTIFIED OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE. PARTS DISTRIBUTION DISCONNECT.