2009 Toyota RAV4 Tires & Wheels Problems

TL* THE CONTACT OWNS A 2009 TOYOTA RAV4. THE CONTACT STATED THAT ALL FOUR RIMS ON THE VEHICLE WERE CORRODED. THE VEHICLE WAS TAKEN TO A DEALER WHERE IT WAS DIAGNOSED THAT THE RIMS WERE CORRODED AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 70,000. ..UPDATED 06/08/17 *BF *CN

STUDS THAT THE LUG NUTS ARE SCREWED ON TO HAVE DETERIORATED. I JUST HAD MY TIRES ROTATED AND MY MECHANIC TOLD ME THAT THE NEXT TIME I ROTATE THE TIRES, THE STUDS WILL BREAK OFF. I ROTATE MY TIRES EVERY 6000 MILES

ON MAY 14, 2014 IN THE AFTERNOON I PICKED UP MY VEHICLE AND DROVE TO HOME DEPOT HERE ON ST. THOMAS, US VIRGIN ISLANDS. UPON GETTING READY TO LEAVE HOME DEPOT, I OBSERVED THE TIRE LIGHT ON. I SAID MAYBE THE TIRE HAS A LEAK. I THEN DROVE TO BARBEL PLAZA AND OBSERVED THAT THE TIRE WAS AIRING DOWN. I THEN TOOK MY VEHICLE TO THE TIRE SHOP NEXT TO SILVER DOLLAR. THE GENTLEMAN CHECKED THE TIRE AFTER THROWING SOAP LIQUID ON IT AND OBSERVED NO NAILS OR SCREWS STUCK IN THE TIRE. HE THEN TOOK OFF THE RIGHT FRONT TIRE AND POURED WATER INSIDE THE RIM AND SHOWED ME THAT THERE IS CRACK ON THE INSIDE RIM. HE SAID THAT SOMEONE COULD'VE DROPPED TBE TIRE ON THE GROUND OR SOMETHING FELL ON IT. I CALLED THE NHTSA WEBSITE AND WAS ADVISED TO CALL THE TOYOTA MANUFACTURER. I CALLED TOYOTA AND WAS ADVISED TO NOTIFY MY LOCAL TOYOTA SO THEY CAN ASSIST ME. I BROUGHT IT TO THE MANAGERS ATTENTION FOR TOYOTA AND I RECEIVED NO ASSISTANCE. HE IS GIVING ME A SIX FOR A NINE. I BOUGHT MY CAR IN NOVEMBER OF 2009. THE CAR HASN'T MAKE FIVE YEARS OLD AND THE RIM FOR THE TIRE IS CRACKED. I NEED SOME ASSISTANCE WITH MY RIM TO MY VEHICLE. IT SEEMS TO ME LIKE THE RIM WAS NOT FIXED PROPERLY. ALSO THE LUG NUT ARE NO GOOD EITHER. POOR MATERIAL. THANK YOU HOPE I GET SOME SORT OF ASSISTANCE. *TR UPDATED 11/5/2014 *JS

I WAS DRIVING MY VEHICLE A TOYOTA RAV 4 AND WAS APPROACHING THE ACCESS RAMP ON TO THE WV TURNPIKE, I WAS STRATING TO ACCELERATE AND HEARD A BANGING SOUND ON THE RIGHT REAR TIRE AREA I PULLED OFF THE ROAD TO CHECK, THE TIRE WAS LAYING AT A 95 DEGREE ANGLE SIDWAYS, LOOK LIKE ONLY HELD IN PLACE BY THE TOP BY THE REAR BRAKE. FOUND OUT LATER IT WAS THE RIGHT LOWER SUSPENSION ARM BROKEN. BASICALLY I LOST MY REAR WHEEL WHILE DRIVING MOST WHO SAW IT SAID I WAS LUCK TO BE ALIVE AND UNHARMED AND THAT PIECE WAS ON RECALL JUST FOR THAT REASON. *JS

I WRITE THIS LETTER SEEKING FOR HELP. SINCE THE YEAR 2011 I AM HAVING SERIOUS PROBLEMS WITH THE RIGHT WHEEL OF MY CAR WHERE THE TIRE STICKS CONSTANTLY. THE PANEL SHOWS THE LIGHT ON FOR ALL TIME. IN TWO YEARS ALREADY BOUGHT TWO TIRES, MY CAR IS THE YEAR 2009, I CONSIDER A NEW CAR. THE VISITS BEGAN TO BE FREQUENT IN THE COMPANY TOYOTA, WITH REPORT OF BUYING ANOTHER TIRE. I WONDER IF THIS PROBLEM BECOMES NORMAL. BECAUSE CHILDREN ARE IN MY CAR DAILY. *TR

TL* THE CONTACT OWNS A 2009 TOYOTA RAV4. THE CONTACT STATED THAT THE VEHICLE WAS EQUIPPED WITH YOKOHAMA G91 TIRES, SIZE 235/65/17(NA). THE CONTACT NOTICED THAT THE TIRE TREAD WAS PREMATURELY WORN ON ALL FOUR TIRES AND ALSO EXHIBITED SEVERAL CRACKS. THE FOUR TIRES WERE REPLACED BY AN INDEPENDENT TIRE CENTER. THE MANUFACTURER WAS NOT NOTIFIED OF THE DEFECT. THE APPROXIMATE FAILURE MILEAGE WAS 18,000. THE DOT NUMBER WAS UNAVAILABLE.

2009 RAV 4 YOKOHAMA GEOLANDAR 225/65R17 35,680 MILES.TIRES HAVE BEEN ROTATED EVERY5K MILES MY WIFE WAS ON EXPRESSWAY GOING 65 MPH,WHEN LEFT REAR TIRE BLEWOUT .SHE HAD SWERVE THREE LANES INTO THE BREAKDOWN LANE,SHE CALLED AAA WHICH CALL THE STATE POLICE.AAA CHANGED THE TIRE.WHEN SHE GOT HOME I LOOKED A THE REST OF THE TIRES AND NOTICED ALL TIRES WERE DRIEROTTED ALONG THE SIDEWALL. *TR

THIS IS TO NOTIFY YOU OF A POTENTIAL PROBLEM WITH YOKOHAMA GEOLANDAR G91 TIRES. ON WEDNESDAY, AUGUST 3, 2011, I HAD A BLOWOUT IN ONE OF THEIR TIRES LOCATED IN THE RIGHT REAR OF MY SUV. THE TIRES ARE ORIGINAL EQUIPMENT IN A 2009 RAV4, WITH 32,900 MILES, AND ARE INFLATED TO A PRESSURE OF 32.5 PSI. THE TIRE THREAD IS EVENLY WORN TO A DEPTH OF 5/32?, MEASURED VIRTUALLY EVERYWHERE ALONG THE TIRE, INDICATING EVEN WEAR. THE PHOTOGRAPH BELOW SHOWS THE TIRE WALL WITH THE DIMENSIONS, 225/65 R17 101H. THE BLOWOUT OCCURRED AT 4 AM, ON A SMOOTH ROAD (SANIBEL-CAPTIVA ROAD, BETWEEN THE 1 AND 2 MILE MARKERS) WHILE I WAS GOING BETWEEN 35 AND 40 MPH. THE AMBIENT TEMPERATURE WAS 82F ACCORDING TO THE CAR THERMOMETER. I DO NOT THINK I HIT ANYTHING, OR THAT THE TIRE WAS PUNCTURED, AS YOU CAN SEE WHEN I FOLD THE PIECE OVER THE SPACE, AS SHOWN IN THE PICTURE BELOW. BECAUSE OF THE SPEED AND ROAD CONDITIONS THERE WAS NO DAMAGE TO THE VEHICLE, BUT THE RIM BENT AND CRACKED. I HAVE FOUR PICTURES AND A DETAILED DESCRIPTION IN MY FILES, AND CAN SHARE IF YOU NEED THEM. I WILL REPLACE THE YOKOHAMA TIRES AS SOON AS A REPLACEMENT WHEEL ARRIVES. *TT

TIRES ROTATED. WHEEL STUD BROKE WHEN BEING HAND TORQUED TO FACTORY SPECS. NO AIR HAMMER WAS USED. BROKEN STUD WAS REPLACED. ALL OTHERS WILL BE REPLACED THIS WEEK. I HAVE HALF THE BROKEN STUD AND WILL KEEP THOSE REPLACED. *TR

2009 RAV4 1700 MI. HAD A TIRE PATCH REPAIRED AT A VERY REPUTABLE ,EXCLUSIVELY TIRES BUSINESS. WHEN THE SERVICEMAN ATTEMPTED TO PUT THE LAST LUG AT THE RECOMMENDED 80 FT LB TORQUE, THE WHEEL STUD SNAPPED OFF. THE AFFECTED STUD WAS/ IS NOT MIS-THREADED AND SHOWS A SHINY WEAK SPOT IN THE INTERIOR OF THE STUD. *TR

WE PURCHASED A NEW RAV4, IN MAY 2009. YESTERDAY WHILE THE CAR WAS PARKED THE LEFT REAR TIRE EXPLOSIVELY BLEW OUT THE SIDEWALL, THE CAR HAS 2400 MILES ON IT. THE PERSON WHO WITNESSED THE FAILURE SAID IT SOUNDED LIKE A SHOTGUN BLAST. I ALSO FOUND THIS IN OUR TOYOTA VEHICLE OWNER SERVICE RECORDS: BY DEALER 05/05/09TOYOTA OF MCDONOUGH 5 0092548REPAIR FLAT TIREVIEW DETAILS BASICALLY THIS CAR HAS HAD TWO TIRE FAILURES IN LESS THAN 3000 MILES. A RELATIVE OF OURS, THE ONE WHO RECOMMENDED THE RAV 4 TO US, HAD A SIMILAR EXPERIENCE WITH HIS NEW 2009 RAV4 WITH YOKOHAMA TIRES, BUT SINCE HE WAS ON THE INTERSTATE TRAVELING AT A HIGH RATE OF SPEED THE TIRE WAS SHREDDED TO BADLY TO DETERMINE THE CAUSE OF FAILURE. *TR