2016 Toyota RAV4 Engine Problems

The contact owns a 2016 Toyota Rav4. The contact received notification of NHTSA Campaign Number: 23V734000 (Electrical System). The contact stated that while his wife was driving at approximately 35 MPH, the check engine warning light and an additional unknown warning light illuminated. The vehicle was driven home. The vehicle was taken to an independent mechanic where it was diagnosed that the oil and air filter, and an additional unknown part needed to be replaced. The vehicle was repaired. The manufacturer was notified of the failure. The failure mileage was 65,000.

The contact owns a 2016 Toyota Rav4. The contact stated that the vehicle consumed an excessive amount of engine oil. The engine consumed half a quart of oil every 300 to 400 miles. The dealer was made aware of the failure and scheduled an upcoming appointment for an oil consumption test. The vehicle was not yet diagnosed or repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 47,000.

The contact owns a 2016 Toyota Rav4. The contact stated that while the vehicle was parked, unattended in the driveway, it caught fire in the engine. The fire department extinguished the fire. There were no reported injuries, property damage or police report filed. The local dealer was not contacted. The vehicle was not diagnosed or repaired. The vehicle was towed to an independent lot. The manufacturer was not contacted. The fire department provided report number 2022-05-FV. The approximate failure mileage was 112,000.

I called in a complaint a few weeks ago, the ref# is 1145-8214. ODI. I would like to upload my photos and other information of my RAV4 fire that started without any warning. I would also like to add that this was not a battery related issue. We never replaced the battery in the 2 years we had this RAV4. We bought this car from a reputable Toyota dealership. My husband would have also noticed if the battery was the incorrect size. We believe this fire was caused by rodents eating on the soybean wiring coating. We had issues with our Camry with chewed up wiring we had to replace those wires and saw feces in our all ourToyota cars.

On the evening of February 5th, I drove to my friend's house to pick them up for dinner. They live on the same street and are about 1200' away. I made a left turn into their driveway which is concrete with a fairly steep decline. While my foot was on the brake the car suddenly accelerated and I was unable to stop it before it hit the rear bumper of my friend's pickup. There was no damage to the pickup and my car had damage to the passenger side bumper and fender. Erie insurance looked at the car on March 1st and provided an estimate and payment on the same day. ($2,716 minus the $1,000 deductible) After receiving the estimate, I drove the car to Nashville Toyota North where I agreed to pay for a scan of the computer. After returning home I received a call from them requesting me to pick up the car. Their tech told the service manager that they could not do the scan since the car had been involved in a crash. I was told I needed to contact corporate Toyota which I did on the same day. I didn't have a ride to get back to the dealership and they let me keep it there. It was at the dealership from March 1st through April 15th when I picked it up. The car is now at a body shop.

The contact owned a 2016 Toyota Rav4. The contact stated that while driving approximately 50 mph when they noticed smoke and flames were coming from underneath the hood of the vehicle. The contact stated that when they attempted to move to the passenger side of the road they realized there was not enough room to do so causing them to roll over several times downhill eventually crashing into two trees. The contact stated that a civilian came and assisted them out of the vehicle once they noticed the crash. The air bags did deploy. The contact received head, neck, rib, sternum, and foot. Medical attention was needed. A police report was filed. The vehicle was towed and deemed totaled. The manufacturer was not made aware of the failure. The approximate failure mileage was 89,000.

WHEN BACKING UP (LIKE FROM YOUR DRIVEWAY) IF YOU SHIFT FROM "R" TO "D" TOO FAST ONE OF THE FOLLOWING EXTREMELY DANGEROUS ACTIONS WILL OCCUR: 1. THE ENGINE WILL STALL LEAVING YOU A SITTING DUCK IN TRAFFIC. RESTARTING IS NOT QUICK OR EASY. YOU MUST PUT YOUR FOOT ON THE BRAKE, SHIFT INTO "P" AND THEN HIT THE I/O BUTTON A NUMBER OF TIMES TO CYCLE BACK TO "START" POSITION TO GET THE CAR STARTED AGAIN. ALL THE TIME YOU ARE PRAYING ONCOMING TRAFFIC DOESN'T HIT YOU! 2. THE CAR WILL ENGAGE TRACTION CONTROL (TRAC INDICATOR ON). WHEN THIS HAPPENS PRESSING ON THE ACCELERATOR PEDAL HAS (ALMOST) NO EFFECT (I.E. SEVERE HESITATION) ONCE AGAIN THIS LEAVES YOU A SITTING DUCK IN THE MIDDLE OF THE ROAD UNTIL THE CAR DECIDES IT WANTS TO MOVE AGAIN. FROM WHAT I CAN TELL THIS DEFECT IS 100% REPEATABLE. I HAVE EXPERIENCED IT NUMEROUS TIMES AND IT SCARES THE LIVING CR@P OUT OF ME EACH TIME IT DOES IT!

ENGINE STALLS FOR A FEW SECONDS ON HILLS

THIS INCIDENT OCCURRED ON 8/30/16 AND INVOLVED A SUDDEN TOTAL AND UNEXPECTED LOSS OF POWER IN TRAFFIC AT INTERSTATE SPEEDS. VEHICLE INVOLVED WAS A SIX MONTH OLD 2016 TOYOTA RAV4 WITH 5300 MILES. INCIDENT OCCURRED IN SOUTHBOUND LANES OF I-65 BETWEEN LAFAYETTE AND LEBANON, IN. WHILE MOVING AT 60 MPH IN A VERY HEAVY RAINSTORM. FORTUNATELY, I WAS IN THE RIGHT HAND LANE AND WAS ABLE TO COAST TO THE SHOULDER OF THE ROAD WITHOUT BEING STRUCK BY FOLLOWING TRAFFIC AND HAD THE VEHICLE TOWED TO A TOYOTA DEALER IN AVON, IN. AFTER EXAMINING MY VEHICLE THE DEALERSHIP INFORMED ME THAT THERE WAS WATER IN MY ENGINE WHICH WAS NOT COVERED BY MY WARRANTY. THEY ALSO TOLD ME THAT I HAD BEEN DRIVING THROUGH DEEP STANDING WATER. WHEN TOLD THAT I WAS DRIVING ON INTERSTATE, THE DEALERSHIP TOLD ME THAT THEN IT WAS "AN ACT OF GOD" AND STILL WAS NOT COVERED. SINCE DEALING WITH REPLACEMENT OF THE ENGINE, AT A COST OF $10,000, I HAVE HAD THE CAR EXAMINED BY A MECHANICAL ENGINEER WHO IS OF THE OPINION THAT THIS PROBLEM OCCURRED DUE TO THE RE-DESIGN OF THE AIR INDUCTION SYSTEM. AIR IS INDUCTED AT LEFT FRONT WHEEL AND, WITH HEAVY RAIN, WATER SPLASHING OFF ROAD IS FORCED THRU AIR FILTER. WATER SHOULD NOT REACH THE AIR FILTER BUT, SINCE THIS IS THE ONLY AVENUE FOR ENTRANCE TO THE ENGINE WITHOUT SUBMERSION, IT OBVIOUSLY DID. ONCE FILTER IS SATURATED THERE ARE NO BAFFLES OR SWALES TO PREVENT WATER FROM RUNNING DIRECTLY INTO THE INTAKE OF THE ENGINE. TOYOTA ACCEPTS NO RESPONSIBILITY FOR THIS INCIDENT EITHER FINANCIALLY OR FOR SAFETY CONCERNS. THEY DO NOT BELIEVE THAT I WAS JUST DRIVING DOWN THE INTERSTATE. I HAVE A DISTINCT ADVANTAGE IN THAT IKNOW THAT THIS IS TRUE. I FEEL EXTREMELY FORTUNATE TO HAVE AVOIDED A CRASH AT THIS SPEED AND IN THESE CONDITIONS. I HOPE THAT TOYOTA DOES NOT WAIT UNTIL WE HAVE SERIOUS INJURY OR LOSS OF LIFE TO ACKNOWLEDGE AND CORRECT THIS DESIGN FLAW. *TR