2006 Toyota Sequoia Body & Structure Problems

Back in 2018 toyota did the undercoat to my 2006 Toyota sequoia frame to prevent rust. Now my frame is completely rotted out to the point i can’t drive my vehicle.

Frame of this vehicle has lot of rust damage, is it still under manufacture recall? How can I ensure safety of my vehicle along with rusty frame? I’ll be glad to receive more information how to contact manufacturer in order to get this resolved. I drove this vehicle on Nov 19, 2023 last time just hear some knocking sounds while driving

Frame rusted so badly the the brackets attached to it are coming off

The driver side, rear, trailing arm broke away from the vehicles frame due to “frame rot” while driving. The vehicle became extremely dangerous to drive. Toyota has since declined to help. They said they notified us via mail of a customer service campaign addressing the premature rust issue, but we never learned of the program and lawsuit until after the frame broke and I almost crashed. Later I saw the broken arm/frame under the vehicle. This frame failure can potentially be a catastrophic and deadly event. I opened an insurance claim and it was denied and I was referred back to Toyota. Our vehicle has been factory maintained it’s entire life. No service advisors ever mentioned a possible problem to my family and I. I recently spoke to the Toyota service manager at Parker Toyota in Couer d Alene Idaho and his master technicians have seen the same failure that occurred on our vehicle. This is extremely dangerous.

I was on the freeway driving and out of nowhere the body started swaying and bobbing with no control. Was informed by the tow truck driver that i could have rolled the vehicle easily and the consequences would have been serious. The frame is so rusted out that the tie rod and sway bar assembly are completely detached from the frame and hanging loose. Upon further inspection at the auto repair garage there are rusting issues throughout the frame. The frame needs complete replacement.

Frame rusted out and parts dropping off frame with no early warning. Toyota completed corrosion resistant compound 2 years ago following inspection per limited service campaign H0F, saying issue resolved to extent of warranty with known rust issue for this year and model. Now another independent garage saying we never should have been driving, much less hauling 5000 lb. trailer. Only warning was odd sound from under carriage.

THE FRAME IS VERY RUSTED

MY VEHICLE WAS IN FOR ENGINE AND TRANSMISSION REPAIRS AND BEING WORKED ON FOR 3 MONTHS. I WAS UNABLE TO GET IT TO TOYOTA BEFORE THE JANUARY 31 DEADLINE FOR THE FRAME PROGRAM. I CALLED AND WAS TOLD BECAUSE IT WAS BEING WORKED ON, IT WOULD BE HONORED ANYWAYS. CALLED TO SCHEDULE TO BRING IT IN AND THEY SAID, SORRY, THAT EXPIRED, SO YOU HAVE TO GET APPROVAL FROM TOYOTA BUT WE CAN STILL COAT IT IN ANTI CORROSION TIL THE END OF MAY. I CALLED TOYOTA AND SPOKE TO MULTIPLE PEOPLE WHO ALL SAID, ITS EXPIRED AND WE CAN'T HELP YOU. SO NOW I HAVE A VEHICLE WITH A PROVEN UNSAFE FRAME AND NO SOLUTION.

I HAVE REPLACED THE LATCH ON MY LIFT GATE 3 TIMES NOW. THE LATCH KEEPS BREAKING. THIS IS RIDICULOUS. I DON'T SEE A RECALL FOR IT BUT I THINK THERE SHOULD BE A RECALL FOR IT. I CAN'T ACCESS MY SPARE TIRE IF I HAVE A FLAT OR SOMETHING. THIS NEEDS TO BE ADDRESSED ASAP.

SEVERE RUST HOLE IN REAR FRAME OVER LEAF SPRINGS NOTED BY MECHANIC WHEN DOING ALIGNMENT. I WAS INFORMED THAT IT WOULD NOT PASS INSPECTION.

REAR HATCH. REAR HATCH HANDLE MADE OF PLASTIC. HAS BROKEN THREE TIMES SINCE I HAVE OWNED THE CAR. DEALER CHARGES $600 EACH TIME TO REPLACE. TOYOTA SHOULD NOT MAKE CARS WITH SUCH CHEAP PARTS. CANNOT GET INTO VEHICLE.

TL* THE CONTACT OWNS A 2006 TOYOTA SEQUOIA. UPON TAKING THE VEHICLE IN FOR INSPECTION, THE VEHICLE FAILED DUE TO A HOLE IN THE REAR OF THE FRAME NEAR THE HITCH. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO DIAGNOSED THAT THE FRAME WAS SEVERELY RUSTED. THE INDEPENDENT MECHANIC ADVISED THE CONTACT TO TAKE THE VEHICLE TO A DEALER. THE CONTACT TOOK THE VEHICLE TO TRI COUNTY TOYOTA (15 D AND L DR, ROYERSFORD, PA 19468) WHERE IT WAS ALSO DIAGNOSED THAT THE HOLE IN THE FRAME WAS DUE TO RUST. THE CONTACT WAS ADVISED BY THE DEALER THAT THERE WAS A CLASS ACTION LAWSUIT, BUT THE DEALER COULD NOT PROCEED WITH A REPAIR BECAUSE NHTSA HAD TO AGREE TO A PLAN TO INITIATE A RECALL AND REMEDY THE ISSUE. THE VEHICLE WAS NOT REPAIRED, BUT THE DEALER STATED THAT THEY WOULD PERFORM A TEMPORARY WELD ON THE FRAME UNTIL TOYOTA COULD ISSUE A RECALL WITH A FINAL REMEDY. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 145,000. THE VIN WAS UNAVAILABLE.

IN APRIL 2017 OUR 2006 SEQUOIA WAS TAKEN TO A MECHANIC FOR REPAIR. THE MECHANIC TOLD US THE AMOUNT OF RUST UNDER THE VEHICLE AND AROUND THE FRAME WAS SO BAD HE RECOMMENDED WE FILE A COMPLAINT. HIS ASSESSMENT WAS THAT THE CAR IS UNSAFE TO DRIVE. I AM PETITIONING THAT TOYOTA STAND BEHIND THIS ISSUE FOR OUR SAFETY!!

RUST IS RAPIDLY DESTROYING THE FRAME OF MY SEQUOIA!

TL* THE CONTACT OWNS A 2006 TOYOTA SEQUOIA. THE CONTACT STATED THAT THE FRAME OF THE VEHICLE EXHIBITED EXCESSIVE RUST. THE VEHICLE WAS TAKEN TO BOTH A DEALER AND AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE VEHICLE FRAME WAS RUSTED THROUGH. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT INFORMED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 50,000.

THE FRAME, REAR AXLE, SUSPENSION, BRAKE LINES COMPONENTS ARE SEVERELY RUSTED IN PARTICULAR THE FRAME WHERE IT IS RUSTING FROM THE INSIDE OUT. THESE FRAMES SUFFER FROM THE SAME ISSUE AS OTHER TOYOTA TRUCKS WHERE TOYOTA REPLACED THE FRAMES. THIS RUST CONDITION MAKES THESE VEHICLES UNSAFE TO BE ON THE ROAD. TOYOTA NEEDS TO RECALL OF THESE VEHICLES BEFORE PEOPLE ARE HURT. I PURCHASED THIS VEHICLES NEW IN 2006 AND MAINTAINED IT WELL. I ADDRESSED THE EXTERNAL RUST BUT CAN NOT PREVENT THE INTERNAL RUST. THE FRAMES NEED TO BE REPLACED OR THE VEHICLE BROUGHT BACK AND DISPOSED OF.

BROUGHT VEHICLE IN TO HAVE VSC LIGHT SERVICE AND FOUND OUT THAT THE FRAME WHERE THE VEHICLE REAR STABILITY BAR CONNECTS TO IS ALL RUSTED OUT. AND THE OTHER SIDE WILL SOON FOLLOW. I WAS TOLD THAT THE VEHICLE WAS UNSAFE TO DRIVE, SEE PHOTOS.

THERE'S AN 18 TO 24 INCH HOLE IN THE FRAME ON THE LEFT FRONT, WHICH SHOULD NOT HAVE DETERIORATED SO QUICKLY OR TO THAT EXTREME. EXTREME SAFETY HAZARD AS THE FRAME COULD BRAKE WITH ANY SIGNIFICANT STRESS, SUCH AS POTHOLES.

FRAME HAS RUST CORROSION CAUSING 18 INCH PERFORATED HOLE IN FRONT FRAME OF CAR. THIS IS SAME PROBLEM THAT HAS WARRANTED A RECALL OF THE TOYOTA TUNDRA WHICH USES THE SAME FRAME. THE CAR HAS BEEN DEEMED UNSAFE TO DRIVE DUE TO THE EXTENSIVE RUST CORROSION ON THE FRAME. THIS MUST BE DUE TO POOR QUALITY MATERIAL AND COATING OF THE ORIGINAL FRAME. THROUGH RESEARCH APPEARS TO BE A VERY COMMON PROBLEM IN SEQUOIA THAT ARE IN AREAS DEALING WITH ROAD SALT. THE RECALL SHOULD BE EXTENDED TO INCLUDE THIS MODEL ALONG WITH THE TUNDRA. THE CAR IS PARKED OUTSIDE DRIVEWAY AND MOSTLY LOCAL DRIVING.

SEVERE FRAME CORROSION, 2006 TOYOTA SEQUOIA: I WAS UNAWARE OF THE "COLD WEATHER STATES" FRAME CORROSION PROBLEM WITH TOYOTAS (AND RECALLS OF OLDER SEQUOIAS AND OTHER TOYOTA TRUCKS) UNTIL I TOOK MY '06 SEQUOIA TO MY LOCAL DEALER FOR AN AIRBAG RECALL REPLACEMENT AND DIAGNOSIS OF WHAT I THOUGHT WAS A MINOR FRONT END RATTLE. WHEN THEY RAISED IT ON THE LIFT, THEY SAID THE VEHICLE BEHAVED IMPROPERLY AND THEY WERE ALARMED. THAT IS WHEN THEY DISCOVERED THE LARGE, RUSTED HOLE IN THE FRAME! WHAT A SHOCK IT WAS WHEN THEY TOLD ME, AND THEN, TO BE ADVISED THAT IT IS UNSAFE TO DRIVE! IF I HAD NOT TAKEN IT IN FOR THE AIRBAG RECALL, MY FAMILY AND I COULD BE DEAD RIGHT NOW, IF CONDITIONS HAD BEEN JUST SO. THIS IS ABSOLUTELY UNBELIEVABLE THAT TOYOTA IS PUTTING PEOPLES' LIVES IN DANGER BY NOT RECALLING ALL VEHICLES WITH THIS FRAME AND STANDING BY THEIR PRODUCT. ARE THEY WAITING FOR A DEATH(S) TO OCCUR BEFORE THEY ARE FORCED TO RECALL? THEY CERTAINLY KNOW THAT OTHER NON-RECALLED MODELS OF SEQUOIA HAVE FRAME ROT. PRESENTLY, MY LOCAL TOYOTA DEALER IS WAITING FOR APPROVAL OR DISAPPROVAL TO HAVE THE FRAME REPLACED FREE OF CHARGE. I AM WARY AND LEFT IN CONSTANT WORRY IF TOYOTA WILL HELP, BASED ON THE REPORTS OF OTHER PEOPLES' EXPERIENCES WHOSE VEHICLES WERE NOT RECALLED YET. I AM FACED WITH IT BEING A TOTAL LOSS IF TOYOTA DOES NOT CHOOSE TO DO THE RIGHT THING. (THIS IS THEIR FAULT. THEY SHOULD FIX IT FREE OF CHARGE. PERIOD.) I BOUGHT THIS VEHICLE BECAUSE OF ITS REPORTED RELIABILITY. I HAVE BEEN A 3 TIMES LOYAL CUSTOMER TO TOYOTA AND AM IN UTTER DISBELIEF HOW I HAVE BEEN MISLED. PLEASE PUSH TO HAVE TOYOTA RECALL ALL TOYOTA SEQUOIAS THAT HAVE BEEN MADE ON THIS FRAME SO THAT NOBODY ELSE HAS TO GO THROUGH THIS UNIMAGINABLE STRESS, AND MORE IMPORTANTLY, BEFORE SOMEONE DIES OR IS SEVERELY INJURED. WILL MY REPORT BE THE FINAL REPORT THAT PROMPTS A RECALL OR THIS DEATH TRAP? I HOPE SO.