2008 Toyota Sienna Complaint Log

RECEIVED LETTER,7/24/14, ADVISING THAT MY 2008 TOYOTA SIENNA HAD A POTENTIAL PROBLEM WITH THE CABLE, HOLDING THE SPARE TIRE UNDERNEATH THE VEHICLE, WHICH NEEDED TO BE REPLACED. ON 8/26/14, MY SPARE TIRE WAS RELOCATED TO THE LUGGAGE COMPARTMENT OF MY VAN WHICH RENDERED THE AREA UNUSABLE FOR FOLDING THE REAR SEATS DOWN TO USE THAT AREA FOR TRANSPORTING LARGER ITEMS, ETC! I CHECKED SEVERAL TIMES WITH MY LOCAL DEALER REGARDING A PERMANENT SOLUTION/REPAIR AND WAS TOLD THEY HAD NOT YET RECEIVED NOTICE OF AND/OR REPAIR PARTS FOR THE IDENTIFIED PROBLEM.ON 11/20/14, I CONTACTED THE TOYOTA CUSTOMER EXPERIENCE CENTER AND SPOKE, AT LENGTH, WITH A REPRESENTATIVE WHO STATED THAT THEY HAD BEEN RECEIVING NUMEROUS CALLS REGARDING THIS ISSUE AND THAT SHE WAS AWARE OF SEVERAL MEETINGS REGARDING THE ISSUE BUT NO RESOLUTION AS YET AND NO IDEA WHEN A RESOLUTION WILL OCCUR. IT WOULD SEEM THAT BY NOW, IF THE SITUATION IS BEING ACTIVELY WORKED ON, AN ACCEPTABLE REPAIR WOULD BE AVAILABLE! I AM FRUSTRATED AND DISAPPOINTED WITH TOYOTA FOR THEIR SEEMING INDIFFERENCE TO THOSE OF US WAITING FOR THEIR ACTION ON THIS MATTER. THANK YOU FOR YOUR PROMPT ATTENTION TO THIS SITUATION. *TR

UPON EXITING FREEWAY IN BUTTE, MT, AND SLOWING DONE FOR RED LIGHT AT BOTTOM OF RAMP, HEARD TAPPING NOISE COMING FROM ENGINE. DROVE ONE BLOCK TO GAS STATION, AND WHILE PUMPING GAS, NOTICED LARGE QUANTITY OF ENGINE OIL PUDDLING UNDER THE ENGINE. HAD VEHICLE TOWED TO TOYOTA DEALER, WHO DETERMINED THAT OIL COOLER HOSE HAD RUPTURED. FORTUNATELY, NO APPARENT ENGINE DAMAGE. AFTER SOME RESEARCH ON SIENNA OWNERS' FORUM, LEARNED THAT THIS WAS A RECURRING PROBLEM ON CERTAIN TOYOTA MODELS IN CERTAIN YEARS, INCLUDING THE 2008 SIENNA WITH TOW PACKAGE LIKE OURS, AND THAT TOYOTA HAD PUT OUT A TSB ON THIS, BUT APPARENTLY HAD NEVER INFORMED OWNERS. IT TOOK 4 DAYS FOR THE REPLACEMENT HOSE TO ARRIVE, AND THE REPAIR COST $520. THIS INCIDENT OCCURRED WHILE MY FAMILY WAS FAR FROM HOME (SILVER SPRING, MD) ON A CROSS-COUNTRY TRIP AND THUS FORCED THEM TO CANCEL PART OF VACATION AND SPEND EXTRA $$ ON HOTELS AND A RENTAL CAR. BUT IT COULD HAVE BEEN MUCH WORSE - THE OIL COULD HAVE DRAINED WHILE AT SPEED ON THE HIGHWAY, RUINING THE ENGINE, STRANDING MY FAMILY IN AN ISOLATED AREA OR CAUSING AN ACCIDENT OR ENGINE FIRE AND POSSIBLE INJURIES. GIVEN THAT TOYOTA WAS AWARE OF THE PROBLEM, IT COULD HAVE INFORMED US SO WE COULD HAVE HAD THE HOSE REPLACED BEFORE IT FAILED. *TR

THE DASHBOARD SEEMS TO BE MELTING, IS STICKY AND IS CRACKED IN SEVERAL PLACES. *TR

THE PASSENGER SEAT BELT HAS FOLDED OVER AND JAMMED. IT IS NOT ABLE TO RETRACT NOW. THIS IS A SAFETY HAZARD. *TR

VVT-I HOSE BROKEN, RAPID OIL LOSS AND ALMOST NO OIL LEFT IN ENGINE WHEN PROBLEM WAS SPOTTED. OIL SPILLED TO THE BELTS AROUND THE VVT-I HOSE. WHEN TURN STEERING WHEEL, NOISE HEARD. THIS IS THE SAME ISSUE TO THE OTHER RECALLS BUT NOT APPLICABLE TO TOYOTA SIENNA. HTTP://TOYOTANEWS.PRESSROOM.TOYOTA.COM/ARTICLE_DISPLAY.CFM?ARTICLE_ID=1906 I WAS TOLD MAY CAUSE PROBLEM TURNING THE STEERING WHEEL, OR ACCIDENT. I WAS INSTRUCTED TO FILE THE CLAIM TO YOUR OFFICE. THANKS. *TR

MY 2008 TOYOTA SIENNA LE WAS BOUGHT BRAND NEW, HAVE IT SERVICED AT TOYOTA DEALERS, ON JUNE 5TH, 2014, L TOOK THE VAN TO A DEALER FOR A REGULAR SERVICE L WAS TOLD MY STEERING RACK WAS LEAKING AND WILL NEED TO HAVE THE WHOLE STEERING RACK REPLACE. THE VAN ONLY HAS 57,000 + ON IT AND SERVICED REGULARLY. WITH THE HISTORY OF SEVERAL RECALL ON SIENNA, L BELIEVED THIS MIGHT BE A DEFECT FROM TOYOTA. THIS IS A SAFETY ISSUE WHICH THE DEALER REFUSED TO ACKNOWLEDGE CAUSED THE VAN WARRANT HAS RAN OUT EVEN THOUGH L BOUGHT AN EXTENDED WARRANTY (COST GUARD) WHICH L WAS TOLD AGAIN THAT THE COST GUARD WARRANTY HAS EXPIRED TOO. I HAVE REPORTED THIS ISSUE TO TOYOTA BUT NOTHING WAS DONE. I AM APPEALING TO YOUR HONORABLE OFFICE TO INVESTIGATE AND ASK TOYOTA TO TREAT THIS AS A DEFECT AND SAFETY ISSUE. [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

TL* THE CONTACT OWNS A 2008 TOYOTA SIENNA. THE CONTACT STATED THAT THE ELECTRONIC SLIDING DOORS ON THE VEHICLE HAD EXPERIENCED SEVERAL FAILURES. THE CONTACT STATED THAT THE DOORS ERRONEOUSLY SLID OPEN WHILE THE VEHICLE WAS BEING DRIVEN AND THE SLIDING DOORS WERE VERY DIFFICULT TO OPEN WHEN USING THE DOOR HANDLE. THE DOORS, AT TIMES, WOULD NOT UNLOCK FROM INSIDE THE VEHICLE AND WOULD BECOME JAMMED. THE VEHICLE WAS TAKEN TO THE LOCAL DEALER (KOLAR TOYOTA, 4781 MILLER TRUNK HWY, HERMANTOWN, MN 55811, (218-733-0100) WHO REPLACED THE CABLES AND GREASED THE DOOR PARTS, BUT THE FAILURES CONTINUED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURES. THE FAILURE MILEAGE WAS 100,000.

UPON EXITING THE INTERSTATE, WE BEGAN TO SMELL A BURNING SMELL AND THE LIGHT FOR THE A/C STARTED FLASHING AND WOULDN'T TURN BACK ON. WE DROVE ABOUT A MILE THINKING THAT THE SMELL WAS ROADWORK, BUT THEN WE DECIDED TO STOP AND CHECK IT UNDER THE HOOD. ONCE WE OPENED THE HOOD, WE WERE HIT WITH A PLUME OF SMOKE, AND REALIZED THERE WAS A POOL OF OIL UNDER THE VAN. WE BEGAN TO LOOK ON THE INTERNET FOR CAUSES, WHERE WE CAME ACROSS SEVERAL INSTANCES OF THE OIL HOSE BLOWING AND THE VEHICLE CATCHING FIRE. WE CALLED THE DEALERSHIP THE NEXT DAY TO SEE IF THERE WAS A RECALL. THEY DIDN'T KNOW OF ONE, BUT STATED THAT THEY'D FIXED SEVERAL VEHICLES FOR THE SAME ISSUE. THIS IS VERY ALARMING SINCE THE CHECK ENGINE LIGHT, OIL LIGHT, ETC DIDN'T EVEN TURN ON. HAD WE DRIVEN ANOTHER MILE, WOULD THE VAN HAVE CAUGHT FIRE? WE HAVE A VAN FULL OF CHILDREN, AND IT'S FRIGHTENING TO THINK THAT THIS COULD HAVE ENDED MUCH WORSE.

BOTH SLIDING DOORS ARE NOT WORKING PROPERLY. THEY DO NOT LATCH AND STAY CLOSED. BOTH DOOR HAVE OPENED WHILE VEHICLE WAS IN MOTION. BACK POWER SLIDING DOOR HAS OPENED WHILE THE VEHICLE WAS BEING DRIVEN AT LEAST 10 TIMES. THE BACK NON-POWER SLIDING DOOR IS NOT WORKING EITHER. HOWEVER, THIS ONE WE DO NOT USE AND IT HAS STAYED CLOSED MOST OF THE TIME. IT HAS ONLY OPENED 3 TIMES WHILE DRIVING. THIS IS AN EXTREME DANGER. TOYOTA IS ONLY COVERING PART OF THE COST TO REPAIR BUT I WAS PAST THE 120,000 MILES WHEN MY PROBLEM BEGAN. SO WE ARE LEFT FOOTING THE BILL ON A DEFECT OF TOYOTA'S DOING. I FEEL THIS IS OUTRAGEOUS BECAUSE IT IS A HUGE SAFETY CONCERN. *TR

TL* THE CONTACT OWNS A 2008 TOYOTA SIENNA. THE CONTACT RECEIVED A NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 14V273000 (TIRES) HOWEVER, THE PART TO DO THE REPAIR WAS UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS MADE AWARE OF THE DELAY. THE CONTACT HAD NOT EXPERIENCED A FAILURE. MAILOUT 1/13/15*LJ

TL* THE CONTACT OWNS A 2008 TOYOTA SIENNA. THE CONTACT STATED THAT WHILE TRAVELING 25 MPH, THE CHECK ENGINE LIGHT ILLUMINATED. THE STEERING WHEEL BECAME VERY DIFFICULT TO CONTROL AND HAD TO BE TOWED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND DIAGNOSED THAT THE ENGINE NEEDED TO BE REPLACED. THE VIN WAS NOT PROVIDED. THE FAILURE AND CURRENT MILEAGE WERE 80,000.

BOUGHT THIS VEHICLE USED FROM A DEALER ON 5/10/2014. NOTICED "STICKINESS" ON THE ENTIRE TOP OF DASHBOARD. THOUGHT IT COULD BE CLEANED OR WASHED OFF. IT NEVER CAME OFF. SAW IN THE MEDIA THAT THIS IS A PROBLEM WITH TOYOTA DASHES-MELTED DASHBOARDS, STICKY AND CAN SCRAPE SURFACE OFF WITH YOUR FINGERNAIL. THERE IS A SHINY GLARE TO THE DASHBOARD. *TR

THE FRONT DRIVER'S SEAT BELT BECAME JAMMED AND COULD NOT BE RELEASED. I WAS 3 MILES AWAY FROM HOME AND, AFTER STRUGGLING FOR A WHILE, HAD TO DRIVE HOME WITHOUT WEARING A SEATBELT. WE HAD TO TAKE APART THE INTERIOR PANEL TO FIX THE SEATBELT. I HAVE GOOGLED AND APPARENTLY THIS IS A COMMON PROBLEM FOR THE SIENNA. *TR

THE AUTOMATIC SLIDING DOOR CABLE CAME LOOSE, CAUSING THE DOOR TO GET STUCK AND FURTHER DAMAGE THE CABLE. THIS FLAW IS NOTED IN A RECALL FOR 2004-2007 MODELS, BUT WE BELIEVE IT SHOULD BE INCLUDED IN THE 2008 MODELS, AS WELL. *TT

DURING A RECENT TRIP TO ALABAMA FROM VIRGINIA, OUR 2008 TOYOTA SIENNA SUDDENLY ACCELERATED WHILE PRESSING THE BRAKE PEDAL INSTEAD OF BRAKING. BOTH TIMES, WE WERE APPROACHING MODERATELY HEAVY TRAFFIC. MY WIFE WENT TO APPLY THE BRAKES TO SLOW THE VAN. INSTEAD OF BRAKING AND SLOWING THE VEHICLE, THE VAN WENT INTO FULL ACCELERATION MODE. THE TRANSMISSION DOWNSHIFTED AND STARTED APPLYING FULL THROTTLE. THE FIRST TIME WE THOUGHT WE WERE GOING CRAZY. THE SECOND TIME, BOTH MY WIFE AND I WATCHED AS HER FOOT APPLIED THE BRAKES AND TO OUR AMAZEMENT, THE VAN STARTED ACCELERATING AGAIN! LUCKILY BOTH TIMES, MY WIFE TOOK HER FOOT OFF THE BRAKE PEDAL AND REAPPLIED ONCE THE VAN STOPPED ACCELERATING AND THE BRAKES WORKED THEN. I HAVEN'T HAD TIME TO TAKE THIS INTO THE TOYOTA DEALER YET. WE ARE STILL UNDER A 30 DAY WARRANTY WITH CARMAX, SO I HAVE COMMUNICATION OUT TO THEM TO SEE HOW WE SHOULD HANDLE THIS SITUATION. I THOUGHT THIS TOYOTA SUDDEN ACCELERATION STORY WAS EXAGGERATED. NOW I'VE EXPERIENCED IT MYSELF. *TR

AIRBAG WARNING LIGHT CAME ON WITHOUT APPARENT CAUSE. WE TOOK IT IN TO TOYOTA DEALER, THEY SAID THEY REPLACED THE PASSENGER SIDE AIRBAG HARNESS , BUT COULD NOT COMPLETE REPAIR, AIRBAG WARNING LIGHT STILL ON. TOYOTA STILL WAITING FOR ANOTHER PLUG TO REPAIR 2 MONTHS LATER. VERY SERIOUS ISSUE AS THEY SAID AIRBAGS WILL NOT WORK PROPERLY. *TR

TL* THE CONTACT OWNS A 2008 TOYOTA SIENNA. THE CONTACT STATED THAT WHILE DRIVING AT APPROXIMATELY 5 MPH, THE VEHICLE STALLED WITHOUT WARNING. THE VEHICLE WAS UNABLE TO RESTART AND WAS TOWED TO THE DEALER. THE DEALER DIAGNOSED THAT THE FUEL PUMP RESISTER NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 62,000.

2008 SIENNA HAS DEVELOPED STEERING ISSUE AND ALMOST LOST STEERING CONTROL OF VAN. PROBLEM APPEARS TO BE FAILURE OF STEERING INTERMEDIATE SHAFT THAT RESULTED IN INTERMEDIATE ABILITY TO STEER VEHICLE. VERY CHOPPY STEERING. THIS IS A VERY COMMON ISSUE WITH TOYOTAS. CONTACTED TOYOTA CUSTOMER SERVICE AND WAS INFORMED THERE ARE TSB'S FOR PRIOR AND POST YEAR VEHICLES BUT NOT FOR 08 SIENNA. TOYOTA NEEDS TO FURTHER INVESTIGATE AS FAILURE OF STEERING COMPONENT IS NOT ACCEPTABLE. TSB IS NOT ACCEPTABLE.

MY WIFE WAS PARKING OUR 2008 TOYOTA SIENNA WITH OUR 3 YOUNG BOYS IN THE AUTOMOBILE. SHE SLOWLY BROUGHT THE VEHICLE TO A COMPLETE STOP; NEVER USING GAS, JUST COVERING AND TAPPING LIGHTLY ON THE BRAKE. ONCE THE AUTOMOBILE CAME TO A STOP MY WIFE PRESSED THE BRAKE A LITTLE MORE IN ORDER TO PUT THE VEHICLE IN PARK. AT THAT MOMENT THE VEHICLE ACCELERATED INCREDIBLE FAST, JUMPED OVER AN 8 INCH CONCRETE PARKING LOT DIVIDER AND CRASHED INTO A TREE ABOUT 10 - 15 FEET FROM THE CONCRETE DIVIDER. WE ARE CERTAIN THAT THIS WAS A "SUDDEN UNINTENDED ACCELERATION" INCIDENT CAUSED BY SOME MECHANICAL, ELECTRICAL, PROGRAMMING OR OTHER DEFECT IN THE '08 SIENNA. THIS WAS NOT "DRIVER ERROR"! MY WIFE DID NOT CONFUSE THE GAS PEDAL AND THE BRAKE. THIS WAS NOT CAUSED BY A FLOOR MAT OBSTRUCTING THE GAS PEDAL. THIS WAS CAUSED BY SOME TYPE OF A DESIGN OR COMPONENT DEFECT. HOW CAN W BE SO CERTAIN? MY WIFE AND I HAVE PARKED IN THIS PARKING SPOT (LOCATED IN OUR APARTMENT COMPLEX) HUNDREDS OF TIMES. TO PARK IN THIS PARKING SPOT YOU FIRST HAVE TO MAKE A LEFT HAND TURN AT A STOP SIGN. THIS STOP SIGN IS ABOUT 30 - 40 FEET FROM THE PARKING SPOT, WHICH REQUIRES THAT YOU MAKE A SHARP RIGHT TURN. ONCE YOU PRESS THE ACCELERATOR SLIGHTLY TO MAKE THE LEFT AT THE STOP SIGN, YOU DO NOT USE THE GAS AGAIN. YOU SIMPLY TAP AND COVER YOUR BRAKE UNTIL YOU MAKE THE RIGHT INTO THE PARKING SPOT. OUR VEHICLE CAME TO A STOP. IN FACT, UPON "STOPPING" ONE OF OUR 3 BOYS REMOVED HIS SEAT BELT IMMEDIATELY BEFORE THE VEHICLE ACCELERATED OUT OF CONTROL. I'M ASKING FOR ASSISTANCE FROM SOMEONE WITHIN TOYOTA OR THE NHTSA WITH KNOWLEDGE OF THIS FLAW. MY WIFE AND KIDS WERE "FORTUNATE". BUT THIS IS A "FATAL FLAW" AND SOMETHING MUST BE DONE. *TR

TL* THE CONTACT OWNS A 2008 TOYOTA SIENNA. THE CONTACT STATED THERE THE VEHICLE WAS INCLUDED IN NHTSA CAMPAIGN ID 13V429000 (POWER TRAIN) HOWEVER, THE DEALER REFUSED TO HONOR THE RECALL FOR AN UNKNOWN REASON. THE MANUFACTURER WAS NOTIFIED AND WOULD NOT AUTHORIZE ANOTHER DEALER TO SERVICE THE VEHICLE UNDER THE RECALL. THE CONTACT HAD NOT EXPERIENCED A FAILURE. UPDATED 7/25/14*CN CONSUMERS HANDWRITING IS ILLEGIBLE. UPDATED 08/05/14

WHEN I WAS DRIVING ON THE HIGHWAY , THE TIRE ON THE RIGHT SIDE IN THE BACK ON THE SIDE OF THE PASSENGER SIDE EXPLODE AND BROKE THE PIPES OF THE HEATER AND THE ANTI FREEZE OF THE AIR CONDITION THAT WERE NEXT TO THE WHEEL THAT EXPLODED ON THE PASSENGER SIDE ON THE BACK WHEEL. *TR

NOTE: I HAVE TWO CARS, TWO RECALLS AND THE SAME PROBLEM WITH THE DEALERSHIP. THIS COMPLAINT IS IN REGARDS TO FRED ANDERSON TOYOTA RALEIGH'S SERVICE DEPARTMENT. I HAVE BOUGHT 4 CARS WITH THIS DEALERSHIP, THREE OF THEM HAVE HAD MANUFACTURES DEFECTS. EVERY TIME I CALL, INCLUDING THIS LAST TIME FOR MY RECALL THEY TELL ME THAT NOT ONLY DO THEY NOT HAVE THE PARTS AVAILABLE TO FIX THE RECALL, IT WILL TAKE THEM "AT LEAST" 30 DAYS TO GET THE PARTS AVAILABLE FOR THE RECALL. THE SERVICE DEPARTMENT IS HORRIBLY RUN AND THE FACT THAT THEY DON'T HAVE REMEDIES FOR SERIOUS SAFETY RECALLS READILY AVAILABLE OR AT LEAST ON QUICK DELIVERY IS UNACCEPTABLE. ALSO, THEY TOLD ME THAT IT WOULD TAKE AT LEAST HOURS TO FIX THE PART WHEN IT FINALLY COMES IN BUT ONLY OFFER A RENTAL CAR IF THE FIX IS MORE THAN $400, WHICH OF COURSE, SINCE THIS IS FREE OF CHARGE THE CONSUMER HAS TO FIGURE OUT TRANSPORTATION TO MAKE UP FOR THE FACT THAT THEY DON'T KNOW HOW TO MAKE SAFE CARS. IT IS MY OPINION THAT FRED ANDERSON TOYOTA RALEIGH'S SERVICE DEPARTMENT WOULD RATHER PUT ITS CUSTOMERS AT RISK THAN FIX THEIR RECALL SO THEY MAKE IT AS HARD AS POSSIBLE TO GET THE FIX TAKEN CARE OF. I HAVE TRIED TO CONTACT MANAGER AND OWNER OF THE DEALERSHIP AND THEY BOTH IGNORE MY CALLS. ONE WOULD THINK THAT AFTER BUYING 4 CARS WITH THEIR COMPANY THEY WOULD HAVE SOME LEVEL OF CARE FOR MY FAMILY'S SAFETY. THEY DON'T! *TR

MY 2008 TOYOTA SIENNA HAS POWER REAR SLIDING DOORS. WHILE THE DRIVER SIDE REAR DOOR WAS OPENING, THE CABLE FOR THE DOOR MECHANISM SNAPPED AND WOULD NOT CLOSE COMPLETELY. AFTER INVESTIGATING THE SITUATION, THE BROKEN CABLE WAS JAMMED IN THE DOOR MECHANISM, PREVENTING THE DOOR FROM CLOSING. AS A RESULT, THE DOOR NOW DOES NOT FULLY OPEN, AND WILL NOT HOLD IN THE OPEN POSITION. IF PARKED ON A HILL, THE DOOR WILL CLOSE IF NOT HELD OPEN. LOOKING AT THE CABLE, THE PLASTIC SHEATHING AROUND THE CABLE HAD MANY CRACKS CAUSING THE CABLE ITSELF TO RUST AND FAIL. THE PASSENGER SIDE DOOR CABLE HAS SIMILAR CRACKS BUT HAS NOT FAILED YET. I BROUGHT THE VEHICLE TO OUR LOCAL TOYOTA DEALER. THEY MENTIONED THIS CABLE FAILURE WAS A KNOWN PROBLEM AND PREVIOUS MODEL YEARS WERE COVERED UNDER AN EXTENDED WARRANTY PROGRAM. HOWEVER, THE 2008 MODEL YEAR WAS NOT COVERED. *TR

MY DASHBOARD IS MELTING AND CRACKING. IT IS STICKY AND IMPOSSIBLE TO CLEAN. OVER THE LAST FEW MONTHS, IT'S ALSO CRACKING ON THE FRONT EDGES, BOTH ON THE DRIVER'S AND PASSENGER'S SIDE. *TR

T-SB-0047-10 FROM SAFERCAR.GOV "SOME VEHICLES EQUIPPED WITH 2GR-FE/FXE ENGINE. THE RUBBER PORTION OF THE OIL SUPPLY HOSE FOR VVT-I ACTUATOR MAY DEGRADE OVER TIME. THIS CONDITION MAY CAUSE OIL TO LEAK FROM THE VVT-I OIL HOSE PRODUCING ABNORMAL ENGINE NOISE AND THE OIL PRESSURE LIGHT TO ILLUMINATE " THIS TSB AFFECTS TOYOTA VEHICLES GOING BACK TO AT LEAST 2008-PRESENT. THIS IS A MAJOR ISSUE, AND I FEEL THIS SHOULD BE HANDLED AS A RECALL INSTEAD OF A TSB DUE TO THE SEVERITY OF THE ISSUE IF/WHEN THE PIPE BREAKS. I RECENTLY ELECTED TO HAVE MY VEHICLE REPAIRED ON MY OWN JUST SO I WOULDN'T HAVE TO WORRY ABOUT THIS ISSUE HAPPENING TO ME OR MY WIFE, AND THUS BLOWING UP MY SIENNA'S ENGINE CAUSING THOUSANDS OF DOLLARS IN DAMAGES. SEEMS PRETTY BAD THAT A RECALL CAN BE ISSUED FOR FLOOR MATS AND ACCELERATOR ISSUES, BUT NO RECALL IS ISSUED FOR THIS ISSUE WHICH CAN DRAIN THE OIL FROM YOUR ENGINE IN A MINUTE, BLOW UP YOUR ENGINE, AND THEN POSSIBLY WRECK YOUR VEHICLE. CONSUMER'S ENGINES ARE NOW BEING DESTROYED, AND THIS IS SHOWING UP IN DIFFERENT ONLINE FORUMS. I FEEL THAT THE NHTSA NEEDS TO FORCE TOYOTA TO REPLACE ALL OF THE DEFECTIVE ENGINE OIL COOLER PIPES WITH THE NEWER METAL ONES THAT THE TSB ADDRESSES. THEY SHOULD ALSO BE FORCED TO REIMBURSE ALL COSTS TO THOSE INDIVIDUALS THAT EITHER NEEDED TO HAVE THE REPAIR DONE, OR DECIDED TO PREVENTATIVELY HAVE THE REPAIR DONE ON THEIR OWN BEFORE THOSE PIPES BURST ON THEIR OWN. TOYOTA HAS TOLD ME THAT MY VEHICLE WAS NOT AFFECTED BY THEIR LIMITED SERVICE CAMPAIGN CSC-10033553-6074 BUT MY CAR HAS SEEPAGE FROM THE RUBBER PORTION OF THE HOSE THAT WAS DIAGNOSED BY GRAPEVINE TOYOTA DEALERSHIP YESTERDAY. VERY SAD SITUATION THAT SUCH A DANGEROUS CONDITION EXISTS IN SO MANY TOYOTA VEHICLES WITH THE V-6 (2GR-FE) ENGINE. PLEASE HELP!!! *TR

AIR BAG LIGHT STARTED BLINKING WHEN CAR STARTED AND STAYED BLINKING. BROUGHT IN TO DEALER AND COMMENTS WERE "OPEN IN SIDE. SQUIB RH CIRCUIT" AND "NEEDS PASS. SIDE FRONT SEAT AIRBAG" FOR $865. SAME ISSUE SEEMS TRUE FOR 2007 SIENNAS ONLINE. LIGHT STOPPED BLINKING AND HAS NOT RECURRED. *TR

MY TOYOTA 2008 SIENNA LE PASSENGER AUTOMATIC SLIDING DOOR WON'T CLOSED AND OPENED COMPLETELY. I'VE EXPERIENCED AN INTERMITTENT JAMMED WITH THIS DOOR FOR THE PAST 3 DAYS. AS A TEMPORARY FIX, I NEED TO GET OUT FROM THE CAR TO HELP THE DOOR IN CLOSING AND OPENING IT BECAUSE THE BUTTON INSIDE THE CAR AND EVEN THE REMOTE(HAS NEW BATTERY INSTALLED) WON'T DO THE WORK . ONE DAY, WHEN DRIVING MY KIDS TO SCHOOL. AS I MADE A LEFT TURN, I HEARD AN AUDIBLE NOISE/ALARM AND WE WERE SURPRISED AND TRIED TO FIGURE OUT WHERE THE SOUND CAME FROM UNTIL MY KIDS TOLD ME THAT THE DOOR IS PARTIALLY OPEN WHILE DRIVING. I PULLED OVER AND TEMPORARY CLOSE THE DOOR. I MANAGED TO GO BACK HOME AND STILL WITH THE ALARM ON AND THEN RE-PUSHED HARDER TO MAKE THE DOOR COMPLETELY CLOSED. THAT WAS SCARY BECAUSE MY KIDS WERE SITTING IN 2ND ROW. TO ADDRESS THIS PROBLEM. ON SAME DAY, I RUSHED MY CAR TO TOYOTA DEALERSHIP AND THE REPRESENTATIVE TOLD ME THAT CABLE ASSEMBLY IS BROKEN AND NEED TO REPLACE ALL PARTS BUT MUST PAY $1700 + TAX BECAUSE THE ISSUE WAS THE POWER SLIDING DOOR CABLE ASSEMBLY ALTHOUGH MY CAR HAS VERY LOW MILEAGE 30, 312 MILES (SITTING MOST OF THE TIME INSIDE THE GARAGE) AND STILL NOT COVERED BY TOYOTA WARRANTY ENHANCE PROGRAM FOR REAR SLIDING DOOR CABLE. THIS IS VERY FRUSTRATING AND ADDING INSULT TO INJURY, I WAS TOLD THAT I'M NOT THE ONLY ONE HAD THIS PROBLEM. *TR

POWER DOOR OPENED PART WAYS AND WOULD NOT SHUT. HAD TO DRIVE TO MECHANIC WITH DOOR PARTIALLY OPEN AND HE HAD TO FORCE IT SHUT. TOYOTA MECHANIC SAID IT WAS A KNOW CABLE PROBLEM WITH THE DOOR MOTOR, BUT TOYOTA HAS NOT ISSUED A RECALL YET. *TR

TL* THE CONTACT OWNS A 2008 TOYOTA SIENNA. THE CONTACT WAS ATTEMPTING TO OPEN THE REAR DRIVER'S SIDE DOOR THE BUT THE DOOR ONLY OPENED SIX INCHES WIDE WHILE USING THE FOB, THEN SHUT INDEPENDENTLY AND WITHOUT WARNING. THE CONTACT STATED THAT SHE HAD TO MANUALLY PRY THE DOOR OPEN. THE VEHICLE WAS TAKEN TO A DEALER FOR INSPECTION WHERE THE CONTACT WAS INFORMED THAT THE DOOR CABLE HAD SNAPPED AND WRAPPED AROUND THE MOTOR. THE MOTOR AND THE CABLES WOULD NEED TO BE REPLACED, THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE INCIDENT. THE APPROXIMATE FAILURE MILEAGE WAS 80,000.

TL* THE CONTACT OWNS A 2008 TOYOTA SIENNA. THE CONTACTED STATED THAT THE FRONT PASSENGER'S SIDE SEAT BELT BECAME INOPERABLE AND WOULD NOT RETRACT. THE VEHICLE WAS NOT TAKEN TO A DEALER FOR DIAGNOSIS OR REPAIRS. THE MANUFACTURER HAD NOT BEEN MADE AWARE OF THE PROBLEM.THE APPROXIMATE FAILURE MILEAGE WAS 96,000.

I PURCHASED THIS VEHICLE USED FROM HOSELTON AUTO MALL IN ROCHESTER NY IN AUGUST 2013.I WAS TALKED INTO A "TOYOTA PLATINUM CARE" BUMPER TO BUMPER EXTENDED WARRANTY.I WAS TOLD THIS WARRANTY WAS EXACTLY THE SAME AS THE NEW VEHICLE WARRANTY BUT FOR AN EXTENDED TIME.I WAS TOLD IT COVERED EVERYTHING.I SPECIFICALLY ASKED IF IT COVERED ALL PARTS ON THE SLIDING DOORS, THE DVD PLAYER, ETC.I WAS TOLD YES. IN JANUARY 2014 I EXPERIENCED A PROBLEM WITH ONE OF THE SLIDING DOORS.MY LOCAL DEALERSHIP SAID THE CENTER HINGE WAS BAD AND WAS NOT COVERED UNDER MY WARRANTY.I INSISTED THAT HOSELTON PAY FOR THE REPAIR,THEY RELUCTANTLY DID SO.I HAVE SINCE HAD BOTH SIDING DOORS REPAIRED MULTIPLE TIMES DUE TO THE LOCK ASSEMBLY NOT WORKING.THE LOCK ASSEMBLY IS COVERED UNDER A NEW SPECIAL CONDITION WARRANTY BECAUSE TOYOTA HAS RECEIVED SO MANY COMPLAINTS.NOW THE OTHER DOORS CENTER HINGE IS BAD.I WAS TOLD IF I DON'T REPLACE THE HINGE THAT THE LOCK ASSEMBLY WILL KEEP GOING BAD.SO THESE ARE OBVIOUSLY RELATED ISSUES.THIS COMBINED ISSUE CAUSES MY DOORS TO EITHER BE STUCK OPEN, BE STUCK CLOSED, OR TO OPEN WHILE I AM DRIVING.ALL SAFETY ISSUES AS I HAVE CHILDREN IN THE BACK SEAT.I HAVE CONTACTED TOYOTA AND THE WARRANTY PEOPLE AND NEITHER WANT TO ASSIST.I WANT THE HINGE REPLACED AT TOYOTAS COST.THIS IS DANGEROUS AND IT IS A KNOWN ISSUE BY THEM.THEY NEED TO RESOLVE THIS ASAP.MY VEHICLE IS UNSAFE TO DRIVE. I HAVE CONTACTED THEM VIA TELEPHONE AND THEIR EMAIL SYSTEM, ALL WITH NO LUCK WITH ASSISTANCE. *TR

WHILE DRIVING MY VEHICLE IT BEGAN TO MAKE A STRANGE KNOCKING SOUND AS I ACCELERATED. I HAD BEEN DRIVING AROUND TOWN FOR SEVERAL HOURS THAT MORNING. I PULLED OVER TO INSPECT THE ENGINE, AND SAW SOME TYPE OF FLUID ON THE LEFT SIDE OF THE ENGINE AND WALL. I PULLED THE OIL DIPSTICK OUT AND THERE WAS NO OIL ON IT AT ALL. COMPLETELY DRY! I HAD SOMEONE BRING ME SOME OIL AND I DROVE MY CAR UP TO THE REPAIR SHOP JUST A SHORT DISTANCE AWAY. THEY DISCOVERED THAT THE OIL PRESSURE LINE -VALVE COVER VARIABLE TIMING-ON TOP OF MOTOR TO RIGHT ON PASSENGER SIDE HAD BURST. PART OF THE LINE IS RUBBER AND THAT PART HAD RUPTURED AND ALL THE OIL HAD BLOWN OUT OF THE ENGINE. MY OIL LIGHT DID NOT COME ON AT ANY TIME NOR DID MY CHECK ENGINE LIGHT. EVEN AFTER I STOPPED IT DID NOT COME ON. *TR

THE DRIVER SEAT SEATBELT KEEPS JAMMING, TO THE EXTENT THAT IT WON'T UNJAM. *TR

THE RUBBER IN THE OIL COOLING LINE BROKE DOWN AND DRAINED MOST OF THE OIL FROM THE ENGINE. FROM LOOKING AT THE DIFFERENT BOARDS THIS SEEMS TO BE A COMMON PROBLEM WITH THIS HOSE. TOYOTA EVEN RE-DESIGNED THE HOSE WITH A METAL SLEEVE BECAUSE OF THIS. *TR

I RECENTLY PURCHASED A 2008 TOYOTA SIENNA THAT I BELIEVE HAS A SAFETY ISSUE, PARTICULARLY IN COLD WEATHER. THE EXTERIOR SWITCH THAT ALLOWS THE REAR HATCH TO OPEN IS NOT FUNCTIONAL IN COLD WEATHER DUE TO A MATERIAL MALFUNCTION. I NOTICED THAT DURING WARMER WEATHER, THE RUBBER SEAL OVER THIS EXTERIOR SWITCH HAD BECOME SOFT AND GUMMY. OVER TIME, THE RUBBER SEEPED BETWEEN THE SWITCH HOUSING AND THE SWITCH BUTTON. AS THE WEATHER BECAME COLD, THE RUBBER HAS HARDENED AROUND THE SWITCH BUTTON AND THE EXTERIOR SWITCH IS NO LONGER FUNCTIONAL. THE ONLY WAY I CAN OPEN THE REAR HATCH IN COLD WEATHER IS TO OPEN A FRONT DOOR AND USE THE INTERIOR SWITCH TO OPEN THE REAR HATCH. MY CONCERN IS IF WE WERE TO GET INTO AN ACCIDENT DURING THE COLD MONTHS AND THE ONLY WAY SOMEONE COULD GET ACCESS TO THE INTERIOR OF THE VEHICLE IS THROUGH THE REAR HATCH, IT COULD NOT BE DONE BECAUSE THE EXTERIOR SWITCH ON THE REAR HATCH WOULD BE SEIZED PREVENTING ACCESS. IT IS VERY ALARMING WHEN I THINK OF MY ENTIRE FAMILY, ESPECIALLY MY 15 YO, MY 3 YR, AND MY 6 MO, BEING INSIDE OF THIS VAN AND PEOPLE NOT GAINING ACCESS TO THE INSIDE TO HELP THEM DUE TO INJURIES, FIRE, WATER HAZARDS, ETC... I OWN A 2005 TOYOTA 4RUNNER AND IT APPEARS TO HAVE THE SAME SWITCH. HOWEVER, THE RUBBER ON THE SWITCH IS PERFECTLY FINE AND FUNCTIONS NORMALLY. THERE APPEARS TO HAVE BEEN A MATERIAL CHANGE ALLOWING THE RUBBER TO SOFTEN RESULTING IN A POTENTIAL SAFETY HAZARD DURING THE COLD MONTHS. I SPOKE TO OUR LOCAL TOYOTA DEALERSHIP AND THEY ARE FULLY AWARE OF THIS ISSUE AND SAID THAT TOYOTA DOES NOT CONSIDER THIS TO BE A SAFETY ISSUE. INITIALLY I THOUGHT THE PREVIOUS OWNER APPLIED A SOLVENT OR SOMETHING TO SOFTEN THE RUBBER. AS I RESEARCHED MORE ON THE INTERNET, THIS ISSUE APPLIES TO MANY TOYOTA VEHICLES, WITH MODELS INCLUDING THE SIENNA AND THE 4RUNNER. THE EARLIEST MODEL YEAR THAT I CAN FIND FOR EITHER MODEL IS 2007. *TR

TL* THE CONTACT OWNS A 2008 TOYOTA SIENNA. THE CONTACT STATED THAT UPON INSPECTION, THE TRUNK DOOR UNEXPECTEDLY CLOSED WITHOUT ANY WARNINGS. THE CONTACT ALSO MENTIONED THAT THE TRUNK DOOR LANDED ON HER BACK AND CAUSED A BRUISE, WHICH WAS A RECURRING INJURY. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED. THE FAILURE MILEAGE WAS 85,000.

TL* THE CONTACT OWNS A 2008 TOYOTA SIENNA. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 1 MPH, THE VEHICLE SUDDENLY ACCELERATED AND CAUSED THE CONTACT TO CRASH INTO A TREE WITHOUT WARNING. THE CONTACT STATED THAT THE BRAKES WERE DEPRESSED BUT FAILED TO STOP THE VEHICLE. ALSO, THE CONTACT MENTIONED THAT THE FAILURE RECURRED ON TWO OTHER OCCASIONS. THE CONTACT WAS NOT TAKEN TO A HOSPITAL AND THERE WERE NO INJURIES REPORTED. A POLICE REPORT WAS NOT FILED. THE VEHICLE WAS TOWED TO A PRIVATE MECHANIC BUT THERE WAS NO DIAGNOSTIC PERFORMED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE AND CURRENT MILEAGE WAS 146,000. THE VIN WAS NOT AVAILABLE.

WHEN OPERATING THE REAR LIFT GATE (TRUNK) ON THIS 2008 TOYOTA SIENNA MINIVAN, WE HAVE NOTICED THE LIFT GATE DOES NOT OPEN ALL THE WAY UP, CAUSING AN AVERAGE HEIGHT ADULTS TO BUMP THEIR HEADS ON THE LIFT GATE. BUT WORSE, THIS HAPPENS ON SEVERAL OCCASIONS, THE LIFT GATE COMES FALLING DOWN, HITTING AN ADULT ON THE HEAD, CAUSING A HEAD INJURY. WORSE YET, IF A CHILD HAPPENS TO BE STANDING UNDER THE LIFT GATE, THE HEAVY TRUNK CAN CAUSE A MAJOR INJURY OR DEATH! THIS IS HAPPENING ON A NUMBER OF OCCASIONS, AND SHOULD BE COVERED BY TOYOTA AS THIS IS NOT ACCEPTABLE FOR A FAMILY MINIVAN WITH LESS THAN 5 YEARS OLD. I WOULD LIKE TO SEE A SAFETY RECALL ISSUED ON THIS TYPE OF MALFUNCTION AND HAVE THIS REPAIRED OR REPLACED FREE OF CHARGE BY TOYOTA DEALERS. *TR

APPROXIMATELY SIX (6) MONTHS AGO, I STARTED TO NOTICE MY DASHBOARD GETTING STICKY WHEN THE SUN BEATS DOWN ON IT. IT STARTED IN A SMALL AREA OF THE DASHBOARD ABOUT THE SIZE OF A QUARTER, BUT NOW APPEARS TO SPREADING. I HAVE CONTACTED THE TOYOTA DEALERSHIP THAT I PURCHASED THE VEHICLE FROM AND THEY CLAIM THAT THEY HAVE NEVER HEARD OF SUCH A CONDITION. AFTER DOING SOME RESEARCH ON THE WEB, I FOUND THE FOLLOWING NEWS SEGMENT THAT POINTEDLY IDENTIFIES THE EXACT PROBLEM THAT I AM HAVING: HTTP://WWW.WPTV.COM/MONEY/CONSUMER/TOYOTA-DEALER-CALLS-MELTING-DASHBOARDS-A-DEFECTIVE-PRODUCT-AND-WANTS-AUTO-MAKERS-TO-PAY-FOR-REPAIRS I AM NOT CERTAIN WHAT CAN BE DONE, HOWEVER IN MY OPINION THERE SHOULD BE A FACTORY REGARDING ON THIS EXTREMELY HAZARDOUS CONDITION. PLEASE LOOK INTO THIS MATTER AND ADVISE. THANK YOU FOR YOUR CONSIDERATION AND PROMPT ATTENTION TO THIS IMPORTANT MATTER. [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

I WAS DROPPING MY KIDS OF TO SCHOOL IN THE MORNING. I STOP BY AT MY FRIEND'S APT TO PICK HER UP WITH HER BABY. THIS IS MY DAILY ROUTINE. SO ON THE DAY OF THE INCIDENT, I DID THE SAME THING, PARKED MY VAN, GOT OUT, AND WENT TO THE APARTMENT' S EXIT DOOR FROM WHERE MY FRIEND WAS COMING. MY CHILDREN WERE SEATED IN THE CAR AND I WAS PICKING UP THE BABY FROM MY FRIEND WHEN BOTH OF US HEARD MY ELDEST SON AGED 10, SCREAMING THAT "THE CAR IS MOVING MAMA", AND IN PANIC HE OPENED HIS DOOR AND TRIED TO GET OFF HIS SEAT BELT AND WAS TRYING TO JUMP. I SAW THE VAN ROLLING BACK , I PUT THE BABY ON THE GRASS AND RUSHED TO HELP MY KIDS IN THE MOVING VAN THAT WAS ROLLING BACKWARDS DOWNHILL. FIRST I PUSHED MY SON IN AS HIS LEG WAS CAUGHT IN THE SEAT BELT AND HE COULDN'T JUMP FORWARDS AND THEN I MOVED AROUND THE BACK OF THE VAN, HIT MY KNEE ON THE BUMPER AND MY FRIEND CAME FROM THE FRONT , SHE OPENED THE DOOR AND I WAS ABLE TO PUT THE HANDBRAKES ON. BUT IN DOING SO AFTER BUMPING HARD ON MY RIGHT KNEE FROM THE MOVING CAR, AND WHEN I APPLIED THE BRAKES, I SAT ON THE GROUND AND HIT MY KNEE AGAIN. THE CAR STOPPED AND I TRIED TO CALM MYSELF BECAUSE THERE WERE 4 KIDS INSIDE WHEN THE VAN WAS ROLLING AWAY AND 3 OF THEM WERE SMALL, SO THEY WERE CRYING. MY FRIEND CALMED ME AND WE SET OFF. MY KNEE WAS HEAVILY BRUISED AND ACHING. I CAME HOME AND TOOK PAINKILLERS AND COULDN'T GET ANY XRAYS DONE BECAUSE I DIDN'T HAVE ANY MEDICAL INSURANCE. TO THIS DAY ONCE OR TWICE A WEEK, I USE PAINKILLERS FOR MY KNEE WHICH WAS PERFECT BEFORE. MY KIDS WERE SAFE AND NOTHING MAJOR HAPPENED WHICH COULD HAVE, BUT WE ALL WENT THROUGH A VERY PANICKY AND TERRIBLE EXPERIENCE WHICH I HOPE NEVER HAPPENS AGAIN. IF THE VAN WOULDN'T HAVE STOPPED IN TIME, MY CHILDREN COULD HAVE BEEN BADLY INJURED. *TR

TL- THE CONTACT OWNS A 2008 TOYOTA SIENNA. THE CONTACT STATED THERE WAS A RECALL ASSOCIATED WITH NHTSA CAMPAIGN ID NUMBER 13V429000 (POWER TRAIN); HOWEVER, THE CONTACT WAS UNABLE TO HAVE THE VEHICLE SERVICED BECAUSE THE REMEDY PART WAS NOT AVAILABLE TO PERFORM THE REPAIR. THE MANUFACTURER WAS NOT NOTIFIED OF THE PROBLEM. THE CONTACT HAD NOT EXPERIENCED A FAILURE. RK

TL* THE CONTACT OWNS A 2008 TOYOTA SIENNA. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 55 MPH, THE SPARE TIRE BECAME DETACHED FROM THE VEHICLE CAUSING THE CONTACT TO DRIVE OVER THE TIRE AND EXPERIENCE A FAILURE WITH THE BRAKES. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC FOR DIAGNOSIS. THE MECHANIC STATED THAT THE SPARE TIRE CABLE WAS CORRODED AND CONSEQUENTLY CAUSED DAMAGE TO THE BRAKING SYSTEM. THE CONTACT REFERENCED NHTSA CAMPAIGN NUMBER: 10V160000 (STRUCTURE) BUT WAS ADVISED BY THE MANUFACTURER THAT THE RECALL HAD EXPIRED AND THEY WOULD NOT HONOR THE REPAIR. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 82,000.

THE VEHICLE HAS DEVELOPED A CRACKED (PIECES BROKEN OFF) DASHBOARD. IT GETS VERY HOT AND FEELS LIKE IT IS MELTING. TOYOTA RECOGNIZED THE PROBLEM ALMOST TWO YEARS AGO WHEN THEY STARTED SENDING RECALL NOTICES BUT TO DATE THEY HAVEN'T COME UP WITH A SOLUTION TO FIX IT. I HAVE ALREADY RECEIVED ABOUT FIVE RECALL NOTICES BUT EACH TIME THE DEALER TELLS ME THEY WILL HAVE A FIX IN THE WINTER OR FALL ETC.. JUST CONCERNED THAT IT IS TAKING ALMOST TWO YEARS AND TOYOTA KEEP SENDING THE NOTICES. I ALSO HAVE A 2009 CAMRY AND THE DASHBOARD IS VERY STICKY TOO (NOT BREAKING YET). NOT SURE WHAT THERE STRATEGY IS BUT THEY NEED TO HANDLE THE LIABILITY IF THEY WANT TO KEEP REPEAT CUSTOMERS AND AVOID BIGGER ISSUES WITH VEHICLE SAFETY.

THE RUBBER PORTION OF THE OIL SUPPLY HOSE FOR THE WT-1 ACTUATOR FAILED RESULTING IN A SUDDEN LOSS OF SEVERAL QUARTS OF OIL. THIS OIL WAS CARRIED ALONG THE UNDERCARRIAGE AND SPRAYED A FINE MIST OF OIL ON THE WINDSHIELDS OF THE CARS BEHIND THE VAN. LUCKILY THIS OCCURRED CLOSE TO HOME AT A LOW SPEED. IF THIS WAS ON THE HIGHWAY IT COULD HAVE CAUSED SUDDEN REDUCED VISIBILITY FOR THE DRIVERS BEHIND THE VEHICLE AND COULD HAVE LED TO AN ACCIDENT. I AM SORRY BUT USING A RUBBER HOSE ON AN OIL LINE IS ONE OF THE DUMBEST THINGS I HAVE HEARD OF. FORTUNATELY FOR US, NO ONE WAS HURT AND NO DAMAGE WAS DONE TO THE VEHICLE. I DON'T UNDERSTAND HOW THIS HAS NOT TURNED INTO A RECALL. THIS WAS A BIG MISTAKE ON TOYOTA'S PART. *TR

MY SISTER AND I HAD JUST RETURNED HOME FROM THE STORE AND I PRESSED THE BUTTON TO LIFT THE BACK DOOR TO GET OUR THINGS OUT. WE WERE IN THE MIDDLE OF GETTING OUR THINGS OUT WHEN THE DOOR STARTED CLOSING ON US. I GOT OUT AND MY SISTER GOT CAUGHT AND IT CAME DOWN ON HER BACK AND SCRATCHED HER UP PRETTY GOOD. EVER SINCE THEN JUST OUT OF THE BLUE IT WILL NOT STAY UP AND IT WILL CLOSE DOWN ON YOU. I THINK THIS IS A MAJOR SAFETY ISSUE ESPECIALLY SINCE I HAVE TWO LITTLE CHILDREN. IT COULD REALLY DO SOME HARM TO THEM. THE SLIDING DOORS STOP CLOSING IF SOMEONE IS IN THE WAY AND IT SHOULD BE THE SAME FOR THE BACK DOOR. I BOUGHT THIS VEHICLE BECAUSE IT IS SUPPOSED TO BE ONE OF THE TOP OF THE LINE FANS FOR SAFETY. SO FAR I AM NOT IMPRESSED. SOMEONE NEEDS TO RESOLVE THIS ISSUE! I AM SCARED TO EVEN OPEN UP THAT BACK DOOR BECAUSE OF THIS.....AND THAT IS NOT GOOD. *TR

VAN SPONTANEOUSLY BEGAN LEAKING OIL. I BROUGHT IT INTO THE DEALER AND WAS TOLD THAT IT WAS THE VVT1 ACTUATOR HOSE. APPARENTLY THIS WAS PART OF A VOLUNTARY RECALL THAT TOYOTA STARTED IN 2010 AND I WAS NEVER NOTIFIED! I CALLED TOYOTA MOTOR CORPORATION AND WAS TOLD THAT THIS WAS IN FACT A DEFECTIVE HOSE BUT BECAUSE IT WAS NOT REPAIRED PRIOR TO THE 3/31/13 DEADLINE THAT TOYOTA WOULD NOT PAY FOR THIS DEFECTIVE HOSE TO BE REPLACED. I AM CERTAIN THAT I WAS NEVER NOTIFIED OF THIS VOLUNTARY AND WORRY THAT MANY OTHER 2008 SIENNA OWNERS ARE UNAWARE OF THIS DEFECTIVE PART AND HENCE WILL NOT HAVE THIS REPAIRED. THIS HOSE IS UNDER PRESSURE AND IF IT GOES COMPLETELY CAR WILL SPEW OIL EVERYWHERE AND SEIZE UP! THIS IS A POTENTIAL FIRE AND SAFELY HAZARD!!! TOYOTA IS VERY AWARE OF THIS PROBLEM! IN THE END MY DEALER AGREED TO COVER THE COST OF REPLACEMENT, BUT I AM FOREVER DISMAYED AT TOYOTA'S LACK OF CONCERN FOR THEIR CUSTOMERS! THIS WAS PART OF CAMPAIGN RECALL 90K-2GR-FE V6 ENGINE OIL HOSE. *TR

I HAD A OIL HOSE IN MY VAN GET A HOLE. WHEN IT HAPPENED IT SPILLED OIL ALL OVER AND IN MY OPINION COULD HAVE STARTED A FIRE.THE HOSE IS CONNECTED TO A PIPE AND THE HOSE CANNOT BE REPLACED. THE WHOLE PIPE HAS TO BE REPLACED AND I REPLACED MINE. MY RESEARCH REVEALED THIS IS A FAIRLY COMMON PROBLEM AND THAT THERE IS A TOYOTA SERVICE BULLETIN FOR THIS PROBLEM BUT IN THE BULLETIN THEY CLAIM IT'S FOR SEEPAGE OF OIL. OBVIOUSLY TOYOTA KNOWS THIS IS A PROBLEM AS THE NEW PART I ORDERED IS COMPLETE PIPE WITH NO HOSES. THE PART NUMBER FOR THE PIPE IS 15767. IS THIS SOMETHING THAT CAN BE FURTHER LOOKED INTO AS TO WHY THIS IS NOT A RECALL THAT TOYOTA SHOULD PROPERLY FIX? *TR

TPMS BROKE WHILE INFLATING TIRES FOR A CUSTOMER. *TR

AFTER DRIVING VEHICLE FOR APPX. 15 MINUTES THEN PARKING, THEN COMING BACK TO VEHICLE 5 MINUTES LATER I FOUND A POOL OF OIL UNDER THE HOOD OF VAN AND CALLED FOR TOW TO THE DEALERSHIP. ROB FROM THE TOYOTA REPAIR SERVICE, CLAIMS I HAD BAD LUCK REGARDING THE OIL COOLER LINE RUPTURING. IT WILL COST ME $442.00 TO REPAIR/REPLACE AND CLEAN THE VEHICLE. AFTER HEARING THIS I CHECKED ONLINE AND OTHER VEHICLE OWNERS ARE HAVING SIMILAR PROBLEMS WITH SIMILAR VEHICLES THAT HAVE A V6 ENGINE WITH TOWING PACKAGE FROM TOYOTA. THE SERVICE PERSON CLAIMS ITS NOT COVERED UNDER MY WARRANTY. HE ALSO CLAIMS THAT IT WASN'T DAMAGED ACCIDENTALLY NEITHER.

I WAS DRIVING DOWN THE ROAD AND SAW SMOKE ROLLING OUT OF ENGINE. BY THE TIME I PULLED OVER I NOTICED OIL LEAKING OUT EVERYWHERE. IT WAS THE ENGINE OIL COOLER LINE AND I HAVE SINCE REPLACED THE RUBBER HOSE TWICE AND HAS RUPTURED TWO MORE TIME SINCE. THIS IS VERY DANGEROUS. I LOST OVER 12 QUARTS OF OIL IN THE LAST MONTH.