2018 Volkswagen Tiguan Body & Structure Problems

1)My sunroof/window is leaking. This has caused internal damage. My car had 2-2.5 inches of water that has damaged by carpeting and pads the 60E5 was performed. ~72,500 miles 2018 Tiguan. 2) dealer service has advised of service:REPLACE SET OF (4) FUEL INJECTOR O-RINGS DUE TO FUEL LEAK AT FUEL RAIL-INCLUDE INTAKE MANIFOLD GAKET AND THROTTLE BODY GASKET.

There is an excessive amount of water leaking into the passenger compartment and also the cargo area The result is that considerable mold growing on the carpeting of the entire car The dealer has ordered repair parts but the parts are on back order leaving me to drive the vehicle while it has mold I have been advised if I remove the molded carpeting I will invalidate the warranty Very dangerous as occupying this vehicle results in inhaling mold

Driving down the Highway with my kids in the car and the sunroof shattered. No was around driving near me, nothing was hit, no other damage on my vehicle. the sunroof just exploded with my 4 children in the car. Now Im 1,000 miles away from home.

TL* THE CONTACT OWNS A 2018 VOLKSWAGEN TIGUAN. THE CONTACT STATED THAT WHILE DRIVING AT APPROXIMATELY 65 MPH IN INCLEMENT WEATHER, THE FRONTAL COLLISION WARNING LIGHT ILLUMINATED. THE VEHICLE WAS TAKEN TO (VOLKSWAGEN OF DOWNTOWN CHICAGO, LOCATED AT 1111 N. CLARK ST, CHICAGO, IL 60610), TO BE DIAGNOSED. THE MECHANIC WAS UNABLE TO DUPLICATE THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS CONTACTED AND INFORMED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 30,000.

BOUGHT THE VEHICLE NEW IN EARLY APRIL 2019, AFTER A COUPLE HUNDRED MILES I NOTICED A SCREECHING/RATTLING NOISE COMING FROM BOTH THE DRIVER'S AND PASSENGER'S SIDE B PILLARS. I TOOK IT BACK THE DEALER FOR A RESOLUTION TO THE ISSUE. THEY HEARD THE NOISE AND SAID THERE IS FIX FOR THE PROBLEM THAT INVOLVES GUTTING THE ENTIRE INTERIOR AND WELDING BAD OR MISSING WELDS ON THE STRUCTURE UP NEAR THE ROOF. I HAVE TWO PROBLEMS WITH THEIR SOLUTION. FIRST, THIS IS A SAFETY ISSUE. WHO KNOWS IF THE ROOF WOULD HOLD UP DURING A ROLLOVER ACCIDENT CONSIDERING THE DEALERSHIP MECHANICS ARE NOT QUALIFIED WELDERS FOR SUCH A CRITICAL APPLICATION. SECOND, THE NOISE IS VERY DISTRACTING WHILE DRIVING. SO I HAVE DECIDE WHETHER OR NOT TO LET THEM TEAR THE ENTIRE INTERIOR OUT OF MY VEHICLE AND LET THEM MAKE SHODDY REPAIR ON MY BRAND NEW VEHICLE OR TAKE A CHANCE ON MY AND MY PASSENGER'S SAFETY. SHAME ON VOLKSWAGEN. THESE VEHICLES SHOULD BE BOUGHT OR REPLACED WITH A 2019 WHICH DOESN'T SEEM TO HAVE THE PROBLEM.

ON OCTOBER 11, 2018 I WAS DRIVING STRAIGHT DOWN A SIDE STREET TRAVELING 30 MILES AN HOUR I HEARD A LOUD BANG. I TURNED AROUND AND SAW MY SIDE MIRROR BROKEN AND SMASHED INTO THE SIDE OF MY CAR WINDOW. TO MY SURPRISE THERE WAS NO OTHER DAMAGE TO THE CAR. IT WAS ISOLATED TO THE SIDE MIRROR. I BROUGHT THE CAR TO THE DEALER. I EXPLAINED WHAT HAD HAPPENED AND THEY LOOKED AT THE SIDE MIRROR. THEY CAME BACK TO TELL ME THAT SOMETHING HIT MY CAR LIKE A ROCK OR STICK. I WAS SURPRISED AND SAID REALLY THE ROCK OR STICK ONLY HIT THE SIDE MIRROR AND PUSHED THE MIRROR INTO THE WINDOW? I SAID I BELIEVE THAT THE DEFROST, LANE CHANGE OR POWER MIRROR WIRING CAUSED THE EXPLOSION. IT WAS DETERMINED THAT IT WAS NOT COVERED BY THE WARRANTY AND ESTIMATED TO COST TO $1100. I HAD DEALER ORDER A NEW MIRROR. I SCHEDULED THE SERVICE AND CONFIRMED WITH THE DEALER THAT THE PART WAS READY. AN HOUR WAITING FOR THE CAR TO BE SERVICED THE SERVICE ADVISOR GOT ME FROM THE WAITING ROOM TO TELL ME THAT THE NEW PART THAT WAS ORDERED FROM VOLKSWAGEN AND PAINTED TO ORDER WAS DAMAGED! TO THE SERVICE ADVISOR INFORMED ME THAT THE SERVICE DEPARTMENT HAD A REPLACEMENT MIRROR THAT HAD BEEN ORDERED FOR ANOTHER CUSTOMER. SINCE THAT CUSTOMER HAD NOT SCHEDULED A TIME FOR SERVICE IT WAS GOING TO BE SENT OUT TO BE PAINTED FOR ME. I LEFT THE SERVICE DEPARTMENT WITH MY BROKEN MIRROR. WHILE DRIVING HOME I REALIZED, I HAD A PROBLEM WITH THE SIDE MIRROR, THE REPLACEMENT MIRROR CAME IN DAMAGED, AND ANOTHER CUSTOMER HAD A PROBLEM WITH A SIDE MIRROR. I CAN PROVIDE ADDITIONAL PICTURES.

SINCE BRAND NEW THERE IS A RATTLE COMING FROM THE DRIVER'S SIDE PILLAR. TAKEN TWICE TO VOLKSWAGEN SERVICE AND THE RATTLE STILL THERE. ALSO THE VEHICLE HAS SHUT OFF COMPLETELY ON TWO DIFFERENT OCCASIONS FORCING ME TO RESTART MY VEHICLE COMPLETELY. COLD STARTS VEHICLE DOES NOT ACCELERATE WELL, FEELS LIKE WHEN SOMEONE IS LEARNING HOW TO DRIVE A MANUAL CAR FOR THE FIRST TIME AND MISSES THE CLUTCH AND THE VEHICLE JUMPS. TAKEN TWICE TO VOLKSWAGEN SERVICE AND THEY SAID THEY ADJUSTED THE TRANSMISSION AND EVERYTHING IS WELL. AS SOON AS I DROVE OFF THE LOT IT BEGAN TO DO THE SAME THING. WORRIED THAT THE VEHICLE MAY SHUT OFF COMPLETELY AT AN INTERSECTION OR THAT THERE MAY NOT BE ENOUGH POWER DUE TO LAG WHEN NECESSARY.

WHILE DRIVING AT ANY SPEED AND ON ANY ROAD SURFACE THERE IS A CONSTANT RATTLING COMING FROM THE DOOR AND WINDOW PILLARS. IT IS VERY LOUD AND NOTICEABLE AT ANY SPEED.GOING OVER ROUGH ROADS AND UNEVEN SURFACES MAKES THE RATTLING WORSE. THIS VEHICLE IS BRAND NEW AND ONLY FOUR DAYS OLD. WHEN I CALLED I WAS TOLD THERE IS NO KNOWN STRUCTURAL ISSUE. HOWEVER THERE ARE DOZENS OF THIS ISSUE REPORTED HERE AND ON VARIOUS VW FORUMS.

VEHICLE WAS MAKING A SMALL ANNOYING RATTLING SOUND, EMANATING FROM THE DRIVER SIDE B-PILLAR, NEXT TO DRIVER'S HEAD. RATTLE HAD BEEN INTERMITTENT INITIALLY BUT BY 8,000 MILES ON THE VEHICLE THE RATTLE WAS ALMOST CONSTANT AT ANY SPEED WHILST BEING DRIVEN OVER ANY SURFACE SMOOTH OR OTHERWISE. WE TOOK THE VEHICLE TO OUR LOCAL VOLKSWAGEN DEALERSHIP AND IT HAS NOW BEEN THERE FOR 32 DAYS. A REPAIR WAS DONE, BUT THE RESULT WAS SATISFACTORY, SO THEY ARE TRYING TO REPAIR IT AGAIN.

RATTLING NOISE COMING FROM THE SEATBELT COLUMN. HAVE BROUGHT IN MY CAR AND SENT RECORDINGS OF THE NOISE AND THE DEALERSHIP SAID THEY CANNOT REPLICATE THE NOISE THEY NOW HAVE IT FOR THE 3 MRS TIME AND I HAVE SHARED U TUBE LINKS AND THE VW FORUM TO SHOW THEM THAT OTHER CUSTOMERS HAVE THE ISSUES

I PURCHASED MY TIGUAN SE 4MOTION IN JULY 2018 AND SINCE I HAVE OWNED THE VEHICLE I HAVE HAD ISSUES WITH THE ACCELERATION AND NOISE COMING FROM THE PASSENGER SIDE B PILLAR. THE ACCELERATION FEELS LIKE A TURBO LAG FROM THE START WHERE THE GAS PEDAL IS PRESSED BUT THE VEHICLE HESITATES TO RESPOND CAUSING A SMALL "STALL". THIS HAPPENS IN BOTH DRIVE AND SPORT MODES. WHEN ACCELERATING UP-HILL THE VEHICLE HAS ISSUES WITH FINDING THE PROPER GEAR AND CONSTANTLY SEARCHES FOR A GEAR TO SETTLE ON. THE B PILLAR NOISE SOUNDS LIKE LOUD CLICKING WHEN GOING OVER BUMPS AND RUTS IN THE ROAD AND EVEN MAKES A NOISE WHEN OPENING THE DOOR TO ITS FULLEST.

TICKING NOISE/RATTLING FROM THE B-PILLAR ON BOTH THE DRIVER AND PASSENGER SIDE.

CREAK/RATTLE FROM DRIVER'S SIDE B-PILLAR ALMOST SINCE NEW. HAPPENS WHEN DRIVING OVER BUMPS IN THE ROAD; HAPPENS MOST BUT NOT ALL OF THE TIME. RECENTLY STARTED SAME FROM PASSENGER-SIDE B-PILLAR, BUT LESS FREQUENTLY. MOST OFTEN NOTICED WHEN DRIVING A MODERATE SPEEDS (35-55). THIS IS A KNOWN ISSUE WITH A TSB FOR EARLY MODEL YEAR PRODUCTION. MAY INVOLVE POOR/MISSING WELDS.

THE NEWEST GENERATION VW TIGUAN HAS A B PILLAR ISSUE WHERE THE RIVETS WHERE THE B PILLAR IS WELDED RATTLES. I AM CONCERNED OF THE OVER ALL STRUCTURE OF THE VEHICLE AND HOW IT WOULD WITHSTAND A CAR ACCIDENT.

TL* THE CONTACT OWNS A 2018 VOLKSWAGEN TIGUAN. WHILE DRIVING UNKNOWN SPEEDS ON ROUGH TERRAIN, THERE WAS AN ABNORMAL TICKING, RATTLING, AND KNOCKING NOISE EMERGING FROM THE FRAME. THE VEHICLE WAS TAKEN TO HAMILTON VOLKSWAGEN (2200 NJ-33 HAMILTON, NJ 08690, 844-858-4565) WHERE IT WAS DIAGNOSED THAT THE B PILLAR NEEDED TO BE REPAIRED. THE VEHICLE WAS REPAIRED, BUT THE FAILURE RECURRED. THE MANUFACTURER WAS NOTIFIED AND PROVIDED CASE NUMBER: 181087619. THE FAILURE MILEAGE WAS 3,000. THE VIN WAS NOT AVAILABLE.

INTERMITTENT CLICKING EMINATING FROM DRIVERS SIDE B PILLAR WITH OCCASIONAL CREAKING FROM VEHICLE FRAME IN THE SAME AREA. QUESTION AS TO SAFETY OF THE VEHICLES FRAME. THE CLICKING IS VERY IRRITATING AS IT IS NEXT TO DRIVERS EAR.

PURCHASED A 2018 TIGUAN AND DEVELOPED A RATTLE IN THE B-PILLAR. VW/BODY SHOP IS REPAIRING IT ACCORDING TO A TSB THAT IS NOT UP TO STANDARD IN MY OPINION. HOW CAN YOU FIX A BAD WELD BY MAKING THE SPACE WIDER AND SPRAYING IT WITH A SEALER?

B PILLAR RATTLE/CREAKING METAL SOUND, BOTH SIDES, BUT WORSE ON PASSENGER SIDE WHILE IN MOTION. SOUND IS ALWAYS PRESENT.

TICKING IN THE B PILLAR. IT COMES AND GOES BUT IS LOUD ENOUGH THAT ALL PASSENGERS IN THE CAR HEAR IT. IT IS IDENTICAL TO THE RATTLE THAT ALL OTHER TIGUANS HAVE. VW HAS A SERVICE BULLETIN FOR THIS ISSUE BUT IT HAS A NARROW VIN RANGE. THERE IS MOST CERTAINLY A STRUCTURAL CONCERN AND INHERENT DESIGN FLAW IN THE B PILLAR. TSB # 2050753/2

THE DRIVER'S SIDE B-PILLAR HAS A RATTLE/CREAK. IT'S A SLIGHT TICKING THAT HAPPENS MOST OF THE TIME OVER UNEVEN ROADS OR WHEN YOU HIT A BUMP; THE RATTLE/NOISE HAPPENS OVER THE SMALLEST BUMP. NOISE CAN BE HEARD EVEN ON EVEN ROADS.I'VE HAD THE CAR SINCE 1/31/2018 WHEN I PURCHASED IT NEW, AND AS OF TODAY 5/12/18 HAS 2637 MILES. I HAVE NOTICED THE RATTLE SINCE THE WEATHER HAS BEEN WARMER AND AFTER THE VEHICLE SITS IN THE SUN OR OUTSIDE. THE RATTLE OCCURS AT ANY SPEED; 15 MPH - 70 MPH.I HAVE NOT TAKEN THE VEHICLE TO THE DEALERSHIP SINCE I WANT THIS ISSUE DOCUMENTED SINCE IT'S A KNOWN ISSUE BASED ON MY RESEARCH AND THE FIX IS NOT FULL PROOF YET. I DON'T WANT MY CAR DISMANTLED UNTIL I KNOW THE FIX WILL ACTUALLY FIX IT PERMANENTLY. THIS IS A KNOWN ISSUE WHICH HAS BEEN REPORTED TO THE NHTSA AND VW ALREADY BY OTHER VW TIGUAN OWNERS. VW HAS ISSUED TECHNICAL SERVICE BULLETIN 2050753 ON 4/2/18 WITH A SUPPOSED FIX, BUT MULTIPLE OWNERS ARE STAYING THAT FIX HAS NOT SOLVED THEIR ISSUES. FOR DETAILS ON THE ISSUE PLEASE REFER TO THE FOLLOWING VW OWNER FORUM - HTTP://FORUMS.VWVORTEX.COM/SHOWTHREAD.PHP?8860202-2018-TIGUAN-B-PILLAR-RATTLE-AND-OTHER-ANNOYANCES&P=107961257#/TOPICS/8903433?PAGE=1