There are 4 stored owner reports matching the tires & wheels leading-label group for the 2019 Volvo S60 in our NHTSA-sourced dataset. These are unverified consumer reports and may not reflect confirmed defects.
This group counts stored reports whose component label starts with one of this site's matching prefixes, ignoring case. Each matching report counts once within the group. Components mentioned later in the label or only in the narrative are not searched. How component counts work
Loaded 4 of 4 matching reports.
Open the full vehicle complaint log (all categories)Have there been complaints about the Pirelli tires with foam inlays falling apart because the foam comes unattached, then causing misalignment. Car becomes unsafe to drive as the tires start to disintegrate. My car started shaking so bad it became difficult to drive. Turned out foam inlay had become unattached which caused uneven wear and some tire disintegration along with the alignment getting out of whack. Tire size 235/40R19 96V pirelli p-zero - It happened with all four tires. Two in the front were relatively new and had less than 10000 miles on them
235/40/19 XL RUN FLAT: At 20,750 miles, Sudden Extreme Vibration at Interstate Speed. Confirmed by Schumacher Volvo Service on 28 Oct 2023. Service Writer and Technician advised tire/s failing due to 'foam' separating inside tire. Rotated tires and could not determine which tire. Advised to replace all tires due to experience with same problem on same tires. Recommended purchasing another brand at Costco.
Sudden, Extreme vibration of front tires on I-95 West Palm Beach FL. Drove immediately to Schumacher Volvo to keep initial service appointment. Service manager advised to replace all 4 tires due to previous experience with OEM Perelli tire failures on Volvo vehicles. Replaced all 4 tires at Costco at $1112+ cost. All photos show failure of foam/padding inside tires by Pirelli P Zero Run Flat. Tire size: 235/40/19 XL
WITHIN THE FIRST MONTH OF LEASING THIS NEW CAR (< 250 MILES), BOTH LOW PROFILE OEM FRONT TIRES (235/40R-19 PIRELLI P ZERO ALL SEASON VOL VOLVO, KS, PNCS XL, PART NUMBER 3158400) WERE DAMAGED BY POTHOLES. I WAS TOLD BY ONE LOCAL TIRE SHOP THAT LOW PROFILE TIRES ARE MORE SUSCEPTIBLE TO THIS TYPE OF DAMAGE. I HAVE NOT DAMAGED TIRES ON POTHOLES LIKE THIS BEFORE. VOLVO DOES NOT WARRANT THESE (UNLESS YOU PURCHASE THEIR EXPENSIVE ROAD HAZARD PACKAGE), AND PIRELLI'S WARRANTY DOES NOT COVER THIS TYPE OF DAMAGE. THE NEW TIRES COST $536.34, AND THERE'S AN ADDITIONAL $25 PER TIRE FOR MOUNTING AND BALANCING.
Complaints are unverified consumer reports submitted to NHTSA. A high complaint count may reflect vehicle popularity, not defect severity. Data sourced from NHTSA public records.
NHTSA source checks for this vehicle year
Checks are recorded separately for each dataset, not for the whole page. Dates use UTC. A missing check date does not mean no records exist.
Vehicle import recorded: Apr 28, 2026. This is the stored import date, not confirmation that every source was successfully refreshed.