2002 Volvo XC70 Fuel System Problems

FUEL LEAK AT THE TOP OF THE FUEL PUMP. FUEL ODER IN CAN. FUEL LEAKING UNDER THE CAR

VOLVO XC V70 2002 OCEAN RACE EDITION HAS DEVELOPED A STRONG GASOLINE SMELL AFTER DRIVING. THERE IS NO 1) LEAKAGE UNDER VEHICLE, 2) CHECK ENGINE LIGHT, OR 3) APPARENT REDUCTION IN MILEAGE OR PERFORMANCE. I ALSO REPLACED THE GAS CAP, BUT NOTHING CHANGED. WE KEEP OUR VOLVO IN THE GARAGE UNDER OUR HOUSE AND THE GASOLINE SMELL HAS BECOME SO BAD THAT WE ARE NERVOUS ABOUT LEAVING IT THERE AT NIGHT SINCE THE UPSTAIRS BEGINS TO SMELL LIKE GASOLINE. WE DO NOT KNOW IF WE ARE CREATING A REAL SAFETY HAZARD BECAUSE OF THIS CAR? IN RESEARCHING 2002 VOLVO V70 XC WAGONS I FOUND THERE WAS A SIGNIFICANT VOLVO FUEL PUMP RECALL IN 2009 FOR THIS MODEL AND YEAR...BUT APPARENTLY ONLY IF THE VEHICLE WAS DRIVEN IN WARMER CLIMATES?? WE WERE NEVER INCLUDED IN THE RECALL AND DO NOT KNOW WHY SINCE WE DROVE THIS CAR BACK AND FORTH TO FL FOR YEARS AFTER THIS. NOT SURE WHY WE DID NOT QUALIFY? NONE OF OUR OTHER VOLVOS HAVE EVER HAD THIS PROBLEM. ANY WAY, WE ARE NOW BEING ADVISED THE FUEL PUMP MUST BE REPLACED AND DO NOT KNOW HOW BIG A SAFETY CONCERN THIS ISSUE IS UNDERNEATH OUR HOUSE. ANY ADDITIONAL INFORMATION AND/OR RESPONSE TO OUR CONCERN ARE APPRECIATED.

TL* THE CONTACT OWNS A 2002 VOLVO XC70. WHILE DRIVING AT VARIOUS SPEEDS, THERE WAS A STRONG FUEL ODOR COMING FROM THE VEHICLE. IN ADDITION, THERE WAS FUEL LEAKING FROM THE REAR OF THE VEHICLE. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 09V483000 (FUEL SYSTEM, GASOLINE). THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 140,000.

FUEL PUMP CRACKED, SLOW LEAK ON TO GAS TANK CAUSING EXTREME FUMES, MYSELF, 5 MONTH OLD GRANDDAUGHTER AND HER MOTHER WERE SICK FROM THESTRONG FUMES. I AFTER THAT TRIP I FOUND OUT ABOUT THE RECALL THIS COULD HAVE CAUSED A FIRE AND WE ALL WOULD HAVE GONE UP IN FLAMES. THIS PUMP IS UNDER THE REAR SEAT WHERE THE TWO PASSENGERS WHERE SITTING. ON MARCH 22, 2014, THE THREE OF US WENT TO ARRUNDEL MILLS MALL CLOSE TO BALTIMORE ON THE WAY HOME TO ALEXANDRIA VA., WE SMELT STRONG GAS FUMES. EVEN WITH ALL THE WINDOWS AND SUNROOF OPEN THE FUMES DID NOT DISSIPATE. I CALLED DON BEYER VOLVO AND FAIRFAX VOLVO AND BOTH STATED THE WARRANTY HAD EXPIRED SO THIS REPLACEMENT IS NOT COVERED. I WAS NOT AWARE THAT RECALL NOTICES EXPIRED! I WAS TOLD IF I HAD BROUGHT THE CAR IN WHEN THERE WAS NO PROBLEM THEY WOULD NOT HAVE REPLACED THE PUMP EVEN FOR SAFETY REASONS. SO WHAT GOOD IS A RECALL THERE SHOULD BE A STATEMENT ON RECALLS " YOU MUST KEEP UP YOUR WARRANTY UPDATED ON ALL VEHICLE PARTS". BECAUSE THE WARRANTY EXPIRED IN 2012, 10 YEARS FROM 2002, I BOUGHT THE CAR IN 2004, THE RECALL CAME OUT IN 2009, I WAS STILLUNDER WARRANTY AT THAT TIME. IF I BROUGHT THE CAR IN TO GET REPAIRED, BOTH VOLVO DEALERS SERVICE DEPARTMENTS STATED THEY WOULD NOT HAVE REPLACED THE PART BECAUSE THERE WAS NOTHING WRONG WITH IT AT THAT TIME. THIS IS THE ONLY VEHICLE I OWN MY DAUGHTER CANNOT DRIVE AND MY GRANDDAUGHTER IS ONLY 5 MOS. OLD, WILL VOLVO, DON BEYER, OR FAIRFAX VOLVO PAY FOR THREE FUNERAL EXPENSES, IS THAT WHAT IT WILL TAKE. *TR

TL* THE CONTACT OWNS A 2002 VOLVO XC70. THE CONTACT STATED THAT FUEL FUMES WERE PRESENT INSIDE THE VEHICLE AT ALL TIMES. THE CONTACT WAS MADE AWARE OF NHTSA CAMPAIGN NUMBER: 09V483000 (FUEL SYSTEM, GASOLINE); HOWEVER, THE VIN WAS NOT INCLUDED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 128,000.

2002 XC 70 HAS A BAD SMELL OF GAS AFTER DRIVING. THE CAR IS GETTING HARDER TO CRANK. I HAVE CHECKED THE GAS CAP AND IT SEEMS GOOD. *TR

MY 2002 VOLVO XC 70 SEEMS TO SMELL LIKE GASOLINE INSIDE THE CAR. I HAVE READ ON NUMEROUS VOLVO FORUMS REGARDING VOLVO OWNERS THAT HAS THE SAME OR SIMILAR CONCERNS. THIS CANT BE GOOD FOR THE DRIVER(MYSELF) OR THE VEHICLE. ANY INSIGHT ON A RECALL WOULD BE WONDERFUL. THANK YOU FOR YOUR TIME. JOE BOYLAN .... A CONCERNED VOLVO DRIVER....... *TR