2008 Volvo XC70 Fuel System Problems

DESPITE FUEL GAUGE READING OVER 1/4 TANK CAR STOPPED IN MIDDLE OF A HIGHWAY AND NEARLY CAUSED A COLLISION; THANKFULLY NO ONE HURT. DESPITE SERVICE BULLETINS ON THIS ISSUE WITH 2008XC70 NO RECALL EVER ISSUED. SEVERAL OTHERS HAVE REPORTED THIS ISSUE TO NHTSA, I BELIEVE A RECALL IS APPROPRIATE DUE TO THE OBVIOUS SAFETY PROBLEMS AND BECAUSE THIS ONLY HAPPENS TO THE 2008 MODEL- OBVIOUSLY IT WAS FIXED ON ALL THE FUTURE MODELS.

FUEL GAUGE ERRATICALLY MOVES DOWNWARD INAPPROPRIATELY. SEEMS TO RESET WHEN CAR RESTARTED, BUT TOTALLY UNDEPENDABLE IN TERMS OF ACCURACY. AUTO IS 3.5 YEARS OLD BUT OUT OF WARRANTY AT 60K MI. DEALER RECOMMENDS NEW FUEL TANK (WHICH INCLUDES SENDING UNIT) AND FUEL PUMP. RECOMMENDED AGAINST USED PART AS "OLD PART HAS BEEN SUPERCEDED" IT SOUNDS LIKE THIS IS A DEFECT WHICH HAS NOT RESULTED IN A RECALL/CAMPAIGN. NOTE: REPAIR WITH PARTS AND LABOR IS $2100.00.

WHILE DRIVING ALONG WITH FUEL INDICATOR READING 1/4 - 1/2 TANK REMAINING, MY 2008 XC70 ENGINE COMPLETELY STALLS OUT. THIS HAS HAPPENED TWICE AND BOTH TIMES COULD HAVE BEEN POTENTIALLY VERY DANGEROUS. I AM SICKENED TO LEARN THERE IS A RECALL FOR THE 2011 MODEL (SOFTWARE CALIBRATION FOR THE FUEL CUT-FUNCTIONALITY IN THE ENGINE CONTROL MODULE IS TOO SENSITIVE) BUT NOT THE 2008! THANKS VOLVO!! *TR

TL*THE CONTACT OWNS A 2008 VOLVO XC70. THE CONTACT WAS DRIVING APPROXIMATELY 70 MPH WHEN THE VEHICLE SUDDENLY SHUT OFF. THE CONTACT WAS UNABLE TO RESTART THE VEHICLE. THE FUEL GAUGE DISPLAYED A QUARTER OF A TANK FULL. THE VEHICLE WAS TOWED TO AN AUTHORIZED DEALER. THE TECHNICIAN STATED THAT THE VEHICLE SHUT OFF, AS A RESULT OF AN EMPTY FUEL TANK; HOWEVER, THERE WAS FUEL ADDED TO THE FUEL TANK PRIOR TO HAVING IT TOWED. THE CONTACT WAS AWARE OF THE SAFETY COMPLAINTS REGARDING THE FUEL SYSTEM; AND STATED THAT THE MANUFACTURER SHOULD IDENTIFY THE PROBLEM. THE FAILURE MILEAGE WAS 13,000.

IN MAR, 2010 WHILE IN HEAVY SLOW MOVING TRAFFIC, CAR STALLED. MILEAGE INDICATOR SHOWED 245 MILES TO EMPTY. CAR TOWED TO VOLVO DEALERSHIP AND IT WAS FOUND TANK WAS EMPTY AND FUEL SENSOR WAS NOT FUNCTIONING PROPERLY. PROBLEM WAS SUPPOSEDLY FIXED UNDER WARRANTY. IN MAR, 2012 ON INTERSTATE IN DRIVING RAIN CAR STALLED AGAIN. I WAS ABLE TO GET TO SHOULDER BEFORE COMPLETE STOPPAGE. FUEL INDICATOR SHOWED 255 MILES TO EMPTY. AGAIN WE WERE OUT OF GAS. CAR TAKEN TO DEALERSHIP WHERE IT WAS PURCHASED FROM AND THEY REPORTED THEY COULD FIND NO PROBLEM. FUEL INDICATOR SEEMED TO WORK FINE AFTER THAT UNTIL AUG, 2013. ON A MAJOR HIGHWAY THE CAR BEGAN STALLING AGAIN. I GOT IT OFF THE MAJOR ROAD TO WAIT FOR AAA ASSISTANCE. FUEL INDICATOR SHOWED 245 MILES TO EMPTY BUT TANK WAS AGAIN EMPTY. VOLVO DEALERSHIP STATES IT WILL COST APPROX. $800 TO DIAGNOSE THE PROBLEM WITH FUEL SENSOR AND THEY ARE UNABLE TO QUOTE A POTENTIAL COST FOR THE REPAIR WITHOUT THE DIAGNOSIS. THE LOSS OF CONTROL WHEN CAR RUNS OUT OF GAS IS DANGEROUS AND TERRIFYING. EVEN IF WE COULD AFFORD THE DIAGNOSIS AND REPAIR, THERE IS NO GUARANTEE THAT THIS WILL NOT HAPPEN AGAIN, ESP. SINCE IT WAS SUPPOSEDLY REPAIRED IN 2010! *TR

A 2008 VOLVO XC70 WITH APPROXIMATELY 30,000 MILES STALLED WHILE DRIVING ABOUT 30 MPH. THE FUEL GAUGE INDICATED 1/4 TANK AND THE LOW FUEL INDICATOR ON THE DASH WAS NOT ON. THE VEHICLE HAD RUN OUT OF GAS. *TR

2008 VOLVO XC70 ON ROAD TRIP TO COLLEGE ON I-75, STARTED SPUTTERING AND "CHECK ENGINE " LIGHT WENT ON. I EXITED AT NEAREST EXIT LAKE CITY, FL AND PARKED AND CALLED FOR ROAD SIDE ASSISTANCE. MY CAR WAS FLAT-BEDDED AND TAKEN TO OCALA VOLVO. FUEL SENSOR, FUEL TANK , FUEL PUMP ETC REPLACED. I HAD TO USE A LOANER FOR THE ROAD TRIP AFTER ALREADY LOSING ONE DAY OF TRAVEL. *TR

RAPID LOSS OF POWER IN FAST LANE ON BUSY HIGHWAY. TWO INCIDENTS. FIRST TIME, GAUGE SAID 90 MILES TO EMPTY. SECOND TIME, 125 MILES TO EMPTY. NO INDICATION OF QUESTIONABLE LOW FUEL. CHECK ENGINE LIGHT CAME ON. LUCKILY BOTH TIMES WAS ABLE TO GET PAST SEMI'S, AS VEHICLE LOST POWER TOTALLY IN LESS THAN 30 SECONDS. FROM 65 TO 0. OCCURRED IN JANUARY 2009 AND MARCH 2009. JANUARY 2009 REPORTED TO STATE POLICE. MARCH 2009 REPORTED TO DEALERSHIP FOR SERVICE. *TR

2008 VOLVO XC70 HAD A DEFECTIVE FUEL TANK. CONSUMER STATES THAT THE FUEL TANK WAS DEFECTIVE BECAUSE IT REGISTERED A HALF TANK OF FUEL ON THE GAUGE, BUT THE VEHICLE RAN OUT OF GAS. *NJ

TRAVELING ON A BUSY EXPWAY DURING RUSH HOUR IN LEFT LANE WHEN CAR STARTED BUCKING. I WAS ABLE TO SWITCH 2 LANES AND ALMOST MADE IT TO THE SHOULDER WHEN THE CAR STOPPED AND WOULDN'T START AGAIN. CAR INFORMATION SYSTEM REPORTED THAT THE BATTERY POWER WAS CRITICALLY LOW. I PUT MY HAZARD LIGHTS ON AND CALLED THE POLICE. I COULD NOT GET OUT OF MY CAR BECAUSE THE TRAFFIC WAS GOING BY TOO QUICKLY (I WAS AT THE BOTTOM OF A EXIT RAMP.) POLICE CALLED THEIR TOW TRUCK TO GET ME OFF THE ROAD QUICKLY. VOLVO ON LINE SERVICE SAID IT WOULD TALE AN HOUR TO GET A TRUCK TO ME EVEN THOUGH I TOLD THEM I WAS IN A VERY HAZARDOUS PLACE) CAR WAS TOWED TO VOLVO DEALERSHIP WHERE WITHIN 5 MINUTES THE PERSON WHO WENT OUT TO LOOK AT MY CAR CALLED ME BACK AND TOLD ME THE CAR WAS OUT OF GAS; THE GAS METER READ APPROX 1/3 FULL. HE REPORTED THAT THERE IS A PROBLEM WITH THE GAS METER IN THE MODEL OF 2008 CAR ( THEY HAVE HAD OTHER CUSTOMERS WITH THIS PROBLEM) THEY HAVE ORDERED A NEW GAS METER AND SAID THAT THEY WILL REPLACE THE OLD ONE AS SOON AS THE PART COMES IN. I AM LUCKY NO ONE REAR ENDED ME AND THE WASN'T A MULTIPLE CAR ACCIDENT DUE TO DRIVERS SWERVING SO THEY WOULDN'T HIT ME. IF THIS IS A PROBLEM IN THE VOLVO 2008 CX70, I THINK OTHER VOLVO OWNERS SHOULD BE ALERTED TO THE POSSIBILITY AND VOLVO SHOULD IDENTIFY AND REPLACE OTHER FAULTY GAS METERS. *TR