2021 Volvo XC90 Complaint Log

I am reporting a failure of the fuel pump system in my Volvo vehicle, which currently has approximately 60,000 miles. The failed component is available for inspection upon request. The issue was confirmed by an authorized Volvo dealership, which diagnosed the fuel pump as defective and requiring replacement. This appears to be a premature failure given the mileage and proper maintenance of the vehicle. This failure presents a serious safety risk. A faulty fuel pump can cause the vehicle to stall unexpectedly while driving, increasing the risk of a crash, especially at highway speeds or in traffic. Loss of engine power without warning places not only the driver and passengers at risk, but also other motorists on the road. Prior to the failure, the vehicle experienced symptoms consistent with fuel system issues, including difficulty starting and intermittent performance irregularities. These symptoms escalated until the vehicle became unreliable to operate. The problem has been confirmed by the manufacturer’s authorized service center, and the vehicle has been inspected accordingly. No external factors or misuse contributed to this failure. It is my understanding that Volvo has issued recalls and/or acknowledged similar fuel pump defects in other vehicles of comparable models and years. Based on the nature of this failure and its alignment with known issues, I believe this vehicle should be evaluated for inclusion under an existing recall or be subject to further investigation. Given the safety implications of fuel system failures, I respectfully request that this issue be formally reviewed to determine whether a broader defect trend exists that could impact other vehicles. The failure occurred at relatively low mileage and under normal operating conditions, raising concern of a systemic defect rather than normal wear and tear.

I drove the car (2021 Volvo XC 90) without incident on Sunday March 8, 2026 and at the end of the day parked the car in my garage. Monday morning, I came out to use the car and found that the seat back on the driver’s side had folded all the way forward and was immovable in a position that was unsafe to drive. Had the seat spontaneously folded all the way forward while I was driving, it would have pitched my body into the steering wheel and the results could have been catastrophic. At the time of the incident my car was approximately four years and seven months old from date of purchase with just 30,315 miles on it. Volvo reported that the seat-back motor had failed and needed to be replaced. The Cost was $1249.82. Volvo offered no explanation of the seat-back motor failure but stated they were aware of one other similar incident. I have no details of that incident. I have photos of the seat position and the seat-back motor after it was removed, but was unable to upload them. I still have the seat back motor in the same condition it was in as provided to me by Volvo Cars of Sarasota.

Driving on a 45 mph road and brakes felt squishy, like air was going out of them. It was slow to stop and had to pump then stomp to get it to stop before crashing. Was fortunate to not hit anything. Pulled into gas station and had it towed to Volvo. There were no warning lights or other indication of problem- the brakes just failed. Volvo said the vacuum pump failed which pushed oil into the brake booster causing it to fail. The car has 74,000 miles and has been serviced regularly.

The contact owns a 2021 Volvo XC90. The contact stated that while retrieving items from the trunk, the contact became aware that there was water leaking into the cargo area. The contact stated that the holders were full of water. There were no warning lights illuminated. The vehicle was taken to the local dealer, where it was determined that the sunroof drain hose needed to be replaced and sealed, and the flooring needed to be replaced. The vehicle was not repaired. The manufacturer was contacted and opened a claim. The failure mileage was approximately 40,000.

Unintentional acceleration.First, I was in line at car wash proceeding slowly ahead as directed in line. Foot on accelerator lightly moving, when car surged rapidly hitting back end of Tesla about 6-8 ft ahead (2/26/26 12:30pm) Impact strong enough to push Tesla into truck hitch damaging it front of it as well. Applied brake, but impact was too rapid. Second incident with my Volvo was a month later(3/22/26 about 10:30 am) and my husband was driving. . Made right turn on green light and started to accelerate when it revived and surged forward until applied brake. Dealer could not replicate. No codes but repair shop had to recalibrate after 1st incident and may have lost code on 1st incident(wreck). Now that insurance knows what happened, I don't know if they will intervene. hopefully. No warnings went off or messages. Airbag did not deploy. I believe that this is an unintentional acceleration, especially occurring twice now. Dealership says car is safe and they will monitor. I guess it means when we have another incident. Hopefully not fatal to us or anyone else. Dealer says it is a transition from hybrid electric to gas. But I have had this car 4yrs10months and this never happened until now. And the transition never has thrown me back in my seat or had the engine rev. The battery was replaced last August because of bad cell and recall on it for fire hazard. Maybe this could have an affect. On first incident I was in shock so thought maybe in hit accelerator instead of break, but when second incident occurred and it was exactly like first except no collision. Thatshow I originally reported to insurance and police as my fault. But that's not true. Now I called insurance to report dual incidents, two different drivers with unintentional acceleration. SR-1 filed

The ERAD (Electric Rear Axle Drive) transmission on my 2021 XC90 T8 Recharge has suffered an internal failure at approximately 112,550 miles. The vehicle makes loud grinding and slamming noises from the rear drivetrain and locks up when attempting to drive, making the vehicle completely undrivable. The dealership (Volvo Cars Gilbert, AZ) diagnosed the ERAD clutch as slamming and suspects internal gears are missing teeth. A software update was attempted but did not resolve the mechanical failure. The ERAD transmission needs full replacement at a quoted cost of $5,211.56 (part number 32324105-9). This is a known failure point on the T8 platform and Volvo has redesigned this component (ERAD2) for newer models due to reliability issues with the original design. This failure presents a safety concern as the rear drivetrain can lock up unexpectedly during driving. This ERAD failure occurred alongside two other hybrid system component failures within a 3 month period: the High Voltage Coolant Heater (HVCH) and the vehicle batteries (VCM and main), suggesting a systemic hybrid system reliability problem.

Our rear backup camera is no longer working. I see that other years have been recalled for the same issue, but our 2021 XC90 is not covered under the recall. It seems to be the same issue.

The aluminum trim on the center console of my 2022 Volvo xc90 has started peeling. The exposed edges are sharp and cut my fingers whenever I move my hands near the console. This issue is very common among this model and presents a serious safety hazard during normal vehicle use.

My vehicle was recalled for a faulty battery module. I turned the car into the dealer (Palo Alto Volvo in Palo Alto, Ca) on December 18 and the dealer has not been able to provide any ETA on repairs.

My 2021 Volvo XC90 Recharge has experienced multiple hybrid system failures under Volvo's factory 8-year/100,000-mile hybrid warranty, with fewer than 45,000 miles on the odometer. The high-voltage battery modules have failed multiple times, directly related to recall R10312 (NHTSA 25V-179), which identifies a supplier process deviation in LG battery modules creating a risk of internal short circuit and thermal runaway — an acknowledged fire risk. Critically, my vehicle has suffered two actual battery module failures, not preemptive recall replacements. This places my vehicle in a substantially higher risk category than others in the recall population with no prior symptoms. A vehicle that has already experienced the exact failure mode identified in a safety recall presents a materially greater ongoing safety risk. Additionally, my vehicle suffered a complete ERAD (Electric Rear Axle Drive) failure — a known defect that Volvo acknowledged by releasing a redesigned ERAD2 unit, confirming awareness of this systemic issue. These repeated failures left my vehicle un-drivable and parked at the dealership for more than 6 months, with replacement parts repeatedly placed on backorder, causing severe and prolonged loss of use. I filed a formal complaint with Volvo Customer Care requesting a vehicle buyback. After months of inadequate communication, Volvo declined to buy back the vehicle or offer reasonable trade-in accommodation. Instead, Volvo offered a nominal monetary concession contingent on signing an NDA, which I declined as insufficient given the documented safety risk, repeated failures of a recalled component, extended loss of use, nor out of pocket car rental expenses. I am filing this complaint to ensure my vehicle's actual failures are part of the NHTSA record for R10312/25V-179, and to request NHTSA evaluate whether Volvo's response to owners who have experienced actual failures — rather than preemptive recall repairs — warrants further regulatory scrutiny.

Title: Possible Defect – Uneven Airbag Deployment Description: On July 20, 2025, around 5:30 PM, i was driving a 2021 Volvo XC90 on a main road when another vehicle suddenly entered from the right side without stopping at a stop sign. I was unable to avoid a collision and my vehicle T-boned the other car (front impact on my vehicle). During the crash, I believe the front airbag system did not deploy properly or deployed unevenly. I felt like the left side of the airbag (from the steering wheel) was full of air but not the right side (that side was flat when it deployed), and I believe I hit my head on the steering wheel. I experienced severe injuries to my head, face, and right eye, including commotio retinae, lens displacement, corneal abrasion, corneal edema, phacodonesis, iridodonesis, and concussion. I am concerned that the Supplemental Restraint System (SRS) malfunctioned, contributing to the severity of my injuries. No modifications have been made to the airbag system. I request that NHTSA investigate whether there is a defect in the airbag deployment of the 2021 Volvo XC90, particularly for asymmetric or partial deployment. The automatic emergency braking (AEB) system also did not activate despite the imminent collision. There were no warning lamps, messages, or unusual symptoms prior to the crash. The issue has not yet been reproduced or confirmed by a dealer or service center, but The police was at the scene. My insurance company has inspected the vehicle. I have also reported this to the customer care team at Volvo.

The vehicle’s Start/Stop system began displaying warning messages and malfunctioning prior to the expiration of the factory warranty. The issue first appeared before 50,000 miles and reappeared at 49,997 miles, when a warning was displayed on the dashboard. The vehicle was taken to an authorized dealer for inspection. A diagnostic review confirmed the need to replace the Start/Stop auxiliary battery and repair the Park Assist system. A diagnostic fee was charged, and both system failures were documented. The Start/Stop system’s failure raises a potential safety concern because the vehicle may not reliably restart after automatically stopping at intersections or in traffic. This could lead to dangerous situations if the vehicle stalls unexpectedly or fails to re-engage power at a critical moment. Although the issue has not caused a crash or injury, it introduces unpredictable behavior that could compromise safe operation. The Park Assist system also failed, triggering system warnings and disabling parking assistance features. If a driver is relying on these systems during low-speed maneuvers, a sudden or silent failure may increase the risk of collision with objects, pedestrians, or other vehicles. The dealership confirmed the problem through inspection and diagnostic testing. The manufacturer was contacted and declined to cover the repairs under warranty, despite the vehicle being within the mileage limit when the issue was first documented and presented for service.

I plugged my usb to usb-c charging cable into my iphone 20 seconds after starting the vehicle. I proceeded to exit my driveway when the infotainment screen went completely blank and the same thing to the driver's display 10 seconds later. I drove to the end of my street to a stop light where the car completely shut off and automatically restarted within a few seconds. I was traveling with my wife and [XXX] daughter. I have yet to reproduce the problem but have an appointment scheduled with the dealership later this week. Zero warnings or messages were present before, during or after the incident. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The contact owns a 2021 Volvo XC90. The contact stated that upon starting the vehicle and shifting to drive(D), the vehicle failed to respond unless the brake pedal had been released for 2-3 seconds. Additionally, the contact stated that upon starting the vehicle and releasing the brake pedal to reverse out of the driveway, the vehicle rolled back at a faster speed, and the vehicle failed to respond as intended upon depression of the brake pedal. The contact noticed a pattern with the brakes malfunction. The contact stated that the brake pedal required to be depressed 2-3 seconds after the first depression for the brakes to operate as intended. The contact stated that he was a master mechanic and had concluded that the failure was considered a safety issue because the vehicle was only designed with electronic braking, which left the driver with no manual option for braking. The contact stated that the failure had only occurred upon starting the vehicle. The contact related the failure to NHTSA Campaign Number: 25V392000 (Service Brakes, Hydraulic, Service Brakes); however, the VIN was not included. The vehicle was taken to the dealer, where it was diagnosed that the brakes had failed and Software Update Number: 3.5.14 was needed. The vehicle was not repaired. The manufacturer was informed of the failure, and it was confirmed that the repair was not covered under the recall or under warranty. The failure mileage was approximately 78,500.

The brakes did not work when the automatic emergency braking turned on. When I pressed the brakes all the way down, the brakes didn’t respond because it was still in automatic mode. I was able to swerve into the next lane to not hit the vehicle in front of me. The automatic emergency braking also turned on when I was reversing from a parked location when there was a vehicle waiting to park behind me and my vehicle stoped and didn’t come off of brake/park mode. I had to turn my vehicle on and off again to get it to move again. I have taken my vehicle in twice for shaking. My back rotors were replaced 2 weeks ago but my vehicle still shakes. This car only has around 21,000 miles to have so many issues already with rotors and shaking.

Vehicle steer violently on pilot assist and powertrain disabled, not allowing us to steer the wheel on a highway. (Last year) We were lucky no other cars were nearby, needed a reboot for the wheels to work again. Dealership isn’t sure what happened. Now we have a hybrid system failure which a lot of cars with the same model Xc90 T8 is having with the hybrid system. Please investigate into this

Heat does not work in Hybrid Vehicle. Prevents windshield from being able to be defrosted in winter. Should be covered under warranty, however when I took it to the dealer they report that multiple Volvo have this problem and there is a part shortage. Because of this problem, the vehicle is unsafe to drive the vehicle in the winter because it won't generate enough heat to melt the snow and ice that hits the windshield.

The infotainment system has locked up and has shut completely off while driving. When it shuts down (screen goes black) or glitches, the car actually loses power. Luckily it powered right back on but it was scary and could happen again and be much worse. The screen/ infotainment system has had this issue for awhile. We’ve even told Volvo of Tulsa about it when it was in for service but they said they couldn’t do anything about it because they couldn’t reproduce the issue. We have also had the brakes and rotors replaced twice at the dealership because they seem to be lemons or faulty. We are currently dealing with vibration once again (conveniently now the warranty is out).

The harness can be loosened by lightly pulling on it without use of the harness release button. The harness is not holding the child in place and the car seat is therefore unsafe for use.

On two separate occasions, while driving car on highway at high speed, the car has gone into a special shutdown mode, where a turtle icon lights up on the dash and the car begins to shut itself down rapidly, limiting maximum speed of vehicle to 35mph. There is no warning or advanced alert. Suddenly the car reduces speed and feels like it is dead, and the systems begin to alert you that they are going into a reduced function mode. This was extremely scary thing to happen at highway speeds with flowing traffic. I had to crawl to side of rose at very low speeds. I could have been injured. I took the car to dealer for service and they said it was a software issue. A few months after, this happened yet again, also while at highway speeds. I have read that others are having similar issues with the Volvo XC90 model. This is so dangerous and the dealerships are writing it off as a software matter! It is extremely dangerous.

Vehicle is lurching on slow acceleration in Hybrid Mode. For example, lurching occurs when pulling away from a stop sign, pulling out into traffic, pulling into a parking spot. Issue started beginning of January 2023. In February Fields Volvo Service diagnosed issue as a software problem (Code IEM-P287100) and that Volvo hasn't written the software yet. Fields Volvo Service said software update should be available in Quarter 2. Advised that I do not drive my car in Hybrid Mode. I own a hybrid vehicle that I have been told not to drive in Hybrid. Unfortunately, Hybrid is the default mode so upon each start I have to manually change mode to AWD. There is also lurching in AWD on slow acceleration (not as bad as in Hybrid). On several occasions while driving in AWD the vehicle will spontaneously change the mode back to Hybrid resulting in decreased or no acceleration and lurching. This has happened several times in parking lots (minimal fear for safety) but also several times while pulling into traffic (e.g., making left hand turns which require acceleration) and acceralerating on onramps to the freeway (definite fear for safety). Problem has been experienced by sales staff at Fields Volvo because we are trying to get rid of the car because it is still under warranty (36,000 miles). Fields Volvo has not gotten back to us as to whether they will buy back the car. Volvo USA has been contacted via phone and email about the issue. I have received no response.

I brought a 2021 XC90 Volvo on 8/18/2022 with 12861 miles on it. The attached photo will show the current mile on the vehicle is 17421, so you can see I have only put 4560 miles on the vehicle. This vehicle was only brought 3 months ago. It's very concerning that I was driving down interstate 530 on Sunday 11/13/2022 and for the first time ever the low-pressure light comes on and then seconds later the vehicle starts the shakes and I almost lost control of the vehicle. I managed to get to the side of the highway to find that my back passenger rear tire had separated around the rim (pictures are attached). Perelli 275/40 R21 107V M+S Scorpion Verde All Season

Took my car in because one of my backseat seatbelts no longer retracted properly and Was so loose that I couldn’t possibly buckle my daughter in safely in her car seat. I had noticed the seatbelt on the other side was also starting to retract more slowly. When the service center did the test they said the one that no longer retracted was covered under warranty but the other was not broken enough to be covered and that I could come back when it was. So basically I should keep buckling my child into a faulty seatbelt until it is completely broken. When I asked why the seatbelts were like this they told me it was “wear and tear” and when I said it’s a new car they said it’s because of the car seats. When I got home I did some googling and found that thousands of other Volvos have already been recalled because of the exact same problem I am having and when I told them this they said I would have to contact Volvos head office. When I did that Volvo had me wait for weeks and then finally agreed they would fix my other seatbelt as a gesture of goodwill. Even though this is obviously they same problem as the recalled cars neither the company or the service place is going to tell anyone else. There are clearly more cars affected and they are lying to people and saying the seatbelts are safe when they are not and they do not care that children are being buckled into their unsafe seatbelts. I am appalled and hope you will take action ASAP. Who knows how many kids are being buckled into these seatbelts that won’t save them.

My Xc90 is shuttering at interstate speeds as well as below. When I purchased, they had to machine the rotors and said they balanced the front tires. It did not help much. The brakes shake less. I'm sure the entire rotors are warped. All this with 12k miles on the vehicle.

With 2700 miles my XC90 has the Emission Control System light is on. The engine noise is considerably louder than normal (being a hybrid the SUV is pretty quiet) and it is not using the electric option.

Check engine light illuminated at 11,000 miles. Diagnostics showed a software update was needed but the software update did not fix the problem. Volvo corporate said the IEM module needed to be replaced. The IEM module controls the rear axle / propulsion and this is a serious safety issue because sudden loss of propulsion while driving at high speeds increases risk of having an accident. After replacing the IEM module, the mechanic cleared the DTC codes, test drove the car, and re-ran the DTC - and the code indicating a software update was still needed was present. Also the hybrid battery doesn’t keep its charge and depletes at an extremely fast rate.

The contact owns a 2021 Volvo XC90. The contact stated that upon shifting to Drive(D) while the vehicle was on an incline, the vehicle rolled back before moving forward as intended. The contact stated that the failure had been recurring, causing the vehicle to hit a garage door and a brick mailbox on two different occasions. The contact stated that the tailgate was opened and sustained a dent when the vehicle hit the garage door. The contact stated that upon shifting to Reverse(R) on a decline, the vehicle rolled forward before reversing as intended. The contact stated that the failure had caused the vehicle to hit two pedestrians. There were no reported injuries. No police report was filed. The vehicle was taken to the dealer on several occasions, and several unknown repairs were performed; however, the failure persisted. Additionally, the contact stated that the vehicle had experienced difficulty starting on several occasions, leaving the contact stranded while the contact was in the process of taking his son to the emergency room. The contact stated that while attempting to start the vehicle, the vehicle failed to start. The message "Press Knob To Start" was displayed. The contact stated that while driving at 65 MPH, the vehicle suddenly stopped. The message "Hybrid System Failure - Service Required" was displayed, and the message "Performance Reduced" was displayed along with a turtle. The contact was able to restart the vehicle, but the vehicle failed to exceed 5 MPH while driving. The contact was able to pull over to the side of the road. The contact stated that the failure recurred on several occasions. The vehicle was taken to the dealer, where unknown repairs were performed; however the failure persisted. The dealer had recommended the vehicle sale due to the persistent failure. The vehicle was taken to Park Place Volvo(3515 Inwood Rd, Dallas, TX 75209), where the battery cells were recharged, and the hybrid system module and an unknown hybrid system part were replaced; however, the failure persisted.

ELECTRIC PARKING BRAKE ENGAGING VIOLENTLY AT HIGHWAY SPEEDS AT LEAST. 3 TIMES. RESULTING IN ABRUPT STOP IN MOVEING TRAFFIC! DEALER IN NO HURRY TO REPAIR SUGGESTING BRING BACK WHEN THEY ARE ABLE! AM NOTIFYING VOLVO, DEALER , THEY WILL ASSUME ALL LIABILITY FOR INJURY OR DEATH FOR THIS DEFECT AND LACK OF CONCERN IN REPAIRING ( TOLD A SOFTWARE PROBLEM , BUT ALSO TOLD CAUSED DAMAGE TO OTHER COMPONENTS DUE TO VIOLENT AND ABRUPT STOPS! VERY UNCOMFORTABLE ESPECIALLY SINCE REPAIR MGR IS SO ARROGANT!

TL* THE CONTACT OWNS A 2021 VOLVO XC90. THE CONTACT STATED THAT WHILE OPERATING THE VEHICLE IN REVERSE, THE BACKUP CAMERA DISPLAY APPEARED VERY BLURRY AND DISTORTED CAUSING A VISIBILITY HAZARD TO THE DRIVER. THE CAUSE OF THE FAILURE WAS NOT DETERMINED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE BUT, NO ASSISTANCE WAS OFFERED. THE LOCAL DEALER WAS NOT NOTIFIED. THE FAILURE MILEAGE WAS 200. *LN*JB

*WITH THE BOWERS & WILKINS SOUND SYSTEM* TWICE WITHIN 1400 MILES, THERE WAS A LOUD "POP" SOUND FROM THE SPEAKERS FOLLOWED BY NO SOUND FROM ANY PORTION OF THE VEHICLE. THE POP SOUNDED LIKE A WINDOW OR THE SUNROOF SHATTERED. ALL SOUND WAS LOST: SENSUS FEEDBACK, TURN SIGNALS, PARKING SENSORS, PHONE, ETC. THE ONLY THING THAT WORKED WAS THE BASS. AFTER THE CAR WAS PARKED AND OFF, AND RE-STARTED, EVERYTHING WORKED AS NORMAL. ODDLY, THERE WAS THE FEELING OF STATIC ELECTRICITY JUST PRIOR TO EACH POP. THESE POPS WERE CAUGHT ON DASH CAM FOR PROOF. THERE WAS STATIC HEARD IN THE DASH CAM VIDEO TOO. THE DEALER PROVIDED A "FIX" WITH A SOFTWARE UPDATE DESCRIBED IN TECHNICAL JOURNAL. TJ 35554.20-2020 (IHU VOLUME RESTRCTION WITH ORANGE KEY). THIS SOFTWARE UPDATE HAD NOTHING TO DO WITH THE PROBLEM I HAD. THE ORANGE KEY WAS NO WHERE NEAR THE CAR DURING ANY OCCURRENCE. SINCE THE UPDATE, THERE HAVE BEEN SEVERAL IDENTICAL LOUD POPS, BUT THE AUDIO CONTINUED WORKING. THE SAME STATIC ELECTRICITY FEELING OCCURRED MILLISECONDS BEFORE THE POP. ALL INCIDENTS OCCURRED WHILE ON A FREEWAY OR MERGING ON A FREEWAY, WITH MY PHONE ON THE WIRELESS CHARGER AND THE AUDIO ON AT LEAST AROUND 50%. MULTIPLE REPORTS OF THE SAME ISSUE ON A REPUTABLE VOLVO FORUM.