2003 Acura TL Suspension Problems

REAR SUBFRAME RUSTED

FRAME AND UNDERCARRIAGE OF THIS AUTO CONDEMNED BY SERVICE DEPT. DUE TO PREMATURE RUSTING OF FRAME. AUTO ALWAYS GARAGED. FRAME RUST APPEARED AT 40,000 MILES.

MOTOR FRAMES OR ENGINE CRADLE ON THE PASSENGER SIDE IS BADLY RUSTED, AND IT ABOUT TO FALL APART. I HAVE BEEN LOOKING FOR REPLACEMENT PART, AND EVERYONE OF THEM THAT THAT I HAVE FOUND HAS THE SAME PROBLEM. I FOUND OUT THE PROBLEM WHEN I WAS TRYING TO REPLACE THE FRONT ROTORS BACK IN JUNE OF THIS YEAR 2018 AND I HAVE NOT BEEN DRIVING IT BECAUSE I ALSO NEED TO REPLACE THE DRIVE AXLE AND I COULDN'T FIND THE ENGINE CRADLE FOR REPLACEMENT, I COULDN'T DO ANYTHING WITH IT.

THE FRAME THAT SUPPORTS THE ENGINE IS RUSTING OUT!....IT ONLY SOUNDED LIKE A SQUEAK...BUT THE ISSUE IS WAY BIGGER THAN ANTICIPATED...IT ONLY MAKES A SOUND WHEN BACKING UP OR TURNING....OTHER PARTS RELATED TO THE FRAME ARE ALSO AFFECTED.

AUTO HAS ONLY 49,072 MILES ON IT AND THE FRAME BEAM HAS SERIOUS RUST SHOWING.

TL* THE CONTACT OWNED A 2003 ACURA TL. THE CONTACT STATED THAT WHILE DRIVING AT 65 MPH, THE VEHICLE ENCOUNTERED A POT HOLE CAUSING THE VEHICLE TO JERK VIOLENTLY. AS A RESULT, THE VEHICLE VEERED OFF THE ROAD AND FLIPPED OVER. THE AIR BAGS DID NOT DEPLOY. THE CONTACT'S LEFT SHOULDER STRAP SEAT BELT WAS DETACHED FROM THE VEHICLE LEAVING BEHIND ONLY THE WAIST STRAP SEAT BELT AS THE CONTACT SHIFTED FROM THE DRIVER'S SEAT TO THE PASSENGERS SEAT DURING THE ACCIDENT. FURTHERMORE, THE CONTACT'S HEAD WAS PARTIALLY HANGING OUT OF THE WINDOW AFTER THE ACCIDENT. THE VEHICLE WAS DESTROYED. THE CONTACT SUSTAINED A FRACTURED WRIST, CHEST PAINS, MULTIPLE LACERATIONS AND A CONCUSSION. IN ADDITION, THE CONTACT'S STOMACH WAS SEVERELY TWISTED OUT OF SHAPE AND THE CONTACT VOMITED AND FAINTED NUMEROUS OCCASIONS AFTER THE ACCIDENT. THE CONTACT REQUIRED MEDICAL ATTENTION. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 123,000. THE VIN WAS NOT AVAILABLE.

TL* THE CONTACT OWNS A 2003 ACURA TL. WHILE THE VEHICLE WAS AT AN INDEPENDENT MECHANIC FOR A ROUTINE OIL CHANGE, THE TECHNICIAN NOTICED THAT THE SUB FRAME AS CORRODED AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 180,000. UPDATED 1/12/16 *CN

I HAVE ENCOUNTERED AN UNSAFE CONDITION ON MY 2003 ACURA TL (MADE BY HONDA). THIS CONDITION WAS SHOWN TO ME BY MECHANIC WHO INDICATED THAT THE VEHICLE IS UNSAFE TO DRIVE DUE THE FRONT PASSENGER CROSS FRAME MEMBER IS COMPLETELY RUSTED THROUGH (PHOTOS ARE AVAILABLE UPON REQUEST). THE CONDITION WAS FOUND AFTER 96,746 MILES DURING A REPAIR AFTER A ROUTINE OIL CHECK. THE APPARENT CAUSE IS THE HOSE LINE CONNECTED TO THE AIR CONDITIONING UNIT IS POSITIONED IN SUCH A WAY THAT IT LEAKS ONTO THE SUB-FRAME, CAUSING IT TO RUST OUT. THE COST FOR THE FRAME REPAIR WAS $ 2,052.970, BUT WHAT IS MORE DISTURBING IS THAT I WAS DRIVING THIS CAR WITH MY GRANDCHILDREN AND FAMILY UNDER THE RISK OF AN ACCIDENT WITHOUT MY KNOWLEDGE OF THE CONDITION. ALSO, DISTURBING IS TO KNOW THERE MAY BE OTHER CARS WITH THE SAME ISSUE BEING DRIVEN TODAY. *TR

UPON A NORMAL RECALL INVITATION FOR THE AIR BAG INFLATOR ( PER MANUFACTURER REQUIREMENT) A SEPARATE NORMAL INSPECTION WAS DONE TO VEHICLE. THE MECHANIC FOUND THE FRONT AND RIGHT FRONT MOTOR MOUNTS HAVE COLLAPSED. I KNOW SEVERAL OTHER OWNERS OF HONDA AND ACURA OF THE SAME YEAR AND SUV MODELS WITH THE SAME FAILURE.

TL* THE CONTACT OWNS A 2003 ACURA TL. WHILE DRIVING 40 MPH THE VEHICLE DOWN-SHIFTED WITHOUT ANY PRIOR WARNINGS. THE VEHICLE WAS TAKEN TO A LOCAL REPAIR FACILITY, AND A MECHANIC CONCLUDED THAT THE GEARS IN THE TRANSMISSION WERE SLIPPING. THE VEHICLE WAS TOWED TO A DEALER. THE TECHNICIAN ADVISED HIM THAT BEFORE REPAIRS COULD BE PERFORMED HE WOULD HAVE TO PAY AN $140.00 DIAGNOSTIC FEE. NO REPAIRS WERE MADE. THE TECHNICIAN CONCLUDED THAT HE WOULD CALL THE MANUFACTURER TO DETERMINE WHAT RECOURSE THEY WOULD PROVIDE. THE FAILURE MILEAGE WAS 63,300. UPDATED 11/06/09. *LJ THE BALL JOINTS WERE REPLACED. UPDATED 11/10/09

TL*- THE CONTACT STATED THAT WHILE DRIVING HIS 2003 ACURA 3.2 TL AT 63000 FAILURE MILAGE AT 30 MPH THE FRONT DRIVER'S SIDE OF THE VEHICLE DROPPED. THE DRIVER STEERED THE VEHICLE ONTO THE SIDE OF THE ROAD. THE VEHICLE HAD TO BE TOWED TO THE DEALER. THERE HAD BEEN NO DIAGNOSIS AS TO THE FAILURE , AND THE VEHICLE HAD NOT BEEN REPAIRED. *AK

2003 ACURA TL TYPE-S EXPERIENCING EXCESSIVE WEAR ON ONLY THE DRIVER'S SIDE FRONT TIRE. CAR WAS TAKEN TO AN ACURA DEALER FOR SERVICE. UPON INSPECTION OF THE VEHICLE, THE ACURA MECHANIC INDICATED THAT THE PROBLEM HAS BEEN SEEN PREVIOUSLY ON SEVERAL OTHER VEHICLES OF THE SAME MAKE/MODEL AND THAT THE PROBLEM WAS RELATED TO THE TRACTION CONTROL SYSTEM (VSA) ALLOWING SLIPPAGE OF THE FRONT DRIVER'S SIDE TIRE DURING RIGHT TURNS. ACURA STATED THAT THERE WAS NO RESOLUTION AVAILABLE AND THE ONLY RECOURSE WAS TO ROTATE THE TIRES ON A MORE FREQUENT BASIS. TIRE DEALER WAS ASKED IF THERE WERE ANY KNOWN ISSUES WITH THE TIRE ITSELF (MICHELIN) AND INDICATED THAT THERE WERE NO SERVICE NOTIFICATIONS ISSUES FROM THE MANUFACTURER. THE WEAR ON THIS TIRE IS HEAVILY ACCELERATED AND WAS ONLY NOTICED ON A ROUTINE EXAMINATION OF THE VEHICLE. BASED ON THE STATEMENTS BY THE ACURA MECHANIC, I BELIEVE THERE TO BE A PROBLEM WITH THE TRACTION CONTROL SYSTEM THAT ALLOWS THE FRONT DRIVER'S SIDE TIRE TO SLIP, THEREBY CAUSING THE EXCESSIVE WEAR. GIVEN WINTER DRIVING CONDITIONS, THIS SLIPPAGE WAS INCREASED DUE TO THE LOSS OF ROAD TRACTION. IF UNNOTICED, THE TIRE WOULD HAVE FAILED (WITH LESS THAN 28000 MILES) POTENTIALLY CAUSING SIGNIFICANT DAMAGE TO THE VEHICLE. THE WORN TIRE IS AVAILABLE FOR INSPECTION AND PICTURES OF THE TIRE IN COMPARISON TO THE PASSENGER SIDE FRONT TIRE ARE AVAILABLE UPON REQUEST. *NM

WHILE DRIVING, THE CONSUMER HEARD A "WHIRRING" NOISE AND ASSUMED IT WAS ROAD NOISE. TOOK VEHICLE TO DEALER, WHO DIAGNOSED THE WHEEL BEARINGS HAD FAILED. CONSUMER HAD TO PAY $26 FOR REPAIRS. *AK *CB *JB