2010 BMW 5 Series Engine Problems

The contact owns a 2010 BMW 528I. The contact stated that the vehicle was repaired under NHTSA Campaign: 23V707000 (Engine and Engine Cooling); however, the repair failed to prevent a failure. The contact stated that while attempting to start the vehicle, there was an abnormally loud rattling sound coming from under the hood. The check engine warning light was illuminated. The contact stated that while driving at an undisclosed speed in Manual Mode, the vehicle independently shifted to neutral(N), the steering wheel became firm, and the transmission failed to shift out of neutral. In addition, the contact stated that while attempting to accelerate from a stop, the vehicle hesitated while accelerating with the accelerator pedal depressed. The contact stated that the vehicle was towed back to the same local dealer on various occasions; however, the failure reoccurred. The manufacturer was not made aware of the failure. The failure mileage was approximately 145,000.

The contact owns a 2010 BMW 528I. The contact stated while making a left turn and depressing the brake pedal, the vehicle failed to respond as needed. The brake and transmission warning lights illuminated. A dealer was contacted. The contact pulled over to the side of the road, turned off the vehicle, and then attempted to restart the vehicle; however, the vehicle failed to respond as intended and was towed back to the residence. The vehicle was next towed to an independent mechanic, where it was diagnosed and determined that the camshaft and timing belt chain needed to be replaced. The vehicle was not repaired. The contact related the failure to NHTSA Campaign Numbers: 23V707000 (ENGINE AND ENGINE COOLING) and 22V119000 (ENGINE AND ENGINE COOLING); however, the parts to do the recall repairs were unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue but offered no assistance. The failure mileage was 124,000.

I brought the car into BMW Manhattan after receiving the recall letter. They have refused to perfom the correction based on the fact that I had to replace the engine dues to a engine defect that cracked the number 6 cylinder in the original engine. I am confident BMW has the abilty to check the engine number and see that it requires the recall. They only stated it wasnt the original engine so they did not perform the work required by ther recall.

The contact owns a 2010 BMW 528I. The contact received notification of NHTSA Campaign Number: 23V707000 (Engine and Engine Cooling) however, the part to do the recall repair was not yet available. The local dealer was contacted and confirmed that the parts were not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact stated while driving at an undisclosed speed, the vehicle stall and jerked while coming to a stop. The check engine warning light was illuminated. The failure mileage was approximately 178,000. VIN tool confirms parts not available.

The contact owns a 2010 BMW 528I. The contact received notification of NHTSA Campaign Number: 23V707000 (Engine and Engine Cooling) however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.

The contact owns a 2010 BMW 528I. The contact received notification of NHTSA Campaign Number: 23V707000 (Engine and Engine Cooling) however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact stated that while driving at an undisclosed speed, the vehicle lost motive power. The vehicle was taken to a local dealer, where it was diagnosed that the VANOS bolts needed to be replaced. The vehicle was not repaired. The dealer was made aware of the failure but confirmed that parts were not yet available. The manufacturer was made aware of the failure. The failure mileage was approximately 160,000. VIN tool confirms parts not available.

Camshaft over retarded. Stalled while driving.

Bolts on the backside of the camshaft adjusters broke off and went into the engine.

The contact owns a 2010 BMW 528I. The contact stated that while driving at approximately 45 MPH, the vehicle stalled. The driver was able to coast off the roadway. While at a stop, the vehicle stalled upon acceleration. Upon starting the vehicle, the vehicle started to shake. There were no warning lights illuminated. The vehicle was taken to an independent mechanic, and the contact was referred to the local dealer. The contact received notification of NHTSA Campaign Number: 23V707000 (Engine and Engine Cooling) however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. VIN tool confirms parts not available. The approximate failure mileage was 100,000.

The contact owns a 2010 BMW 528I. The contact stated that upon starting the vehicle, there was an abnormal knocking sound coming from the vehicle. There were no warning lights illuminated. The contact continued driving at an unknown speed and then parked and had the vehicle towed to the residence. The vehicle was then towed to the local dealer, where it was diagnosed and determined that the engine needed to be replaced. The contact was informed that there was debris in the filter. The vehicle was not repaired. The manufacturer was contacted, but no assistance was provided. The failure mileage was approximately 132,553. The contact stated when he took his wife’s car for an oil service at the BMW dealership he was told that there was a VANOS Unit recall much to his surprise. However the VANOS Unit recall did not include all 2010 528i BMW’s. The contact is requesting this vehicle to be included in the recall.

The contact owns a 2010 BMW 528I. The contact received notification of NHTSA Campaign Number: 22V119000 (Engine and Engine Cooling) however, the part to do the recall repair was not yet available. The dealer was made aware of the issue and confirmed that parts were not yet available. The manufacturer was made aware of the issue. The contact stated that while driving at various speeds, an abnormal whistling sound was coming from the vehicle. The contact stated that the RPM was fluctuating. There was no warning light illuminated. The contact stated the vehicle started vibrating as if it was going to stall. There was no warning light illuminated. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The failure mileage was approximately 90,000. VIN tool confirms parts not available.

The contact owns a 2010 BMW 528I. The contact stated that the vehicle was experiencing rough starts and the failure persisted while driving. The vehicle was taken to the dealer where it was diagnosed that the motor mounts had collapsed and needed to be replaced. Additionally, the oil pan gasket was leaking and needed to be replaced. The contact was also informed that the fuel sending unit needed to be replaced due to a fuel leak. The parts were replaced; however, upon replacing the oil pan gasket, the dealer noticed fragments of vanos adjuster units bolts used to fasten the intake and exhaust camshaft inside the oil pan. The dealer informed the contact that the cylinder head cover needed to be taken apart to verify whether the motor mounts were fractured. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 132,000. Manufacturer Safety recall issued NHTSA #22V-119 Recall #22V-119:407 POSITIVE CRANKCASE VENTILATION (PCV) VALVE HEATER Status: Remedy Available

The contact owns a 2010 BMW 528i. The contact received notification of NHTSA Campaign Number: 22V119000 (Engine and Engine Cooling) however, the part to do the recall repair was unavailable. The contact stated that while driving at various speeds, a fuel odor began to emit from the vehicle without warning. Upon inspection, the contact discovered that a grayish smoke had emitted from the rear valve cover. The contact then had the had the vehicle towed to the dealer and was informed that the PCV valve was normal; however, the valve cover gasket was defective and needed to be replaced. The manufacturer had yet to be notified of the failure. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The vehicle had yet to be repaired. The failure mileage was approximately 170,000. VIN tool confirms parts not available.

The contact owns a 2010 BMW 528i. The contact stated upon starting the vehicle, she smelled a burning odor and there was smoke coming from underneath the hood and through the vent. The (!) malfunction indicator warning light illuminated. The contact continued to drive the vehicle. Additionally, the contact stated that the vehicle would jerk intermittently while driving. The contact received recall notification of NHTSA Campaign Number: 17V683000 (Engine And Engine Cooling), which she associated with the failure. The dealer was not contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the failure. The vehicle was not diagnosed or repaired. The failure mileage was approximately 141,000. VIN tool confirms parts not available.

This recall notice received almost 8 months back. This recall concerns me. I didn’t have any accidents to report but it’s too bad no remedy was given by BMW.

The contact owns a 2010 BMW 528i. The contact received notification of NHTSA Campaign Number: 22V119000 (Engine and Engine Cooling) however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.

The contact owns a 2010 BMW 528I. The contact received notification of NHTSA Campaign Number: 22V119000 (Engine and Engine Cooling) however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount time for the recall repair. The contact stated that while driving at an undisclosed speed, he attempted to operate the heater and noticed a fuel odor inside the vehicle. The contact then stated that smoke was coming from under the hood. There was no warning light illuminated. The vehicle was towed to the dealer but was not diagnosed. The contact was informed that parts were not available for the recall repair. The manufacturer was not notified of the failure. The contact stated that he noticed a fuel odor throughout the vehicle. The failure mileage was approximately 100,000. VIN tool confirms parts not available.

The contact owns a 2010 BMW 528I. The contact received notification of NHTSA Campaign Number: 22V119000 (Engine and Engine Cooling). The contact stated that after she scheduled an appointment at the local dealer, she was later made aware that parts were not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure. Parts distribution disconnect.

The contact owns a 2010 BMW 528I. The contact received notification of NHTSA Campaign Number: 22V119000 (Engine and Engine Cooling) however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.

On 11/10/21 I was advised by Long Beach BMW (Long Beach, CA) that my car needs a new engine. The car smells of gas (both when running and when sitting) and burns excessive amounts of oil. The car requires a quart of oil every 200 - 400 miles. The first engine was replaced after only 77,000 miles because the car was stalling unexpectedly. Now, the current engine needs to be replaced after only 51,000 miles because the car smells of gas (likely because the fuel injection system is not working properly) and because it is burning excessive amounts of oil. BMW expects me to cover the cost of a new engine even thought there is an obvious defect. I contacted BMW of North America and they offered to take the car back & give me $2000 toward a new car. There is currently a recall because of engines at risk of blowing up but for some reason, my car does not appear to be part of that recall. https://abcnews.go.com/amp/US/wireStory/bmw-recalls-vehicles-3rd-time-due-engine-fire-83338862 BMW has been notified of the defects with this car and has diagnosed the defective engine but refuses to replace the engine at their cost as part of the current recall. Instead, the car remains a hazard at risk of catching fire. BMW's negligence is placing me, my family & other travelers at risk of harm or death because they know of the problem & will not address it. This is the 2nd complaint that I've sent to the NHTSA (the first on 9/13/21) and now there is a recall & so the NHTSA is aware of the problem as well.