2010 BMW 5 Series Fuel System Problems

Consistent fuel pump error code 2AAF

The car smells like gas by the rear wheels. In speaking with other owners of this vehicle this is a defective flaw in the vehicle it is a known problem in this vehicle and there has been no recall. This is a serious concern as gasoline is highly flammable. I have had to spend thousands of dollars fixing problems with this car and I cannot afford to fix this issue. This is a major concern. Please advise a fix ASAP

The contact owns a 2010 BMW 528I. The contact stated that while driving at an undisclosed speed, the check engine warning light illuminated and flashed. The vehicle was towed to the dealer where it was diagnosed that fuel was leaking form the engine. The contact was unaware of what part needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure. The failure mileage was unknown.

The contact owns a 2010 BMW 550i Gran Turismo. The contact stated that while driving at an undisclosed speed, there was a fuel odor detected inside the vehicle. The vehicle was taken to an independent mechanic for a smog test but failed the smog test after the fuel odor was detected. The vehicle was taken to the dealer and diagnosed as a fuel leak at the connection on the high line to injectors on bank 2. The vehicle was not repaired and remained at the dealer. The manufacturer was made aware of the failure and referred the contact to take the vehicle to a dealer for diagnosis. The contact related the failure to NHTSA Campaign Number: 16V746000 (Fuel System, Gasoline). The failure mileage was 122,515.

TL* THE CONTACT OWNS A 2010 BMW 535I. THE CONTACT STATED WHILE DRIVING APPROXIMATELY 20-25 MPH, THE VEHICLE LOSS MOTIVE POWER. THE CONTACT COASTED AND MANUALLY STEERED THE VEHICLE TO THE SIDE OF THE ROADWAY. THE CONTACT STATED THAT THE FUEL PUMP WARNING LIGHT WAS ILLUMINATED. THE CONTACT HAD THE VEHICLE TOWED TO RALLYE BMW (1 BRUSH HOLLOW RD, WESTBURY, NY 11590, (516) 226-7947) WHO HAD REPLACED AN UNKNOWN PART HOWEVER, APPROXIMATELY A WEEK LATER THE FAILURE RECURRED WITH THE SAME WARNING LIGHT ILLUMINATED. THE CONTACT RETURNED THE VEHICLE TO THE SAME DEALER AND THE FUEL PUMP WAS REPLACED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 120,000.

RECEIVING P0087 LOW PRESSURE FUEL, CAR GOES INTO DRIVETRAIN MALFUNCTION. FIX IS REPLACING HIGH PRESSURE FUEL PUMP.

SEVERAL TIMES I WAS PLACED IN PERIL WHILE TRAVELING AT HIGH RATES OF SPEED THEN THE CAR STALLS ON US HIGHWAY 95. THERE WERE ALSO TIMES WHEN THE CAR STALLED WHILE DRIVING LESS THAN 35MPH. WHEN THIS HAPPENS I HAVE NO REAL CONTROL TO STEER THE WHEEL, NO PRIOR WARNING OR ISSUES WITH THE CAR TO INDICATE IT WOULD STALL. IT IS EXTREMELY TRAUMATIZING. TRAUMATIZING! MESSAGE OF "FUEL PUMP MALFUNCTION. MODERATE DRIVING POSSIBLE". CAR STALLS WHILE IN MOTION WHETHER IT IS 20MPH OR 65MPH. INITIAL MALFUNCTION IN JULY WAS AFTER 1HR OF DRIVING THEN SEVERAL TIMES AFTER THAT PERIODICALLY AS THE CAR ISN'T DRIVEN OFTEN DUE TO STAY AT HOME RESTRICTIONS. THE ISSUE COULD NOT BE DUPLICATED AT TWO AUTO MECHANIC SHOPS, IN FACT BY THE TIME THE TOW TRUCK ARRIVED, THE CAR STARTED AND WAS ABLE TO BE DRIVEN ONTO THE TRUCK. THERE IS NO PATTERN OF DRIVING BEHAVIOR OR MESSAGES BETWEEN FAILURE / STALL AND AS MONTHS WENT ON, THE TIME BETWEEN STALL AND INABILITY TO START THE CAR SHORTENED FROM DRIVING1HR TO DRIVING 10 MINUTES. BMW OF THE MAIN LINE REPLACED THE FUEL PUMP, FUEL FILTER AND STALL AND ERROR ISSUE REMAINS. WIRING TO FUEL PUMP ISSUE POSSIBLE. THERE ARE SEVERAL OPEN COMPLAINTS ON THE EXACT SAME ISSUE. MODEL YEAR 2010 SHOULD BE INCLUDED IN THE RECALL FOR 535I XDRIVE HTTPS://WWW.NHTSA.GOV/VEHICLE/2010/BMW/5%252520 SERIES/4%252520DR/RWD%25252F4WD#COMPLAINTS HTTPS://WWW.NHTSA.GOV/VEHICLE/2010/BMW/5%252520SERIES/4%252520DR/RWD%25252F4WD#COMPLAINTS WIRING ISSUE DETECTED AND MAY BE PART OF THE RECALL NHTSA RECALL NO. : 16V-746. IF THE FUEL PUMP BECOMES INOPERATIVE, A NO-START CONDITION OR, IN RARE CASES, A STALLING CONDITION WITHOUT THE ABILITY TO RESTART THE VEHICLE COULD OCCUR. STARTED JULY AND DEGRADED SEPTEMBER, OCTOBER, NOVEMBER THEN FINALLY DECEMBER. $$$$ IN REPAIR COSTS THAT DID NOT RESOLVE THE "FUEL PUMP MALFUNCTION. MODERATE DRIVING POSSIBLE" MESSAGE. HELP

WHEN STARING UP, EXTENDED CRANK/SLOW STARTUP . CONTACTED BMW 'FUEL PUMP ISSUE'. NOT COVERED ON CURRENT RECALLS BECAUSE OF YEAR OF CAR. ALL OTHER 5 SERIES HAVE AN OPEN RECALL FOR THE SAME PROBLEM

WAS DRIVING DOWN THE ROAD AND WAS PASSING A VEHICLE AND AS I WAS GETTING PAST OTHER DRIVER MY ONBOARD DASH POPPED UP SAYING CAR NEEDED TO GET SERVICED. DESCRIPTION OF FAULT WAS FUEL PUMP. ALL POWER WAS LOST AND WAS BARELY ABLE TO GET PAST OTHER MOTORIST TO GET TO THE SHOULDER. ONCE I SAT FOR ABOUT 20 MIN WAS ABLE TO RESTART VEHICLE AND GET TO MY DESTINATION 8 MILES DOWN THE ROAD. THIS MADE ME FEEL VERY U SAFE AND COULD HAVE CAUSED AN ACCIDENT WITH THE OTHER MOTORIST. I WAS ON A 2 LANES STATE ROAD WHEN THIS HAPPENED. THERE WAS ALSO ANOTHER VEHICLE BEHIND THE MOTORIST I WAS PASSING TO OVER TAKE. *TR

WHILE DRIVING STEADILY ON THE INTERSTATE (I494 IN BLOOMINGTON, MN) WITH TRAFFIC AT ROUGHLY 65MPH, I RECEIVED A MESSAGE ON THE DASH OF FUEL PUMP FAILURE, DRIVE SLOWLY. CAR PROCEEDED TO GO INTO 'LIMP MODE' WITH REDUCED POWER AND THEN STALLED OUT'GAVE ME JUST ENOUGH TIME TO NAVIGATE TO A RELATIVELY SAFER SPOT ON THE SHOULDER OF THE INTERSTATE. TRIED TO RESTART CAR, BUT IT WOULD STRUGGLE AND THEN FAIL EACH TIME.

FUEL PUMP RANDOMLY CAUSES ENGINE FAILURE DURING NORMAL DRIVING CONDITIONS CAUSING IT TO MALFUNCTION, STALL ENGINE, AND ENDANGER THE CARS OCCUPANTS SAFTEY IN NORMAL TO HEAVY TRAFFIC CONDITIONS. THE FUEL PUMP WILL RESET ITSELF AFTER 5-10 MINUTES AND THE CAR WILL START AGAIN ALLOWING IT TO THEN SAFELY EXIT THE ROADWAY.. THIS ISSUE IS RANDOM IN OCCURANCE. IT COULD HAPPEN TWICE IN ONE DAY, OR IT COULD HAPPEN ONLY TWICE IN ONE MONTH.

HIGH PRESSURE FUEL PUMP FAILED. THIS PART HAS BEEN HIGHLY PUBLICIZED AS FAULTY. INCLUDING RECALLS AND EXTENDED WARRANTEES. THE FAILURE AT HIGH SPEEDS CAUSED STALLING AND WAS VERY DANGEROUS. BMW FAILED TO REPLACE FOR FREE THE HIGH PRESSURE FUEL PUMP AND CHARGED ME FULL PRICE. FAILURE TO HONOR RECALL/WARRANTY. IT HAS BEEN NOTED 150,000 PLUS VEHICLES ARE AFFECTED. THIS NEEDS TO BE A MANDATORY RECALL AND PAID IN FULL BY BMW. SEEKING INVESTIGATION AND REIMBURSEMENT. I HAVE THE INVOICE IF NEEDED.

TL* THE CONTACT OWNS A 2010 BMW 535I. THE CONTACT STATED THAT WHILE DRIVING AT AN UNKNOWN SPEED, THE VEHICLE STALLED WITHOUT WARNING. THE CONTACT ATTEMPTED TO RESTART THE VEHICLE WHILE IN TRAFFIC BUT IT FAILED TO START. THE VEHICLE WAS TOWED TO THE CONTACT'S RESIDENCE. ON ANOTHER OCCASION, THE CONTACT STATED THAT THE PASSENGER REAR SIDE OF THE VEHICLE DROPPED CLOSER TO THE ROAD AND WAS DRAGGING WHILE DRIVING. THE CONTACT COASTED OVER TO THE SIDE OF THE ROAD BUT DID NOT NOTICE WHAT CAUSED THE FAILURE. THE CONTACT DROVE THE VEHICLE TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE HYDRAULIC DETACHED AND NEEDED TO BE REPLACED. THE VEHICLE WAS TAKEN TO NALLEY BMW OF DECATUR DEALER, LOCATED AT 1606 CHURCH ST, DECATUR, GA 30033, (404) 994-4329, FOR THE STALLING FAILURE AND IT WAS INFORMED THAT THE FUEL PUMP NEEDED TO BE REPLACED. THE VIN WAS INCLUDED IN NHTSA CAMPAIGN NUMBER: 16V746000 (FUEL SYSTEM, GASOLINE). THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 110,000.

BMW EXTENDED WARRANTY TO 10 YEARS FOR THE INJECTORS. VEHICLE EXPERIENCED INJECTOR PROBLEMS SEVERELY IMPACTING ACCELERATION AND FAILING TEXAS EMISSIONS TESTING. BMW THEN DENIED REIMBURSEMENT. THIS ISSUE IS A SERIOUS SAFETY PROBLEM AND A RECALL SHOULD HAVE BEEN IMPLEMENTED.

THE BMW 535I THAT I HAVE HAS HAD MANY PROBLEMS WITH THE FUEL SYSTEM. ALL PUMPS HAVE BEEN REPLACED AND STILL THE CAR WILL STOP RUNNING AT ANY TIME. IT HAS HAPPENED AT DIFFERENT SPEEDS AND HAS CAUSED ME TO GET OFF THE ROAD AND GET THE CAR TOWED. I HAVE SPENT SO FAR OVER 6,000 DOLLARS ON PUMPS . NOW THE CAR IS BACK IN THE SHOP AND I AM TOLD THAT I AM STARING AT ANOTHER BIG BILL. THIS HAS BEEN AN ON GOING PROBLEM FOR ABOUT A YEAR AND A HALF. BMW HAS GIVEN ME ONE EXCUSE AFTER THE OTHER. THIS IS VERY DANGEROUS BECAUSE IT HAS HAPPENED TO ME IN TRAFFIC AT SPEED. BEEN LUCKY NOT TO CRASH THE CAR.

CAR STALLS AT HIGH SPEED, FUEL PUMP WARNINGS LIGHT COMES ON. CAR WILL RESET AFTER 30 MINS BUT WILL CONTINUE TO SHUT OFF DURING DRIVING. BOTH FUEL PUMPS HAVE BEEN REPLACED

WHILE TRAVELING IN THE MIDST OF TRAFFIC ON BUSY ROADWAY THE FUEL PUMP STOPPED OPERATING(ON-BOARD COMPUTER DISPLAY). I RECEIVED A MESSAGE INDICATING THE VEHICLE WOULD CONTINUE TO OPERATE BUT SHOULD BE CHECKED. I MANAGED TO STEER THE VEHICLE FROM THE MAIN ROADWAY BEFORE THE POWER STEERING CEASED TO OPERATE. THIS IS THE THIRD INCIDENT IN WHICH THE FUEL PUMP FAILURE OCCURRED. A PREVIOUS REPOST WAS MADE TO THE NHTSA #(10938620). A SAFETY RECALL WAS ACTIVATED FOR SEVERAL VEHICLE WITH THE SAME HIGH PRESSURE FUEL PUMP, BUT MY VIN IS NOT LISTED IN THE DATABASE. I FEAR FOR MY LIFE AND FOR THE LIVES OF OTHERS THAT COULD BE LINKED TO THE POTENTIAL TRAGEDY THAT MAY OCCUR. TODAY MY VEHICLE WAS TOWED TO A BMW SERVICE CENTER FOR ASSESSMENT. OF COURSE THE WARRANTY HAS EXPIRED AND I AM WAITING FOR AN OUTCOME AND FEEL VULNERABLE. I FEAR THAT I WILL BE STUCK WITH THE EXCESSIVE EXPENSE OF RESOLVING THE ISSUE OR THE RISK OF LOSING MY LIFE. *TR

TWO TIMES IN THE PAST FIVE DAYS MY 2010 BMW 535XI HAS SHUT DOWN. EACH TIME IT HAS MALFUNCTIONED(12/24/16 AND 12/29/16), THE AUTOMATIC DOWNSHIFT ACTIVATED). ONCE WHILE TRAVELING UP A HILL AT APPROXIMATELY 35 MILES PER HOUR AND ONCE WHILE TRAVELING IN EXCESS OF 55 MILES PER HOUR ON A VERY BUSY HIGHWAY. I WAS NOT ABLE TO RESTART THE VEHICLE AND HAD THE VEHICLE TOLLED TO A LOCAL GARAGE. SHORTLY AFTER ARRIVING THE TOW OPERATOR STARTED THE VEHICLE. IT STARTED WITHOUT HESITATION A SECOND TIME. I LEFT THE VEHICLE AT THE REPAIR SHOP AND PICKED IT UP FOUR DAYS LATER. IT HAS STARTED AND OPERATED AS BEFORE UNTIL DAY FIVE WHEN I WAS TRAVELING UPHILL AND IT INITIATED A DOWNSHIFT AND STOPPED OPERATING. EACH TIME THE FUEL PUMP FAILURE INDICATOR CAME ON. IT IS A SCARY FEELING, ESPECIALLY SINCE EACH TIME I WAS IN THE MIDST OF OTHER VEHICLES. *TR

16V-746 RECALL CAMPAIGN NO. BMW DOESN'T WANT TO REPLACE FUEL TANK PUMP, JUST EXTEND THE WARRANTY.

I RECEIVED A LETTER IN EARLY DECEMBER ABOUT A RECALL, HOWEVER 6 MONTHS LATER, NO OTHER INFORMATION PROVIDED.