2015 BMW X3 Complaint Log

The contact owns a 2015 BMW X3. The contact stated that while driving at an undisclosed speed, the vehicle stalled. The check engine warning light was illuminated, and the "Service Engine Soon" message was displayed on the instrument panel. The vehicle was taken back to the residence. The dealer was contacted; however, the vehicle was not diagnosed or repaired. The manufacturer was notified of the failure. The failure mileage was approximately 140,000.

BMW illegally stopped updating my car which relies totally on it’s OS system in its iDrive. You used to be able to download them to a usb stick. 1 year newer cars can remotely still download the updates. This is dangerous and needs to be addressed. It is also biased and runs my entire car. The download should still be available for free. There was a technical report but BMW doesn’t honor that.

High pressure fuel pump Stalling almost caused an accident Yes the problem has been confirmed by BMW BMW has inspected the component Check engine light and drivetrain errors BMW replaced a high pressure fuel pump and fuel system in 2019, see attachment. I was not notifies of the 2021 BMW recall for the high pressure fuel pump. The high pressure fuel pump fail in 2025, see attachment at around 60,000 on the replaced high pressure fuel pump in 2019, less than the original fuel pump. BMW now says they are not going to repair this because of the age and mileage on the car. My position is the mileage on the car is irrelevant. It’s the mileage on the fuel system replaced in 2019. In addition, I was not notified of the recall in 2021and now the question is “ is the high pressure fuel pump replaced in 2019 the same fuel pump replacement part that came with the car when new? Obliviously the 2021 recall may have upgraded the fuel pump to satisfy the recall. If so, that should have been put into my car in 2021. BMW has been very deceiving on answering my questions.

The contact owns a 2015 BMW X3. The vehicle was repaired under NHTSA Campaign Number: 24V608000 (ENGINE AND ENGINE COOLING, ELECTRICAL SYSTEM). The contact stated that on a separate occasion, the vehicle was taken to an independent mechanic for maintenance, and the contact was informed that the water pump had failed. The contact showed the independent mechanic the receipt for when the vehicle was repaired under the recall for the water pump. The contact was informed that the water pump was not replaced. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was 71,245.

Engine over heating alert issued and to pull over immediately. We had car towed to bmw dealership who stated it is water pump issue. This is a known issue for this make and model but recall not in effect for our vin. We are having the same issues as stated in recall for water pumps and temperature control issues. Just because our vin number is not associated with this recall they will not repair this issue unless we pay out of pocket. This is a known issue for our make and model of car and should be a covered expense by bmw. I have attached a link to the recall issues. Please review and respond accordingly. Thank you!

Our vehicle alerted us to over heating and to pull over immediately. Our car then stopped running. We had it towed and was told there was an issue with the water pump sensor and corrosion issues. They alerted us that there was a recall for these issues on our vehicle. We researched and found this to be true. When I contacted BMW they stated our vin number was not part of the recall but our vehicle match the exact models listed in the recall. We took it to the dealership and they repaired it for $2500 and the reason for the repair was the exact reason for the recall. Spoke with BMW again regarding this and they said if our vin was not on the recall list there was nothing they could do. I would think when your vehicle make and model matches the recall and the issues are the same you would be part of the recall no matter the vin number. I would like for this to be reviewed and see if we can get a reimbursement from bmw for the charges we paid out of pocket for an issue that should have been covered by the recall. The recall form attached is one my friend received who has the exact same car we have. The other documents are the service invoice and verification of our payment. Thank you!

My from passenger seatbelt will always beep even when no one is sitting in it and the back middle seat has the wrong seatbelt installed and isn’t correct for use, so I am not able to ever use it, I don’t even know how that’s even possible that it’s an incorrect one installed but it won’t click into place at al!!!!! It’s jot safe of I have three passengers in the back. It was on recall for certain models and mine was not included but it’s clearly a safety issue!!!

The contact owns a 2015 BMW X3. The contact received notification of NHTSA Campaign Number: 24V608000 (ENGINE AND ENGINE COOLING, ELECTRICAL SYSTEM); however, the part to do the recall repair was not yet available. The local dealer was contacted and confirmed that the part was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced the failure. VIN tool confirms parts not available.

The contact owns a 2015 BMW X3. The contact stated while driving 40-50 MPH, the check engine warning light illuminated and the message "Engine Overheated -Stop Vehicle Immediately" was displayed. The contact parked and turned off the vehicle. The vehicle was later restarted, but the message "Engine Overheated Stop - Vehicle Immediately" was displayed again. The contact stated that the vehicle stalled while driving. The vehicle was taken to an independent mechanic, who determined that the water pump had overheated and needed to be replaced. The vehicle was then towed to the dealer, who also determined that the water pump needed to be replaced. The vehicle was not repaired. The contact related the failure to NHTSA Campaign Number: 24V608000 (Engine and Engine Cooling, Electrical System); however, the VIN was not included in the recall. The manufacturer was made aware of the failure and advised the contact to file a complaint with the NHTSA Hotline. The failure mileage was approximately 63,000.

The contact owns a 2015 BMW X3. The contact received notification of NHTSA Campaign Number: 24V608000 (ENGINE AND ENGINE COOLING, ELECTRICAL SYSTEM); however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The dealer was made aware of the issue. The manufacturer was not made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.

The contact owns a 2015 BMW X3. The contact received notification of the NHTSA Campaign to Number: 24V608000 (Engine and Engine Cooling, Electrical System); however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The dealer was contacted and confirmed that parts were not yet available. The manufacturer was not made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.

Vehicle was driving when it stalled while driving. The vehicle would not start after that. After having a mechanic look at the vehicle it was found the high pressure fuel pump failed causing extensive damage to the fuel system and a repair quote of $15,000. Even though vehicles manufacturered in the same model year had a recall for this issue my vin number did not receive the recall. The recall number for the recall I'm referencing is 21V586000. BMW denies any recall for my vehicle and will not cover repairs.

The vehicle was driven 30 miles and parked at 9am weather was in the 30s-40s F. There were no check engine light, warning lights or abnormal readings on the gauges during the commute. At approximately noon, the vehicles was started and idled for approximately 20 min, it was not driven or moved from the parking spot, the car did not reach full operating temp. Smoke with a burnt plastic and electrical odor was noted emanating from under the hood while parked idling. The car was immediately shut off and exited. The driver went inside to get help. After returning to the vehicle in approximately 5minutes it was fully engulfed in flames. The fire department came to put out the fire. The vehicle is a total loss. The fire damaged adjoining vehicles and the property where it was parked. The vehicle was towed back to my residence where it remains for evidence. Upon review of BMW recall 24v-608 i performed an inspection of the water pump electrical connection plug and identified there is evidence of an electrical short on the plug which appears to have burnt through the connector prior to the major engine compartment fire. I have contacted BMW to file a complain and have followed up multiple times with the point of contact identified to me by BMW, but have been unsuccessful to date to establish communications with the BMW representative.

The contact owns a 2015 BMW X3. The contact stated while driving on the interstate at an undisclosed speed and attempting to make a right turn onto the exit, the transmission unexpectedly shifted into neutral, and the vehicle shut off unintendedly. The vehicle was towed to a dealer where it was diagnosed and determined the fuel pump control module (EKPS) needed to be replaced. The manufacturer was notified of the failure and informed the contact that there was no recall on the VIN for the failure. The failure mileage was 180,000.

I was driving on the interstate [XXX] when the car (2015 x3 BMW xDrive28d) went into neutral out of nowhere and the car completely stopped and never came back on. I was just about to get off of the next exit and did not make it I was stuck in the middle of the interstate scared no one would pull over to help me it was dark when all of this was taking place cars were speeding and would come up on the car at the last minute to go around almost causing a accident once they realized the car wouldn’t start. When trying to see if the car would turn back on it wouldn’t things came up on the screen saying power train along with the check engine light and some smoke was coming from underneath the hood it was also saying battery not charging. I had to wait 2hrs for a tow truck to get the car back to my house and the police never came. On [XXX] I then had the car towed to bmw dealership (Bmw of Bloomfield) in New Jersey where the vehicle is currently at they have told me it was a fuel pump issue. This has never happened to me before until the night of [XXX]. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The contact owns a 2015 BMW X3. The contact received notification of NHTSA Campaign Number: 24V608000 (Engine and Engine Cooling, Electrical System); however, the part to do the recall repair was not yet available. The contact stated that while the vehicle was parked in the driveway, the contact noticed a coolant leak on the floor. The local dealer was not contacted. The vehicle was not diagnosed or repaired. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the failure. The failure mileage was approximately 125,000. VIN tool confirms parts not available.

Vehicle was idle in the driveway next to my home and had not been driven since the night before. That morning, I started to smell what I thought was an electronic overheat of some sort in the house. When I inspected outside, the entire front end of the vehicle was on fire and the fire department needed to respond. The fire spread rapidly along the side of my home causing significant damage to my property as well as my neighbor's property. Our safety was put at risk because this fire could have occurred overnight while my wife, children and I were sleeping since the vehicle was not being operated at the time the fire happened. Representatives from my insurance company removed the vehicle and had it inspected at their facility, where they determined the vehicle to be a total loss as the entire front half of the car burned. Further, I did not receive notice of the known recall on my vehicle (with no know remedy as yet) which could be the cause of the fire, until a week after the incident occurred in October.

I received a recall notice from BMW in October 2024 for Recall 24V-608 involving a water pump electrical connector defect in my vehicle. According to the notice, this defect may cause liquid to drip onto the water pump’s electrical connector, potentially leading to a short circuit and, in rare cases, a fire. As of June 2025, nearly eight months later, there is still no remedy available. I have contacted BMW, and although they acknowledge the risk, they have not offered a loaner vehicle or any alternative despite the known fire hazard. I am concerned for my safety and do not feel comfortable continuing to drive a vehicle with a known, unresolved safety defect. I am submitting this complaint because I believe this delay is unreasonable and puts drivers at risk. The vehicle is currently operational, but the issue has not been fixed or properly addressed.

The contact owns a 2015 BMW X3. The contact received notification of NHTSA Campaign Number: 24V608000 (Engine and Engine Cooling, Electrical System); however, the part to do the recall repair was not yet available. The local dealer was made aware of the issue and confirmed that parts were not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.

The contact owns a 2015 BMW X3. The contact was notified of NHTSA Campaign Number: 24V608000 (Engine and Engine Cooling, Electrical System); however, the part to do the recall repair was not yet available. The local dealer was made aware of the issue and confirmed that parts were not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.

The contact owns a 2015 BMW X3. The contact received notification of NHTSA Campaign Number: 24V608000 (Engine and Engine Cooling, Electrical System); however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact stated that while driving at approximately 30 MPH, there was a burning odor coming through the vents on the dashboard. The contact stated that she had not observed any warning lights being illuminated. The contact stated that the odor was intermittent but had been occurring for almost 4 months. The contact had stopped driving the vehicle out of concern that the vehicle might catch on fire. The dealer and the manufacturer were contacted. The contact was advised by the dealer that a second letter would be sent when parts were available for the recall repair. The failure mileage was approximately 50,000. VIN tool confirms parts not available.

The contact owns a 2015 BMW X3. The contact stated that while operating the vehicle, the engine overheated, and the messages "Low Coolant" and "Service Engine" were displayed. Upon inspection, the contact identified a damaged coolant hose causing coolant to leak onto several electrical wires within the engine compartment. The cause of the failure was not yet determined. The local dealer was notified of the failure. The manufacturer was not yet contacted. The failure mileage was 120,000.

The contact owns a 2015 BMW X3. The contact received notification of NHTSA Campaign Number: 24V608000 (Engine and Engine Cooling, Electrical System); however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. Additionally, the contact stated that the high-beam headlights failed to operate as needed; however, the vehicle was not diagnosed by the dealer. The vehicle was not repaired. The failure mileage was 18,000. VIN tool confirms parts not available.

Intermittent, but frequent failure of seat occupancy sensor on front passenger seat. Appears to be related to occupancy weight sensor. As sensor is not functioning properly, passenger airbag is being unsafely deactivated, leading to lack of airbag deployment if a front end collision were to occur. Problem is reproducible, but has not been taken to dealer, nor has it been inspected. Warning alert displays, then turns off, then returns frequently while the front passenger seat is occupied.

Fuel pump failed, leading to overheating notice, leading to engine cutting out while driving. I was on one lane road 50 MPH speed limit and able to drift to side of road at around 10-15mph, but if I was on freeway and engine cut and had to get to side of road at 10-15mph it would have been extremely dangerous. Car towed to BMW dealership, replaced water pump, but since 2015 x3 35i not subject to recall , paid out of pocket.

The contact owns a 2015 BMW X3. The contact received notification of NHTSA Campaign Number: 24V608000 (Engine and Engine Cooling, Electrical System); however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact stated there was an abnormal burning odor coming from the engine compartment. There were no warning lights illuminated. The dealer was contacted. The manufacturer was made aware of the issue. The manufacturer referred the contact to the NHTSA Hotline to report the failure. The failure mileage was 120,000. VIN tool confirms parts not available.

On 07/06/2024, I turned on my car and hear a loud ticking noise that ticked faster or slower when I tried to accelerate or decelerate the car. I turned the car off and towed it to a AAA mechanic. They reported my engine was damaged and I’ll need a new engine. I towed it to a second mechanic for a second opinion, at Jindal-Andre Automotive/Yellow Cab and the reported engine rod bearings failure on my BMW that has only 86,880 miles.

I am writing to formally report a serious and dangerous safety defect affecting my 2015 BMW X3, which I believe warrants immediate investigation and a recall. Description of the Defect: On multiple occasions, while driving in rainy or wet road conditions, my BMW X3 has suddenly and forcefully reduced speed without any brake pedal input from the driver. The vehicle appears to apply braking on its own, causing abrupt deceleration. This behavior occurs: On wet roads only, while driving straight at steady speed without warning lights or alerts, without driver input and at speeds that pose a high risk of rear-end collision. The sudden and unexpected braking has created an imminent danger to myself, my passengers, and surrounding vehicles, particularly on highways where traffic flow is fast and close. Uncommanded braking under normal driving conditions is a critical safety failure. A driver has no reasonable opportunity to anticipate or correct this behavior, and it places the vehicle at significant risk of being struck from behind. Given the seriousness of this issue, I have requested that BMW: Formally investigate this defect across 2015 BMW X3 (F25) vehicles Determine whether a systemic fault exists involving DSC, ABS, wheel speed sensors, or collision mitigation systems in wet conditions. Issue a recall or safety service action to permanently correct this behavior in order to provide affected owners with a reliable and documented fix. Reason for which I wanted to bring this situation to the NHTSA.GOV attention.

The contact owns a 2015 BMW X3. The contact stated that while driving at an undisclosed speed, the vehicle stalled. The vehicle was towed to an independent mechanic where it was diagnosed with engine failure. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 153,000.

A low oil pressure signal flashed after regular service and my engine died as a result. No warning just died after years of regular service

This is a very common malfunction happening with this motor/fuel injection system. N47T/N57T DIESEL FUEL INJECTORS: LTD WTY EXTENSION TO 10 YEARS/120,000 MILES. The vehicles listed have the same engine as mine, yet my specific model is not listed. Please can I have a letter explaining to the dealership that this is a faulty fuel injector and the warranty extension should cover my vehicle as well. SI B01 09 19 (DC 13 53 90 06 00)

I continue to get airbag warning light and front passenger seat occupant detection malfunction. I was told by local mechanic that ACSM fault codes are 930A60 and 930A1C.

The contact's mother owns a 2015 BMW X3. The contact stated while his mother was driving 40 MPH, the check engine warning light illuminated. The owner took the vehicle to the local dealer, where it was diagnosed with needing the diesel fuel injector to be replaced. The vehicle was not repaired. The manufacturer had been informed of the failure. The failure mileage was approximately 102,000.

Yesterday I was driving on the highway and in the fast lane, with only a break down lane off of the slow lane, the car just shut off. I was extremely lucky that I was able to coast over to the slow lane and then to the break down lane. I could have caused an accident or been hurt myself traveling at high speeds and the car just shutting off. I had the vehicle towed and was told the timing chain broke. This is a known issue and a class action lawsuit was filed against BMW and they settled outside of court. BMW has failed to admit they made a mistake when designing my vehicle and others like it that use the same engine and features. They have refused to admit this should be a recall. The timing chain is inside the engine and is very labor intensive for to be replaced or if it can be at all. There are so many BMW owners that have had this problem that it is known, the timing chain can be replaced before it breaks but once it breaks the entire engine has to be replaced. The only warning light I had was while it was happening. There was not pre-warning that I should take it to the shop and have it replaced. If there was, I would have had the work done! Now I am left with a totaled vehicle that isn't covered by insurance and BMW won't back their product and help in any way. I called BMW North America and several BMW dealerships, no one is willing to do anything. They are telling me I have too many miles on the vehicle. I brought the vehicle in to a BMW dealer (with 98k miles) for a noise and that it was shutting off. They said it was the battery. They replaced it and sent me on my way. Never mentioned the lawsuit or bad part. Now the timing belt has broken at 113k miles. BMW is supposed to be known for their longevity but they will not back their product.

2015 BMW X3. CONSUMER WRITES IN REGARD TO BMW DESIGN DEFECTS. THE CONSUMER STATED THE DEALER INFORMED THE REPAIRS FOR THE VEHICLE REQUIRES BUYING A NEW ENGINE. THE CONSUMER STATED THE REPAIRS WERE MADE AT THE OWNERS COST BUT THEY WANT TO BE DISCUSS REIMBURSEMENT FOR REPAIRS.

NHTSA Recall Number 21V907 It has been over a year since I received notification that there was a recall on my vehicle. I have contacted BMW for this to be repaired several times, but the local dealer always says, "We're sorry, there aren't any parts available for your recall." This recall is NOT being performed in a timely manner and based on my interpretation of the recall notice that keeps appearing in my mailbox every few months, my car may burst into flames at any moment. I'm living in fear. Please help.

Drivetrain malfunction light due to bad EGR valve, which is causing car to run rough. Currently there is safety recall out for the EGR cooler. BMW of Bloomfield diagnosed and recommended EGR valve replacement but cost was excessive at over $1,100. Another BMW specialist (G&T in Jersey City) recommended replacement of EGR valve and cooler due to potential hazardous conditions described in safety recall but said I shouldn't have to pay due to safety recall. So I called BMW dealers in Bloomfield and Springfield both say the "remedy is not available". So am I just supposed to drive the car until it catches fire? This seems reckless so my other option is to pay the mechanics to replace the system that is already subject to a recall.

The contact owned a 2015 BMW X3. The contact stated while her husband was driving at 65 MPH with her in the front passenger seat, the vehicle stalled. A message indicating a power train malfunction was displayed. The contact's husband was able to veer to the side of the road. The contact noticed dark smoke coming through the AC vents. The contact stated upon opening the hood, her husband saw fire. The contact immediately exited the vehicle. The contact was able to extinguish the fire with the assistance of the fire department. However, the engine compartment and the front passenger's side end of the vehicle had melted. A fire department was filed. There was no police report filed. There were no injuries sustained. The vehicle was towed to a tow lot where it was totaled. The contact associated the failure with NHTSA Campaign Number: 21V907000 (Fuel System, Diesel). The dealer was notified of the failure and referred the contact to the manufacturer. The manufacturer was notified of the failure but provided no assistance. The failure mileage was approximately 76,000.

Engine light comes on and the code says: error code 24BF00 - Injector #2 "zero-quantity adaptation injector cylinder 1: permitted filtered actuation duration correction too high I found a 10yr/120k extended warranty on N47T diesel injectors https://static.nhtsa.gov/odi/tsbs/20...67976-9999.pdf but the document only lists Sedan and Wagon N47T models, the X3 with same engine is excluded. Would request to extend warranty on DIESEL FUEL INJECTORS for my car as well.

The contact owned a 2015 BMW X3. The contact had received notification of NHTSA Campaign Number: 21V907000 (Fuel System, Diesel). The contact stated that unknown warning lights were intermittently illuminated. The vehicle was taken to a local dealer for the recall repair, and the contact was made aware of additional unknown failures and repairs that were needed. The recall repair was completed, and the vehicle was then traded in. The manufacturer was made aware of the failures. The approximate failure mileage was 96,000.

Problem is that the display says "passenger restraint malfunction" -- which brings safety concern. Upon online search, it is likely caused by design flaw of passenger occupancy detector. Here are some reasons why it is design flaw (i.e. not just individual failure) 1. There has been a recall for the same problem for earlier year models (2006-2007 etc). It seems the other years have the same problem (previous recall wasn't a complete fix) 2. There is actually a third party electrical device online that bypass passenger occupancy detector (so that the car thinks passenger seat is occupied all the time) -- which indicates the commonality of the problem because it even became a profitable market.

The contact owns a 2015 BMW X3. The contact received notification of NHTSA Campaign Number: 21V907000 (Fuel System, Diesel) however, the part to do the recall repair was not yet available. The dealer was made aware of the issue. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact had not experienced a failure. VIN tool confirms parts not available

The contact owns a 2015 BMW X3. The contact received notification of NHTSA Campaign Number: 21V907000 (Fuel System, Diesel) however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue and informed the contact that the part was not yet available. The contact had not experienced a failure. VIN tool confirms parts not available.

The contact owns a 2015 BMW X3. The contact stated that while the family was sitting inside the vehicle with the engine idling, there was smoke coming from underneath the hood. There were no warning lights illuminated. The vehicle was taken to the local dealer and diagnosed with an EGR valve failure. The vehicle was not repaired. The contact stated that the failure was related to NHTSA Campaign Number 21V907000 (Fuel System, Diesel) for which the VIN was included. The manufacturer was notified of the failure. The approximate failure mileage was 69,000. (RECALLRELATED INCIDENT) TS

Front passenger air bag seat occupancy sensor (OC3) mat. The air bag is on for a while "passenger restrain system", nothing really happened it appear one day and never left.

When driving for more than 10 minutes I am noticing smoke coming from the near the engine compartment and strong smell of burning plastic. It smells and appears as if something will catch on fire if I don’t shut off the vehicle. A similar issue was previously reported for older models, which had led to a recall. In that recall the problem stemmed from a manufacturing defect involving the PCV valve heater, which helps recirculate waste gases within the engine. The heater could short-circuit, overheat, and catch fire. This defect is now effecting my own vehicle, which is a 2015 BMW X3.

X3 started locking up the brakes, it seems that every time you pressed the breaks the calipers will engage and would not release them, making the vehicle completely stop or force you to accelerate to move the vehicle forward by force and get out of the moving traffic. No error codes came up at all or warning lights on the dashboard. The only way to resolve the issue was to turn the vehicle off and start again after a few minutes. The same issue occurs if you use the Auto Hold function, the vehicle will automatically engage the emergency breaks and you lose complete control of the vehicle, until the car is turned off to reset. The calipers were replaced and drained the brake fluids as a measure since no error codes were detected. Problem persisted and it got worse, making it very unsafe to continue to drive the vehicle. Fields BMW in Winter Park Florida, confirmed the problem as the DSC Hydro Unit failure, although no error codes or warnings still and shared that they had several BMW's come in with the same issue and no error codes detected. 4K for the part only and in back order in Germany for 2 months. I contacted BMW Corporate to discuss the problem. It seems BMW Corporate is aware of the issues with the Hydro unit in some models, but not on my model, it seems to me that this is not only a major BMW design failure but a safety problem with the vehicle I believe needs to be addressed by the company.

Sunroof exploded and shattered while driving down the highway.

The contact owns a 2015 BMW X3. The contact stated that while operating the vehicle the check engine warning light would remain illuminated. The vehicle was taken to the local dealer who diagnosed that the #3 fuel injector was faulty and needed to be replaced. The vehicle was repaired but approximately 3 weeks later the failure reoccurred and the vehicle was returned to the dealer who diagnosed that the #4 injector was faulty. The vehicle was not yet repaired. The manufacturer was notified of the failure but no assistance was offered. The failure mileage was 58,451. Consumer's vehicle is not listed on the 10year/120k extended warranty, the document list error codes (ODB2) that indicate the injector should be replaced under warranty.

The contact owns a 2015 BMW X3. The contact stated that the driver's side and passenger’s side door handles had melted and was falling apart. The passenger’s side door handle had split down the middle and was peeling. The driver's side door was melted and had detached. There were no warning lights illuminated. The contact called the local dealer and declined to assist. The vehicle was not diagnosed or repaired. The manufacturer was contacted and referred the contact to the NHTSA Hotline. The failure mileage was approximately 52,000.