NHTSA Owner Complaint Log
This page lists owner-reported complaints filed with NHTSA for the 2016 BMW X3. Complaints are unverified consumer reports submitted to NHTSA and do not by themselves prove a defect or defect rate.
Key Details of BMW EGR Recall: • Affected Models: Primarily 2013-2018 BMW 328d/xDrive, 535d/xDrive, 740Ld, X3 xDrive28d, and X5 XDrive35d. • The Problem: The Exhaust Gas Recirculation (EGR) cooler may leak coolant internally, which can mix with soot to form flammable deposits, potentially leading to a Fire I was driving and my car started to smoke out of engine compartment I pulled over and waited called my husband and drove it back home. Took it to a shop and they are saying it’s my erg leaking internally and need it replaced along with the intake manifold. I looked up recalls and only the diesel one is on recall for the exact same issue,
The contact owns a 2016 BMX X3. The contact stated that while driving at an undisclosed speed, the accelerator pedal was depressed; however, the vehicle failed to accelerate as intended. The RPM was elevated; however, the vehicle failed to respond as intended. The vehicle was driven to the shoulder of the road. No warning lights were illuminated. The vehicle was towed to an independent mechanic and was diagnosed with Electronic Power Steering Control Unit failure. The contact was informed that the Electronic Power Steering Control Unit needed to be replaced. The vehicle was not repaired. The contact was advised to tow the vehicle to the dealer. The vehicle was towed to the dealer, where the failure was confirmed as an Electronic Power Steering Control Unit failure. The contact referenced an unknown recall with a similar description; however, the VIN was not under recall. The contact was informed that the repair was not covered under the recall. The vehicle was not repaired. The manufacturer was made aware of the failure, and a case was filed. The contact was advised to contact the NHTSA Hotline to report the failure. The failure mileage was approximately 70,000.
The contact owns a 2016 BMW X3. The contact received notification of NHTSA Campaign Number: 24V608000 (ENGINE AND ENGINE COOLING, ELECTRICAL SYSTEM). The vehicle was taken to the dealer for the recall repair; however, the dealer refused to perform the recall repair and stated that since the vehicle was manufactured in Canada, the recall repair could not be performed. The manufacturer was not made aware of the issue. The contact had not experienced a failure.
The contact owned a 2016 BMW X3. The contact stated that while parking in the garage, the warning message "engine overheated" had displayed, but the temperature gauge displayed a normal temperature reading. The contact noticed smoke coming from under the hood before entering the home, along with a strange sound. Moments later, the contact returned to the garage and discovered flames coming from under the front end of the vehicle. The contact quickly drove the vehicle out of the garage onto the driveway. The vehicle became engulfed in flames, and the fire department was called to the scene and extinguished the flames. During the fire, the vehicle was destroyed, and the driveway and parts of the lawn were damaged. No injuries were reported. A fire and police reporter was taken to the scene. The cause of the failure was not determined. The manufacturer and local dealer were not yet contacted. The contact was informed that the VIN was not included in the NHTSA Campaign Number: 24V608000(ENGINE AND ENGINE COOLING, ELECTRICAL SYSTEM). The failure mileage was 220,000.
BMW has not been able to offer a repair for the engine coolant pump recall issued in August 2024. I wanted to register a formal complaint because I would like to get this repaired and off my vehicle record. I have not experienced any problem with the recalled part yet.
The contact owns a 2016 BMW X3. The contact received notification of NHTSA Campaign Number: 24V608000 (Engine and Engine Cooling, Electrical System); however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The dealer was made aware of the issue and confirmed that parts were not yet available. The manufacturer was made aware of the issue and confirmed that parts were not yet available. The contact had not experienced a failure.
The low-pressure fuel temperature/pressure sensor failed internally, causing diesel fuel to intrude via capillary action into the engine wiring harness and ultimately contaminate the Digital Diesel Electronics (DDE) control unit (ECU). The failed components (sensor, harness, DDE) are available for inspection upon request at BMW of Loveland, CO. My safety was put at risk in two primary ways: Engine Stalling Risk: The DDE is the engine control unit. As the fuel contaminated the electrical connections, the engine's reliability was compromised, creating a significant risk of sudden engine stalling while driving in traffic or at high speeds. Fire Hazard: The intrusion of diesel fuel—a combustible fluid—directly into the electrical wiring harness and the DDE created a clear fire hazard. Fuel near active electrical components poses a serious safety risk. Inaccurate Temperature Readings: The EGT (Exhaust Gas Temperature) sensor received incorrect readings due to the DDE/wiring issue, leading to potential engine damage due to excessively high exhaust temperatures. The problem has been confirmed by BMW of Loveland. The Service Director and their technical team identified the root cause in less than one day and confirmed it requires the replacement of the sensor, harness, and DDE. This was also validated by an internal BMW technical support case (TSARA). Gebhardt BMW failed to diagnose the issue correctly over three prior attempts starting in June 2023 through Aug 2025. Prior symptoms appeared over a period of months and included: Intermittent check engine light/MIL. Multiple, confusing diagnostic fault codes (related to air mass, charging pressure, and DPF efficiency). Increased frequency of DPF regeneration intervals.
The electric water pump, has shorted internally , even with the vehicle off , this caused the battery to run down.
* in 2018, the car started automatically going into Park when the engine is running but at a stop (e.g. Stop light). This created a safety issue because the gear had to be reengaged into Drive * It was repaired under warranty by BMW * It started reoccuring this year. We have stopped driving it because it creates a safety issue * BMW has refused to fix this (though it was previously addressed under warranty). In addition, they have said it may cost thousands or 10's of thousands of dollars to fix because they do not know the problem (could be camshaft sensor or mechatronics or something else). * The problem has been confirmed by BMW * We cannot risk the car not being in gear and getting rear-ended because it takes a while to move it back to drive. * No warnings or any mesages * We have already spent money at the dealer replacing unnecessary parts because they thought it would fix the problem (e.g. batteries) * The car is available for inspection on request
The complete A/C unit has completely gone out and I am just now getting notice after almost a year of a coolant pump recall that could potentially create a fire hazard. I am told that to date a remedy has still not been available.
The contact owns a 2016 BMW X3. The contact received notification of NHTSA Campaign Number: 24V608000 (Engine and Engine Cooling, Electrical System); however, the part to do the recall repair was unavailable. The dealer was not contacted. The vehicle was not diagnosed or repaired. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.
The contact owns a 2016 BMW X3. The contact received notification of NHTSA Campaign Number: 24V608000 (Engine and Engine Cooling, Electrical System); however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.
The contact owns a 2016 BMW X3. The contact received notification of NHTSA Campaign Number: 24V608000 (ENGINE AND ENGINE COOLING, ELECTRICAL SYSTEM); however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.
the passenger restraint system malfunction error came out several times since last month.
The contact owns a 2016 BMW X3. The contact stated that while driving at undisclosed speeds, the steering wheel became difficult to turn to the left or the right. In addition, the contact stated that while driving at undisclosed speeds, the vehicle loss automotive power on several occasions. The vehicle was towed to the local Midas where the battery was replaced; however, the failure occasionally reoccurred. The contact received notification of NHTSA Campaign Number: 24V608000 (Engine and Engine Cooling, Electrical System); however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the failure. The failure mileage was approximately 100,000. VIN tool confirms parts not available.
The contact owns a 2016 BMW X3. The contact stated that while driving at an undisclosed speed, there was smoke coming from under the hood. In addition, the contact noticed a burning odor. The vehicle was not diagnosed or repaired by an independent mechanic or the dealer. The contact received notification of NHTSA Campaign Number: 24V608000 (Engine and Engine Cooling, Electrical System) however, the part to do the repair was unavailable. The dealer was made aware of the failure and confirmed that parts for the repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the failure but provided no assistance. The failure mileage was unknown. VIN tool confirms parts not available.
The contact owns a 2016 BMW X3. The contact received notification of NHTSA Campaign Number: 24V608000 (Engine and Engine cooling, Electrical System); however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not unavailable.
The contact owns a 2016 BMW X3. The contact received notification of NHTSA Campaign Number: 24V608000 (Engine and Engine Cooling, Electrical System); however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact had not experienced a failure. The manufacturer was not made aware of the issue. VIN tool confirms parts not available.
The contact owns a 2016 BMW X3. The contact received notification of NHTSA Campaign Number: 24V608000 (Engine and Engine Cooling, Electrical System); however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The dealer was made aware of the issue and confirmed that parts were not yet available. The manufacturer was not made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.
The contact owns a 2016 BMW X3. The contact received notification of NHTSA Campaign Number: 24V608000 (Engine and Engine Cooling, Electrical System); however, the part to do the recall repair was not yet available. The local dealer was not contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.
I have reached out to the manufacturer for a solution and they said to wait till there is a remedy. I’m scared to drive this car for fear that something could happen to me or my family.
The contact owns a 2016 BMW X3. The contact stated while driving at an undisclosed speed, the contact noticed a burning odor inside the vehicle. The check engine warning light was illuminated. The vehicle was taken to the dealer; however, the contact was informed that parts to repair the vehicle was not available. The vehicle was not diagnosed or repaired by an independent mechanic or the dealer. The contact received notification of NHTSA Campaign Number: 24V608000 (Engine and Engine Cooling, Electrical System); however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the failure, however, was unable to confirm when parts would become available. The failure mileage was 99,000. VIN tool confirms parts not available.
The contact owns a 2016 BMW X3. The contact stated that while driving approximately 75 MPH, the vehicle unintendedly decelerated and failed to properly accelerate. The vehicle was taken to the local dealer, who was unable to determine the cause of the failure. The vehicle was not repaired. The manufacturer was notified of the failure, but no assistance was offered. The contact was informed that the VIN was not included in NHTSA Campaign Number: 21V586000 (FUEL SYSTEM, DIESEL). The contact stated that the vehicle had experienced the failure listed in the recall. The failure mileage was 55,000.
I got an engine light and found a recall for BMW's online so I made the service call. Once there at Fields Winter Park, I was asked to sign a service agreement where i would pay $219.95 for the diagnostic if the issue didn't fall into a recall. Well, I saw the recall in my computer, in the National Highway Traffic Safety Administration, for a coolant thermostast, and also one for the engine Coolant Pump, so I knew it should be covered, so I signed. Later they said that the issue was the thermostat, and that since they couldn't find a recall on the BMW USA website, I would be responsible for payment. I did bring my laptop and phone and showed them both recalls. They say they do not go by any other website than theirs, which conveniently does not reflect any recall on my vehicle. When I said that I was looking at the information in an official website, they said said that technically, I set the appointment because of an engine light, not a recall. I politely mentioned that technicalities on this case come down to wording from a consumer that trusts the dealership of a brand but should not be used against such consumer in any tricky and deceiving way. I called for an engine light and saw two recalls for BMW of my year. On official sites. I was overwhelmed while talking to both a service manager and the general manager, in the presence of also the service representative. They said to me that the engine light would NOT be triggered by a coolant pump issue (which is not true). And they said that even when Safety Recall Report 24V-608 is in the NHTSA website, it is not active on their side and therefore they do not need to do anything about it, until I receive a letter to come to have it looked at. So they denied any action until i received a letter and even then, they said I would not be welcome to do business there. So basically they did not take any action on the recall! And then they gave me my car back with a large scratch in the front bumper and fender!
The contact owns a 2016 BMW X3. The contact stated that there was a message that the passenger’s side restraint had malfunctioned. The dealer had been contacted to schedule an appointment; however, the vehicle had not been taken to the dealer. The vehicle was not diagnosed or repaired. The manufacturer was not made aware of the failure. The failure mileage was 107,000.
The contact owns a 2016 BMW X3. The contact received notification of NHTSA Campaign Number: 24V608000 (Engine and Engine Cooling, Electrical System); however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.
a long overdue recall without remedy
BMW has failed to issue a remedy for the COOLANT PUMP that may lead to fires, if not replaced. For months now, I have called several BMW dealerships and they do not have an idea of when BMW would issue a remedy. BMW needs a push from the NHTSA to address this recall instead of looking to the other side because the car's date is 2016. If they cannot fix that hazard, then they must replace vehicles.
The contact owns a 2016 BMW X3. The contact received notification of NHTSA Campaign Number: 24V608000 (Engine and Engine Cooling, Electrical System); however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The dealer was not contacted. The manufacturer was not made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.
The contact owns a 2016 BMW X3. The contact received notification of NHTSA Campaign Number: 24V608000 (Engine and Engine Cooling, Electrical System); however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.
The manufacturer had exceeded a reasonable amount of time for the recall remedy. NHTSA: #24V-608, Recall: #24V-608:474 Engine Coolant Pump
We have had several occurrences of the following issue during the last several months. When slowing the vehicle down at a traffic light/stop with the goal of bringing the vehicle to a complete halt, as the vehicle decelerates to almost a stop with the foot firmly on the brake pedal, there have been several instances where the engine suddenly revs up and the vehicle lunges forward instead of stopping. It is an intermittent issue which is very hard to predict. It has occurred on flat roads, or going downhill, a couple of times with the air conditioner on. It's a split second lunge needing one to apply brakes even harder. Since at other times, this doesn't happen it's very concerning since we're questioning the reliability of the vehicle. It's a matter of chance that this may cause rearending the vehicle ahead. Thankfully, that hasn't happened but have come within a hair of happening.
The liftgate opened while the car was being driven down the road.
Driving on highway when car would not accelerate. No power. N for neutral on dashboard and transmission malfunction. No other warning or warning lights came on dashboard. Temp was in middle not elevated. Coasted to breakdown lane. No power, unable to start. Towed to BMW dealership that we go to. Told it was a catastrophic engine failure. Video from dealership, has mechanic showing metal pieces in oil filter. As of this date, car has been at dealershipabout 10 days without findings. *Car was at dealership two days prior for oil change. Unsure if dealer did something or this is a problem with this series. Australia had recall for engine failures in this model. Just letting NHTSA know.
The contact owns a 2016 BMW X3. The contact stated that while driving at an undisclosed speed, the low oil pressure and drive train warning lights illuminated. The vehicle was taken to an independent mechanic and the contact was informed that the timing chain guide failed which and caused a catastrophic engine failure. The contact was informed that the engine needed to be replaced. The vehicle was not repaired. The contact related the failure to Technical Service Bulletin: 110317 (Engine Timing Chain and Oil Pump Drive Chain). The manufacturer was made aware of the failure. The failure mileage was approximately 117,000.
When coming to a stop, my trunk continues to open and will not close unless you turn the car off and get out and close it. I tried to replace the battery in my key fob, but it will not work. The trunk button when you hold it down, says “remote battery, change battery.”. The rear hatch continues to open every time you stop your car unless you hold the trunk button down. This is extremely unsafe having things, people, or items in your car or trunk because it opens while operating your car.
This vehicle shuts down the engine when stopped at a stop sign or light. The engine resumes when you press on the brake or gas peddle. But sometimes, the engine will turn back on for no apparent reason. That is not an issue of concern. BUT, sometimes, when the engine turns on automatically, it will drop the transmission into PARK. So when you attempt to apply gas, the car will not move forward as it is not in gear. This is intermittent. My German Auto repair shop has observed the issue and spoken with many other shops who have reported the same issue with the X3. BMW does not have a solution to the problem. The driver never knows if the car will move forward after a traffic stop, as it is not obvious that the transmission has dropped into park until you attempt to move forward. Instead of using this engine turn-off feature of the vehicle, they suggest turning it off to avoid the problem. That is a gas-saving feature of the car.
The contact owns a 2016 BMW X3. The contact received notification of NHTSA Campaign Number: 21V907000 (Fuel System, Diesel) however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact stated that while his wife was driving at an undisclosed speed, the "Drive Train Malfunction" message was displayed. The vehicle was taken to the dealer where it was diagnosed that the Exhaust Gas Recirculation (EGR) cooler needed to be replaced but confirmed that parts were not yet available. The failure recurred with an abnormal fuel odor detected while the vehicle was parked inside the garage. Additionally, fuel was leaking from underneath the vehicle and the check engine warning light illuminated while driving. The vehicle was taken back to the dealer where it was determined that there was a pinhole in the fuel hose and the fuel hose was replaced. The manufacturer was made aware of the failure. The failure mileage was 66,869. VIN tool confirms parts not available.
2016 BMW X3, CONSUMER WRITES IN REGARD TO DEFECTIVE DIESEL PARTICULATE FILTER. THE CONSUMER STATED THE EXHAUST GAS ISSUE HAD NO REMEDY. THE VEHICLE ALSO HAD A LEAKING VALVE COVER AND DIESEL PARTICULATE FILTER. THE CONSUMER REQUESTED TO BE REIMBURSED FOR THE REPAIRS AND HAVE THE VEHICLE BOUGHT BACK FROM THE DEALER.
The contact owned a 2016 BMW X3. The contact received notification of NHTSA Campaign Number: 21V907000 (Fuel System, Diesel) however, the part to do the recall repair was not yet available. The contact stated that the dealer had previously performed an engine inspection and pressure test for the coolant system due to coolant loss with the low coolant warning light illuminated. The contact had added a quart of coolant. The contact stated that while his wife was driving at an undisclosed speed, the vehicle lost motive power with a loss of power warning message displayed. The contact's wife was able to pull over on the shoulder of the roadway and noticed there was smoke coming from underneath the hood before it caught fire. The contact's wife was able to safely exit the vehicle. The fire department arrived on the scene and was able to extinguish the fire. Police and fire department reports were filed. The vehicle was towed to a tow yard and then to the contact's residence. The dealer was made aware of the failure and referred the contact to the manufacturer. The vehicle was not yet deemed totaled by the insurance company. The manufacturer was made aware of the failure and informed the contact that an inspector would perform an inspection to determine the cause of the fire. The failure mileage was approximately 88,500. VIN tool confirms parts not available.
The incident that happened to us was the shattered front panel sunroof while driving in a cold temperature on the highway. We don't believe this was caused by a rock because it should have cracked the whole panel but instead, it shattered.
The contact owns a 2016 BMW X3. The contact received notification of NHTSA Campaign Number: 21V907000 (Fuel System, Diesel) however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.
In early August 2021, the fuel pump on our BMW X3 failed in the middle of an intersection and the car stopped completely. No way to move to one side until a flatbed wrecker came. Fuel pumps will fail after 100,000 miles and we above that figure, Which is why it was surprising then to have the same problem four months later when we had multiple error codes come up on the same car. At least this time I could pull over to the side off the road. The problem was a failing fuel pump. When a pump fails the car stops. If we had been on a highway we would have been rear ended and potentially killed. I shared my concern with a contact at BMW Corporate who only noted that the repair was under extended warranty. One BMW service rep I spoke to said that fuel pump failures are a known issue and yet in my experience there still seems to be a major problem with the part.
IT HAD BEEN RAINING IN MY AREA THE WEEK OF 4/16/2021. ON THE EVENING OF 4/16/2021 MY REAR HATCH CONTROL AND REAR HATCH ALARM STARTED MALFUNCTIONING. I DISCOVERED WATER HAD GOTTEN INTO THE ELECTRICAL COMPARTMENT IN THE REAR HATCH. I BROUGHT MY SUV TO THE SHOP/DEALER FOR REPAIR AND WAS TOLD THE SUNROOF FRAME WAS CRACKED ALLOWING WATER PENETRATION FROM THE HEADLINER TO THE REAR HATCH CAUSING THE HATCH CONTROL UNIT TO MALFUNCTION. MY VEHICLE HAS NEVER BEEN INVOLVED IN AN ACCIDENT AND I HAVE NEVER STORED OR TRANSPORTED ANYTHING ON MY ROOF. THE REPAIR SHOP/DEALER WAS UNABLE TO OFFER A REASON FOR WHAT COULD HAVE CAUSED THE SUNROOF FRAME TO CRACK. THE ONLY EXPLANATION THAT MAKES SENSE IS THAT THE SUNROOF WAS EITHER INSTALLED IMPROPERLY BY THE MANUFACTURER OR THE SUNROOF FRAME IS DEFECTIVE. IT WAS $4,298.08 TO REPAIR THE SUNROOF AND CONTROL UNIT. THIS IS MOST CONCERNING AS MY SUV IS LESS THAN 5 YEARS OLD, ONLY HAS 81,448 MILES AND THERE IS NO RECOMMENDED MAINTENANCE FOR THE SUNROOF.
I DROVE MY 2016 BMW X3 FOR ABOUT 30 MILES ON THE HIGHWAY. I EXITED THE HIGHWAY AND CAME TO A STOP AT A LIGHT. MY REAR HATCH OPENED WHILE AT THE LIGHT AND MY VEHICLE WAS IN DRIVE. I HAD TWO DOGS IN THE REAR AREA THAT NEARLY JUMPED OUT. WE DID DETERMINED THAT A KEY FOB IN A POCKET PROBABLY WAS PRESSED. WHILE THE VEHICLE IS IN DRIVE AND THE DOORS ARE LOCKED THERE IS NO REASON A REAR HATCH SHOULD BE ABLE TO OPEN. I WAS ABLE TO REENACT THIS EXACT SAME SITUATION WITH THE VEHICLE IN DRIVE, AND THE DOORS LOCKED BY PUSHING THE HATCH BUTTON. ITDOES ALLOW THE REAR HATCH TO FULLY OPEN EVEN WHEN THE VEHICLE IS IN DRIVE.
MY EMERGENCY BRAKE KEEPS MALFUNCTIONING, I HAVE BEEN UNABLE TO USE THEM FOR ABOUT 3 MONTHS NOW. ALSO STARTING AROUND 2/20/21 WHEN IM AT A RED LIGHT FOR MORE THAN A MINUTE AND THE LIGHT TURNS GREEN, MY TRANSMISSION GETS STUCK AND THE CAR WONT GO, A WARNING SIGN COMES ON. THEN I HAVE TO RE PUT IT IN DRIVE AND CAN GO.
The contact owns a 2016 BMW X3. The contact stated while cold starting the vehicle, there was significant amounts of white and blueish smoke coming out of the exhaust pipe. The contact stated that the failure had been recurring. The vehicle was taken to the local dealer, where it was diagnosed that oil was leaking onto the turbocharger, and that the turbo charger oil supply lines needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure and referred the contact to the NHTSA Hotline for assistance. The failure mileage was approximately 70,000.
ON 8/30/20,AFTER SITTING FOR AN HOUR AFTER A LONG DRIVE, THE CAR BURST INTO FLAMES AND BURNED DOWN TWO ADJACENT HOMES. THE CAR WAS PARKED FOR AN HOUR BEFORE IT STARTED TO BURN.
MY 8-YEAR OLD DAUGHTER WAS SITTING ON REAR PASSENGER SIZE SEAT ON A BOOSTER SEAT WITH SEAT BELT ON. SHE FIRST PLAYED WITH MY SON WHO WAS SITTING ON A READ DRIVER SEAT ON A CAR SEAT. THEN SHE FELL ASLEEP. IN THIS PROCESS THE SEAT BELT SOME HOW GOT WRAPPED AROUND HER. WHEN WE STOPPED FOR A BATHROOM BREAK WE UNBUCKLED THE BELT TO FIND OUT THAT THE BELT WAS WRAPPED AROUND HERE AND WE COULD NOT UNWRAP IT. THE MORE WE TRIED TO PULL OUT THE MORE TIGHTER IT GOT. SHE WAS IN SEVERE PAIN. WE HAD TO BORROW A SCISSOR FROM THE GAS STATION TO CUT THE BELT.SEE THE PIC WITH THE SCAR. SHE WAS IN PAIN FOR NEXT FEW DAYS. WE TOOK THE CAR TO DEALER AND THEY SAID THAT BELT WORKED AS DESIGNED. THE CHILD LOCK KICKED IN AND THE LOCK WONT RELEASE UNTIL THE BELT GOES ALL THE WAY IN. BELT COULD NOT GO ALL THE WAY IN BECAUSE IT WAS WRAPPED AROUND HER. THERE SHOULD HAVE BEEN SOME MANUAL BUTTON/SWITCH TO RELEASE THE BELT.
PASSENGER AIRBAG POSSIBLE FAILURE. PASSENGER AIRBAG HAS BEEN TURNED OFF BY THE VEHICLE.
Data synced from NHTSA on May 4, 2026