2003 BMW X5 Complaint Log

TL* THE CONTACT OWNS A 2003 BMW X5. THE CONTACT STATED THAT THE TIMING CHANGE FRACTURED. THE VEHICLE WAS TAKEN TO THE DEALER WHO STATED THAT THE TIMING CHANGE NEEDED TO BE REPLACED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 90,000.

CAR SHUT DOWN WHILE DRIVING APPX 35MPH WITHOUT WARNING, NEARLY CRASH DUE TO LOSS OF STEERING ASSIST AND INSTRUMENT. DEALER REPLACED BOTH DME AND BATTERY WHICH WAS SUSPICIOUS SINCE TWO UNRELATED COMPONENT FAILED AT SAME TIME? EXTREMELY DANGEROUS WHEN IT HAPPENED IN TRAFFIC, ENDANGERING BOTH MY PASSENGERS AND OTHER DRIVERS NEARBY. RECALL TO THE DME AND BATTERY SHOULD BE ISSUED. REPAIR COST $2500. *TR

WATER GETS INSIDE REAR LIGHTS, CAUSING CORROSION, AS A RESULT, THE LIGHTS STOP WORKING AND A WARNING LIGHT APPEARS ON THE DASHBOARD "CHECK BRAKE LIGHTS", "CHECK REAR LIGHTS". *TR

MY 2003 BMW 530I SEDAN CAUGHT FIRE DUE TO AN ELECTRICAL FAULT WHILE PARKED IN NEW HAVEN, CONNECTICUT. THE FIRE DEPARTMENT AND POLICE WERE CALLED. CASE #[XXX] WAS ASSIGNED BY OFFICER [XXX] OF THE NEW HAVEN PD. THE CAR, TOO BADLY DAMAGED TO REPAIR, WAS HAULED AWAY FOR EVENTUAL SCRAPPING. I WAS CLOSE TO THE CAR WHEN THE FIRE STARTED. FLAMES WERE ERUPTING FROM THE DASH, WHERE THE CLIMATE CONTROL SWITCHES ARE LOCATED. I TRIED SMOTHERING THE FLAMES WITH A SWEATER. THIS DID NOT INTERRUPT THE PROGRESS OF THE FIRE. THERE WAS NO PERSONAL INJURY OR PROPERTY DAMAGE OTHER THAN TO THE CAR AND ITS CONTENTS. ITEMS SITUATED IN THE FRONT SEAT AREA WERE NOT RECOVERED, DUE TO THE INTENSITY OF THE FIRE. THE APPARENT CAUSE OF THE FIRE WAS AN ELECTRICAL FAULT. IN 2010 NEW COUNTRY BMW IN HARTFORD TWICE REPLACED THE CLIMATE CONTROL FAN FINAL STAGE RESISTOR, ONCE IN APRIL AND AGAIN IN OCTOBER, AT NO CHARGE FOR THE SECOND REPLACEMENT. IN THE DAYS BEFORE THE FIRE THE CLIMATE CONTROL WAS AGAIN ACTING ERRATICALLY, AND THE EVIDENCE INDICATES THE FINAL STAGE RESISTOR WAS FAILING ONCE AGAIN. BMW NORTH AMERICA INSPECTED THE CAR AND CONFIRMED THAT THE FIRE WAS CAUSED BY AN ELECTRICAL FAULT IN THE AREA BEHIND THE DASH WHERE THE FINAL STAGE RESISTOR IS LOCATED. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).*TR

2003 BMW X5 4.4I TRANSFER CASE/FRONT DRIVE SHAFT FAILED LEAVING CAR STRANDED ON A RAILROAD CROSSING WITH NO POWER. RR LIGHTS BEGAN TO FLASH BUT MANAGED TO PUSH CAR OFF TRACKS IN TIME ONCE WE FOUND HELP (TOO HEAVY TO PUSH ALONE). SAME FAILURE AT 90K MILES HAD STRANDED CAR ON A LOCAL STREET ABOUT 2.5 YEARS EARLIER. BMW REPLACED TRANSFER CASE AND FRONT DRIVE SHAFT UNDER CERTIFIED PRE-OWNED WARRANTY. CURRENT FAILURE OCCURRED ON TRANSFER CASE/DRIVE SHAFT LESS THAN 40K MILES / 2.5 YEARS OLD. SAME FAILURE IS WELL DOCUMENTED WITH NUMEROUS OTHER OWNERS ON VARIOUS INTERNET MESSAGE BOARDS. RESEARCH SUGGESTS THE FAILURE IS DUE TO A DESIGN FLAW INVOLVING INSUFFICIENT SPLINE ENGAGEMENT AND POOR PLACEMENT OF A/C CONDENSATE DRAIN DIRECTLY ABOVE TRANSFER CASE / SHAFT CONNECTION CAUSING ACCELERATED RUSTING OF DRIVE SHAFT SPLINES WHICH EVENTUALLY WEAKEN AND STRIP OUT. ATTEMPTED TO GET BMW TO COVER REPAIR OUT-OF-WARRANTY DUE TO CIRCUMSTANCES OF EARLY FAILURE OF A DRIVETRAIN PART. MULTIPLE CALLS (MESSAGES FOR SERVICE MANAGERS) TO TWO LOCAL DEALERSHIPS WENT UNRETURNED. CALL TO BMWNA WAS UNHELPFUL - WOULD NOT TAKE ANY ACTION UNTIL CAR WAS TOWED TO A DEALERSHIP FOR INSPECTION AT MY EXPENSE AND WOULD (AT BEST) BE REPAIRED WITH SAME PARTS OF POOR DESIGN. *TR *KB

I OWN A 2003 BMW X5 4.6IS MY TRANSMISSION HAS GONE COMPLETELY OUT WITH ONLY 70000 MILES . I HAVE DONE A LOT OF RESEARCH. I'M NOT THE ONLY ONE WITH THIS PROBLEM. I HAVE READ IN FORUMS THAT OTHER 2002-2003 4.6IS OWNERS HAD TRANSMISSION TRANS FAILURES. I BELIEVE THE TRANSMISSION IS DEFECTIVE ON THIS VEHICLE. THERE IS NO REASON THAT A 75K VEHICLES TRANSMISSION SHOULD NOT LAST UNDER 100K MILES. *TR

WHILE DRIVING VEHICLE OBSERVED SMOKE COMING OUT FROM THE LEFT SIDE OF DRIVER SEAT. SLOWLY FELT THE HEAT SENSATION GROWING STRONGER IN THE AREA. ALMOST IN A PANIC, AND AT GREAT RISK TO MYSELF AND OTHERS ON THE ROAD, TRIED TO NAVIGATE THROUGH TRAFFIC ON THE BUSY STREET, TO THE RIGHT HAND TURN LANE, WHILE TRYING TO AVOID WHAT WAS OBVIOUSLY GROWING INTO A FIRE IN THE SEAT. HAD TO AVOID SITTING IN THAT AREA OF THE SEAT, WHILE KEEPING THE SEAT BELT ON IN CASE THERE WAS A CRASH. FINALLY MADE IT TO A PARKING LOT AND JUMPED OUT. THERE WAS A HOLE IN THE LEATHER SEAT THAT WAS SMOLDERING. THE SEAT HEATER HAD BURNED A HOLE THROUGH THE LEATHER SEAT. TRIED TO FIND SOMETHING TO DOUSE IT OUT WITH BEFORE IT SPREAD TO OTHER PARTS OF THE SEAT. ALSO, DISCOVERED THAT MY PANTS WERE STILL SMOLDERING ON THE REAR LEFT LEG TOWARDS THE HIP AREA. THERE WERE TWO HOLES BURNED INTO THE PANTS FROM CONTACT WITH THE BURNING SEAT. CALLED THE DEALER AND SCHEDULED A SERVICE APPOINTMENT. CALLED BMW NA, WHO SAID THEY WERE NOT AWARE OF ANY OTHER SUCH INCIDENTS AND THEY WOULD HAVE TO WAIT FOR THE DIAGNOSIS FROM THE DEALER. THEIR ATTITUDE ALSO SEEMED VERY LAISSEZ-FAIRE ABOUT THE WHOLE THING, SEEMINGLY NOT TO CARE SINCE I WASN'T REPORTING ANY INJURIES. JUST THE FACT THAT MY SEAT WAS ON FIRE AND I BARELY AVOIDED GETTING IN A CRASH AND GETTING BURNED, WHILE MY PANTS ACTUALLY DID GET BURNED! MEANWHILE RESEARCHED THE INCIDENT AND FOUND ONE CASE REPORTED ON THIS VERY NHTSA WEBSITE, SEVERAL OTHERS ON THE X5 ON VARIOUS FORUMS AND A DOCUMENTED RECALL ON THE 5 SERIES FOR A SIMILAR ISSUE WITH THE SEAT HEATER. NOW BMW WANTS TO COVER ONLY THE COST OF THE PARTS AND NOT EVEN THE LABOR TO GET IT INSTALLED? FORGET ABOUT MY PANTS, OR THE TIME/EFFORT AND STRESS ALL THIS HAS CAUSED, THAT I DIDN'T EVEN ASK TO BE COMPENSATED FOR. NHTSA - WHY HAS THERE NOT BEEN A RECALL ON THE BMW X5 FOR THIS ISSUE AS YET? IS IT NECESSARY TO WAIT UNTIL SOMEONE IS KILLED IN AN ACCIDENT DUE TO THIS OR GETS BURNED? *TR

THE TEMPERATURE WAS ABOUT 5 DEGREES F. AFTER DRIVING A SHORT DISTANCE, THERE WAS A LARGE AMOUNT OF SMOKE FROM TAILPIPES AND SMOKE FROM ENGINE COMPARTMENT. ENGINE OIL WARNING MESSAGE AND SES LIGHT ILLUMINATED. THE ENGINE HESITATED AND MISFIRED. AFTER STOPPING, THE BACK OF THE X5 WAS COVERED IN OIL. THE ENGINE COMPARTMENT WAS COVERED IN OIL AND OIL COATED THE EXHAUST MANIFOLD. THE X5 HAD TO BE TOWED TO THE DEALER. THE DEALER INDICATED THE CCV WAS FROZEN AND IT WAS COMMON IN THESE CARS. WHEN THE CCV FREEZES, IT CAN SUCK THE OIL FROM THE OIL SUMP THROUGH THE CCV INTO THE INTAKE MANIFOLD. THE VALVE COVER GASKET USUALLY BLOWS FROM THE INCREASED PRESSURE. IF ENOUGH OIL IS SUCKED IN THROUGH THE INTAKE MANIFOLD, IT CAN HYDROLOCK THE ENGINE, BREAKING PISTON RODS, ETC OR THE ENGINE CAN SEIZE FROM LACK OF OIL. BMW IS AWARE OF THIS DESIGN FLAW IN THESE CARS WHEN OPERATED IN COLD CLIMATES AND IS PROVIDING SOME RELIEF FOR SOME OF THE CARS THAT EXPERIENCE THIS ISSUE. THE VALVE COVER GASKET WAS REPLACED. OIL HAD TO BE VACUUMED FROM THE SPARK PLUG WELLS. THE CCV AND ASSOCIATED HOSES WERE REPLACED WITH A NEWER INSULATED DESIGN. THE DIPSTICK TUBE WAS REPLACED. THE OIL FILTER WAS REPLACED. ANY OIL THAT MAY REMAIN IS DRAINED AND NEW OIL WAS ADDED. THE ENGINE COMPARTMENT WAS DEGREASED. *TR

TL* THE CONTACT OWNS A 2003 BMW X5. THE CONTACT STATED THAT WHILE DRIVING 35 MPH THERE WAS SMOKE COMING FROM UNDER THE HOOD AND EXHAUST PIPE. THE VEHICLE WAS TAKEN TO THE DEALER WHERE THE CONTACT WAS ADVISED THAT THE OIL SEPARATOR WAS LEAKING AND DRAINED ONTO THE EXHAUST PIPE AND ENGINE ABNORMALLY, CAUSING THE FAILURE. THE CONTACT STATED THAT THE FAILURE WOULD ONLY OCCUR IN COLD TEMPERATURES. THE OIL SEPARATOR WAS REPAIRED. THE MANUFACTURER WAS CONTACTED WHO OFFERED NO ASSISTANCE. THE FAILURE MILEAGE WAS 74,200.

DRIVE ONE MILE ONE 1 IN 22 DEGREE WEATHER BMW 2003 X5 BEGIN TO BLOW THICK WHITE SMOKE FROM EXHAUST PIPES AND ENGINE SHUT DOWN. THERE WERE NO INDICATOR LIGHTS THAT WARN THERE WAS A PROBLEM. *TR

TL*THE CONTACT OWNS A 2003 BMW X5. THE CONTACT STATED THAT WHILE DRIVING 30 MPH SMOKE STARTING COMING THROUGH THE VENTS WITHOUT ANY WARNINGS. THE VEHICLE WAS TAKEN TO THE DEALER WHO DIAGNOSED THAT THE CCV VALVE FROZE CAUSING AN OIL SPILLAGE. THE MANUFACTURER WAS NOT CONTACTED. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGES WERE 58,076. UPDATED 3/14/11 *CN ACCORDING TO THE INVOICE, THE VALVE COVER GASKET WAS LEAKING OIL EXCESSIVELY. UPDATED 06/24/11

OIL SEPARATOR MALFUNCTIONED IN COLD TEMPERATURES. WHEN DRIVING EXPERIENCED SMOKE UNDER THE HOOD AND WAS FORCED TO PULL OVER. DROVE SLOWLY WITH HAZARDS TO NEAREST MECHANIC AND INCURRED $1,955 IN REPAIR CHARGE. MECHANIC INFORMED ME THAT THIS WAS BECOMING A POPULAR DEFECT WITH THE OEM OIL SEPARATOR ON THIS MAKE AND MODEL. *KB

1. THE WEATHER OUTSIDE WAS -10 DEGREES CELSIUS. 2. I OWN A 2003 BMW X5, 4.4 LITRE ENGINE, V8. THE CRANK CASE VALVE FROZE SHUT, CAUSING OIL TO SPILL INTO THE ENGINE. THIS PROBLEM HAS OCCURRED TWICE - ONCE LAST WINTER (2010) AND THIS WINTER (2011). IT HAS COST ME A TOTAL OF $1,600 THIS YEAR AND $3,000 LAST YEAR TO REPAIR. 3. SPARK PLUGS NEEDED TO BE REPLACED, ENGINE NEEDS TO BE CLEANED, AND A NEW HEATER BLANKET WAS INSTALLED LAST YEAR, BUT FAILED TO KEEP THE VALVE FROM FREEZING SHUT AGAIN THIS YEAR! *TR

DRIVER SIDE SEAT HEATER MALFUNCTION CAUSING A HOLE TO BURN THROUGH LEATHER AND NEARLY CREATED FIRE. WHEN HEATER IS TURNED ON IT CREATES AN INTENSE AND CONCENTRATED HEAT ON SEAT BOLSTER TOO HOT TO TOUCH. REPLACEMENT FROM DEALER IS OVER $700 AND ITS BEEN REPORTED ON NUMEROUS FORUMS THAT THIS IS A DEFECT. *TR

THE 2003 BMW 540I POWER STEERING PUMP SPOOL VALVE WAS FOUND (DISASSEMBLED AND JUDGED BY BMW TECHNICIAN) TO JAM AT LOWER RPM THUS CAUSING COMPLETE LOSS OF POWER STEERING ASSIST, ESPECIALLY IN REDUCED RPM TURNS OFF HIGHWAYS. ON SEVERAL OCCASIONS I NEARLY CRASHED INTO THE MEDIAN-WALL BECAUSE OF IT. I SENT A LETTER TO BMW BUT ALL THEY TOLD ME IS THAT IT WOULD BE FORWARDED BUT THAT I WOULD NEVER HEAR BACK FROM THEM AGAIN. I CONSIDER THIS A MATERIAL/PART FLAW THAT BMW HAS TO CONSIDER AS SERIOUS AND OFFER SOME FORM OF REPAIR/REPLACE PLAN OR CUSTOMER-DIRECTED ACTION AS IT CAN LEAD TO SERIOUS CRASHES DURING TURNING MANEUVERS! *TR

INSTALLED TWO NEW BRIDGESTONE POTENZA POLE POSITION RE 960AS IN JULY 2010(PURCHASED FROM THETIRE RACK),ON MY 2003 BMW 540I(AT BRIDGESTONE TIRE DEALER).REAR,275R1835.TWO MONTHS LATER WHILE DRIVING 40MPH ON A VERY WELL MAINTAINED ROAD(LAKE SHORE DRIVE,IN CHICAGO),LOUD BANG WAS HERD FROM THE BACK AND GOT FLAT WITHOUT RUNNING OVER ANY DEBRIS ON THE ROAD.CLAIMED THROUGH THE SELLER(THE TIRERACK),THE TIRE WAS SENT TO THE MANUFACTURER FOR INSPECTION(SINCE THE CUT AND THE DISINTEGRATION SEEMED CONSISTENT WITH MATERIAL DETECT) BUT RECEIVED A COLD SHOULDER FROM THEM CITING THAT THE BLOWN TIRE DID NOT HAVE A DEFECT. THE SELLER REFUSED TO HONOR MY WARRANTY(THE TIRE WAS REGISTERED FOR THAT). WHAT TO DO? *TR

INTERMITTENT ENGINE SHUT-DOWN. ENGINE SHUTS OFF WHILE VEHICLE IS IN MOTION AT ANY SPEED. "ENGINE FAILSAFE" WARNING LIGHT COMES ON. VEHICLE MUST BE STOPPED, KEY TURNED OFF AND RE-STARTED. THIS IS A SERIOUS SAFETY ISSUE THAT BMW IS AWARE OF AND HAS ISSUED A RELATED TSB. $2000 PLUS REPAIR BILL FOR A NEW "ENGINE WIRING HARNESS". BMW SHOULD BE RECALLING THESE VEHICLES. *TR

2003 BMW X5 CCV "OIL SEPARATOR VALVE" HAS ISSUES IN COLD WEATHER AND IS KNOWN TO FAIL. THE PROBLEM RELATES TO A NON PROPER DESIGN WHERE THE VALVE CAN FREEZE. THE ENGINE BLOCK CAN THEN BLOW OIL AND CAUSE FIRE. BEFORE IT BLOWS THE BLOCK THE ENGINE WILL HAVE "HARD STARTS" WHICH WILL PUSH FROZEN OIL THROUGH THE SEPARATOR. IF THE CCV FAILS IT WILL COMPLETELY BLOW YOUR ENGINE GASKETS. THIS IS A KNOWN ISSUE AND THEIR IS A BMW X5 SERVICE BULLETIN THAT THIS SHOULD BE LOOKED AT. BMW WILL NOT ADDRESS THE ISSUE UNTIL IT BLOWS. IT IS A MAJOR MALFUNCTION THAT IS NOT ONLY EXPENSIVE TO FIX WELL OVER THE 3000 BUT VERY DANGEROUS. I THINK AN INVESTIGATION INTO THE BMW PROBLEM SHOULD BE LOOKED CLOSELY. *TR

2003 BMW X5 RADIATOR CRACKED DURING DRIVING AND WATER SPILLED. CAR WAS IDLING AND SMOKY SMELL AND OIL PRESS, STOP ENGINE PROBLEMS. HAD 2 CHILDREN IN THE CAR WHILE DRIVING AND SEEMS LIKE CONNECTION/HOSE PROBLEMS WHICH DO NOT ALLOW THE ENGINE TO WORK PROPERLY. DO NOT FEEL SAFE DRIVING THE CAR, WON'T HOLD THE COOLANT WATER IN. A CAR THIS EXPENSIVE SHOULD NOT BE SO DEFECTIVE. *TR

WHILE TRAVELING IN THE MIDDLE LANE OF TRAFFIC AT 55 MPH MY BMW X5 STARTED POURING SMOKE FROM THE EXHAUST AND COMPLETELY SHUT DOWN LEAVING ME HELPLESS WITH NO POWER ON A MAJOR HIGHWAY. *TR

BMW 530I 2003. DRIVER DOOR WILL NOT UNLOCK, EITHER ELECTRONICALLY OR MANUALLY. DOOR LOCK ACTUATOR FAILURE. NO MANUAL OVERRIDE. FORCED TO CRAWL OVER CONSOLE AND EXIT FROM ANOTHER DOOR. *TR

OIL SEPARATOR FROZE CAUSING HIGH PRESSURE AND BLOWN SEALS. INITIAL COST ABOUT $1100 TO REPAIR. DEALER STATES THIS "HAPPENS ALL THE TIME" TO X5'S IN COLD WEATHER. TEMP WAS IN THE SINGLE DIGITS. IN JANUARY 2013 OIL SEPARATOR FROZE TWO MORE TIMES;HOWEVER, THIS TIME DAMAGING THE ENGINE - COST OVER $5000 TO REPAIR - BASICALLY TOTALING THE CAR. WITH ABOUT 15 MINUTES OF RESEARCH, THIS APPEARS TO BE A COMMON AND KNOWN ISSUE ON BMW X5 3.0, 4.4 AND 4.8 ENGINES FROM 2001 TO 2008... LOOKS LIKE THE PARTS WERE REDESIGNED IN 2009. LOOKS LIKE A SIMPLE PREVENTIVE MAINTENANCE ROUTINE AND INSULATED OIL LINES WOULD HAVE PREVENTED THE "CATASTROPHIC ENGINE FAILURE" AND DANGEROUS CONDITION OF TAILPIPE FIRE, OR BEING STRANDED IN ZERO DEGREE WEATHER (WHICH SEEMS TO BE A CONDITION REQUIRED FOR THE FAILURE). OWNER OF CAR IS THE ORIGINAL OWNER, WITH ALL MAINTENANCE BEING DONE AT LOCAL BMW DEALERSHIPS INCLUDING MAJOR SERVICES AT 60K AND 90K SO THERE APPEARS THERE IS NO "PREVENTIVE MAINTENANCE" INCLUDED IN EITHER OF THESE MAJOR SERVICE MILESTONES FOR THE KNOWN OIL SEPARATOR DEFECT. A RECALL ON THIS DEFECT TO INSTALL THE SMALL AMOUNT OF PARTS TO PREVENT "CATASTROPHIC ENGINES FAILURE" AND DANGEROUS CONDITIONS "BEING STRANDED IN SINGLE DIGIT WEATHER" SEEMS LIKE A LOGICAL CHOICE... OR AT LEAST CHANGING MAJOR SERVICE MILESTONES TO ADD PREVENTIVE MAINTENANCE SO THE PROBABILITY OF THE FAILURE CAN BE REDUCED. *TR

PASSENGER-AIRBAG-DISABLED WARNING LAMP COMES ON INTERMITTENTLY WHILE SEAT IS OCCUPIED BY AN ADULT. PROBLEM FIRST NOTED IN 2007, BECOMING PROGRESSIVELY WORSE. DEALER CHECKED AND FOUND DEFECTIVE SEAT OCCUPANCY DETECTOR, BUT REPLACEMENT QUOTED AT $800 NOTE - THIS IS A BMW MODEL X3 BUT YOUR WEB FORM DID NOT LIST X3 SO I SELECTED X5. *TR

SEAT BELT LATCH BROKEN. *TR

BMW 2003 X5 STALLED 3X. ABS, ENGINE FAILED SAFE TURNED ON. IRVINE BMW REPAIRED THE PROBLEM. LAST MONDAY OCT. 19, 2009 I PICKED UP MY VEHICLE AFTER DRIVING IN THE FREEWAY FOR ABOUT 10 MILES IT STALLED AGAIN FOR THE 3RD TIME. *TR

THE DRAIN VALVE IN 2003 BMW X5 DISINTEGRATES DUE TO MANUFACTURING DEFECT, IT IS INHERENTLY DEFECTIVE AND IS A SOURCE OF LEAKS AND IF NOT REPLACED WOULD CASE THE RADIATOR TO DRAIN OUT, CAUSING OVERHEATING AND RUINING THE ENGINE. THIS PROBLEM HAS BEEN NOTED ON BMW OWNER WEBSITES. HTTP://WWW.BIMMERFEST.COM/FORUMS/SHOWTHREAD.PHP?T=154553 HTTP://WWW.BIMMERFEST.COM/FORUMS/SHOWTHREAD.PHP?T=287894. *TR

I HAVE A 2003 BMW X5 4.4. WHICH SEEMS TO VIBRATE/JERK BETWEEN 20 AND 30 MPH. THE FIRST TIME (2009) I WENT TO THE DEALER THEY TOLD ME I NEEDED TO REPLACE MY TIRE WHICH I DID. THIS DID NOT HELP. I WENT BACK TO THE DEALER AGAIN AND NOW THEY TELL ME I NEED TO REPLACE THE TRANSMISSION. AFTER RESEARCHING THIS ISSUE ONLINE, I AM LEARNING MANY OTHER BMW OWNERS HAVE THIS SAME PROBLEM. I AM CURIOUS TO KNOW IF THIS IS A DEFECT. *TR

80K ON MY BMW X5 AND THE TRANSMISSION NEEDS REPLACED. *TR

I WAS DRIVING TO WORK WHEN I GOT A FOUL BURNING SMELL IN THE CAR. I HAD THE HEAT AND DEFOGGERS CRANKING SO I LOWERED THE FAN SPEED THINKING IT WAS COMING IN FROM OUTSIDE WHEN I NOTICED SMOKE FORMING ON THE FLOOR OF BY THE PASSENGER SEAT. AT THAT TIME I CAME TO A STOP LIGHT AND THE CAR SHUT OFF. I WAS ON A BUSY ROAD AND IT WAS VERY COLD OUT. I TRIED TO CRANK IT AND NOTHING. THE SECOND ATTEMPT SOUNDED AS IF SOMEONE THREW SOMETHING INTO A FAN. I WAS TOWED AND ADVISED BY THE MECHANIC THAT THE OIL SEPARATOR WENT CAUSING THE SPARK PLUGS TO FILL WITH OIL CAUSING THE MOTOR TO SHUT DOWN. BMW ADVISED THE MECHANIC THAT THIS IS A RECURRING PROBLEM AND THEY HAVE A KIT TO UPGRADE THE WHOLE MECHANISM. I WAS READING EDMUND BLOGS AND A NUMBER OF PEOPLE HAVE HAD THIS PROBLEM COSTING ANYWHERE FROM $1300 - $6000 DEPENDING ON THE DAMAGE. I HAD MISSED WORK THE DAY BEFORE DUE TO A SNOW STORM. I COULD HAVE BEEN IN A SERIOUS ACCIDENT IF I HAD BEEN CAUGHT IN BAD WEATHER OR ON THE HIGHWAY WHICH I TAKE TO WORK. THIS IS GOING TO BE AN EXPENSIVE FIX AND BMW IS AWARE OF THE PROBLEM. WHY ISN'T IT A RECALL? WHAT HAS TO HAPPEN BEFORE IT IS? WHAT ARE MY OPTIONS IN TRYING TO RECOVER MY EXPENSES. THE CAR HAS ALL OF 51000 MILES ON IT. *TR

THE RIGHT REAR BRAKE LIGHT BULB SHORTS OUT. INSTRUMENT WARNING FOR REAR BRAKE / TAIL LIGHTS ACTIVATES. PROBLEM OCCURS MULTIPLE TIMES DUE TO AN APPARENT FLAW IN THE BRAKE LIGHT ASSEMBLY CIRCUIT AND PLASTIC THAT FORMS THE SPLIT CIRCUIT FOR POSITIVE (+) NEGATIVE (-) CONNECTION POINTS TO BULB SOCKET LEADS. TO REPAIR - THE METAL ASSEMBLY NEEDS TO BE BENT OUTWARD (DIRECTION AWAY FROM TAIL LIGHT LENS) TO INCREASE TENSION BETWEEN BULB SOCKET ELECTRICAL CONNECTIONS AND METAL PLATE OF TAIL LIGHT ASSEMBLY. PROBLEM SEEMS TO BE CAUSED BY WEAKENED PLASTIC THAT CAUSES THE METAL PLATE IN TAIL LIGHT ASSEMBLE TO LOOSEN CREATING INADEQUATE BACK SPRING TENSION BETWEEN THE PLATE AND SOCKET CONNECTORS. RECALL ON BMW 3 SERIES FOR: NO. 11V-438: LAMPS IN REAR QUARTER PANEL 2002-2005 3 SERIES IS DESCRIBED AS THE EXACT PROBLEM. *JS

TL*THE CONTACT OWNS A 2003 BMW X5. WHILE DRIVING 10 MPH, THE VEHICLE STALLED AND THEN COMPLETELY SHUT OFF, LOSING ALL POWER AND ELECTRICITY. THERE WERE NO WARNING INDICATORS ILLUMINATED PRIOR TO THE FAILURE. THE VEHICLE WAS TOWED TO THE DEALER AND THEY STATED THAT THE OIL SEPARATOR WAS THE CAUSE OF THE FAILURE. THE VEHICLE IS CURRENTLY BEING REPAIRED. THE MANUFACTURER HAS NOT BEEN NOTIFIED. THE CURRENT AND FAILURE MILEAGES WERE APPROXIMATELY 83,000.

I OWN A 2003 X5. I LIVE IN NY. WHENEVER THE WEATHER GOES BELOW 20 DEGREES MY DOOR LOCKS FREEZE. I AM ABLE TO PULL OPEN THE DRIVERS SIDE DOOR, BUT ONCE I GET IN AND TRY TO CLOSE IT THE DOOR SWINGS BACK OPEN. I HAVE PULLED THE DOOR CLOSED AND MANUALLY PUSHED DOWN THE LOCK, BUT WHEN I TRY TO EXIT THE CAR I AM LOCKED IN. THE LOCKS WILL NOT OPEN AND I AM STUCK IN THE CAR UNTIL IT WARMS UP. THERE HAVE BEEN TIMES THAT I HAD TO CRAWL OVER TO THE PASSENGER SIDE DOOR TO GET OUT. THE WINDOWS WILL NOT GO DOWN AND THE LOCKS WILL NOT ENGAGE. I HAVE TAKEN THE TRUCK TO THE DEALER AND THEY STATE THAT THERE IS NOTHING THAT THEY CAN DO. I HAVE HAD TO SIT IN THE CAR OVER 30 MINUTES IN ORDER FOR THE LOCKS TO UNFREEZE SO THAT I CAN EXIT THE CAR. THIS IS A SAFETY HAZARD AND I BELIEVE IT SHOULD BE LOOKED INTO. MAYBE THE LOCKS CAN HAVE SOME TYPE OF PROTECTIVE MATERIAL PUT ON THEM SO THEY DO NOT SUCCUMB TO FREEZING TEMPERATURES SO EASILY. I PURCHASED THIS TRUCK SPECIFICALLY FOR THE WINTER AND FIND IT TROUBLING THAT THE WINTER IS THE WORST TIME FOR THIS VEHICLE. THIS HAS HAPPENED 5 TIMES THIS WINTER SO FAR AND WE ARE ONLY IN FEBRUARY WITH MANY MORE COLD DAYS TO COME. *TR

THIS PAST WEEK CONNECTICUT HIT A VERY COLD SPELL. 0*F. CRANK CASE VENT VALVE FROZE. AS A RESULT, TREMENDOUS PRESSURE BUILT INSIDE THE CRANK CASE, THE OIL CAP BLEW OFF AND THE ENGINE STOPPED WORKING PROPERLY. HAVE BEEN TOLD BY THE DEALER THAT THEY HAVE SEEN THIS PROBLEM BEFORE IN THE 2003 MODEL YEAR AND THAT IT IS NOT AN UNCOMMON PROBLEM IN VERY COLD WEATHER. WE HAVE ALSO LEARNT THE 2003 MODEL HAS A DESIGN FLAW WHERE THE VALVE IS NOT INSULATED AND NEWER MODELS HAVE CHANGED THE DESIGN TO CORRECT THE PROBLEM. PART REPLACED BY DEALER. WE WERE LUCKY OUR ENGINE DID NOT FAIL COMPLETELY. SINCE THIS PROBLEM IS KNOWN BY BMW, AND IS A CLEAR DESIGN DEFECT. SHOULDN'T IT BE THE SUBJECT OF A RECALL? *TR

ON 01/15/2009, THE EXTREMELY CHILLY DAY, MY WIFE DROVE THE X5 ON ROUTE 2 EAST BOUND AROUND EXIT 58 IN ARLINGTON, MA, THE EXHAUST SYSTEM SUDDENLY EMITTED HEAVY WHITE SMOKE, BUT THE OIL WARNING LIGHT DID NOT TURNED ON AT ALL. MY WIFE PULLED OVER THE CAR AND TURNED OFF THE ENGINE IMMEDIATELY. 15 MINUTES LATER, SHE FOUND THE ENGINE WAS DISABLED WHEN SHE TRIED TO RESTART IT. AFTER THE CAR WAS TOWED TO BMW SERVICE CENTER ,I WAS INFORMED THE CAR NEEDS THE FOLLOWING REPLACEMENTS 'CRANK CASE VENT VALVE 'VALVE COVER GASKETS AND SPARK PLUGS 'TRANSFER CASE THE TOTAL COST IS $1360+$3125= $4485. *TR

I HAVE HAD SEVERAL PROBLEMS WITH MY VEHICLE INCLUDING FAILURE OF SUSPENSION SYSTEM BUT OF CONCERN IS WHEN ABOUT 2 YEARS AGO I WAS MAKING A U TURN AT A TRAFFIC LIGHT, COMPLETED THE U TURN AND MY ENGINE DIED. CAR CAME TO A STOP. I TURNED OFF THE KEY AND RESTARTED THE IGNITION AND ENGINE TURNED ON AGAIN. THIS HAS NEVER HAPPENED AGAIN BUT I AM CONCERNED THAT IT MIGHT IN LIGHT OF RECENT ARTICLES THAT BMW HAS BEEN HAVING SIMILAR PROBLEM WITH NEWER CARS. *TR

TL*THE CONTACT OWNS A 2003 BMW X5. WHILE PULLING INTO THE DRIVEWAY AT 5 MPH, THE DRIVER NOTICED THAT THE INSTRUMENT PANELS LIGHT BEGAN TO DIM AND THE VEHICLE STALLED. APPROXIMATELY TWO HOURS LATER, THE VEHICLE WAS ABLE TO BE RESTARTED AND WAS DRIVEN TO THE DEALER. THE MECHANIC INFORMED HER THAT THE INSTRUMENT CLUSTER WAS DEFECTIVE AND NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED AND THE MANUFACTURER WAS NOT NOTIFIED. THE CURRENT MILEAGE WAS 100,200 AND FAILURE MILEAGE WAS 95,000. UPDATED 03/09/09. *LJ AFTER SHUTTING THE VEHICLE OFF, THE FRONT AND REAR LIGHTS STAYED ON AND THE DOOR LOCKS WERE INOPERATIVE. THE CONSUMER ATTEMPTED TO RESTART THE VEHICLE, BUT IT WOULD NOT START. THE DEALER FOUND COMMUNICATIONS FAULTS IN THE INSTRUMENT CLUSTER. UPDATED 03/12/09. *JB

TL*THE CONTACT OWNS A 2003 BMW 540. WHILE THE CONTACT'S DAUGHTER WAS DRIVING APPROXIMATELY 30 MPH, SHE HEARD A LOUD NOISE. THE FRONT DRIVER'S SIDE DOOR AIR BAG AND REAR DOOR AIR BAGS DEPLOYED, INJURING HER LEFT ARM AND LEG. THE VEHICLE WAS DRIVEN TO A BMW DEALER. THE VIN WAS UNKNOWN. THE CURRENT AND FAILURE MILEAGES WERE 68,000.

TL*THE CONTACT OWNS A 2003 BMW X5. WHILE THE CONTACT WAS DRIVING 50 MPH HE NOTICED A CLICKING SOUND COMING FROM THE FRONT OF THE VEHICLE. WHEN THE CONTACT ATTEMPTED TO ACCELERATE THE RPM'S WOULD RISE BUT THE VEHICLE WOULD NOT MOVE. THE CONTACT DID NOT NOTICE ANY DIFFERENCES IN THE VEHICLE BEFOREHAND AND WAS NOT IN A CRASH DUE TO THE FAILURE. THE VEHICLE WAS TOWED TO THE DEALER WHERE THE CONTACT WAS INFORMED THAT THE TRANSMISSION AND THE DIFFERENTIAL FAILED. THE VIN IS UNAVAILABLE. THE CURRENT AND FAILURE MILEAGES WERE 48000.

STARTING SMELLING A BURNING ODOR IN CAR. SHORTLY AFTER, NOTICED (FELT) A "HOT SPOT" ON THE LEFT SIDE OF THE DRIVER'S SEAT SO I TURNED THE HEATER OFF. I HAD THE DEALER LOOK AT THE SEAT - THE RESPONSE WAS THAT THE LEATHER HAD WORN THEREFORE I WAS FEELING A LITTLE MORE WARMTH IN THAT SPOT (AT THE TIME I TOOK THE CAR IN, I MUST HAVE HAD ONLY 40-50,000 MILES ON IT AS I ONLY PUT AN AVERAGE OF 8,000-10,000 MILES PER YEAR ON THE CAR. IT SEEMS RIDICULOUS TO ME THAT THE LEATHER WOULD WEAR THAT MUCH IN SUCH A SHORT AMOUNT OF TIME ESPECIALLY SINCE I AM OF SLIGHT BUILD). I ADVISED THAT IT SMELLED LIKE BURNING AND THE SPOT WAS SO HOT THAT IT FELT LIKE SOMETHING WAS WRONG WITH THE ELECTRICAL. AGAIN, I WAS TOLD THERE WAS NOTHING WRONG WITH THE HEATER; IT WAS SIMPLY ME FEELING MORE HEAT DUE TO THE THINNING LEATHER. SHORTLY AFTER, SINCE THE DEALER TOLD ME THERE WAS NOTHING WRONG WITH THE HEATER, I TRIED IT AGAIN. THIS TIME THOUGH, A HOLE ACTUALLY BURNED THROUGH THE LEATHER (ENOUGH THAT I FELT THE BURN). I HAVEN'T USED THE SEAT HEATER SINCE. I'M TOLD THE ENTIRE SEAT BOTTOM MUST BE REPLACED AND THE COST IS ABOUT $2400. THE COST OF THE SEAT IS HIGH AND LABOR IS VERY HIGH SINCE THE ENTIRE SEAT MUST BE TAKEN OUT. *TR

COLD WEATHER (NEW YORK WINTER). 2003 BMW X5, 3.0 ENGINE SEIZED WITHOUT WARNING. OIL SEPARATOR AND VALVE COVER GASKET FAULTY. THE CRANK CASE VALVE FREEZES, CAUSING OIL TO SPILL INTO THE ENGINE. THIS PROBLEM OCCURRED THREE TIMES. 1. FEB 13 2008 2. JAN 28 2009 AND 3. JAN 2011. TOTAL COST FOR USED ENGINE $6,000 THIS YEAR AND $3000 IN 2008/2009 TO REPAIR. SPARK PLUGS NEEDED TO BE REPLACED, ENGINE NEEDED TO BE CLEANED 2008 AND DEFECTIVE DISA VALVE REPLACED 2009.

WITHOUT PRIOR WARNING, THE CAR (2003 BMW X5) WILL STALL. THE STALLING HAS OCCURRED IN TRAFFIC AND IN PARKING LOTS. *TR

FUEL GUAGE FAILED, INDICATED HALF TANK GAS WHEN TANK WAS EMPTY, AND CAR RAN OUT OF GAS ON FREEWAY. *AK

CRANKCASE VENT VALVE FROZE & BLEW OFF OIL CAP. OIL ALL OVER ENGINE. REPLACED CRANKCASE VENT VALUE, W/ NON ORIGINAL, & ALL HOSES. REMOVED & CLEANED OUT DIPSTICK TUBE, DISTRIBUTION PIECE. REMOVED LOWER ENGINE SPLASH PAN & STIFFENING PLATE. DE-GREASED TOP & BOTTOM OF ENGINE COMPARTMENT. THERE IS A SERVICE BULLETIN ABOUT THIS PROPENSITY FOR THE CRANKCASE TO FREEZE. THIS IS UNACCEPTABLE IN COLD WEATHER STATES. THE AUTO IS SOLD IN THE COLD WEATHER STATES REGARDLESS. *TR

NO EVENT NECESSARY LEADING UP TO FAILURE AIR STRUT FAILED WHICH CAUSES A SIGNIFICANT STEERING AND HANDLING PROBLEM BECAUSE THE COMPUTER THINKS THE CAR IS IN A POSSIBLE ROLL, AND BEGINS TO COMPENSATE BY AUTOMATICALLY BRAKING. I HAVE REPLACED THREE AIR STRUTS - ALL IN THE FRONT OVER THE PAST TWO YEARS. THE COST IS APPROXIMATELY $2,000 PER. THE AIR STRUT OPTION WAS NOT ON VERY MANY BMW X5 AUTOS - BUT THEY ARE A SERIOUS PROBLEM WHEN THEY FAIL. THE DEALER REPLACE THE FIRST ONE - AND WOULD NOT LET ME DRIVE THE VEHICLE BECAUSE IT COULD BE "DANGEROUS". *TR

DT*: THE CONTACT STATED WHILE MAKING A SLOW LEFT HAND TURN, THE VEHICLE STALLED WITHOUT WARNING, BUT RESTARTED EACH TIME. THE DEALERSHIP REPROGRAMMED THE DME WITH VERSION 43 AND SET THE MINIMUM IDLE TO 750, THIS HAS CORRECTED THE PROBLEM. UPDATED 06/27/06 *JB THE CONSUMERS WIFE EXPERIENCED THE SAME PROBLEM.

DT: THE CONTACT STATED WHILE DRIVING THE ENGINE TEMPERATURE RAISED ALL THE WAY TO THE RED WITHOUT ANY WARNING. THERE WASN'T ANY SMOKE OR ANY OTHER INDICATORS OF PROBLEMS WITH THE VEHICLE. SHE CONTACTED HER DEALER, AND WAS ADVISED TO HAVE THE VEHICLE TOWED TO THE DEALERSHIP.*AK

PREMATURE WEAR OF REAR TIRES: THE FACTORY SET ANGLE OF CAMBER LEADS TO SEVERE CUPPING OF THE REAR TIRES ON A 2003 BMW X5 4.4 AFTER 30000 MILES, CORD IS SHOWING ON THE INSIDE OF THE TIRE. (BRIDGESTONE TURANZA ER30(TZ) 285-45R19 107V). DEALER SAID THIS IS NORMAL WEAR. IN ADDITION, THE DEALER SAID THE VEHICLE IS SETUP WITH HIGH NEGATIVE CAMBER BECAUSE IT IS MEANT TO BE DRIVEN AT 100 MPH. THE REST OF THE TREAD IS NORMAL, THE VEHICLE HAS BEEN DRIVEN CONSERVATIVELY, AND THE TIRE PRESSURE IS CHECKED OFTEN. REPAIR INCLUDES REPLACING THE REAR TIRES AND A 4 WHEEL ALIGNMENT. ($800). *NM

BMW X-5 HAS CAUSED TWO ACCIDENTS BY SPONTANOUS ACCELLERATION - AFTER FIRST ACCIDENT BMW WAS CONTACTED AND ENGINEERS KEPT VEHICLE AND DETERMINED THAT CAUSE OF ACCIDENT DRIVER ERROR-WE PAID FOR REPAIR OF VEHICLE. SAME "ACCELERATION" HAPPENED ABOUT SIX MONTHS LATER ON JANUARY 7 SENDING CAR CRASHING THROUGH FRONT OF BUILDING - ONLY BY MIRACLE PEOPLE WEREN'T INGURED IN THESE ACCIDENTS (THE BUILDING WAS A A RETAIL STORE). THIS IS A LEASED VEHICLE AND WE DON'T KNOW WHAT TO DO. LSO, THESE INCIDENTS HAVE CAUSED OUR INSURANCE TO SKYROCKET.*AK

CONSUMER WAS TRAVELING 45 MPH AND VEHICLE SURGED FORWARD, AND DROVE ROUGHLY. A LOUD GRINDING NOISE WAS HEARD COMING FROM THE FRONT. CONSUMER NOTICED THAT THE CHECK ENGINE LIGHT FLASHED ON THEN OFF. CONSUMER DROVE IT TO THE DEALER, AND MECHANIC DETERMINED THAT TWO IGNITION COIL SPRINGS NEEDED TO BE REPLACED INSIDE OF THE ENGINE. *AK

DRIVING BMW X5 AT 50 MPH, FRONT DIFFERENTIAL LOCKS UP TAKING VEHICLE FROM 50 MPH TO APPROXIMATELY 25 MPH IN ABOUT 1 SECOND THEN DIFFERENTIAL FAILS. GEAR OIL SPRAYED ON HOT EXHAUST AND ENGINE, CAR WOULD NOT MOVE FORWARD, PASSENGER (MY WIFE) JUMPS OUT WHEN WE STOPPED THINKING CAR WAS GOING TO CATCH FIRE (SMOKE AND STRONG BURNING SMELL FROM OIL). DEALER HAD CAR TOWED TO SHOP, HAD TO REPLACE FORWARD DRIVE TRAIN. CAR WAS IN SHOP 4 DAYS. MY WIFE WILL NOT RIDE IN CAR AGAIN, SHE ALMOST IMPACTED THE DASH WHEN AXEL LOCKED UP, HAD ROAD BEEN WET OR ICY, WE COULD HAVE VERY EASILY LOST CONTROL. HAD A VEHICLE BEEN BEHIND US, VERY LIKELY THEY WOULD HAVE RUN INTO THE BACK OF THE CAR IT STOPPED SO FAST AND UNEXPECTEDLY. FELT LIKE WE RAN OVER A LARGE TREE IN THE ROAD BUT THE ROAD WAS PERFECTLY CLEAR. IMMEDIATELY TRADED THE CAR AND BOUGHT ANOTHER VEHICLE, BELIEVE NTSB NEEDS TO BE AWARE OF THE FAILURE AND SEE IF IT HAPPENS ELSEWHERE, VERY SCARY TO HAVE CAR WHEELS LOCK UP ON THE HIGHWAY AT ANY SPEED. *JB