BMW · Z4 · 2003
4
Recalls
413
Complaints
-
Not Rated
The 2003 BMW Z4 has 4 recalls and 413 owner-reported complaints on file with NHTSA. Most reported issue: steering (320 reports).
Source: NHTSA Public Records · Updated Apr 28, 2026
The 2003 BMW Z4 page works best as a research starting point. Complaint totals show how much owner-reported activity exists, while recalls and investigations help show whether any of that activity turned into formal safety action.
Because this is a newer-era vehicle page, it usually helps to compare this year against nearby model years before deciding whether a complaint pattern looks isolated or persistent. On this page, the most prominent complaint area is steering with 320 reported complaints.
This page combines three types of NHTSA data: recall campaigns (official manufacturer or government actions), owner complaints (unverified consumer reports), and crash test ratings (where available). A vehicle with many complaints is not necessarily less reliable — complaint volume correlates with sales volume and vehicle age. Recalls indicate identified defects, not overall quality. To compare this model year with others, use the year navigation in the sidebar or return to the model overview page.
If you are researching a used vehicle, start with the complaint categories, compare them against the recall list, and then check nearby model years to see whether the same issue profile repeats. That usually produces a better buying or research signal than treating the raw complaint total as a standalone safety ranking.
ON CERTAIN PASSENGER VEHICLES, INCOMPATIBLE ELECTRONIC AIR BAG SYSTEM PROCESSORS MAY HAVE BEEN INSTALLED.
Remedy Status
DEALERS WILL INSPECT AND, IF NECESSARY, REPLACE THE AIR BAG SYSTEM PROCESSORS. THE RECALL BEGAN JUNE 11, 2004. OWNERS SHOULD CONTACT BMW AT 1-800-831-1117.
ON CERTAIN PASSENGER VEHICLES, UNDER CERTAIN ENVIRONMENTAL CONDITIONS, A VAPOR LOCK IN THE FUEL PUMP COULD OCCUR CAUSING THE ENGINE TO STALL. IF THIS WERE TO HAPPEN, THE ENGINE WOULD NOT BE ABLE TO BE RESTARTED FOR APPROXIMATELY 15 TO 20 MINUTES.
Remedy Status
DEALERS WILL INSTALL A RESISTOR IN THE ELECTRICAL LINE POWERING THE FUEL PUMP IN ORDER TO PREVENT AN OCCURRENCE OF VAPOR LOCK. THE RECALL BEGAN MAY 11, 2004. OWNERS SHOULD CONTACT BMW AT 1-800-831-1117.
ON CERTAIN VEHICLES EQUIPPED WITH 18" TIRES, IT IS POSSIBLE THAT THE TIRE HAS BEEN DAMAGED DURING THE MOUNTING PROCESS TO THE RIM.
Remedy Status
DEALERS WILL UNSEAT THE TIRE FROM ITS RIM, INSPECT FOR ANY DAMAGE, AND THEN RESEAT THE TIRE TO ITS RIM. IF INSPECTION REVEALS THAT A FRONT TIRE HAS INCURRED DAMAGE DURING THE MOUNTING PROCESS, IT WILL BE REPLACED. OWNER NOTIFICATION BEGAN JULY 14, 2003. OWNERS SHOULD CONTACT BMW AT 1-800-831-1117.
ON CERTAIN PASSENGER VEHICLES, THE CONNECTION OF THE SAFETY BELT BUCKLE TO THE STEEL ROPE OF THE TENSIONER DOES NOT MEET BMW SPECIFICATIONS. IN SEVERE FRONTAL CRASHES, THIS CONNECTION CAN DETACH.
Remedy Status
DEALERS WILL INSPECT BOTH FRONT SAFETY BELT TENSIONER AND BUCKLE ASSEMBLIES, AND IF NECESSARY, REPLACE THESE PARTS. OWNER NOTIFICATION BEGAN MARCH 19, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT BMW AT 1-800-831-1117.
Steering is binding up, very hard to steer and control. Car starts out running fine after parked in hot weather and restarted it is almost uncontrollable. Looking for corrective action. Only 39,920 miles on car. Would like to use it or sell it, can do neither in current condition...
Preview excerpt
When outside temp is 80degrees or higher it becomes difficult to maintain the vehicle in the correct driving lane due to a stickyness in the steering wheel. I will not allow anyone to drive the vehicle when the temp is over 80 degrees ... sucks to have a convertable that you can...
Preview excerpt
Dealer sold me a car and the next day the car no turn on engine and have a full leaking under
My girlfriend, [XXX] , purchased a used 2003 BMW z4 2.5i. It is pristine with 47K original miles. Always maintained, garaged and never driven in foul weather. I, [XXX] , drove it home for her and noticed the steering to be "sticky". This showed on the highway traveling at 65 MPH...
Preview excerpt
Upon starting the car, power steering does not work making car unmanueverable.
The contact owns a 2003 BMW Z4. The contact stated that the coolant warning light illuminated. The contact then stated that she noticed smoke underneath the hood of the vehicle. The contact stated that upon inspecting the vehicle, she noticed a leak on the ground located near the...
Preview excerpt
Sticky steering steering wheel hard to turn and stops intermittently when outside temperature is hot
The steering in this BMW Z4 gets "sticky" in warm or hot weather. It drives fine in cold weather. The steering has to be constantly corrected as it pulls to the left. It will not track in a straight line and needs constant corrections from side to side to compensate for the prob...
Preview excerpt
DRIVERS DOOR WOULD NOT OPEN. Couldn't get out of the car. Had to get assistance to get out of car.. Had car towed to BMW dealership.. The spent hours trying to get door open. They had to go down through the convertible top to remove the drivers seat in order to get panel off to...
Preview excerpt
STICKY STEERING AFTER CAR WARMS UP. STEERS LIKE A BOAT. DANGEROUS AT HIGHWAY SPEEDS OR WINDING ROAD.
Showing 10 recent complaints from 413 total
View Full Complaint LogThe strongest comparison flow is usually: exact vehicle-year page, then nearby years of the same model, then other 2003 BMW models. That sequence helps separate one-off year spikes from broader make-wide patterns.
The 2003 BMW Z4 has 4 recalls recorded by NHTSA.
NHTSA has received 413 owner-reported complaints for the 2003 BMW Z4.
NHTSA has not published a safety rating for the 2003 BMW Z4.
The most commonly reported complaint categories for the 2003 BMW Z4 are steering (320 reports), air bags (21 reports), engine and engine cooling (7 reports).
Yes. NHTSA has 4 recalls on record for the 2003 BMW Z4. Scroll up to review the published recall summaries, consequences, and remedies. To check for unrepaired recalls on your specific vehicle, use your VIN at nhtsa.gov/recalls.
Look up recalls and complaints for any year, make, and model.
This page summarizes publicly available data from the National Highway Traffic Safety Administration (NHTSA). Complaint counts reflect reports submitted to NHTSA by vehicle owners and do not by themselves prove defect severity or vehicle safety. Safety ratings may not be available for all vehicle-years. This site is not affiliated with NHTSA or any vehicle manufacturer. For official information, visit the official NHTSA page for this vehicle.