2007 Chevrolet Corvette Complaint Log

The contact owns a 2007 Chevrolet Corvette. The contact stated that while the vehicle was parked at the residence, after exiting the vehicle, the contact became aware of an abnormal fuel odor inside the vehicle. A dealer was contacted. The vehicle was not taken to the dealer or an independent mechanic to be diagnosed. The vehicle was not repaired. The manufacturer was notified of the failure and informed the contact that a special coverage had expired. The failure mileage was 11,500.

Fuel smell - possible fuel leak - the issue had been previously addressed with replacement of fuel subassembly in both saddle tanks. I believe that it is happening again ...

There was a strong fuel smell after the last 2 times I drove it. I took it to the shop and they tell me the evap canister was saturated and the fuel pump had small cracks in it likely seeping when the car heats up. I am having the fuel pump replaced, the evap canister and several seals/hoses in hopes it won't leak again.

After filling the tank with fuel, I was immediately aware of a strong smell of gas. I am always extremely careful not to overfill causing any fuel to escape. The heavy smell/escape of fumes is such that the car simply can’t be put in my garage. The risk of igniting and fire is a risk that is unacceptable. General Motors knows about this issue as they did notify me in 2017 that my car could have this condition and that if it did, they would fix it at no charge. I didn’t have the issue at that time so didn’t take the car in. So, now that I the problem, I have taken the car to Bradley Chevrolet in my town, Lake Havasu City, AZ and am told that in order to inspect the car for this issue, I will have to pay for 10 hours of labor ($2200) and only then will they see if they can find a new tank at another dealer. You see, GM no longer makes or has the tanks (according to their parts department). I have contacted their Customer Service Department and have a Case (#[XXX]). I am told that they will not participate going forward unless I spend the $2200 and then if they can’t find a new tank, they will put the car back together and send me home with it! It’s my belief that since this is a documented safety defect resulting in an apparent fire hazard that they would/should take care of it. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Fuel smell but no leaks detected, can't store car in garage because of fumes. Worried when driving a fire will occur Had a service bulletin 150682 special vehicle adjustment, need help.

Fuel smell inside and outside when car is parked.

The contact owns a 2007 Chevrolet Corvette. The contact stated while starting the vehicle, there was a loud creaking and popping noise coming from the sunroof. The dealer was contacted; however, the vehicle was not repaired. The contact was concerned about the safety of the vehicle. The manufacturer was made of the failure and advised the contact to reach out to NHSTA Hotline for assistance. The failure mileage approximately was 22,000.

The fuel tank leaks after filling with fuel, resulting in gas vapors filling the garage. This is a known issue with many C6 corvettes. May result in a fire or explosion

There is a strong smell of gasoline coming from the outside of the car. It is strongest once the car has been sitting in my garage overnight. Some evidence of fuel under the car.

Fuel pump had hairline cacks on top. Gas leak under pressure. Strong fumes while in garage. Gas leaks down on exhaust pipes

There is a fuel leak most likely coming from the fuel pump or gasket from within the 2 gas tanks. Gas fumes are building up in my garage causing a horrible smell. Very dangerous please do something about this. Chevrolet has no recalls for this common problems.

Strong fuel smell inside car as well as in garage. Drivers side tank does appear to have a leak when filled. Doing a search online it appears this is a common issue with this vehicle and that a recall/repair was created for owners however my 2007 (not the original owner) I suspect has since expired. In my opinion any defects that puts the owner and personal property at risk should be covered regardless of age.

We are having an issue with our vehicle leaking fuel on left side fuel tank. The vehicle is constant smell of gas on that left side. It has been a safety concern for us and the dealer wants us to pay at least $1200 just for diagnostic alone. There was a Special Coverage Adjustment for this issue but we were never notified. The notice is Special Coverage Adjustment 15682. I spoke with GM/Chevrolet Customer Assistance and spoke with [XXX] he said I would have to get diagnostic and that the fee could be applied to repair. I understand there is a time limit on most things but it seems that something that relates to safety issue should not have and end date. This is a type of car that most people just have as a collector car and you can see by the low miles that this is the case. I am not trying to get a repair on a vehicle that has 100,000 or more miles. It may seem trivial but this is important to me. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Very strong fuel smell from driver side wheel well and inside of car. When car is parked inside garage it is unbearable.

For last 3 years whenever I fill my vehicle with gas the garage smells of gas until the tank is less than half a tank... The other major issue is the vehicle will not come out of park multiple time. This has put me in embarrassing situations many times. I stay away from driving the vehicle so many times when I could be in physical danger .

The Body Control Module has failed and there are no replacement parts available except used parts. The BCM is hard coded with the VIN. If you use a BCM from another car, certain safety systems are deactivated such as the air bags. The BCM is central to the electronic architecture so all other systems are at risk. The unit can be responsible for the car not starting, the headlights not working, the power windows and door locks failing, or in my case the active suspension not functioning. Since BCM's are widely used, this is a looming major safety issue for the nation because GM quit making new ones, no one else makes these parts, no one can repair the units. I know a number of C6 Corvette owners are using used parts which deactivates the air bags and the security system.

I started smelling gas from my car two weeks ago. I discovered on Corvette Forum.com that this is a common problem. If the car is filled up over 1/2 tank gas will come out of the top and drip on the exhaust, which is very concerning. Chevrolet claims that the cars with this issue were recalled, but mine was not. This is one of two reoccurring issues with the C6 Corvette, and unfortunately, I am a victim of both. The other is the shifter locks in place, and the car will not come out of park. Chevrolet does not own up to the responsibility for this defective engineering as well. Please add me to the complaints for these two recallable issues as Chevrollet refuses to address the issue. Fuel dripping on the exhaust preplexes me why NHTSA has not got involved already.

Headlights suddenly stopped working.

There is a very strong fuel odor coming from the car when I shut it down, especially when I park in the garage. The smell is overwhelming. Seems like it's coming from the rear part of the car, drivers side. I don't see fuel leaking nor on the garage floor, but it is very evident there is a problem. This is a safety issue that needs to be addressed. thank you

Every time the fuel tank is filled to full (not past the click), there is a very bad fuel smell but no fuel leaking on the ground. I bought the car with 69000 and have noticed it every time I have filled the tank to full but never past the "click". I have read of many others having the same problem. I am afraid to park my car inside my garage. I have had fuel system parts replaced but it still continues. No leak has ever been noted.

The airbag indicator light on the dash of the vehicle periodically lights up indicating a fault with the system. The car was checked by a dealer who could find no issue. The light resets if you cycle the vehicle on/off, but the problem returns randomly when driving the vehicle. The airbag system disabling itself without warning puts the driver at risk of not having the system deploy under conditions it should. The system resetting the warning to every on/off cycle is also misleading because unless you experience the behavior there is no reliable way to know that there is an issue with the SRS system on the vehicle.

The contact owns a 2007 Chevrolet Corvette. The contact stated the engine of the vehicle was replaced because he wanted to update the engine. The contact stated that once the engine was replaced the vehicle would not start. The dealer diagnosed the vehicle and stated that 5 cylinder fractured causing the engine to lock up. The manufacturer was contacted and provided no further assistance. The failure mileage was 0.

The contact owns a 2007 Chevrolet Corvette. The contact stated there was an abnormal fuel odor inside the vehicle while the vehicle was parked in the garage. The contact had not found a fuel leak. The dealer was contacted however, the vehicle was not diagnosed or repaired. The contact was informed that the repair would be an out-of-pocket expense. The manufacturer was not notified of the failure. The approximate failure mileage was 37,000.

Smell gas around and in car. Cannot see where it is coming from no sign on ground continuing issue for at least a year. I do not use the car . Afraid of fire. My primary car has been in for repair last 30 days and I am forced to use this car

The contact owns a 2007 Chevrolet Corvette. The contact stated the transmission had been seized in the park(P) position intermittently. The transmission would eventually release after manipulating the gear shifter several times. There were no warning lights illuminated. The contact had not taken the vehicle to the dealer. The vehicle had not been diagnosed or repaired. The manufacturer was made aware of the failure. The approximate failure mileage was 1,621.

The contact owns a 2007 Chevrolet Corvette. The contact stated that while the vehicle was at an inspection station for a smog test, the technician informed him that there was fuel leaking from the fuel tank onto the exhaust pipe. Additionally, a strong fuel odor was detected inside the vehicle. The dealer was made aware of the failure and scheduled an upcoming appointment for diagnostic testing. The vehicle was not diagnosed or repaired. The manufacturer was made aware of the failure but informed the contact that the Special Coverage Adjustment Number: 15682 for the Primary Tank Module Flange Fuel and Vapor Leaks had expired. The contact related the failure to TSB: N150682. The failure mileage was approximately 89,000.

Strong smell in car of gasoline and around car

This vehicle has a strong odor of gasoline from the rear of the vehicle. There are no signs of fuel on the ground where the vehicle is parked. I understand that this was the subject of another GM special coverage adjustment 15682. I am concerned that the vehicle may catch fire and cause damage to person and property.

The contact owns a 2007 Chevrolet Corvette. The contact stated that while the vehicle was parked in his garage with the engine off, the contact turned on the accessory switch which caused the engine to start. Once the engine started, the vehicle began to roll backward with the driver-side door open which caused the contact to be knocked over. The contact was dragged with the vehicle out of his garage as the driver's side door was caught by a part of the house garage door jamb which folded the door. The driver door detached the vehicle as the driver-side window burst and damaged the interior door panel. The contact was able to roll free from the vehicle once it left the garage; the vehicle rolled into his neighbor's landscaping which caused the vehicle to stop. The contact suffered cuts and scrapes to the right side of his back, buttocks, arm, ankle, as well as, his left and right legs. The contact did not seek medical attention. A police report was not filed. The contact drove the vehicle back into the garage and later had it towed to an independent body shop. The contact called a dealer where they informed him that there were no recalls on his vehicle. The contact attempted to reach the manufacturer but was kept on indefinite hold. The vehicle had yet to be repaired. The failure mileage was approximately 7,800.

After starting the vehicle I am unable to shift out of park. This endangers both myself and a passenger if I need to move the car quickly in case of fire or another vehicle or object coming toward me. It also endangers other passengers in vehicles I may be blocking because they are unable to move. There are many other C6 Corvettes with this same problem documented per the Corvette Forum and YouTube.

I was rear ended on Monday 08/02/21 at approximately 2:45pm in Atlanta, GA. The impact of the accident caused my driver's seat back to collapse backwards. Now I have back pain that I did not have previously. The seats should be recalled and repaired immediately.

The airbag warning light comes on when there is only the driver in the vehicle. When there are two people in the vehicle the airbag warning light goes off. I have had this checked at an independent Corvette mechanic and he says the parts are very expensive and not available at this time. I was wondering if you could tell me if this is a problem that has been reported by other Chevy owners? Where can I go to get parts? There has been no injury or accident. I would like for my airbags to work properly. In case of an accident lack of airbags could be a problem.

On this car there is no way to manually open the convertible top in the down position. The spot where there is a hole depicted in the car manual where a button to push to manually open the top is missing. I view this as a safety problem.

Warning light that indicates an airbag system malfunction comes on intermittently for no reason. Occurrs when vehicle is not being driven, but lights when you start the car. Thia ia a serious safety issue since the airbags wont deploy when it's lit. Car only has 13,000 original miles on it.

WITHOUT THE ABILITY TO SEARCH A DATABASE FOR TSB IMPLEMENTATION, I HAVE NO WAY TO DETERMINE IF MY USED CAR PURCHASE HAS BEEN FIXED PER THE MANUFACTURER RECOMMENDATION OUTLINED IN THE TSB. ON MY PARTICULAR VEHICLE, I AM NOT ABLE TO ASCERTAIN IF THE FUEL LEAK ISSUE WAS REPAIRED!! TSB IMPLEMENTATION NEEDS TO BE HANDLED SIMILAR TO SAFETY RECALLS TO PREVENT SERIOUS PROBLEMS FOR UNSUSPECTING USED CAR BUYERS.

JUST PURCHASED THIS USED CAR WITH LESS THAN 3000 MILES. I HAPPENED TO COME ACROSS THE FUEL LEAK ISSUE IN ONLINE FORUM. SINCE I REC'D INCOMPLETE SERVICE RECORDS, I DO NOT KNOW IF THE REPAIR HAS BEEN DONE TO MY CAR. THIS IS JUST NOT RIGHT WHEN TH EPROBLEM COULD CREATE A FUEL LEAK ONTO THE EXHAUST. IF THE PROBLEM WERE MADE A RECALL, THEN GM WOULD BE FORCED TO NOTIFY ME AS THE CURRENT OWNER SO THAT THE PROBLEM COULD BE FIXED BEFORE THERE IS A FIRE RESULTING FROM FUEL LEAK.

Vehicle will not shift out of park after starting, even when brake pedal is properly depressed.

MY 07 HAS A STRONG ODOR OF GAS BY DRIVER SIDE AND TANK...ALSO ON BOTTOM OF TANK HAD DRIPS ON TANK CANNOT PUT MY CAR IN GARAGE CAUSE THE FUMES ARE INTENSE AND AFRAID IT MIGHT START A FIRE IN MY HOME AND ALSO THE CAR ...I LIKE THIS CAR VERY MUCH AND WANT TO KEEP IT IN GARAGE BUT DUE TO THIS I CANNOT. I WORK OUT OF TOWN AND I HATE TO COME BACK AND MY HOUSE BE ON FIRE SOMETHING NEEDS TO BE DONE ABOUT THIS ISSUE..ACCORDING TO RESEARCH IT SEEMS TO BE MY CAR IS NOT THE ONLY ONE THEY NEED TO RECALL THIS ISSUE AND BEFORE SOMEONE GETS BURN IN CAR OR THEIR HOUSE BURNS DOWN IT CAN CAUSE SERIOUS INJURIES..

I recently purchased my 2007 c6 corvette used. I did not notice anything until I started my drive home which was a 200 mile drive. the gas gauge was reading 1/4 tank of gas and dropped to empty. We stopped in at the gas station and filled the tank but once we did the gauge continued to read empty and a light displayed on the dash stating service fuel system. We continued to drive on our way home and we noticed a strong fuel odor inside the cabin of the car and distinctively from the driver side of the vehicle. I got the car home and noticed a few small drips in the garage that quickly evaporated. To the best of my knowldge I suspected that it was fuel. for the next week or so we did not drive the car but the garage smelled strongly of fuel. I parked it out side and the fuel smell in the garage went away. Odly after filling the tank a few more times the gauge began working again and the service fuel system message went away. It eventually showed an empty tank and then full again. I went to visit my local gm dealer to see if any recalls had been placed on my car over the years and they told me that there are no active recalls. However in my sear accross the forums I found gm bulletin 15682 (primary tank module flange fuel and vapor leaks) for my 2007 corvette. This bulletin was released in july 2016. perfectly matching the issue I am experiencing and was advised my member of many of the forums to file a concern with nhtsa. I have not yet had it inspected by the dealership because they want $1500.00 to inspect and repair because of the need to drop the drive train for proper access. I Would appreciate any assistance with this issue. I am scared to drive my care due to a fire related accident and it is my primary means of transportation.

CAR STICKS IN PARK AT TIMES AND IS HARD TO GET OUT OF PARK, HAPPENS OFTEN FOR PAST YEAR

STRONG FUEL SMELL COMING FROM FENDER AREA WHEN FUEL TANK IS HALF FULL

RECENTLY, 03/01/2021, FILLING GAS TANK TO OVER 1/2 FULL ON MY PARKED 2007 C6 CORVETTE, WITH 30,360 MILES, PARKED VEHICLE CAUSED STRONG INTERIOR GAS ODOR. ON FURTHER INVESTIGATION AND COMMUNICATION WITH GM, I WAS INFORMED FUEL PUMP WAS A KNOWN ISSUE. THE FUEL PUMP WAS THEN REDESIGNED TO SOLVE THIS ISSUE; HOWEVER, REPLACEMENT OF FAULTY FUEL PUMP WAS ONLY GIVEN A WARRANTY EXTENSION INSTEAD OF RECALL. CONSEQUENTLY, I WAS NEVER GIVEN A NOTICE OF THE DANGEROUS CONDITION THAT EXISTED IN MY VEHICLE, WHICH IS NOW BEYOND THAT EXTENDED WARRANTY PERIOD FOR SPECIFIC PARTS; AND, AS AN OWNER, I WAS NEVER NOTICED OF THIS KNOWN ISSUE BECAUSE IT IS NOT REQUIRED UNLESS IT IS A RECALL. APPARENTLY THE CAR HAS TWO TANKS THAT ARE SHARED. WHEN OVER 1/2 FILLED, GASOLINE CAN LEAK AND PUDDLE ON TOP OF THE TANKS. WHEN MOVING, THE GASOLINE CAN THEN LEAK DOWN ON THE HOT EXHAUST AND CAUSE A FIRE. I AM NOW FEARFUL OF DRIVING MY CAR DUE TO THE GASOLINE VAPORS, AND WAS ADVISED BY VAN CHEVROLET TO HAVE THE CAR TOWED FOR REPAIR, AS THIS ISSUE COULD CAUSE A FIRE OR EXPLOSION, OR THE FUMES COULD CAUSE THE DRIVER TO PASS OUT AND HAVE AN ACCIDENT. THE COST OF THIS REPAIR IS OVER $2300-$2500! I WOULD HAVE HAD IT REPAIRED IF IT WERE A RECALL BECAUSE I WOULD HAVE BEEN NOTIFIED OF THE HAZARD. CAR WAS PARKED WHEN I FIRST NOTICED THE PROBLEM AND HAVE NOT DRIVEN IT SINCE. THE RISK OF A FIRE, EXPLOSION, OR ACCIDENT IS TOO GREAT UNTIL IT IS REPAIRED! GM ASSIGNED CASE# [XXX], BUT IS CURRENTLY INFORMING THAT IT IS NO LONGER COVERED. SINCE NO NOTIFICATION WAS GIVEN TO OWNERS, OWNERS WERE NOT AWARE OF THE ISSUE UNTIL TOO LATE, SAVING GM MILLIONS OF DOLLARS, AS THEY WOULD HAVE BEEN RESPONSIBLE FOR REPLACING LARGE NUMBERS OF THE FAULTY FUEL PUMP HAD A RECALL BEEN ISSUED WHICH REQUIRES REGISTERING RECALLS WITH THE GM DEALERS, AND NOTIFYING THE OWNERS.*DT*JB INFORMATION Redacted PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).”

WHILE DRIVING THE CLUTCH PEDAL WENT TO THE FLOOR AND MY STANDARD 2007 CORVETTE COULD NOT BE SHIFTED. CAR WAS FLAT-BEDDED TO DEALER AS CAR WAS NOT DRIVABLE. I COULD HAVE BEEN KILLED IN HEAVY FREEWAY TRAFFIC. MY VEHICLE HAD 8656 MILES APPROX. APPARENTLY GM ISSUED SERVICE BULLETINS ON THIS PROBLEM, REDESIGNED THE CLUTCH MASTER CYLINDER AND ISSUED AN EXTENDED WARRANTY FOR 10 YEARS OR 100,000 MILES THERE WAS NO RECALL. GM WAS TO HAVE NOTICED ALL OWNERS OF THIS PROBLEM BUT DID NOT IN MY CASE. WHEN I CALLED GM THEY SAID THAT THEY WERE SORRY BUT WOULD NOT INDEMNIFY ME FOR THE $2,912.18 COST TO REPLACE THE MASTER AND SLAVE CLUTCH CYLINDERS. IN MY CASE I WAS IN A PARKING LOT IN MOTION. SO LUCKILY I AM STILL BREATHING.

THE AIRBAG LIGHT COMES ON FOR NO APPARENT REASON.

AFTER FILLING UP THE FUEL TANK, A STRONG GAS SMELL IN THE CABIN OF THE VEHICLE. THE SMELL REMAINED AND HASN'T DISPERSED.

THE FUEL PUMP IS LEAKING DUE TO A DEFECTIVE DESIGN

FUEL SMELL IN THE CABIN

GAS LEAK AND SMELL FROM TOP OF DRIVERS SIDE GAS TANK WITH CAR ABOVE HALF FULL REPLACED SENDING UNIT AND FUEL PUMP CANISTER

SERVICE VEHICLE ACTIVE HANDLING SYSTEM WARNING IS ON IN VEHICLE. AFTER READING ONLINE THAT THE BRAKES CAN ACTIVATE ON THEIR OWN WITHOUT BRAKE LIGHTS I NO LONGER FEEL SAFE DRIVING THE CAR. A CASE NUMBER HASE BEEN GENERATED WITH GM CUSTOMER SERVICE.

DUE TO USE OF PLASTICS THAT TEND TO CRACK, AM NOW EXPERIENCING ISSUES WITH FUEL PUMP ON DRIVER'S SIDE. DRIVING CONTINUES TO PRODUCE GAS SMELL. EXTREMELY COMPLICATED FIX THAT REQUIRES DROPPING GAS TANK AND POSSIBLY TRANSMISSION TO REACH FUEL PUMP.