2007 Chevrolet Equinox Fuel System Problems

Fuel leak in fuel tank (on top)

The contact owns a 2007 Chevrolet Equinox. The contact stated while driving 60 MPH, he began to smell an abnormal fuel odor inside the vehicle. The contact stated no warning light was illuminated. The contact stated that after arriving to his destination, he saw fuel leaking from the vehicle. The contact took the vehicle to an independent mechanic and was informed that the fuel module needed to be replaced. The vehicle was not diagnosed or repaired. A dealer was not contacted. Upon investigation, the contact associated the failure with NHTSA Campaign Number: 12V459000 (Fuel System, Gasoline) however, the VIN was not included. The manufacturer had been informed of the failure. The failure mileage was approximately 108,000.

The contact owns a 2007 Chevrolet Equinox. The contact stated that at vehicle start-up, there was a strong gasoline odor inside the vehicle. The contact also stated that the vehicle would appear to lose nearly half a tank of gasoline approximately 1 to 2 hours after fill-up. The contact also stated that a friend who was also an independent mechanic had checked underneath the vehicle and discovered a small amount of gasoline that had spilled out of the fuel pump. The manufacturer was notified of the failure and informed her that the vehicle was not included in NHTSA campaign number: 12V459000 (Fuel System, Gasoline). The vehicle was not repaired. The failure mileage was 100,266.

TL* THE CONTACT OWNS A 2007 CHEVROLET EQUINOX. THE CONTACT STATED UPON STARTING THE VEHICLE, THE VEHICLE WAS LEAKING GASOLINE. THE CONTACT STATED NO WARNING LIGHT WAS ILLUMINATED. THE VEHICLE WAS NOT TAKEN TO A LOCAL DEALER OR INDEPENDENT MECHANIC TO BE DIAGNOSED. THE VEHICLE WAS NOT YET REPAIRED. THE CONTACT RELATED THE FAILURE TO NHTSA CAMPAIGN NUMBER: 12V459000 (FUEL SYSTEM, GASOLINE). THE MANUFACTURER HAD NOT BEEN INFORMED OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 189,000.

While car is running, fuel is leaking out the top of the tank. Fuel is leaking on exhaust, right under the tank. I have seen recalls on this year and model for a ring breaking around the fuel pump.

AFTER WORK STARTED TO SMELL STRONG GAS SMELL. LOOK UNDER VEHICLE AND SEEN PUDDLE OF GAS. SHOP SAYS IT A LEAK IN THE GAS PIPE AND NEEDS TO BE REPLACED

STRONG GAS SMELL FROM RIGHT REAR OF VEHICLE THAT SPREADS THROUGHOUT VEHICLE BOTH PARKED AND IN MOTION

AS MANY OTHERS, I NOW HAVE A LEAKING FUEL SENDING UNIT ON OUR 2007 CHEVY EQUINOX. MANY PEOPLE HAVE THIS SAME PROBLEM AND CHEVY CHOOSES NOT TO ADDRESS IT FOR US BY ISSUING A RECALL. WHEN THE VEHICLE IS RUNNING THE FUEL SYSTEM IS PRESSURIZED WHICH CAUSES FUEL TO SPRAY OUT OF A FAULTY JOINT WHICH IS MADE OF PLASTIC THAT CRACKS, THE FUEL THEN DRIPS DOWN FROM THE TANK AS IT PLEASES AROUND THE EXHAUST AND ON TO THE FLOOR.

TL* THE CONTACT OWNS A 2007 CHEVROLET EQUINOX. THE CONTACT NOTICED AN ABNORMAL ODOR OF FUEL EMERGING FROM THE VEHICLE. ADDITIONALLY, FUEL WAS SEEN LEAKING FROM THE VEHICLE ONTO THE GROUND, AND THE CHECK ENGINE, STABILITY TRACK, AND BRAKE INDICATORS ILLUMINATED. THE VEHICLE WAS TAKEN TO THE LOCAL DEALER (WHITNEY'S CHEVROLET, 123 PIONEER AVE W, MONTESANO, WA 98563, (360) 249-4431) WHERE IT WAS DIAGNOSED THAT THERE WAS A HAIRLINE CRACK IN THE FUEL TANK AND A CRACK ON THE FUEL MODULE. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED AND OPENED CASE NUMBER: [XXX]. NO FURTHER ASSISTANCE WAS PROVIDED. THE FAILURE MILEAGE WAS 114,000. PARTS OF THIS DOCUMENT HAVE BEEN REDACTED TO PROTECT PERSONALLY IDENTIFIABLE INFORMATION PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *AN

FUEL PUMP FUEL LEAK, VISIBLE LEAK (SPRAYING) ONTO TOP OF TANK WHEN PUMP IS PRESSURIZED.

CAR SMELLS OF GASOLINE AND HAS TROUBLE STARTING ON THE FIRST ATTEMPT. CAR WILL START ON SECOND ATTEMPT BUT HAS A VERY STRONG GAS ODOR. AFTER TAKING IT TO A LOCAL MECHANIC, THE CAR WAS DIAGNOSED AS UNSAFE TO DRIVE AND IS CONFIRMED TO BE LEAKING GASOLINE. THERE IS A RECALL FOR THIS EXACT MAKE AND MODEL BUT IS LISTED AS ONLY IMPACTING CERTAIN STATES (ARIZONA, CALIFORNIA, NEVADA, TEXAS) BUT I'M IN NEW JERSEY AND HAVE SEEN IT ALSO REPORTED IN OHIO, SOUTH CAROLINA AND NEW YORK. THIS RECALL NEEDS TO BE EXPANDED AND CAN BE VERY DANGEROUS!!!

THE CAR BEGAN TO SMELL OF GAS AFTER RUNNING AND STARTED TO CUT OUT. TOOK IT TO A MECHANIC AND THEY REPORT A CRACK IN THE FUEL PUMP.

OUR 2007 CHEVY EQUINOX FUEL PUMP RETURN STARTED LEAKING FUEL ON THE TOP OF THE FUEL PUMP CAUSING FUEL TO LEAK ON THE GROUND AND RELEASES STRONG GAS FUMES WHILE PARKED IN OUR GARAGE. THIS VEHICLE IS UNDER CURRENT SAFETY RECALL IN OTHER STATES BUT NOT IN INDIANA. WHY ARE ONLY SOME STATES UNDER RECALL BUT NOT INDIANA?

I STARTED SMELLING GAS ODOR WHEN EXITING THE VEHICLE , I CHECKED AROUND THE VEHICLE DID NOT SEE ANY GAS SPILLING ANYWHERE, CHECKED UNDER THE VEHICLE NOTICED THE FUEL TANK WAS WET ON THE BACKSIDE , THE GAS IS COMING FROM THE TOP OF THE FUEL TANK..I NOTICED THERE WAS A RECALL ON THIS MODEL VEHICLE AND CHECKED AND SAID THAT MY VEHICLE WAS NOT UNDER THE RECALL...WHY? IT SOUNDS LIKE THE SAME THING EVERYONE ELSE IS HAVING THE SAME THING HAPPEN AND THE RECALL IS FIXING THE PROBLEM..

MY CAR JUST RECENTLY STARTED TO SMELL LIKE GAS. AT FIRST, IT WAS A FAINT SMELL. NOW IT IS STRONGER. I CAN STILL DRIVE THE VEHICLE BUT I FEEL AS IF IT IS A SAFETY HAZARD. I HAVE TWO SMALL CHILDREN THAT RIDE IN THIS VEHICLE. MY GAS METER STILL WORKS AND MY RANGE IS ACCURATE BUT THE GAS SMELL IS BECOMING VERY OVERWHELMING.

TL* THE CONTACT OWNS A 2007 CHEVROLET EQUINOX. WHILE THE VEHICLE WAS PARKED, A STRONG ODOR OF FUEL EMITTED IN AND AROUND THE VEHICLE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE SEAL AROUND THE FUEL PUMP FAILED AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 98,500.

THERE SEEMS TO BE A LEAK IN THE FUEL LINE. THERE IS A SMELL OF GAS INSIDE AND OUTSIDE OF THE VEHICLE WHEN STATIONARY AND WHILE DRIVING, WHICH BEGAN IN APPROXIMATELY MARCH 2017.

VEHICLE LEAKING FUEL NEAR RIGHT REAR WHEEL. FUMES IN VEHICLE

TL* THE CONTACT OWNS A 2007 CHEVROLET EQUINOX. THE CONTACT STATED THAT THE VEHICLE HAD A STRONG FUEL ODOR. THE CONTACT NOTICED FUEL LEAKING FROM THE REAR PASSENGER SIDE OF THE VEHICLE AND FUMES ENTERED THROUGH THE VENTILATION SYSTEM. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 09V419000 (FUEL SYSTEM). THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 92,000.

TL* THE CONTACT OWNS A 2007 CHEVROLET EQUINOX. THE CONTACT STATED THAT THE VEHICLE WAS DIFFICULT TO START AND HAD AN ABNORMAL ODOR. THE VEHICLE WAS TAKEN TO A MECHANIC. THE VEHICLE WAS DIAGNOSED THAT THERE WAS A PUDDLE OF FUEL ABOVE THE FUEL TANK AND THEN EVAPORATED. THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 12V459000 (FUEL SYSTEM, GASOLINE). THE MANUFACTURER WAS NOT NOTIFIED. THE APPROXIMATE FAILURE MILEAGE WAS 80,000.