2007 Chevrolet HHR Brakes Problems

when I went to push on the brake, the brake pedal went to the floor... I had No Brakes? This could have been a terrible accident had I been going faster.

TL* THE CONTACT OWNED A 2007 CHEVROLET HHR. WHILE DRIVING APPROXIMATELY 37 MPH, THE BRAKE PEDAL WAS ABRUPTLY DEPRESSED, BUT FAILED TO ENGAGE IN TIME. AS A RESULT, THE CONTACT REAR ENDED ANOTHER VEHICLE. THE DRIVER SUSTAINED INJURIES TO THE RIGHT TOE AND CHEST, WHICH DID NOT REQUIRE MEDICAL ATTENTION. A POLICE REPORT WAS NOT FILED. THE VEHICLE WAS DESTROYED AND TOWED TO AN UNDISCLOSED LOCATION. THE CAUSE OF THE FAILURE WAS NOT DETERMINED. THE MANUFACTURER WAS NOTIFIED, BUT THE LOCAL DEALER WAS NOT. THE FAILURE MILEAGE WAS 71,000. *TT *TR

WHEN I APPLY THE BRAKES THE FRONT LEFT WHEEL SHAKES AND VIBRATES, I REPLACED ROTORS AND BRAKE CALIPERS AND STILL THE ISSUE IS GETTING WORSE. *TR

CAR HAS 38,000 MILES AT THIS TIME. SINCE 5,000 MILES THE CAR WHEN BRAKES ARE APPLIED THE CAR WOULD PULSATE AND SHAKE AT THE STEERING WHEEL AND FRONT END. THE HIGHER THE SPEED THE MORE SEVERE. THIS SEEMS TO BE A CHARACTERISTIC OF THE MODEL. I AM READING ON EDMONDS CAR FORUM ABOUT THOUSANDS OF PEOPLE WITH THE SAME PROBLEMS. THE ROTOR WARPS PREMATURELY CAUSING THE ISSUES. THE ROTORS ARE CLEARLY NOT THE GRADE NEEDED FOR THE CAR. GM HAS NEVER ADDRESSED THE COMPLAINTS AND SHOULD BE PRESSURED TO RECALL THE MODEL AND REPLACE THE DEFICIENT ROTORS. *TT

TL* THE CONTACT OWNS A 2007 CHEVROLET HHR. THE CONTACT STATED THAT WHILE DRIVING AT APPROXIMATELY 35 MPH, THE BRAKE PEDAL WAS DEPRESSED AS THE FRONT OF THE VEHICLE SHOOK VIOLENTLY. THE FAILURE RECURRED NUMEROUS TIMES. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE BRAKES FAILED AND NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED BUT THE FAILURE RECURRED. THE VEHICLE WAS TAKEN BACK TO THE INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE ROTORS AND OUTER TIE RODS FAILED AND THE REAR BRAKE PADS NEEDED TO BE DUSTED. THE VEHICLE WAS REPAIRED BUT THE FAILURE RECURRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 100,000.

2007 CHEVROLET HHR BRAKE PULSATIONS. *TR

2007 CHEVROLET HHR. CONSUMER STATES BRAKES LOCKED AND THE VEHICLE DID NOT STOP DURING RAINY CONDITIONS. *TGW

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

CHEVROLET HHR BRAKE ROTOR PROBLEM. PLEASE SEE ALL OF THE COMPLAINTS ON THE HHR AT WWW.MYCARSTATS.COM/SAFETYSTATION.ASP?CARS=7107127. OWNERS HAVE BEEN BRINGING THEIR HHR'S TO THE CHEVROLET DEALERSHIPS WITH THIS PROBLEM SINCE 02/06/07. OUT OF 73 COMPLAINTS ON THE 2007 CHEVROLET HHR 19 COMPLAINTS, OR 26% OF THE COMPLAINTS ARE RELATED TO THE BRAKES AND ROTORS. PLEASE INVESTIGATE THE ROTORS THAT CHEVROLET IS USING ON THE VEHICLES, BEFORE SOMEONE GETS INJURED OR KILLED. MOST COMPLAINTS ARE AT LOW MILEAGE, AND ARE NEW VEHICLES. SOUNDS LIKE THERE IS SOME KIND OF DEFECT IN THE METAL THAT IS BEING USED TO MAKE THE ROTORS. I CHECKED TO SEE IF THERE WERE ANY RECALLS ON THE ROTORS, BUT IT DOESN'T EVEN SEEM THAT THE PROBLEM IS UNDER INVESTIGATION. I BROUGHT MY HHR TO A CHEVROLET DEALERSHIP IN 2009 AND A MECHANIC TOOK MY HHR FOR A DRIVE BY HIMSELF, BUT SAID THAT HE COULD NOT FIND ANY PROBLEM. THIS TIME THE HHR WAS BROUGHT IN THE DEALERSHIP FOR THE SAME PROBLEM I REQUESTED THAT MY HUSBAND RIDE WITH THE MECHANIC, AND THE MECHANIC WAS ABLE TO DUPLICATE THE PROBLEM, AND SAID THAT HE FELT IT WAS THE ROTORS. THAT IS WHY I AM REPORTING THIS ISSUE. PERHAPS THE CHEVROLET DEALERS, OR OTHER HHR OWNERS HAVE NOT REPORTED THE PROBLEM TO THE RIGHT DIVISION OF GOVERNMENT. THANK YOU *TR

WITH 61,000 MILES ON MY 2007 CHEVY HHR, I AM HAVING TO REPLACE THE FRONT BRAKE ROTORS ONCE AGAIN. I HAVE HAD MANY CARS WITH DISC BRAKES AND HAVE NEVER HAD TO REPLACE THE ROTORS. THERE MUST BE A DESIGN FLAW IN THIS VEHICLE. *TR

THE BRAKE ROTORS ON 2007 CHEVY HHR KEEP WARPING. THEY HAD TO BE TURNED AT 28,000 MILES AND AT 53,000 MILES. I CAN BARELY KEEP THE CAR STRAIGHT WHEN BRAKING FROM THE VIBRATIONS. *TR

MY HHR (WHICH I LOVE) HAS HAD VIBRATING BRAKES FOR QUITE SOME TIME. FROM INFO FOUND ON FORUMS DEDICATED TO THE HHR AND HERE, I DETERMINED THAT GM OR THE CHEVY DEALER WASN'T GOING TO SATISFY THE NEED FOR BETTER QUALITY ROTORS. THE OEM ROTORS ARE JUNK AND SHOULD BE BANNED FROM BEING INSTALLED ONTO A MOTOR VEHICLE. INSTEAD OF GETTING THE REGRIND AS SPECIFIED BY GM, I CHOSE TO GET MY OWN BRAKES UPGRADED TO A CANADIAN MADE ROTOR SET AND NEW PADS. PARTS AND LABOR WERE $282.19 TOTAL. I WILL BE SENDING THE BILL TO CHEVROLET, BUT I DOUBT THAT THEY WILL REIMBURSE ME...LOL. *TR

TL* THE CONTACT OWNS A 2007 CHEVROLET HHR. THE CONTACT STATED THAT WHEN THE BRAKES WERE DEPRESSED FROM 15-20 MPH AND UP, THE FRONT END OF THE VEHICLE WOULD SHAKE AND SHIMMY ABNORMALLY. THE VEHICLE WAS TAKEN TO A REPAIR SHOP WHERE THE FRONT ROTORS WERE TURNED. THE FAILURE RECURRED. THE VEHICLE WAS NOT FURTHER REPAIRED. THE MANUFACTURER OFFERED NO ASSISTANCE. THE FAILURE MILEAGE WAS APPROXIMATELY 9,500 AND THE CURRENT MILEAGE WAS 25,575.

TL*THE CONTACT OWNS A 2007 CHEVROLET HHR. WHILE DRIVING AT APPROXIMATELY 30 MPH, THE CONTACT APPLIED THE BRAKE PEDAL WHEN HE NOTICED THAT THE STEERING WHEEL AND BRAKE PEDAL BEGAN TO VIBRATE. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALERSHIP WHERE THE FRONT ROTORS WERE RESURFACED. HOWEVER, THE PROBLEM STILL OCCURRED. THE VEHICLE WAS TAKEN BACK TO THE DEALERSHIP ON TWO OTHER OCCASIONS AND THE FRONT ROTORS WERE REPLACED ON BOTH VISITS. HOWEVER, THE PROBLEM STILL OCCURRED. THE FAILURE MILEAGE WAS APPROXIMATELY 12,000. THE CURRENT MILEAGE WAS APPROXIMATELY 42,000.

HHR 2007 LTD, BRAKES CHECKED AND ROTORS TURNED BY DEALER AT 20K AND NOW AT 34K THE SHAKING IS BAKE, AND THE ROTORS NEED REPLACEMENT. *TR

TL* THE CONTACT OWNS A 2007 CHEVROLET HHR. THE CONTACT STATED THAT WHEN DRIVING AT VARIOUS SPEEDS, THE VEHICLE WOULD SHAKE AND THE BRAKE PEDAL WOULD PULSATE DURING BRAKING. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO REPLACED BOTH FRONT ROTORS AND THE BRAKE PADS. THE FAILURE RECURRED AND THE VEHICLE HAD NOT BEEN REPAIRED FOR THE MOST RECENT FAILURE. THE MANUFACTURER WAS NOTIFIED OF THE PROBLEM. THE APPROXIMATE FAILURE MILEAGE WAS 10,000. UPDATED 08/13/12

THE BRAKE SYSTEM ON OUR 2007 CHEVROLET HHR VIOLENTLY SHAKES THE WHOLE CAR WHEN TRYING TO BRAKE AT HIGHER SPEEDS ESPECIALLY GOING DOWN HILL. THE BRAKES ARE NO WHERE NEAR NEEDING REPLACED YET AND THE CHEVY DEALER WE BOUGHT IT FROM CLAIMS THEY KNOW ABOUT THE PROBLEM BUT CANNOT DO ANYTHING ABOUT IT WITHOUT CHARGING US FOR A REPAIR??? I DO NOT NEED NEW BRAKES I JUST NEED THE ONES ON IT TO WORK PROPERLY. A SEARCH OF THE INTERNET AND THIS SITE DEMONSTRATES A DESIGN OR PARTS PROBLEM SINCE MANY OWNERS HAVE THE EXACT SAME PROBLEM. I WOULD INVITE ANYONE TO CONTACT ME TO TAKE A RIDE IN THE CAR TO SEE HOW UNBELIEVABLY SCARY IT IS TO BE BEHIND THE WHEEL COMING DOWN A HILL AND TRYING TO GET IT STOPPED. SOME ONE NEEDS TO LOOK INTO THIS BEFORE SOMEONE GET SERIOUSLY HURT WHEN THE BRAKES FAIL. I HAVE OWNED THIS CAR SINCE NEW AND AFTER THE WAY THE DEALERSHIP TREATED THIS AND OUR CONCERNS THIS WILL BE THE LAST CHEVY IN OUR DRIVEWAY. *TR

STEERING WHEEL ON MY 2007 CHEVY HHR WOULD SHAKE EVERY TIME I APPLIED THE BRAKES. THE CAR ONLY HAS 9,200 MILES ON IT. BROUGHT IT BACK TO THE DEALER. SERVICE MANAGER SAID THAT HE HAS SEEN THIS PROBLEM WITH A NUMBER OF HHR'S. HE SHAVED THE ROTORS. ROTORS SHOULD NOT BE AN ISSUE WHEN THE CAR ONLY HAS 9,000 MILES ON IT. I BELIEVE THE ROTORS ARE DEFECTIVE. SERVICE MANAGER TOLD ME HE THINKS THE PROBLEM IS THAT THE STEEL THEY USED IS TOO SOFT. A RECALL IS IN ORDER. PLEASE INVESTIGATE. THIS IS NOT AN ISOLATED PROBLEM. AN INVESTIGATION MUST TAKE PLACE AND AN AUDIT OF HOW MANY HHR'S HAVE THIS SAME PROBLEM. *TR

TL* THE CONTACT OWNS A 2007 CHEVROLET HHR. THE CONTACT STATED THAT WHILE APPLYING THE BRAKES THE FRONT END OF THE VEHICLE WOULD VIBRATE. THE VEHICLE WAS TAKEN TO THE DEALER AND THE ROTORS WERE TURNED AT 9,000 MILES. THE FAILURE HAPPENED AGAIN AND THE ROTORS WERE TURNED AGAIN. THE FAILURE STILL PERSISTED AND AT 30,000 MILES THE ROTORS WERE REPLACED. THE FAILURE MILEAGE WAS APPROXIMATELY 9,000. THE CURRENT MILEAGE IS APPROXIMATELY 31,000. UPDATED 10/27/10. *LJ UPDATED 11/16/10*BF UPDATED 11/23/10*JB

LOUSY BRAKES. WHILE DRIVING IN HOT WEATHER, APPLYING BRAKES SETS OFF VIOLENT SHAKING AND PULSATION IN STEERING WHEEL AND BRAKE PEDAL. THIS WAS NOT CAUSED BY OVER USAGE. OCCURRED AT FIRST APPLICATION. AIR TEMP WAS APPROXIMATELY 95 DEG. BRAKES WORK FINE IN COLD WEATHER. STOPPED AT LOCAL CHEVROLET DEALER AND ASKED IF THERE WERE ANY RECALLS OF SERVICE BULLETINS CONCERNING THIS PROBLEM. SERVICE MANAGER SAID THE BRAKES WERE MADE AS CHEAPLY AS POSSIBLE ESPECIALLY THE ROTORS. *TR