2000 Chevrolet Malibu Complaint Log

NO SUMMARY LISTED FOR ABOVE VEHICLE. *AK

AFTER PURCHASING A NEW CAR AT 13,769 FRONT SHAKING REAL BAD, HAD DEALERSHIP REPLACE ROTORS. AT 24,869 MILES FRONT END SHAKING REAL BAD AGAIN. WENT BACK TO DEALERSHIP TO HAVE REPLACEMENT DONE AND ADVISED ME THAT FLORIDA WEATHER CAUSES THE ROTORS TO WARP. CHEVROLET ADVISED ME THAT WAS A ISSUE THAT IS NOT COVERED UNDER WARRANTY AND WILL NOT REPLACE EVEN THOUGH THEY KNOW IT IS DEFECTIVE ROTORS CAUSING THE PROBLEM. DT

WHEN BRAKES ARE APPLIED VEHICLE SHAKES VIOLENTY, AND TSTOPPING DISTANCES INCREASES. PROBLEM OCCURS EVERY 4-6 MONTHS. DEALER WAS CONTACTED. PLEASE PROVIDE MORE INFORMATION.*AK

THE HAZARD LIGHTS AND TURN SIGNAL LIGHTS WERE DEFECTIVE. SOMETIMES THEY WORKED, AND SOMETIMES THEY DID NOT WORK. IF THE CONSUMER HIT THE DASHBOARD THE SIGNALS WOULD WORK. THIS VEHICLE WAS NOT INCLUDED IN THE NHTSA RECALL 03V327000. *AK *TC

ON FOUR ORGINAL EQUIPMENT FIRESTONE, INFINITY TIRES SIZE P215/60R15 WITH FOURTY THOUSAND MILES TREADS WERE BEGINNING TO CRACK. DEALER HAS BEEN CONTACTED AND HAS REPLACED ALL FOUR OF THE DEFECTIVE TIRES. *AK *TT

BRAKES FAILED FOR THE 2ND TIME ACCIDENT OCCURRED HAVE NOT HAD CAR FOR 3 WEEKS, HAVE BEEN WAITING FOR GM TO SEND INSPECTOR. CAR IS OUT OF SERVICE FOR MORE THAN 15 DAYS AND GM HAS EXHAUSTED THE TIME LIMIT FOR ACTION. I DO NOT WANT THIS "DEATH TRAP" (CAR) BACK. I ALSO WANT TO BE CREDITED FOR LEASE PAYMENTS. I SHOULD NOT HAVE TO PAY FOR MANUFACTURER DEFECTS. *AK

NO SUMMARY LISTED FOR ABOVE VEHICLE. *AK

CONSUMER HEARD A GRINDING NOISE AND FELT PULSATION WHEN APPLYING BRAKE.S. DEALER DETERMINED FRONT ROTORS WERE WARPED AND NEEDED TO BE REPLACED.*AK

TURN SIGNALS WORK INTERMITTENTLY.*AK CONSUMER ALSO STATES THAT THE HAZARD LIGHTS DO NOT WORK AS WELL, THE VEHICLE HAS ALSO EXPERIENCED A FLAT TIRE.*JB

THE RIGHT REAR TAIL LIGHTS HOLDS WATER AFTER DRIVING THROUGH CAR WASHES AND RAIN. THEN THE BRAKE LIGHT BURNS OUT. *JB

WE OWN A 2000 CHEVY MALIBU. THE HEAT/AIR REGULATOR DOES NOT WORK UNTIL IT IS MOVED TO THREE, FOUR OR FIVE. IT DOES NOT WORK ON ONE OR TWO. MY BROTHER OWNS 97 MALIBU WITH THE SAME PROBLEM AND MY SISTER HAS A 98 MALIBU WITH THE SAME PROBLEM.*AK

VEHICLE STALLED WHILE DRIVING 60-70 MPH, THEN AGAIN 3 DAYS LATER. VEHICLE TAKEN TO DEALER BOTH TIMES, COULD NOT FIND CAUSE.

I PURCHSED THE VEHICLE USED IN NOV. OF 2001. SHORTLY THERE AFTER, THE BRAKES STARTED EXPERIENCING EXCESSIVE NOISE AND VIBRATION AND MILD PEDAL PULSING. I TOOK THE VEHICLE IN AND THE DEALER REPLACED/TURNED ROTORS AND REPLACED PADS. ABOUT A MONTH LATER NOISE AND VIBRATION RETURNED. I BROUGHT THE CAR BACK, CLASSIC HAD THE VEHICLE FOR THE DAY THEN SAID THERE WAS NOTHING WRONG. THE NOISE AND VIBRATION DISSAPPEARED BUT RETURNED INTERMITTENTLY ABOUT 2 MONTHS LATER. ALSO THE STOPPING DISTANCE HAS INCREASED NOTICABLEY AS OF LATE. I AM UNSURE TO BRING THE VEHICLE BACK IN TO BE TOLD THERE IS NOTHING WRONG.

BOTH TAIL LIGHT ASSEMBLIES FILL WITH WATER, CAUSING LIGHTS TO SHORT OUT. SEAL AROUND ASSEMBLY IS INADEQUATE.*AK

BRAKE PEDAL PUSHED ALL THE WAY TO THE FLOOR

BRAKES HAVE GONE OUT TWICE,AND STILL NOT BEING FIXED PROPERLY. *AK

VIN IS [XXX] MANUFACTURED 05/00. RAIN WATER COLLECTS AND IS RETAINED IN RIGHT TAIL LIGHT ASSEMBLY. ONE LAMP OF FOUR SHORTED AND BLEW. ASSEMBLY IS INADEQUATELY SEALED AND INSULATED AGAINST WATER. COST OF NEW REPLACEMENT TAIL LIGHT ASSEMBLY IS $249.*AK INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

ALTHOUGH THE DEALER SAYS THAT THE BRAKES ARE DESIGNED TO PRODUCE A SLIGHT CLICKING NOISE WHEN THE PADS BEGIN TO WEAR, NO SUCH NOISE WAS HEARD. WITH ONLY 23,450 MILES ON CAR, THE PADS ON ONE SIDE OF THE ROTOR WORE DOWN CUTTING GROOVES INTO THAT SIDE OF THE ROTOR WHILE PADS ON OTHER SIDE OF SAME ROTOR HAD A WAY TO GO BEFORE BEING WORN DOWN. I UNDERSTAND THIS SAME PROBLEM OCCURRED ON THE CHEVROLET S10 AND FOR WHICH THE S10 WAS RECALLED. DEALER SAID IT IS NOT UNCOMMON FOR ROTORS TO GO BAD SOON AS PADS WEAR OUT ON THE MALIBU. IT IS RIDICULOUS TO HAVE TO PAY FOR ROTORS EACH TIME THE PADS GO BAD, ESPECIALLY AT ONLY 23,000 MILES.*AK

CONSUMER STATES THAT THE DEFROSTER DOES NOT WORK PROPERLY. WARNING LIGHTS DO NOT WORK. PLEASE PROVIDE ANY FURTHRER INFORMATION. NLM

CONSUMER STATES THAT DEFROSTER AND WARNING LIGHTS DO NOT WORK. CONSUMER FEELS THE COMPUTER IS DEFECTED. PLEASE PROVIDE ANY FURTHER INFORMATION. NLM

BOUGHT MY CAR NEW OFF SHOW ROOM FLOOR AND HAVE HAD NUMEROUS PROBLEMS SINCE HAD IT IN FOR STARTING PROBLEMS BATTERY PROBLEMS FUEL PROBLEMS WINDOW PROBLEMS DOOR LOCK PROBLEMS ENGINE NOISE ENGINE OIL LEAKS VIBRATION PROBLEMS BRAKE PROBLEMS DYING PROBLEMS POPPING NOISES IN FRONT END STRUTS BOTTOMING OUT ROUGH RIDE AND STEERING PROBLEMS AND SO ON TOO MANY TO LIST ALL HAVE HAD FRONT END REALIGNED STUTS CHECKED AND REPALCED BRAKES CHECKED AND REPLACED WHEEL STUDS REPLACED FUEL PUMP AND FLOAT REPLACED PISTONS REPLACED BATTERY REPLACED REMOTE START SYSTEM REPLACED ALARM SYSTEM REPLACED WINDOW REGULATOR REPLACED FRONT CRANK SEAL REPLACED ALT CHECKED AND TESTED STARTED CHECKED STILL HAVING FUEL PROBLEMS BRAKE PROBLEMS VIBRATION ECT HAD IN THIS LAST WEEK FO 6 DAYS AND WHEN RETURNED STILL HAVING ENGINE NOISE STEERING PROBLEMS RADIO PROBLEMS FUEL PROBLEMS AND FOUND IMPACT MARK ON L/FRONT OF BUMPER ONE OF DEALERS TECH'S HIT SOMETHING AND NOW WANDERS TO LEFT LEFT HEAD LIGHT OUT OF LINE AND PUSHED BACK UNDER FENDER HOOD OUT OF LINE FENDERS BUMPERS DRIVING LIGHTS AND NUMEROUS OTHER PROBLEMS AND DAMAGE POSSIBLE THAT I AM UNABLE TO DETECT AT THIS TIME HAVE CONTACTED CHEVY AND COMPLAINED HAVE TALKED WITH DEALER AND STILL NO RESPONSIBILITY TAKEN AND STATEMENTS OF WE MIGHT HAVE BRUISED IT IT HAS BEEN WRECKED NOW I AMD PAYING GOOD MONEY FOR JUNK AND WANT REFUND OF ALL COSTS TO ME AND THE CAR TAKEN BACK ENGINES SHOULD NOT NEED TO BE OVERHAULED AT 14000 MILES THE CAR IS 2 YAERS OLD AND ACTS LIKE ITS 20 NEED RESPONESE AND INFO TO HELP RESOLVE PROBLEMS TRYING TO HAVE RETURNED UNDER LEMON LAW UNIFORM CONFORMITY ACT AND MAGNUSON-MOSS ACT CAR HAS BECOME INSTRUMENT THAT IS SUBSTANTIALLY IMPAIRED AND WHOSE OPPERATION IS FROUGHT WITH APPREHENSION SINCERLY UNHAPPY AND HURT CONSUMER IS THE HIGHWAY SAFTY DEVISION INTERESTED AND GOING TO DO ANYTHING FOR ALL OF US WHO ARE HAVING PROBLEMS OR ARE WE OUT OF LUCK ????????? RESPONSE REQUESTED

ROTORS ON BRAKES HAVE WARPED 3 TIMES BEFORE 20000 MILES! *AK

TSB 00-05-23-002A. DEALER AND MANUFACTURER FAILS TO REPAIR PROBLEM. VEHICLE IS UNSAFE TO DRIVE AFTER APPROXIMATELY 5000 MILES. MUST BE REPAIRED TO FIX SAFETY ISSUE. HOWEVER, FIX IS ONLY TEMPORARY.

VEHICLE WAS GOING 25MPH ON A STRAIGHT ROAD. THERE WAS NO WARNING AND LEFT FRONT END DROPPED. LEFT TIRE BLEWOUT, AND VEHICLE SKIDDED/ HIT THE CURVE. LOWER BALL JOINT BROKE, CAUSING REAR END TO SPIN AROUND. MANUFACTURER HAD A TSB MENTIONING PROBLEM ,BUT WILL NOT COVER THE PROBLEM WITHIN WARRANTY AGREEMENT.*AK

BRAKE PADS HAVE BEEN REPLACED 4 TIMES SINCE 14,000 MILES. THE ROTORS VIBRATE AND SHIMMY WHEN APPLYING THE BRAKES. TRYING TO GET THE DEALER TO INVESTIGATE THE PROBLEM IS A HASSLE. THEY SAID THAT BECAUSE I HAVE MY PREVENTATIVE MAINTENANCE DONE BY MY OWN PERSONAL *CERTIFIED* MECHANIC AND NOT AT THE DEALER THAT I HAVE VOIDED MY WARRANTY ON THE ROTORS. THEY WANT TO CHARGE ME $200 + FOR THE REPLACEMENT OF THE ROTORS. I HAVE SPOKEN WITH SEVERAL OTHER MALIBU OWNERS WHO HAVE HAD THIS SAME PROBLEM. IT IS MY OPINION THAT A RECALL SHOULD BE MANDATED AND ENFORCED FOR THIS PARTICULAR PROBLEM WITH THIS VEHICLE. I HAVE NEVER OWNED A CAR THAT I HAD TO REPLACE THE BRAKE PADS EVERY TIME I PULLED INTO A GAS STATION. THANK YOU!

VEHICLE STALLS AT ANY SPEED/ANY TIME ON A DAILY BASIS. DEALER CANNOT FIND PROBLEM.*AK

THE CAR HAS A PING IN THE MOTOR AND COOLING SYSTEM OVERHEATS.

THE BRAKES ON THE MALIBU ARE A SAFETY ISSUE AND GMC DOESNT CARE. I HAVE HAD THE ROTORS DONE 5 TIMES SINCE 3000 MILES. MY DEALER HAS HAD MY CAR FOR A TOTAL OF 19 DAYS FOR REPAIRS. THERE ARE NUMEROUS OTHER PROBLEMS WITH THIS CAR ALSO. IAM TIRED OF BEING TOLD I6TS NOT A SAFETY ISSUE, WELL IT IS TO ALL OF WITH CHILDREN AND OTHER LOVED ONES IN THE CAR. LETS STOP THE POLITICS AND PLEASE DO SOMETHING FOR THE CONSUMER.*AK (TIRESIZE: 215)

AC AUTOMATICALLY TURNS ITSELF OFF SWITCH REPLACES. WHINING SOUND OCCURS DURING AC/HEAT FAN OPERATION FAN MOTOR REPLACED. AC/HEAT DIRECTIONAL CONTROLS WORK INTERMITTENTLY PROBLEM CONTINUES. TRANSMISSION SLIPPING UPON SLOW ACCELERATION REPORTED 3 TIMES 1ST & 2ND TIMES COULDN'T DUPLICATE PROBLEM 3RD TIME IN SHOP 30 DAYS REPLACED MULTIPLE COMPONENTS. ENGINE MISFIRING DIAGNOSTICS INDICATED 3,6,2,5 CYLINDERS MISFIRING REPLACED ALL IGNITION COIL PACKS PROBLEM CONTINUES. TURN SIGNAL BUZZES AND CLICKS HAZARD SWITCH REPLACED. AIR LEAK AROUND PASSENGER SIDE DOOR REPORTED 2 TIMES 1ST TIME COULDN'T DUPLICATE 2ND TIME DOOR REALIGNED. BRAKES CAUSE EXCESSIVE VIBRATIONS UPON STOPPING ROTORS AND PADS REPLACED AT 24000 MILES REOCCURING AT 38000 MILES.*AK

WHILE DRIVING AND WITHOUT A COLLISION OCCURRING DRIVER'S AND PASSENGER'S AIR BAGS DEPLOYED, CAUSE UNKNOWN. *AK CONSUMER STATES THE DAYS PREVIOUS TO THE DEPLOYMENT OF THE AIRBAGS, THE ELECTRICAL SYSTEM GAVE SIGNS THAT IT WAS NOT WORKING PROPERLY, THE ALARM WAS GOING OFF FOR NO REASON, CONSUMER WAS INJURED. *SLC

ROTORS HAVE BEEN TURNED AND PADS REPLACED THREE TIMES WITHIN EIGHT MONTHS, BUT PROBLEM HAS REOCCURRED. FEEL FREE TO PROVIDE ANY FURTHER INFORMATION.*AK

I HAVE BEEN HAVING PROBLEMS WITH MY BRAKES ON MY 2000 CHEVROLET MALIBU SINCE I PURCHASED MY VEHICLE. DOUG CHEVROLET KEEPS REPLACING THE PADS AND ROTATION OF BRAKES. ON 7/23/01 MY CAR WILL BE IN THE SERVICE DEPARTMENT FOR THE SAME REPAIRS. I SPOKE TO GM'S CUSTOMER SERVICES DEPT ON/AROUND 7/11/01. I WAS TOLD BY A CUSTOMER SERVICE REP AT GM, DOUG CHEVEROT WILL HAVE TO FIX THE PROBLEM WITH MY CAR. ON 7/16/01 I WAS TOLD BY DOUG CHEVROLET EMPLOYER (S) GM KNOWS THERE IS A PROBLEM WITH BRAKES AND THEY ARE NOT RECALLING CHEVROLET MALIBU'S. I FEEL THAT WITH MY PROBLEMS I'VE BEEN HAVING WITH THE BRAKES ARE JUST MORE THAN THE PADS AND ROTATION OF BRAKES. ONCE MY CAR IS SERVICED I WILL BE FILING A DISPUTE FORM WITH GMC. *AK

HARNESS STRAP DETACHES FROM SHIELD RENDERING CAR SEAT UNSAFE.*AK

BRAKES SHIMMIED BADLY. APPARENT BRAKE PROBLEM. DEALER KNEW PROBLEM BEFORE I FINISHED TELLING THEM OF PROBLEM. DEALER REPLACED WARPED BRAKE ROTORS AND BRAKE PADS. RESEARCHED PROBLEM AND DISCOVERED HUNDREDS OF SAME IDENTICAL PROBLEM AND COMPLAINTS. CONCERNED BECAUSE OTHER CONSUMERS ARE HAVING SAME PROBLEM FIXED OVER AND OVER FOR DEFECTIVE DESIGN. I AM CONCERNED ABOUT THE SAFETY ISSUE OF THE BRAKE SYSTEM ON THIS CAR. *AK

VIBRATING BRAKES. CALIPERS AND ROTORS CEAZING UP THIS WILL BE THE 6 TIME I AHVE HAD TO BRING THIS CAR IN FOR THE SAME THING I AM TOLD THAT THE ALIPERS CEAZE UP WHICH IN TURN WEARS THE RORTORS DOWN WHICH IN TURN WEARS THE BRAKE PADS DOWN AND NOBODY KNOWS WHY. ALSO HAD TO REPLACE FUEL PUMP

CONSUMER STATED THE VEHICLE STALLED WITHOUT WARNING FOR 2 YEARS. THE WIRES POWERING THE FUEL PUMP MOTOR IN THE FUEL TANK MODULE WERE REPLACED. THE FUEL TANK WAS REPLACED WITH A NEW TANK AND SO FAR NO STALLING HAD OCCURRED. *AK *CB THERE WERE 5 ATTEMPTS TO REMEDY THE PROBLEM. THE CONSUMER REQUESTED REIMBURSEMENT AND EXPECTED GM TO DISCUSS THE PROBLEM AND THE FUEL TANK MODULE DESIGN IMPROVEMENT. *SCC *JB

ENGINE CUT OFF WHILE DRIVING ON FREEWAY 6-8 TIMES. DEALER REPLACED WIRING AND STATED THEY HAVE BEEN HAVING THAT PROBLEM. 2 WEEKS LATER HAPPENED AGAIN. *AK

AIR BAGS DID NOT DEPLOY IN FRONT END IMPACT AND CAR ROLLED AT LEAST ONCE AND STEERING WHEEL BROKEN. *AK( DOT NUMBER: )

WHILE DRIVING, VEHICLE WAS HESITANT AFTER STOPPING, TRANSMISSION WOULD BEGIN TO SHIFT EVERY 4 SECONDS, DEALER STATED THAT A PIECE OF METAL FROM THE FRONT PUMP OF THE TRANSMISSION HAD COME OFF AND SENT PIECES OF METAL CIRCULATING THROUGH THE ENTIRE TRANSMISSION, CONSUMER WAS TOLD THAT SINCE THE TRANSMISSION WAS SEALED THAT IT WAS NOT ANTICIPATED THAT THE METAL PIECES WOULD AFFECT THE OTHER SYSTEMS OF THE VEHICLE, DEALER MADE REPAIRS AND ONE MILE DOWN THE ROAD TRANSMISSION BEGAN ACTING POORLY AGAIN, CONSUMER TOOK BACK TO DEALER WHO STATED THAT TRANSMISSION WAS STUCK IN SECOND GEAR, DEALER REPLACED TRANSMISSION. OXYGEN SENSOR FAILED. ROTORS WARPED AND WERE CAUSING VIBRATION, DEALER REPLACED PADS AND ROTORS. BATTERY LEAKED ACID INTO ENGINE COMPARTMENT. COOLANT CAP WAS DEFECTIVE AND REPLACED. *SLC

SOMETHING WRONG WITH THE BRAKES. DEALER CAN NOT DUPLICATE. WHEN YOU GO TO SLOW DOWN THW BRAKE PEDAL WILL SINK AND VIBRATE AND GIVE YOU A GRINDING NOISE FOR JUST A SECOND. ONLY HAPPENS RIGHT AFTER START UP. DOES NOT HAPPEN ON A REGULAR BASIS. *AK

2000, CHEVROLET, MALIBU BROADSIDED ANOTHER VEHICLE AT APPROXIMATELY 25 MPH, AND BOTH FRONTAL AIR BAGS FAILED TO DEPLOY. CONSUMER SUSTAINED KNEE INJURIES AND WAS TAKEN TO HOSPITAL.*AK THE ENTIRE FRONT HOOD WAS KNOCKED TO WINDSHIELD, CONSUMER IS STILL UNDERGOING PYSICAL THERAPY FOR INJURIES. *SLC

WITHIN THREE MONTHS DEALER HAD TO TURN BOTH FRONT BRAKE ROTORS, AND GAVE NO REASON WHY THIS PROBLEM WAS REOCCURRING. *AK *SLC

I HAVE ALSO HAD A FRONT END ALIGNMENT, REPLACED EMERGENCY LIGHTS, SUSPENSION FIXED, ALL IN LESS THAN 2 YEARS OF OWNING THE VEHICLE. THE BRAKES ARE STILL NOT WORKING CORRECTLY. *AK

TL*THE CONTACT OWNS A 2000 CHEVROLET MALIBU. IN 2001, THE TURN SIGNALS FAILED ON THE VEHICLE. WHEN THE HAZARD INDICATORS WERE ACTIVATED, THE TURN SIGNALS WOULD WORK. THE CONTACT TOOK THE VEHICLE TO THE DEALER AND THEY STATED THAT THE HAZARD WARNING SWITCH FAILED AND WOULD COST $200 TO REPLACE. A REPORT WAS FILED WITH THE MANUFACTURER AND THEY STATED THAT THE VEHICLE WAS OLD AND NOT INCLUDED IN NHTSA CAMPAIGN ID NUMBER 03V327000 (EXTERIOR LIGHTING: HAZARD FLASHING WARNING LIGHTS: SWITCH). THE MANUFACTURER WOULD NOT ASSIST WITH THE REPAIR. THE VEHICLE HAS NOT BEEN REPAIRED. THE VIN WAS UNKNOWN. THE FAILURE MILEAGE WAS 10,800 AND CURRENT MILEAGE WAS 17,000. UPDATED 5/26/09 *CN UPDATED 05/28/09.*JB

WHEN TRYING TO MAKE A STOP, THERE IS GRINDING NOISE WHEN THE BRAKES ARE PRESSED. BRAKES WEAR OUT EVERY 2-3 MONTHS(PAYING AN EXPENSIVE AMOUNT FOR BRAKE SHOES AND ROTORS AIR CONDITONING SWITCH MALFUNCTIONS AND YOU JUST CANNOT TRADE THIS CAR IN BECAUSE THE VALUE DEPRECIATES THE SAME DAY YOU DRIVE OFF THE CAR LOT.

WHILE DRIVING AND UPON APPLYING BRAKES BRAKE PEDAL WENT STRAIGHT TO THE FLOORBOARD, CAUSING EXTENDED STOPPING DISTANCE THAT RESULTED IN A CRASH. THE VEHICLE WAS TOTALED. *AK CONSUMER STATES AIR BAG DEPLOYMENT HURT HER. *SLC

THIS IS THE 2ND TIME ROTORS HAVE BEEN REPLACED. 1ST TIME ROTORS WERE REPLACED AT 8,000, AND 2ND TIME AT 10,000 MILES. CONSUMER WAS DRIVING HOME FROM DEALER AFTER BEING SERVICED, AND WHEN APPLYING BRAKES, PEDAL WENT STRAIGHT TO FLOOR. CONSUMER DROVE BACK TO DEALER, AND STATED THAT IT WAS NORMAL FOR VEHICLE TO DO THAT. CONSUMER DIDN'T HAVE ANY PROBLEMS WITH BRAKE PEDAL WHEN FIRST PURCHASED. FRONT END STARTED DIPPING WHEN THE BRAKES WERE APPLIED. CONSUMER AGAIN HAD TO FIND OUT WHY ROTOR PROBLEM KEEPS COMING BACK.*AK

SINCE I PURCHASED MY NEW 2000 MALIBU ON 12/18/99, TO TODAY 5/9/01, I HAVE REPLACED THE FRONT ROTORS 3 TIMES. COUNTING THE ORIGINAL SET, THIS MAKES IT 4 SETS OF ROTORS THAT MY CAR HAS GONE THROUGH, UNDER 19,000 MILES. MY WARRANTY IS GOOD UNTIL 36,000 MILES, SO I CONTACTED THE CHEVROLET CUSTOMER ASSISTANCE CENTER (1-800-222-1020) AND TOLD THEM THAT I WANTED TO KNOW IF THIS ISSUE WAS GOING TO BE COVERED AFTER THE WARRANTY RAN OUT DUE TO THE TIMELY CHANGING OF THE ROTORS SO MANY TIMES IN SO LITTLE MILEAGE. THE REPLACEMENTS WERE ON 4/11/00 (5,440), 8/31/00 (10,775), AND 5/8/01 (18,394). EACH OF THESE TIMES THE DEALER HAS TOLD ME THAT MY BRAKES AND BRAKE PADS WERE FINE, BUT THAT THE ROTORS WERE WARPED. THE CHEVY # TOLD ME THAT THIS WAS PROBABLY DUE TO SOMETHING I HAVE DONE OR MY DRIVING HABITS/CONDITIONS. I DON'T BELIEVE THIS IN THAT MY BRAKES HAVEN'T WORN OUT YET, BUT THE ROTORS KEEP GOING BAD. I AM VERY DISAPPOINTED IN THEIR PASSING THE BLAME, INSTEAD OF CORRECTING THE PROBLEM OR EXTENDING THE COVERAGE OF AN ISSUE THAT IS COUNTLESSLY REPEATED ON YOUR SITE AND THE NEWSGROUPS FROM 1997 TO PRESENT. CHEVY HAS THE SLOGAN, "CHEVY, WE'LL BE THERE." THEY DON'T SHOW THE FINE PRINT OF: "WE'LL BE THERE, UNLESS WE BLAME YOU AND DON'T DECIDE TO RESOLVE A KNOWN ISSUE." I WOULD LIKE FEEDBACK ON THIS ISSUE, ESPECIALLY SINCE I BELIEVE THIS SHOULD BE A COVERED ISSUE, AND DON'T BELIEVE THAT I AM CAUSING A PROBLEM THAT SEEMS TO BE VERY ROUTINE EVERY 5-8,000 MILES LIKE EVERYONE ELSE IS EXPERIENCING. THANK YOU. *AK

I BOUGHT MY 2000 MALIBU BRAND NEW IN SEPTEMBER 1999.... MY ENGINE WAS PINGING AND MAKING ALL KINDS OF NOISE, EVEN WHEN WARM.... BRAKES ARE VERY HAZARDOUS TO PUBLIC SAFETY... I HAVE BEEN TO THE DEALER NUMERIOUS TIMES FOR ROTOR AND PAD REPLACEMENTS AND EVEN GM'S SO CALLED NEW THICKER AND IMPROVED ROTORS THEY INSTALLED ON MY CAR WAS JUST AS BAD AS ALL THE OTHER ONES ... I ALMOST LOST CONTROL OF MY CAR WHEN I WAS TRAVELING 65 MILES PER HOUR ON OUR LOCAL HIGHWAY WHEN I WAS ALMOST HAD A WRECK DUE TO COMPLETE FAILURE OF MY BRAKES... MY CAR VIBRATED SO BADLY AND DID NOT SLOW DOWN...AT ALL!!....I THOUGHT I HAD 2 FRONT TIRE BLOWOUTS... I PULLED OVER ON THE EXPRESSWAY AND MY TIRES WERE FINE IT WAS MY BRAKES...... I WENT STRAIGHT TO A LOCAL AUTOZONE AND PURCHASED NEW ROTORS AND PADS....GM NEEDS TO ISSUE A RECALL ASAP BEFORE SOMEONE GETS SERIOUSLY INJURED OR KILLED!......I HAVE CALLED GM AND MADE A COMPLAINT AND WAS TOLD NO RECALLS WERE MADE..... ANOTHER ISSUE IM HAVING IS IT TAKES 3 OR 4 TIMES TO GET MY CAR STARTED ... NOT SURE WHY MY CAR IS HAVING ALL OF THESE PROBLEMS BUT IT IS AT A LOCAL GM DEALERSHIP AS I TYPE THIS .......I HOPE THEY WILL BE ABLE TO FIX THE NOISE FROM THE ENGINE AND MY CD PLAYER THAT GOES IN AND OUT OF POWER AND SOMETIMES WONT RELEASE MY CD'S .... I HAVE GIVEN UP ON GM BRAKES. *AK

WHILE DRIVING ABOUT ANY MPH AND THEN WHEN TURNING ON TURN SIGNAL LIGHT STEERING WHEEL WILL MAKE A BUZZ NOISE.*AK CONSUMER STATES STEERING WHEEL SHAKES WHEN BRAKES ARE APPLIED, VEHICLE WAS TAKEN INTO DEALERSHOP 2 MONTHS AFTER PURCHASE, AIR CONDITIONING WOULD ONLY BLOW ON FLOOR, CONTROL PANEL WAS REPLACED. *JB