2000 Chevrolet Malibu Fuel System Problems

TL* THE CONTACT OWNS A 2000 CHEVROLET MALIBU. THE CONTACT SMELLED FUEL WHEN THE VEHICLE WAS PARKED IN THE GARAGE. THERE WAS NO WARNING INDICATOR ILLUMINATED. THE DEALER AND MANUFACTURER WERE NOT NOTIFIED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE FAILURE MILEAGE WAS APPROXIMATELY 137,000.

LEAKING FUEL UNDER CAR BETWEEN DRIVER SIDE DOORS. JUST NOT SURE IF PART OF FUEL SYSTEM RECALL THAT HAS BEEN ON OTHER MALIBU

TL* THE CONTACT OWNS A 2000 CHEVROLET MALIBU. THE CONTACT STATED THAT THERE WAS A FUEL ODOR AND DISCOVERED THAT FUEL WAS LEAKING FROM UNDER THE VEHICLE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC, WHO INSPECTED THE VEHICLE AND INDICATED THAT THERE HAD BEEN FUEL LEAKING ON THE FUEL LINES. THE VEHICLE WAS NOT REPAIRED. THE CONTACT WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 99V302000 (FUEL SYSTEM, GASOLINE). THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 152,000.

TL* THE CONTACT OWNS A 2000 CHEVROLET MALIBU. WHILE DRIVING AT APPROXIMATELY 30 MPH, THE VEHICLE STALLED AND THE ANTI THEFT DEVICE LIGHT ILLUMINATED. THE FAILURE RECURRED SEVERAL TIMES. THE VEHICLE WAS TAKEN TO A DEALER WHERE IT WAS DIAGNOSED THAT THE FUEL PUMP AND THE FUEL REGULATOR NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED; HOWEVER, THE FAILURE RECURRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 120,000. THE VIN WAS NOT AVAILABLE.

TL* THE CONTACT OWNS A 2000 CHEVROLET MALIBU. WHILE THE VEHICLE WAS PARKED, A STRONG ODOR OF FUEL EMITTED OUTSIDE THE VEHICLE. THERE WAS A RECALL REGARDING NHTSA CAMPAIGN NUMBER: 99V302000 (FUEL SYSTEM, GASOLINE); HOWEVER, THE VIN WAS NOT INCLUDED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED. THE APPROXIMATE FAILURE MILEAGE WAS 70,000.

TL* THE CONTACT OWNS A 2000 CHEVROLET MALIBU. THE CONTACT STATED THAT THERE WAS EXCESSIVE RUST BELOW THE FUEL TANK. IN ADDITION, THERE WERE HOLES. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 94,625.

I WAS DRIVING MY VEHICLE AND IT MADE A LOUD NOISE/ SOUND LIKE IT CAME FROM THE HEATING AND COOLING VENT INSIDE. I WENT TO THE STORE AND THE KEY WAS STUCK IN THE IGNITION. I GOT IT OUT . START THE CARD AFTER I LEFT THE STORE. THE CAR SPEED WAS 10 MPH TO 25 MPH WITH NO METER MOVING FOR THE GAS, THERMOSTAT, THERE WAS NO ELECTRICITY. TRIPLE A PICK UP MY VEHICLE ON FEBRUARY 27, 2014. WEBER CHEVROLET REPLACED CYLINDER AND IGNITION SWITCH. THE TOTAL COST WAS $854.22. I HAD THIS IGNITION SWITCH REPLACED FOR THE 3RD TIME. I WOULD LIKE TO HAVE AND REFUND ON MY IGNITION SWITCH. *TR

IGNITION THEFT SYSTEM- WOULD NOT START, RUST AROUND GAS CAP. *TR

ON SEPT. 29, 2010, I BOUGHT A 2000 CHEVY MALIBU IN NY FROM A NJ DEALER, THE NEXT DAY I NOTICED THE CHECK ENGINE LIGHT ON, SO I TOOK THE CAR TO A MECHANIC WHO TOLD ME THAT THERE WAS AN ISSUE WITH THE GAS EMISSIONS. I PAID HIM TO DO A SPECIAL EMISSIONS GAS TREATMENT, THE CHECK ENGINE LIGHT REMAINED ON. THE SAME CAR ALSO HAS EXTERIOR LIGHTING ISSUES (THE TURN SIGNALS SPORADICALLY WORK AND SUDDENLY STOP WITHOUT WARNING AND THE EMERGENCY BLINKERS WON'T WORK EITHER), I SUBMITTED THIS ISSUE IN A COMPLAINT ON THIS WEBSITE NHTSA.DOT.GOV ON YESTERDAY OCT. 22, 2010. HOWEVER I AM SUBMITTING THIS BECAUSE IT IS POSSIBLY RELATED TO THE RECALL GAS TANK ISSUES OF THIS MAKE, MODEL AND YEAR CAR. *TR

I HAVE A 2000 CHEVY MALIBU. IT HAS SOMETHING CALLED THE PASSLOCK SYSTEM OR THEFT SYSTEM AND IT PREVENTS THE CAR FROM STARTING. IT PREVENTS THE CAR FROM STARTING ALL THE TIME. THIS ISN'T THE FIRST TIME YOU HAVE RECEIVED THIS COMPLAINT I BET. I HAVE PUT AN EXTRA $2000 INTO THE CAR AFTER I BROUGHT IT HOPING IT WOULD FIX IT BUT I STILL HAVE THE PROBLEM. I HAVE READ ON-LINE AND EVERYONE WHO OWNS A 96 AND UP GM CAR HAS THIS PROBLEM. EVERYONE SAYS GM DOESN'T CARE ABOUT THIS PROBLEM AND THEY WON'T FIX IT. THEY SAY THIS IS THE ONLY WAY TO GET THEM TO FIX IT. IF WE COMPLAIN ON HERE. PLEASE MAKE THEM FIX THIS PROBLEM WITH THEIR CARS BECAUSE YOU WOULD SAVE OVER 1,000,000 PEOPLE TIME AND FRUSTRATION. NO JOKE, LITERALLY 1,000,000 PEOPLE HAVE THIS PROBLEM. THIS IS WHY THEY WENT BANKRUPT. GM SUCKS. THIS IS WHY AMERICA SUCKS AS A NATION. WE HAVE TO COMPLAIN ON HERE TO FIX OUR PROBLEMS. NO OFFENSE TO YOU. I DON'T HAVE ENOUGH MONEY TO BY ANOTHER CAR, AS MOST PEOPLE WITH THIS PROBLEM. PLEASE DO THE RIGHT THING AND MAKE GM FIX IT. I KNOW IT IS NOT THE AMERICAN WAY TO GIVE THE PEOPLE WHAT THEY WANT BUT MAYBE THIS TIME WE CAN MAKE AN EXCEPTION. PLEASE HELP ALL OF US WHO WOULD LOVE TO BUY A DIFFERENT CAR BUT DON'T HAVE THE MONEY. THANK YOU. *LN

THIS IS A NICE CAR ,ONLY ONE COMPLAINT THIS CAR BURNS TOO MUCH FUEL . IT'S BEEN TUNED UP AND IT STILLS BURNS A LOT OF FUEL ! ! ! *TR

WHILE WE WERE DRIVING OUR 2000 CHEVROLET MALIBU HAD A SUDDEN FAILURE OF SOME COMPONENT IN THE GASOLINE STORAGE OR DELIVERY SYSTEM. WE SMELLED GAS AND SAW IT BEING SPILLED ON THE ROAD BEHIND US. WE PULLED OVER, CUT OFF AND EXITED THE CAR. WITHIN 30 SECONDS OF EXITING THE CAR, IT BURST INTO FLAMES AND WAS COMPLETELY DESTROYED BY FIRE. FORTUNATELY NO ONE WAS BURNED OR HURT, BUT THE POTENTIAL FOR CATASTROPHIC INJURY WAS APPARENT. THE VEHICLE WAS A TOTAL LOSS. *TR

TL*THE CONTACT OWNS A 2000 CHEVROLET MALIBU. THE CONTACT STATED THAT SHE HAS HAD TO REPLACE THE VEHICLE'S FUEL FILTER ON SEVERAL OCCASIONS. THE FIRST TIME WAS SHORTLY AFTER THE VEHICLE WAS PURCHASED. THE MOST RECENT FUEL FILTER CHANGE WAS ON JUNE 20, 2007 AND IT NOW HAS TO BE REPLACED AGAIN ON JULY 17, 2007. THERE IS A SAFETY RECALL ON THE FUEL FILTER, BUT SHE DOES NOT KNOW IF IT APPLIES TO HER VIN. THE PURCHASE DATE AND RECALL NUMBER WERE UNKNOWN. THE CURRENT MILEAGE IS 120,000 AND FAILURE MILEAGE WAS 30,000.

DT*: THE CONTACT STATED AFTER STARTING THE ENGINE A STRONG ODOR OF GASOLINE WAS PRESENT. THE VEHICLE WAS TAKEN TO AN INDEPENDENT REPAIR SHOP FOR INSPECTION. THE MECHANIC DETERMINED THE GASOLINE SOLENOID WAS LEAKING GASOLINE INTO THE ENGINE COMPARTMENT AND THE VEHICLE SHOULD NOT BE DRIVEN UNTIL REPAIRS WERE MADE. THE MECHANIC REPLACED THE GASOLINE SOLENOID. THE GASOLINE ODOR PERSISTED AND THE VEHICLE WAS SEEN BY AN AUTHORIZED DEALERSHIP. THE DEALER SUGGESTED REPLACING THE FUEL PUMP, FUEL INJECTION, AND POSSIBLY THE ENGINE. THERE IS A NHTSA RECALL, # 99V302000, REGARDING THE FUEL SYSTEM. THE VEHICLE HAS THE SAME PROBLEMS AS INDICATED IN THE RECALL; HOWEVER IT IS NOT INCLUDED IN THE RECALL DUE TO THE VIN.

DT*: THE CONTACT STATED IF THE GAS TANK IS NOT KEPT ABOVE HALF FULL, THE VEHICLE SHUTS OFF COMPLETELY, AND WILL NOT START AGAIN UNTIL AT LEAST 5 MORE GALLONS OF GAS IS PUT IN THE TANK. THE VEHICLE HAS BEEN TAKEN TO AN INDEPENDENT MECHANIC, WHO CHANGED THE AIR AND FUEL FILTERS. THEY CAN NOT DETERMINE THE CAUSE OF THE PROBLEM UNLESS THE VEHICLE IS BROUGHT TO THE REPAIR SHOP AT THE TIME THE INCIDENT OCCURS. THIS HAS OCCURRED MORE THAN 10 TIMES WHILE DRIVING, AND USUALLY AT SPEEDS OF 60 MPH.

VEHICLE STALLED WHILE DRIVING ON HIGHWAY I-295 SOUTH AT 65 MPH. APPARENTLY, GASOLINE WAS NOT GETTING TO THE FUEL PUMP. ALMOST CAUSED AN ACCIDENT; I HAD TO COAST FROM THE FAST LANE TO THE SHOULDER (THREE LANES)...IT WAS SCARY! VEHICLE WAS TOWED TO DEALERSHIP (BRANDOW CHEVROLET, FLORENCE, NJ). THE FUEL PUMP RELAY AND SENDER WAS BAD. HAD TO BE REPAIRED/REPLACED. *AK

WHILE DRIVING AT 30 MPH VEHICLE COMPLETELY STOPPED WITHOUT WARNING. A DEALER EXAMINED THE VEHICLE AND FOUND THAT THE FUEL SENSOR MALFUNCTIONED. *AK *M

I HAVE A 2000 MALIBU WITH 16.000 MILES ON IT. THE FUEL PUMP JUST WENT. THE MECHANICS I SPOKE WITH FELT THIS TO BE HIGHLY UNUSUAL. HE FELT THAT THERE MOST LIKELY WAS A MANUFACTURER'S DEFECT. *AK

GOING TO WORK CAR JUST DIES. WAITED FOR A TOW TRUCK. TOOK TO MY MECHANIC. HE REPLACED THE FUEL PUMP. MY CAR IS A 2000 MAILBU WHICH ONLY HAS 15,000 MILES ON IT . CANNOT BELIVE THAT THIS PART WOULD FAIL THAT SOON. THIS REPAIR COST ME 500.00 THE PART ALONE WAS OF COURSE A DEALER ONLY PART. WAS 350.00 PLUS A FILTER. OUTRAGEOUS. ARE THESE THINGS MADE OUT OF GOLD. *AK

DEALERSHIP REPLACED THE HAZARD WARNING SWITCH AT THE OWNER'S EXPENSE. THE CONSUMER ALSO HAD PROBLEMS WITH THE FUEL FITTING WHICH WAS LEAKING GAS. PLEASE PROVIDE FURTHER INFORMATION. *JB