2002 Chevrolet Malibu Complaint Log

The anti-theft/ passlock system fault in this generation of GM vehicles is very widespread and effects a large percentage of vehicles in this generation. I am sure there have been hundreds if not thousands of complaints about same issue and GM refuses to fix the problem. The problem causes the car to randomly shut off due to anti theft fault and can happen on interstate, highway or in town driving. This is a very dangerous fault and very expensive for owners especially when dealerships themselves don't even know what they are dealing with. They will throw parts at the problem with no real knowledge. GM needs to be held accountable. Currently the ignition the BCM have been replaced and now the car will not start at all and I have no lights or gauges on my cluster.

THE TURN SIGNALS WORK SOMETIMES AND SOMETIMES THEY DON'T WORK. I RESEARCHED THIS ON THE INTERNET AND IT SEAMS TO BE A SERIOUS PROBLEM WITH THIS CAR MAKE. IF THERE ARE NO RECALLS ON THIS THERE SHOULD BE. THIS IS A MAJOR SAFETY HAZARD. I JUST BOUGHT THIS CAR FOR MY TEENAGE SON.

THE HYDRAULIC BRAKE LINES BETWEEN THE FRONT AND REAR OF THE CAR CORRODED AND QUICKLY LEAKED FLUID OUT SO THE BRAKES NO LONGER FUNCTIONED. THE FLUID LEAKED OUT WHEN THE CAR WAS PARKED AFTER DRIVING ON THE HIGHWAY THE NIGHT BEFORE. IF THIS HAPPENED WHEN I WAS DRIVING THE RESULTS COULD HAVE BEEN CATESTOPHIC MY MECHANIC STATED THAT THIS IS A COMMON PROBLEM WITH CHEVYS. I SAVED SOME OF THE BRAKE LINES HE HAD TO REMOVE.

THE CHARACTERISTICS OF THE PROBLEM ARE AS FOLLOWS: THE ENGINE JUST DIES RANDOMLY. WHEN THE ENGINE DIES, I NOTED THE GAUGES ALL INDICATED THE KEY WAS IN THE OFF POSITION, EVEN THOUGH THE KEY HAD NOT BEEN TOUCHED. THEY BY TURNING THE KEY TO THE OFF POSITION AND WIGGLING IT ONLY AFTER BRINGING THE VEHICLE TO A COMPLETE STOP AND PUTTING THE GEAR SHIFT IN THE PARK POSITION, COULD I GET THE CAR TO START AND BE ON MY WAY. THIS SAME CONDITION HAPPENS AT 65 MPH ON THE FREEWAY; AT 0 MPH; 5 MPH; APPROACHING A STOP SIGN; SLOWING THE VEHICLE, AND OTHER CONDITION WHILE DRIVING THAT YOU CAN THINK OF TYPE DRIVING CONDITIONS . I HAVE HAD THE IGNITION SWITCH REPLACE TWICE AND THAT HAS NOT CURED THE PROBLEM.

TL* THE CONTACT OWNS A 2002 CHEVROLET MALIBU. THE CONTACT STATED THAT THE ENGINE HESITATED WHEN STARTED. ALSO, THE INSTRUMENT PANEL LIGHTING BECAME VERY DIM AND THE DATA ON THE SCREEN WAS NOT VISIBLE. ALSO, THE PASSENGER DOOR WOULD NOT LOCK AND THE WINDOWS FAILED TO ROLL DOWN. ALL THE WARNING INDICATORS ILLUMINATED ON THE INSTRUMENT PANEL. THE CONTACT JUMPED THE BATTERY AND THE ENGINE RESTARTED. LATER, THE VEHICLE DECELERATED WHILE DRIVING. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO DIAGNOSED THAT THE ANTI-THEFT SYSTEM FAILED. THE MECHANIC WAS CURRENTLY PERFORMING A SECOND DIAGNOSTIC TEST. THE MANUFACTURER AND DEALER WERE NOT MADE AWARE OF THE FAILURES. THE FAILURE MILEAGE WAS 46,786.

PASSLOCK CENSOR IN THE IGNITION LOCK CYLINDER FAILING. SECURITY RELEARN NEEDED. VEHICLE WAS STATIONARY.

CAR WOULD NOT START, HAD TO REPLACE ALTERNATOR. ONE WEEK LATER SAME PROBLEM, HAD A MECHANIC CHECK IT NOW SAYING ITS THE BATTERY SO REPLACED THAT. WAS STARTING OK THEN IT WOULDN'T START SO WE WIGGLED KEY AROUND AND IT STARTED. WAS ABLE TO DRIVE SEVERAL DAYS DOING THIS BUT THEN IT WOULD NOT START AT ALL. THE MECHANIC SAYS IT IS THE IGNITION SWITCH. WHEN I LOOKED THIS UP I SEE THAT LOTS OF PEOPLE HAVING PROBLEM WITH IGNITION SWITCH. GM CARS ARE CRAP!!! I CANT AFFORD TO FIX THIS I AM ON VERY LIMITED BUDGET SO MY CAR BEEN SITING FOR OVER MONTH NOW. GM NEEDS TO FIX FOR FREE.

TL* THE CONTACT OWNS A 2002 CHEVROLET MALIBU. THE CONTACT STATED THAT THE VEHICLE FAILED TO START AND THE KEY FELT HOT WHILE IN THE IGNITION. THE DEALER AND MANUFACTURER HAD NOT BEEN CONTACTED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE FAILURE MILEAGE WAS 92,000.

MY 2002 CHEVROLET CLASSIC HAS A DANGEROUS CONDITION WHERE THE TURN SIGNAL/HAZARD WARNING FLASHERS BECOME INOPERATIVE. THE CONDITION IS COMPLETELY RANDOM AND OCCURS INTERMITTENTLY. THIS HAS CREATED SURPRISE UNSAFE SITUATIONS WHEN MAKING LANE CHANGES AND LEFT AND RIGHT HAND TURNS. CHEVROLET KNOWS ABOUT THE FAULTY TURN SIGNAL/HAZARD WARNING FLASHERS HOWEVER NO RECALLS HAVE BEEN MADE. IN APRIL 2006 CHEVROLET SENT A SOMEWHAT DISMISSIVE LETTER ABOUT THE CONDITION. HOWEVER THE LETTER CLEARLY STATES THIS IS NOT A RECALL AND DO NOT TAKE YOUR VEHICLE IN FOR SERVICE. AT THAT TIME MY 2002 CHEVROLET CLASSIC DID NOT HAVE THE CONDITION DESCRIBED IN THE LETTER. I FEEL THE LANGUAGE AND INTENT OF THE LETTER WAS CONFUSING AND CREATED OPPORTUNITY FOR CHEVROLET TO DISREGARD THE CUSTOMER.

MY CAR CUTS OFF AND GOES INTO THE ANTI-THEFT SYSTEM WHILE I'M GOING DOWN THE ROAD WHEN THIS HAPPENS MY CAR HAS TO BE PUSHED OFF THE ROADWAY AND THEN I HAVE TO SIT WITH MY DRIVER SIDE DOOR OPEN AND MY KEY TURNED ON FOR 10 MINUTES UNTIL IT RESETS ITSELF THIS IS VERY DANGEROUS AND IT SCARED ME BECAUSE I WAS IN THE MIDDLE OF HIGHWAY 150 IN DANVILLE KENTUCKY. PLUSMY HEATING SYSTEM IS MESSED UP I CAN'T GET IT TO BLEED OUT THE AIR IN THE SYSTEM.

MY VEHICLE IS MESSING UP ON ME AND IT WAS SHUT OFF MY VEHICLE IS MESSING UP ON ME IT WILL SHUT OFF WELL DRIVING ILL PULL OVER AND WAIT A COUPLE MINS AND I WILL PULL OUT THE FUEL FUSE AND WAIT A COUPLE MINS AND WILL PUT IT BACK AND IT WILL START AGAIN AFTER A WEEK IT SHUT OFF ON ME AND WOULD NOT START HAD TO HAVE IT TOWED TOOK IT TO A MECHANIC HE CHANGED THE FUEL PUMP AND MARJORAM WORKED FOR 5DAYS THEN THE SAME PROBLEM AGAIN CHANGED THE SENSORS WORKED OK FOR 2DAYS AND THE PROBLEM CAME BACK AGAIN SO I CHANGED THE SPARK PLUGS FUEL FILTER ALL FUSES STILL NOTHING ITS BEEN SITTING FOR 3 TO 4 MONTHS NOW I CAN'T SEEM TO FIND THE PROBLEM I CHANGED EVERYTHING U CAN THING OF NOW THE CHECK ENGINE AND TEST SYSTEM LIGHT IS ON

KEY DOES NOT SHUT OFF CAR CAN NOT SHIFT GEARS

TL* THE CONTACT OWNS A 2002 CHEVROLET MALIBU CLASSIC. WHILE DRIVING UNKNOWN SPEEDS, THE TURN SIGNAL AND EMERGENCY LIGHT INDICATORS FAILED TO ILLUMINATE WITHOUT WARNING. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO STATED THAT AN UNKNOWN MODULE SWITCH NEEDED TO BE REPLACED. THE LOCAL DEALER WAS NOT CONTACTED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED. THE FAILURE MILEAGE WAS 113,000.

ANTI-THEFT LOCKING DEVICE MAKE CAR STOP AND CAN'T START EVEN IN EMERGENCY SITUATION. HAD GONE TO BANK AND WHEN TRIED TO START VEHICLE AND WOULDN'T START. CLIENT IS 88 YEARS OLD AND HAD TO GO OUT ON STREET SEEKING HELP TO GET CAR FIXED. (FORGOT CELL PHONE AT HOME) WALKED SOME DISTANCE AND WAS HAVING RESPIRATORY PROBLEMS WHEN SHE REACHED AN AUTO SHOP. MECHANIC WENT TO CAR TO HELP AND FIXED PROBLEM. SAID IT WAS ANTI-THEFT MECHANISM. THIS SAME THING HAS HAPPENED BEFORE WHEN CAR HAD TO BE TOWED AND WAS DIAGNOSED AS ANTI-THEFT LOCKING DEVICE. RESEARCHING MATTER ON INTERNET AND FIND THERE ARE THOUSANDS OF CHEVROLETS EXHIBITING THE SAME DEFECT. WHY ISN'T CHEVROLET REQUIRED TO FIX THIS PROBLEM BEFORE SOME DIES AS A RESULT. WE CAN'T ALWAYS CONTROL CIRCUMSTANCES OF BEING STRANDED, WHERE WHEN HOW ETC., AND THIS IS ABSOLUTELY A SAFETY PROBLEM FOR THE DRIVER. PLEASE HELP WITH THIS PROBLEM. WHEN INDIVIDUALS ARE ON FIXED INCOME THEY CAN'T KEEP GOING TO DEALER AND HAVE $108 DIAGNOSIS TO DETERMINE PROBLEM (WHEN THEY ALREADY KNOW WHAT IT IS) AND THEN CHARGING BIG BUCKS TO FIX A MINOR FIX. THANK YOU FOR YOUR ATTENTION.

ANTI THEFT DEVICE CAUSED CAR TO BE UNABLE TO START EVEN WITH CORRECT KEY. STATIONARY. COMPUTER HAD TO.BE REPROGRAMMED.

TL* THE CONTACT OWNS A 2002 CHEVROLET MALIBU. WHILE TURNING THE IGNITION SWITCH, THE VEHICLE STALLED AND THE ANTI-THEFT WARNING INDICATOR ILLUMINATED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC, BUT WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED. THE VIN AND FAILURE MILEAGE WERE UNKNOWN. UPDATED 09/06/17*LJ

MY CAR DIES RUNNING AND IT SOMETIMES DOESN'T WANTS TO START DUE TO A SWITCH PROBLEM THE SAME I HAD IN OTHER MALIBU THAT I HAD AND THE DEALER FIXED FOR ME

TL* THE CONTACT OWNS A 2002 CHEVROLET MALIBU. THE CONTACT STATED THAT THE ENGINE WARNING INDICATOR ILLUMINATED AND ANTI-FREEZE WAS LEAKING OUT OF THE VEHICLE. THE CONTACT TOOK THE VEHICLE TO AN UNKNOWN DEALER WHERE IT WAS DIAGNOSED THAT THE HEAD GASKET BLEW OUT AND NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED, BUT THE FAILURE RECURRED. THE OURISMAN CHEVROLET DEALER STATED THAT THE ENGINE NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER INFORMED THE CONTACT THAT THE VEHICLE WAS NO LONGER UNDER WARRANTY. THE APPROXIMATE FAILURE MILEAGE WAS 10,333.

TL* THE CONTACT OWNS A 2002 CHEVROLET MALIBU CLASSIC. WHILE THE ACCELERATOR PEDAL WAS DEPRESSED, THE VEHICLE FAILED TO ACCELERATE AND LOST POWER. THE CHECK ENGINE WARNING INDICATOR ILLUMINATED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE EGR VALVE NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE VEHICLE WAS THEN TAKEN TO GILDNER DODGE-CHRYSLER-JEEP INC (1451 N 10TH ST, ARKADELPHIA, AR 71923 (870) 246-6800), BUT NO DIAGNOSTIC FAILURE CODES WERE FOUND AND THE FAILURE COULD NOT BE REPLICATED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND THE CONTACT WAS PROVIDED A CALL BACK. THE APPROXIMATE FAILURE MILEAGE WAS 99,378.

HAVE A 2002 MALIBU, AND THE THEFT SYSTEM LIGHT KEEPS COMING ON AND I HAVE TO TURN OFF THE RADIO, TURN THE IGNITION KEY TO ACC, WAIT 10 - 15 MINUTES FOR THE THEFT SYSTEM LIGHT TO STOP BLINKING AND "DISAPPEAR", THEN TURN THE KEY TO THE OFF POSITION, WAIT ANOTHER 5 - 10 MINUTES. THEN TURN THE KEY TO THE START POSITION FOR THE CAR TO CRANK. THE WHOLE PROCESS CAN TAKE APPROXIMATELY 25 MINUTES TO START THE CAR. I NEVER KNOW WHEN I GET IN MY CAR IF THE PROBLEM WILL OCCUR, WHEN IT WILL HAPPEN OR WHERE I WILL BE WHEN IT HAPPENS. THE MOST RECENT TIME WAS YESTERDAY 3/22/17.

:TAKATA RECALL" PURCHASED AND NEXT DAY WENT BY DEALERSHIP AS THE TAILLIGHTS WERE INOPERATABLE. HE SAID BRING IT WHEN IT WASN'T RAINING OR WIFE WAS THERE. I WENT TO CRANK IT TO GO TO DR. AND IT WOULDN'T CRANK. I THOUGHT IT WAS FUEL PUMP. AFTER A WEEK OF NOT CRANKING I CALLED A MECHANIC AND HE SAID HE WOULD CHECK IT OUT. I HAD TO HAVE IT TOWED. IT WAS THE IGNITION SWITCH. DROVE THE DAY WAS FIXED AND DROVE AND CHECK ENGINE LIGHT CAME ON. WE DIDN'T TURN OFF BUT DROVE BACK TO WHERE WE GOT IT RUNNING. HE PUT THE LIGHT TO IT AGAIN AND STILL SHOWED IGINITION SWITCH. HE TOLD US TO BE CAREFUL UNTIL YOU GET IT FIXED. I CALLED CHEV DEALER AND SAID THEY DIDN'T HAVE IN STOCK WOULD HAVE TO ORDER FOR RECALL. I FOUND OUT THEN THE RECALL WAS FOR 2 KEYS. I STOPPED BY GRO STORE ON WAY HOME FROM CHURCH AND WENT GOT IN CAR AND ALL THE LIGHTS CAME ON. BRAKE LIGHT, FUEL LIGHT EVEN THOUGH IT WAS FULL, CHECK ENGINE LIGHT, BATTERY, AND THEY ALL STAYED ON UNTIL I GOT HOME ABOUT 2 MILES.THIS IS NOT JUST A COMPLAINT, IT IS FOR MY SAFETY AND FOR EVERYONE ELSE'S. WHAT IF WE ENDED UP WRECKING BECAUSE OF THIS IGINATION SWITCH. ALL THESE PROBLEMS AND ONLY HAD IT LESS THAN 3 MONTHS AND ONLY 100,000. I AM NOT ABLE TO WALK ANY DISTANCE BCAUSE OF BREATHING. SOMETHING NEEDS TO BE DONE BEFORE ONE OF THESE CARS ENDS UP KILLING SOMEONE. THE FIRST TIME THIS OCCURRED, I WAS IN MOTION BUT 2ND IT WAS PARKED IN DRIVEWAY. WHEN I TURNED THE IGNITION SWITCH OFF, IT ALSO MADE A METAL SCRUBBING SOUND AND WOULD NOT STOP UNTIL I GOT IT COMPLETELY OFF. .

HEADLIGHTS DIM WHEN BRAKES ARE APPLIED SUCH AS COMING TO A STOP OR SLOWING DOWN TO NEGOTIATE TURNS. THIS CREATES A DANGEROUS SITUATION WHERE VISIBILITY IS COMPROMISED DURING NIGHT DRIVING. IT IS VERY EASY TO MISS TURNS, EXIT RAMPS, AND ROAD SIGNS. VEHICLE HAS BEEN TO GM SERVICE CENTER, AND WAS TOLD THIS OPERATION IS NORMAL. BATTERY, AND CHARGING SYSTEM NO PROBLEMS FOUND. NEW HEADLIGHT BULBS INSTALLED NO DIFFERENCE. VEHICLE IS LIKE NEW CONDITION; ALWAYS GARAGED. NO DAMAGE, RUST, OR MODIFICATIONS. IT SHOULD BE NOTED THAT THERE IS A TSB #02-06-03-008A CONCERNING THE ISSUE.

INTERMITTEN ON RIGHT AND LEFT HAND TURNS THE CAR WILL STALL AND STOP. REPLACED MODULE ASMELEK/IGNITION CONTROL AND MY SAME PROBLEM PERSISTED. TOOK IT TO THE DEALERSHIP AND THEY FIXED THEY REPLACED THE MODULE AND SWTICH AND MY PROBLEM STILL CONTINUES. MY CAR IS STILL AT THE DEALERSHIP NOW AS OF JAN. 26, 2017.

TL* THE CONTACT OWNS A 2002 CHERVOLET MALIBU. THE CONTACT STATED THAT THE VEHICLE EXPERIENCED A LOSS OF POWER. THE DEALER REPAIRED THE VEHICLE PER NHTSA CAMPAIGN NUMBER: 14V400000(ELECTRICAL SYSTEM); HOWEVER, THE FAILURE RECURRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 100,000.

I PURCHASED MY USED CAR IN THE FALL OF 2015. SINCE THEN, I HAVE EXPERIENCED SEVERAL INCIDENTS - NOW OCCURRING MORE FREQUENTLY - IN WHICH MY CAR WILL NOT START BECAUSE THE ANTI-THEFT SYSTEM BELIEVES I AM TRYING TO STEAL IT. WHEN I TURN THE KEY IN THE IGNITION, THE CAR WILL NOT START AND THE ANTI-THEFT LIGHT STARTS BLINKING. I MUST WAIT EXACTLY 10 MINUTES WITH THE KEY IN THE "ON" POSITION FOR THE LIGHT TO STOP BLINKING. THEN I CAN RESTART THE CAR AND IT WORKS FINE. THIS HAS HAPPENED SEVERAL TIMES IN THE PAST FEW WEEKS. I HAVE LOOKED ONLINE FOR SOLUTIONS TO THIS PROBLEM, AND HAVE DISCOVERED THAT NUMEROUS MALIBU OWNERS HAVE EXPERIENCED THE EXACT SAME PROBLEM. I HAVE BEEN STRANDED IN DARK PARKING LOTS MULTIPLE TIMES, AND DO NOT FEEL SAFE KNOWING THAT MY VEHICLE REGULARLY WILL NOT START WITHOUT A TEN MINUTE DELAY.

TL* THE CONTACT OWNS A 2002 CHEVROLET MALIBU. WHEN THE ENGINE WAS TURNED OFF, THE VEHICLE FAILED TO RESTART AND THE SECURITY LIGHT BLINKED ON AND OFF. THE VEHICLE WAS TOWED TO A MECHANIC WHO REPLACED THE FUEL PUMP; HOWEVER, THE FAILURE RECURRED. THE VEHICLE WAS TAKEN TO A MECHANIC WHO DIAGNOSED THAT THE PASS LOCK SENSOR FAILED. THE VEHICLE WAS NOT REPAIRED. THE VIN WAS UNKNOWN. THE APPROXIMATE FAILURE MILEAGE WAS 140,000.

TL* THE CONTACT OWNS A 2002 CHEVROLET MALIBU. WHILE IN PARK, THE VEHICLE FAILED TO START AND THE KEY FAILED TO TURN FROM THE OFF POSITION. ALL THE LIGHTS ON THE INSTRUMENT CLUSTER ILLUMINATED. THE VEHICLE WAS TAKEN TO A DEALER WHERE IT WAS DIAGNOSED THAT THE IGNITION LOCK CYLINDER NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE VEHICLE WAS PREVIOUSLY REPAIRED PER NHTSA CAMPAIGN NUMBER: 14V400000 (ELECTRICAL SYSTEM). THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 168,000.

I HAD THE RECALL DONE ON 11-26-14 FOR GM WILL NOTIFY OWNERS, AND DEALERS WILL INSTALL TWO KEY RINGS AND AN INSERT IN THE KEY SLOT OR A COVER OVER THE KEY HEAD ON ALL IGNITION KEYS, FREE OF CHARGE. THE RECALL BEGAN ON SEPTEMBER 9, 2014. GM'S NUMBER FOR THIS RECALL IS 14350. NOW THE CHIP IN THE IGNITION SWITCH KEEPS GOING IN TO TAMPER MODE. THE CAR WILL NOT START AND THE COMPUTER HAS TO BE RESET TO MAKE IT START. I HAVE HAD TO HAVE IT TOWED 2 TIMES IN THE LAST 8 DAYS! SO NOW I HAVE TO PAY OVER $500.00 TO HAVE IT REPLACED! THIS SHOULD BE COVERED UNDER THE RECALL! THE KEY FIX DID NOT FIX THE PROBLEM. THE CAR HAS ONLY 124 THOUSAND MILES ON IT! PROSTROLLO MOTOR CO. IN MADISON, SD 570472 605-256-9111 IS THE DEALERSHIP REPAIRING IT AND SAID MANY OTHER CARS LIKE MINE HAVE HAD TO DO THIS ALSO!!! WHAT A RIP OFF!

TL* THE CONTACT OWNS A 2002 CHEVROLET MALIBU. WHEN THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC FOR BRAKE REPAIRS, THE TECHNICIAN NOTICED THAT THE ENTIRE FRAME WAS ROTTED OUT AND ADVISED THE CONTACT TO TAKE THE VEHICLE OFF THE ROAD. THE TECHNICIAN DID NOT PROCEED WITH THE BRAKE WORK, STATING THAT THE VEHICLE WAS COMPLETELY DAMAGED AND NOT ABLE TO BE REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED. THE FAILURE MILEAGE WAS 185,000.

I TURNED ON MY AC AND THE TEMP AND FUEL GUAGE FUSE BLOWED WHILE HAVING THE AIR ON STILL CHANGING OUT FUSES AND THE AUTOMATIC CAR LOCKS ON IT OWN WHEN YOU CLOSES THE DOORS GETTING OUT OR IT WILL LOCK WHEN SOME ONE GETS OUT OF THE CAR ALL BY ITSELF WITHOUT HITTING THE DOOR LOCK ON THE KEYLESS ENTRY.

PURCHASED VEHICLE USED FROM A DEALERSHIP. OVER HEATING ISSUES BEGAN WITHIN 3 MONTHS. HAD THERMOSTAT REPLACED. ALWAYS SEEMED TO HAVE TO BE ADDING WATER AS THE RESERVOIR WAS LOW OR THE INDICATOR LIGHT WOULD COME ON. 18 MONTHS LATER OVER HEATING ISSUES RETURNED WHILE DRIVING HOME ON HIGHWAY. WHEN VEHICLE COULD NO LONGER RUN, WE HAD TO HAVE IT TOWED HOME. HAVE NOW REPLACED THERMOSTAT AND WATER PUMP. ISSUE REMAINS, BUT WORSE. LOW WATER AND NOW CHECK ENGINE LIGHTS ARE ON. ALL INDICATIONS SUGGEST HEAD GASKET ISSUES WHICH WILL ULTIMATELY RESULT IN COMPLETE ENGINE FAILURE. AS SUCH, THE VEHICLE CANNOT BE SAFELY DRIVEN AND REMAINS PARKED. NO SUCH ISSUES WERE DISCLOSED AT THE TIME OF PURCHASE. ONLY LEARNED EXTENT OF PROBLEM AFTER RESEARCHING ISSUE ONLINE TO FIND MANY, MANY OTHER OWNERS OF THIS VEHICLE TYPE EXPERIENCING SAME PROBLEMS. CHEVROLET SHOWED LITTLE CONCERN WHEN CONTACTED. REPRESENTATIVE APOLOGIZED, BUT AS THERE IS NO RECALL WOULD ONLY SUGGEST TAKING THE VEHICLE TO A DEALERSHIP FOR DIAGNOSIS AND REPAIR. OWNER IS A DISABLED VETERAN ON A FIXED INCOME. CHEVROLET'S SUGGESTION IS SIMPLY NOT FINANCIALLY FEASIBLE AND LEAVES THE OWNER WITHOUT RELIABLE TRANSPORTATION TO AND FROM APPOINTMENTS. HE CANNOT USE THIS VEHICLE FOR THE PURPOSES FOR WHICH IT WAS INTENDED. FURTHERMORE, ONLINE REPORTS ALSO SUGGEST THE PROBLEM REMAINS OR RETURNS EVEN AFTER LENGTHY AND EXPENSIVE REPAIRS ARE MADE. ONCE AGAIN, CREATING CONSIDERABLE HARDSHIP TO THIS OWNER WHO NOW FEELS AS THOUGH HE WAS ROBBED FIRST BY THE DEALERSHIP WHERE HE PURCHASED THE VEHICLE FOR THEIR NONDISCLOSURE AND NOW BY CHEVROLET FOR THEIR NEGLIGENT DESIGN, QUALITY AND WORKMANSHIP AS WELL AS THEIR COMPLETE LACK OF DESIRE TO REMEDY THIS YEARS OLD DEFECT. INSTEAD SHIFTING THE FINANCIAL BURDEN FROM ONE UNSUSPECTING OWNER TO THE NEXT AND THE NEXT AFTER THAT.

PURCHASED MY 2002 CHEV MALIBU NEW! HAS 39000MILES ON IT ,GRANTED, CAR IS 14YRS OLD BUT IN MINT CONDITION . ITS GONE THROUGH 3 SETS OF ROTORS ,3 SETS OF FRONT PADS, 2 SETS OF CALIPERS AND ONE SET OF BRAKE LINES, BOTH FRONT HUB & BEARINGS TWICE!! .THERE` S A SERIOUS PROBLEM WITH THE DESIGN OF THIER BRAKE SYSTEM DESIGN!!

THE DRIVER'S SIDE SEATBELT DOES NOT LOCK WHEN STRESSED. THE PASSENGER ONE DOES. CHEVROLET WILL NOT FIX IT FOR FREE. A FRIEND HAS THE SAME VEHICLE AND IT DIDN'T LOCK IN AN ACCIDENT. SHE SMASHED HER FACE OFF THE STEERING WHEEL. WE DON'T WANT TO HAPPEN TO OUR DAUGHTER.

VEHICLE WAS RUNNING FINE. PARKED CAR FOR 1 HOUR WENT TO START CAR IT WOULD TURN OVER BUT NOT START. AFTER CHECKING ALL FUSES AND FUEL PUMP I WAS ADVISED IT COULD BE AN ANTI THEFT MALFUNCTION. I FOLLOWED A PROCEDURE TO RELEARN THE SYSTEM AND THE CAR STARTED. THIS HAS HAPPENED ON 3 OCCASIONS AND I FEAR THE CAR WILL LEAVE ME STRANDED OR MALFUNCTION WHILE OPERATING WHICH COULD LEAD TO A SERIOUS INJURY

TL* THE CONTACT OWNS A 2002 CHEVROLET MALIBU. WHILE ATTEMPTING TO START THE VEHICLE, THE SECURITY THEFT LIGHT ILLUMINATED ON THE INSTRUMENT PANEL. THE VEHICLE WOULD NOT START AND WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE SECURITY SYSTEM PREVENTED THE VEHICLE FROM STARTING. THE CONTACT STATED THAT THE SYSTEM WAS RESET BY THE INDEPENDENT MECHANIC, BUT THE FAILURE RECURRED. THE VEHICLE WAS PREVIOUSLY SERVICED UNDER NHTSA CAMPAIGN NUMBER: 14V400000 (ELECTRICAL SYSTEM), BUT THE REMEDY FAILED TO REPAIR THE VEHICLE. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 159,000. THE VIN WAS NOT AVAILABLE.

CAR WILL NOT START

TL* THE CONTACT OWNS A 2002 CHEVROLET MALIBU. WHILE DRIVING APPROXIMATELY 5 MPH, THE VEHICLE STALLED WITHOUT WARNING AND FAILED TO RESTART. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE IGNITION SWITCH NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE CONTACT MENTIONED THAT THE FAILURE OCCURRED AFTER THE VEHICLE WAS SERVICED UNDER NHTSA CAMPAIGN NUMBER: 14V400000 (ELECTRICAL SYSTEM). THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 110,000.

TL* THE CONTACT OWNS A 2002 CHEVROLET MALIBU. THE CONTACT STATED THAT WHILE DRIVING AT 15 MPH, THE VEHICLE STALLED. THE CONTACT WAS ABLE TO RESTART THE VEHICLE AFTER SEVERAL ATTEMPTS. THE CONTACT STATED THAT THE FAILURE RECURRED FOUR TIMES. THE VEHICLE WAS TAKEN TO A DEALER TO BE DIAGNOSED. THE CONTACT WAS INFORMED THAT THE IGNITION SWITCH NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 14V400000 (ELECTRICAL SYSTEM). THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILE WAS 78,400.

GM HAS A RECALL ON IGNITION SWITCH (GM#14350). WE HAD THE WORK DONE AT A GM DEALER FOR THE RECALL. (DEALER PROVIDES 2 KEY RINGS AND A KEY COVER AND CALLS IT FIXED.) APPARENTLY IT DIDN'T WORK. CAR CURRENTLY IN MY LOCAL MECHANIC SHOP FOR ROUTINE MAINTENANCE. DURING INSPECTION, MECHANIC FOUND THE VEHICLE NEEDS A NEW IGNITION SWITCH ASSEMBLY TO SOLVE THE SAME PROBLEM. MECHANIC SAYS CAR EXTREMELY UNSAFE TO DRIVE UNLESS REPLACED. HE TOOK A VIDEO OF MY IGNITION SHOWING THAT JUST TOUCHING THE KEY WHILE IN IGNITION CAUSES CAR TO TURN OFF. (HAVE 20 YR RELATIONSHIP WITH MECHANIC - VERY RELIABLE.) PLEASE INVESTIGATE IF GM IS REALLY DOING THE PROPER WORK FOR THE RECALL OR JUST SUGAR COATING A DANGEROUS DEFECT.

TL* THE CONTACT OWNS A 2002 CHEVROLET MALIBU. THE CONTACT STATED THAT WHILE DRIVING AT APPROXIMATELY 55 MPH, THE VEHICLE STALLED AS THE ANTI-THEFT WARNING LIGHT ILLUMINATED. THE VEHICLE WAS RESTARTED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 93,567.

THERE WAS A BREAKDOWN, OF THE UPPER AND LOWER MANIFOLDS, CAUSED BY THE DEX COOLANT, AND POOR ENGINE DESIGN. COOLANT GOT INTO MY ENGINE, AND NEEDS TO BE REPAIRED OR A REPLACEMENT ENGINE REPLACED. SENDING A PICTURE OF THE OIL CAP WITH FOAM ON IT, AND ITS LIKE THIS INSIDE THE ENGINE AS WELL.

VEHICLES RACK AND PINION RUSTED OFF FROM THE FRONT CRADLE WHILE DRIVING THE VEHICLE. I WAS LUCKY TO NOT GET INTO AN ACCIDENT. THERE SEEMS TO BE A LOT OF PROBLEMS LIKE THIS ONE WITH THE MALIBU'S THAT I HAVE READ.

TL* THE CONTACT OWNS A 2002 CHEVROLET MALIBU. THE CONTACT STATED THAT THE VEHICLE FAILED TO START INTERMITTENTLY WITHOUT WARNING. IN ADDITION, WHEN THE IGNITION KEY WAS TURNED TO THE OFF POSITION, THE VEHICLE FAILED TO SHUT OFF. AS A RESULT, THE BATTERY WAS DRAINED AND HAD TO BE CHARGED. THE VEHICLE WAS TAKEN BACK TO THE DEALER, BUT WAS NOT DIAGNOSED OR REPAIRED. THE CONTACT STATED THAT THE FAILURE RECURRED AFTER THE VEHICLE WAS SERVICED UNDER NHTSA CAMPAIGN NUMBER: 14V400000 (ELECTRICAL SYSTEM). THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 238,419. UPDATED 1/19/16 LN *CN

AFTER 10 MINS CAR WAS DRIVEN, PARKED IN A PARKING LOT. WENT INSIDE SHOP, AND AFTER 15MINS, CAME BACK AND TRIED TO START THE CAR, AND CAR DID NOT STARTED. ANTI-THEFT SYMBOL WAS BLINKING. TRIED TO JUMP START, DID NOT WORK. TOOK BATTERY TO AUTO ZONE, AND THEN MENTIONED THAT BATTERY IS NOT GOOD. PURCHASED BATTERY, AND INSTALLED. TURNED CAR KEY IN ON POSITION. ANTI-THEFT SYSTEM WAS BLINKING. AFTER ~10MINS, ANTI-SYSTEM STOPPED BLINKING. TURNED KEY TO OFF POSITION, AND TURNED TO ON AND START POSITION, AND CAR STARTED.

THE THEFT SYSTEM LIGHT APPEARS ON DASH WHEN KEY IS PUT INTO THE IGNITION, UPON TURNING THE IGNITION, CAR WON'T START, DUE TO THE THEFT SYSTEM LIGHT, WHY DOES MY CAR NOT RECOGNIZE MY KEY? THIS IS A DEFECT IN THE MANUFACTURING. THE CAR SHOULDN'T "THINK" THE OWNER IS TRYING TO STEAL IT. HAD TO GET CAR TOWED TO DEALERSHIP, THEY TOLD ME THE IGNITION CYLINDER NEEDS TO BE REPLACED, QUOTED ME 613$ PLUS TAX. I AM FORCED TO GET IT REPLACED. THE SERVICE ADVISER SAID UPON REPLACEMENT, THEY WOULD NEED TO REPROGRAM THE COMPUTER TO RECOGNIZE A NEW KEY! AGAIN, THIS IS DEFECTIVE MANUFACTURING, THIS ISN'T JUST A BAD BATTERY, OR BAD ALTERNATOR, THIS IS A COMPUTER GLITCH THAT HAS NOTHING TO DO WITH THE MOTOR, BUT A FAULTY BUILT IN THEFT SYSTEM. THE COMPUTER FAILING IN A VEHICLE PROGRAMMED BY ITS MANUFACTURER NEEDS TO BE RECALLED AND FIXED. THIS ISN'T THE CONSUMERS FAULT. I AM LUCKY MY MOTOR DIDN'T CUT OFF WHILE DRIVING, BECAUSE PREVIOUS TO NOT STARTING UP AT ALL, THE THEFT SYSTEM LIGHT WOULD GO ON WHILE DRIVING DOWN THE ROAD.

TL* THE CONTACT OWNS A 2002 CHEVROLET MALIBU. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 14V400000 (ELECTRICAL SYSTEM); HOWEVER, THE CONTACT STATED THAT WHEN ATTEMPTING TO TURN THE KEY TO START THE VEHICLE, IT FAILED TO START. THE VEHICLE WAS TAKEN TO THE IN DEPENDANT MECHANIC WHO DIAGNOSED THAT THE IGNITION SENSOR, TRIPPED THE ALARM LOCK SYSTEM. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 64,000.

FACTORY POWER SUNROOF SWITCH HAS PREMATURE INTERMITTENT FAILURE CAUSING THE WINDOW TO STOP MIDWAY OR OPEN PARTIALLY. CLOSURE IS ALSO PARTIAL OR STOPPING MIDPOINT. THE SWITCH FAILURE REQUIRES MULTIPLE ATTEMPTS TO OPEN AND OR CLOSE THE GLASS. ALL OTHER POWER ACCESSORIES WORK AS INTENDED INCLUDING OTHER POWER WINDOW SWITCHES. VEHICLE HAS NEVER BEEN MODIFIED OR OR DAMAGED.

TL* THE CONTACT OWNS A 2002 CHEVROLET MALIBU. AFTER REPEATED ATTEMPTS, THE VEHICLE FAILED TO START. THE VEHICLE WAS TOWED TO THE DEALER. THE TECHNICIAN DIAGNOSED THAT THE PASS LOCK SENSOR WAS FAULTY AND CAUSED FAILURE WITH THE ANTI-THEFT PASS LOCK SYSTEM. THE VEHICLE WAS NOT REPAIRED SINCE THE PARTS WERE NOT AVAILABLE. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 43,500. THE VIN WAS UNAVAILABLE.

TL* THE CONTACT OWNS A 2002 CHEVROLET MAILBU CLASSIC. WHILE DRIVING APPROXIMATELY 10 MPH, THE ENGINE STALLED WHILE MAKING A LEFT TURN AND THE SECURITY WARNING LIGHT ILLUMINATED. THE CONTACT ALSOOBSERVED AN ABNORMAL NOISE DURING THE FAILURE. THE CONTACT ALSO STATED THAT THE POWER LOCKS UNLOCKED AND LOCKED WITHOUT BEING PROMPTED AND THE GAUGE LEVELS INCREASED. THE VEHICLE WAS ABLE TO RESTART AFTER VARIOUS ATTEMPTS; HOWEVER, THE FAILURE RECURRED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE CONTACT MENTIONED THAT THE ENGINE WAS SERVICED PER A RECALL, BUT THE NHTSA CAMPAIGN NUMBER WAS NOT AVAILABLE.THE FAILURE MILEAGE WAS 110,000.

I HAD AN IGNITION SWITCH REPLACED BY A DEALER (DIMMITT CHEVROLET, CLEARWATER, FL) BECAUSE MY KEY WAS STUCK IN IT. THE SAME DEALER ALSO REPLACED MY KEY AND KEY CASING BECAUSE OF A RECALL. AFTER THAT I STARTING NOTICING THAT MY CAR WOULD INTERMITTENTLY CUT OFF FORCING ME TO PUT IN NEUTRAL AND RESTART. I THOUGHT IT MAY BE A CLOGGED FUEL FILTER AND HAD THAT REPLACED. THE ISSUE STILL EXISTS AND IT IS A DANGEROUS SITUATION TO ME AND MY FAMILY NOT KNOWING WHEN MY CAR WILL JUST STOP RUNNING, ESPECIALLY WHILE DRIVING AT HIGHWAY SPEEDS. I CHECKED AND DO NOT SEE A GM RECALL ON MY MODEL FOR SOME REASON.