2000 Chevrolet Tahoe Brakes Problems

ABS/Traction Control wheel speed sensors corroded, causing the ABS to activate at low speeds and making it impossible to stop the car. This is the same issue as has been reported for other VIN numbers of the same vehicle; see Safety Recall 05068 Front Wheel Speed Sensor Corrosion, https://static.nhtsa.gov/odi/rcl/2005/RCRIT-05V379-8709.pdf. However, that recall was limited to vehicles registered in the "Rust Belt" states; it appears that as this vintage of vehicle has aged, vehicles outside the Rust Belt now are experiencing the same problem, suggesting that the recall should be broadened.

TL* THE CONTACT OWNS A 2000 CHEVROLET TAHOE. THE CONTACT STATED THAT WHEN HIS DAUGHTER DROVE DOWN HILL AND THE BRAKE PEDAL WAS ENGAGED, THE BRAKE SYSTEM FAILED TO ENGAGE CAUSING THE DRIVER TO HIT A PERSON THAT WAS DRIVING A BICYCLE. THE VEHICLE WENT UP A HILL AND THE DRIVER PROCEEDED ATTEMPTING TO STOP THE VEHICLE BUT IT WENT UP A HILL, ROLLED BACKWARDS INTO BUSHES, AND CRASHED INTO A TREE WHERE IT CAME TO A STOP. THE POLICE WAS PRESENT AND A REPORT WAS FILED; THE POLICE REPORT NUMBER WAS NOT AVAILABLE. THE PERSON ON THE BICYCLE WAS TAKEN TO THE HOSPITAL AND SUFFERED UNKNOWN FRACTURES TO THE BODY. THE DRIVER DID NOT SUSTAIN ANY INJURIES. THE VEHICLE WAS TOWED TO THE CONTACTS FATHER RESIDENCE AND HE NOTICED THAT THE BRAKE LINES WERE CORRODED AND BRAKE FLUID WAS ON THE GROUND. THE VEHICLE WAS NOT TAKEN TO THE DEALER. THE MANUFACTURER WAS CALLED HOWEVER THERE WAS A LONG WAIT TIME AND A REPRESENTATIVE WAS NOT AVAILABLE TO ANSWER THE CALL PROMPTLY. THE APPROXIMATE FAILURE MILEAGE WAS 166,000. THE VIN WAS NOT AVAILABLE.

WHILE DRIVING MY VEHICLE , I APPLIED THE BRAKES TO STOP AT A TRAFFIC LIGHT , AND THE BRAKE PEDAL TRAVELED ALL THE WAY TO THE FLOOR . THE TAHOE FINALLY STOPPED AFTER A MUCH LONGER THAN NORMAL DISTANCE . AFTER INSPECTING THE MASTER CYLINDER , THERE WAS HARDLY ANY BRAKE FLUID REMAINING . I FOUND THAT THE BRAKE LINES WERE VERY RUSTED , AND THAT THE LINE GOING TO THE REAR BRAKES WAS RUSTED THROUGH . THIS RUSTING OF THE BRAKE LINES SHOULD NEVER OCCUR !

The contact owns a 2000 Chevrolet Tahoe. The contact stated that while driving at slow speeds, the ABS would erroneously activate. During the failure, the stopping distance was increased and the ABS warning light was activated. The cause of the failure was not yet determined. The manufacturer was notified of the failure and informed that the vehicle was not included in NHTSA Campaign Number: 05V379000 (Service Brakes, Hydraulic). The local dealer was not contacted. The vehicle was not repaired. The failure mileage was 150,000.

TL* THE CONTACT OWNS A 2000 CHEVROLET TAHOE. THE CONTACT STATED THAT THE ABS WARNING LIGHT ILLUMINATED WHEN ATTEMPTING TO PARK OR MAKING A TURN. THE VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBERS: 05V379000 (SERVICE BRAKES, HYDRAULIC) AND 00V345000 (SERVICE BRAKES, HYDRAULIC). THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 150,000.

WENT TO STOP AT STOP SIGN AT APPROXIMATELY 4MPH AND NO BRAKES. THE BRAKE PEDAL WENT ALL THE WAY TO THE FLOOR WITHOUT ANY RESISTANCE OR HESITATION. AS A RESULT OF THE BRAKE MALFUNCTION I REAR ENDED AN ELDERLY COUPLE IN A LEXUS. RESULTING IN DAMAGE TO THEIR REAR BUMPER PLASTIC COVER AND MORE DAMAGE WAS DONE TO MY FRONT END OF THE DEFECTIVE 200 CHEVROLET TAHOE Z71 I WAS DRIVING

HELLO I AM EXPERIENCING THE EXACT SYMPTOMS DESCRIBED IN GM RECALL 05068C "THESE VEHICLES MAY HAVE A CONDITION PERMITTING CORROSION TO OCCUR BETWEEN THE FRONT HUB/BEARING ASSEMBLY AND THE WHEEL SPEED SENSOR. IF THE BRAKES ARE APPLIED WHILE THE VEHICLE IS TRAVELING AT A SPEED OF GREATER THAN 6 KM/H (3.7 MPH) BUT LESS THAN 16 KM/H (10 MPH), THE CORROSION MAY CAUSE AN UNWANTED ANTILOCK BRAKE SYSTEM (ABS) ACTIVATION. IF THIS CONDITION OCCURRED WHERE STOPPING DISTANCE IS LIMITED, A CRASH COULD OCCUR. " HOWEVER, MY VIN IS NOT INCLUDED IN THE BREAKPOINTS, EVEN THOUGH I HAVE A 2000 CHEVROLET TAHOE. I CAN DEMONSTRATE THAT THIS IS THE PROBLEM IN TWO WAYS, FIRST BY REPRODUCING WITH A SCAN TOOL THAT SHOWS UNEXPECTED ABS ACTIVATION DURING STOPPING AT THIS LOW SPEED, AND SECOND AFTER PULLING THE ABS FUSE THIS PROBLEM DOES NOT HAPPEN. THIS CLEARLY POINTS TO THE ABS ISSUE MENTIONED IN THE RECALL. I HAVE CONTACTED TWO LOCAL DEALERSHIPS, AND AFTER I ASKED ABOUT RECALLS THEY SAID MY VIN WAS INVALID. THEN I CONTACTED THE CHEVY CONTACT CENTER AND THEY SAID THERE ARE NO RECALLS FOR MY VEHICLE. SO NOW WHAT - SHOULD I JUST REPLACE THE ABS SENSORS AND MOVE ON, OR IS THERE ANY CHANCE OF GETTING THIS ACKNOWLEDGED BY GM AS PART OF THE RECALL?

TL* THE CONTACT OWNS A 2000 CHEVROLET TAHOE. WHILE APPROACHING A STOP SIGN, THE BRAKES FAILED. THE CONTACT HAD TO APPLY EXCESSIVE FORCE IN ORDER TO STOP THE VEHICLE. AS A RESULT, THE CONTACT CRASHED THE VEHICLE INTO A POLE. THERE WERE NO INJURIES AND A POLICE REPORT WAS FILED. THE FAILURE RECURRED SEVERAL TIMES. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 256,345.

TRIED TO STOP AND BRAKES FAILED DUE TO RUSTED THRU REAR LEFT STEEL BRAKE LINE. NOW HAVE 2 OTHERS RUSTED THRU. CAR IS AT MECHANIC SHOP NOW MECHANIC IS REPLACING ALL BRAKE LINES BECAUSE HE WOULD NOT TOUCH IT OTHER WISE .HESAID I CAN EXPECT AT LEAST A $1200.00 DOLLAR BILL OR MORE. *TR

TL* THE CONTACT OWNS A 2000 CHEVROLET TAHOE. THE CONTACT STATED THAT WHILE DRIVING AT LOW SPEEDS, THE ABS ACTIVATED INDEPENDENTLY. THE DEALER STATED THAT THE VEHICLE HAD UNWANTED ABS ACTIVATION. THE DEALER CLEANED THE GROUNDS, CALIPERS, AND ROTORS, LUBED THE WHEEL SPEED SENSOR MOUNTS, AND CHECKED AND CLEANED THE HUBS. THE VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 05V379000 (SERVICE BRAKES, HYDRAULIC). THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 148,250. UPDATED 03/17/15*LJ

TL* THE CONTACT OWNS A 2000 CHEVROLET TAHOE. THE CONTACT STATED THAT WHILE DRIVING AT APPROXIMATELY 5 MPH, THE BRAKE PEDAL WAS DEPRESSED AND FAILED TO RESPOND. THE VEHICLE WAS TAKEN TO A PRIVATE MECHANIC WHERE IT WAS DIAGNOSED THAT THE FRONT AND THE REAR BRAKE LINES NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 120,000. THE VIN WAS UNAVAILABLE.

DRIVING TO GAS STATION PRIOR TO GOING ON VACATION, APPLIED BRAKES AND PEDDLE WENT TO THE FLOOR WITH NO WARNING LIGHTS ON TO INDICATE FAILURE OF THE BRAKE SYSTEM. I FOUND BRAKE TUBING FAILURE ON REAR DRIVERS SIDE. THE TUBING IS SO RUSTED THAT IT CAN NOT BE REPAIRED AND MUST BE REPLACED AT A DEALER THE COST IS AROUND $3000.00 FOR ALL NEW BRAKE TUBING, PROBABLY WHY GM HAS NOT FIXED THE PROBLEM IT'S A BIG MONEY MAKER. *TR

TL* THE CONTACT OWNS A 2000 CHEVROLET TAHOE. WHILE DRIVING 10 MPH, THE VEHICLE FAILED TO RESPOND WHEN THE BRAKE PEDAL WAS DEPRESSED. THE CONTACT CRASHED INTO A PARKED VEHICLE. A POLICE REPORT WAS FILED AND NO INJURIES WERE REPORTED. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 183,000.

TL* THE CONTACT OWNS A 2000 CHEVROLET TAHOE. WHILE DRIVING APPROXIMATELY 45 MPH, THE REAR BRAKES MALFUNCTIONED WHEN THE BRAKE PEDAL WAS DEPRESSED. THE FAILURE CAUSED THE STOPPING DISTANCE TO INCREASE. THE CONTACT DISCOVERED A PUNCTURE IN THE BRAKE LINE DUE TO THE BRAKE LINE MAKING CONTACT WITH THE FRAME OF THE VEHICLE. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED. THE FAILURE MILEAGE WAS 148,000.

IT WASN'T AN ACCIDENT, I WAS DRIVING MY TAHOE AND STOPPED AND GOT OUT WHEN I GOT BACK IN AND STARTED DRIVING I PUT MY FOOT ON BRAKE AND IT WENT TO THE FLOOR, AT THE TIME I DID NOT KNOW MY BRAKE LINE HAD BUSTED. IT WAS VERY SCARY FOR ME. NO WARNING LIGHT WENT ON TILL I WAS ALMOST HOME.. WE TOOK IT TO A SHOP TO HEAR THE BRAKE LINE HAD RUSTED THROUGH. I SENDING THIS COMPLAINT DO THE FACT I HEARD ON THE NEWS THAT THIS HAS BECOME A PROBLEM WITH THIS TAHOE. WE WERE PLANNING ON LEAVING THAT EVENING WITH OUR CAMPER. ITS A GOOD THING IT HAPPENED BEFORE WE LEFT OTHERWISE THERE COULD OF BEEN A SERIOUS ACCIDENT PULLING THE CAMPER AND NOT BEING ABLE TO STOP. PLEASE LOOK INTO THIS MATTER. *TR

AS I STOPPED MY TAHOE AT MY APARTMENT, MY FRONT BRAKE LINE BURST DUE TO CORROSION. I LOST ALL BRAKE POWER, AND BRAKE FLUID IS LEAKING OUT FROM THE BURST LINE. *TR

TL* THE CONTACT OWNS A 2000 CHEVROLET TAHOE. THE CONTACT STATED THAT UPON INSPECTION, IT WAS FOUND THAT THE BRAKE LINES WERE PERFORATED DUE TO RUST. THE VEHICLE WAS TAKEN TO THE DEALER WHERE THE FAILURE WAS CONFIRMED. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOT CONTACTED ABOUT THE FAILURE. THE FAILURE MILEAGE WAS 114,000. UPDATED 05/12/14*LJ THE CONSUMER STATED THE HARD STEEL BRAKE LINE TO THE REAR BRAKES COMPLETELY RUSTED THROUGH, CAUSING THE LINE TO BURST. UPDATED 05/15/14

DRIVING AT LOW SPEED AND TRIED TO STOP AT STOP SIGN BUT BRAKE LINE BURST AND VEHICLE WOULD NOT STOP AT ALL. AS A RESULT CAR WENT THRU STOP SIGN BUT LUCKY NO OTHER CAR WAS PRESENT. CAR EVENTUALLY ROLLED TO A STOP. MECHANIC SAID BRAKE LINE RUSTED THRU AND REPLACED IT AND SEVERAL OTHER LINES THAT HAD SEVER RUST GOING ON. *TR

I WAS DRIVING AT ROUGHLY 45 MPH ON A PUBLIC ROAD WHEN I WAS CUTOFF BY ANOTHER VEHICLE WHO ALSO NEARLY CAME TO A STOP. I QUICKLY BRAKE AND WHILE THE BRAKES DID MOMENTARILY WORK THE PEDAL THEN BECAME VERY SOFT AND FELL TO THE FLOORBOARD. THE OFFENDING VEHICLE THEN MADE ITS TURN OR I WOULD HAVE HIT THEM. I LIMPED THE VEHICLE HOME WHERE I FOUND A BUSTED BRAKE LINE DUE TO BAD RUST. THIS IS A VERY DANGEROUS SITUATION. *TR

THIS IS THE SECOND BRAKE INCIDENT I HAVE HAD WITH OUR TAHOE WITHIN THE PAST YEAR. IN OCTOBER 2012, I WAS DRIVING THE TAHOE TO AN AUTO SHOP FOR THE YEARLY INSPECTION. UPON ARRIVAL, ONE OF THE BRAKE LINES BLEW. AT THAT TIME, WE HAD ALL OF THE SOFT BRAKE LINES REPLACED DUE TO CORROSION. WE WERE LIVING IN THE NORTHEAST AT THAT TIME. THAT REPAIR WAS $800. ON JANUARY 6, 2014, I WENT TO DO SOME ERRANDS. AS I ARRIVED HOME AND PULLED INTO MY GARAGE, THE BRAKE PEDAL WENT TO THE FLOOR AND THE CAR MADE A HISSING SOUND FROM THE BACK. I TURNED THE CAR OFF AND THERE WAS FLUID LEAKING FROM BEHIND THE DRIVER'S REAR TIRE. UNBELIEVABLE! WE HAD THE TAHOE TOWED THE NEXT DAY TO AN AUTO SHOP AND WERE TOLD THAT THE "HARD" LINE IN THE BRAKING SYSTEM IS RUSTED AND CORRODED. WE WERE QUOTED BETWEEN $1500-2000. WE ALSO CALLED THE DEALER FOR AN ESTIMATE AND WERE QUOTED $3000+. THIS IS RIDICULOUS! I'VE HAD MORE THAN ONE MECHANIC TELL ME THAT THIS IS A KNOWN PROBLEM WITH THE TAHOES AND THE RUST. BOTH OF THESE INCIDENTS WE WERE VERY LUCKY NOT TO HAVE HAD AN ACCIDENT. WHY THEY ARE NOT DOING ON A RECALL ON THIS IS BEYOND ME. HOW MANY CARS DOES IT TAKE TO HAVE THIS FAILURE BEFORE THEY DO??? OR GOD FORBID, THEY ARE WAITING FOR A CERTAIN NUMBER OF INJURIES OR DEATHS BEFORE THAT SPARKS A RECALL. I AM TIRED OF SHELLING OUT MONEY FOR THIS MATTER OVER AND OVER. WE HAVEN'T DECIDED ON WHETHER IT'S WORTH REPAIRING BUT IF WE DECIDE TO BUY, IT WON'T BE CHEVY. THEY OBVIOUSLY DON'T CARE. *TR