2003 Chrysler PT Cruiser Powertrain & Transmission Problems

The clutch will not disengage every time and never fully disengages. I noticed my car had a recall for this problem in the past, so before doing the work, I called a dealer for Chrysler and was informed that the recall had already been performed. So I took it upon myself at my own expense to have the clutch replaced. It worked fine for a few months, but it started doing the same thing again.

TL* THE CONTACT OWNS A 2003 CHRYSLER PT CRUISER. THE CONTACT STATED THAT THE CLUTCH DID NOT DISENGAGE WHEN THE CLUTCH PEDAL WAS DEPRESSED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 03V076000 (POWER TRAIN). THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 160,000.

TL* THE CONTACT OWNS A 2003 CHRYSLER PT CRUISER. THE CONTACT STATED THAT WHILE ATTEMPTING TO START THE VEHICLE, IT INDEPENDENTLY ACCELERATED. THE CONTACT TOOK THE KEY OUT OF THE IGNITION AND THEN ATTEMPTED TO RESTART THE VEHICLE HOWEVER, THE VEHICLE FAILED TO SHIFT OUT INTO ANY GEAR. THE VEHICLE WAS TAKEN TO INDEPENDENT MECHANIC FOR DIAGNOSIS, WHO STATED THAT THE DUAL MASS FLY WHEEL WOULD NEED REPLACING. THE DEALER AND MANUFACTURER WEREALERTED OF THE FAILURE. THE VEHICLE WAS REPAIRED. THE FAILURE MILEAGE WAS 124,000.

TL* THE CONTACT OWNS A 2003 CHRYSLER PT CRUISER. THE VEHICLE WAS PREVIOUSLY INCLUDED IN NHTSA CAMPAIGN ID NUMBER: 03V076000 (POWER TRAIN:CLUTCH ASSEMBLY) AND WAS REPAIRED PRIOR TO THE CONTACT HAVING OWNERSHIP OF THE VEHICLE. WHILE DRIVING APPROXIMATELY 30 MPH, THE THE CONTACT WAS UNABLE TO SWITCH GEARS. THE CONTACT WAS DEPRESSING THE CLUTCH WHEN HE NOTICED THAT THE GEAR SHIFTER WAS FRACTURED. THE VEHICLE WAS TOWED TO THE DEALER FOR DIAGNOSTICS. THE TECHNICIAN STATED THE CLUTCH ASSEMBLY AND THE SHIFTER CABLE WOULD HAVE TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 67,000.

CAR IS MANUAL TRANS, MY WIFE DRIVES IT AND HAS COMPLAINED FOR QUITE A WHILE OF CAR JUMPING I TOLD HER IT WAS HER, THE CAR NEVER DID IT FOR ME DURING TEST DRIVES. IN JANUARY SWITCHED CARS WITH HER IT TOOK 2 WEEKS FOR IT TO HAPPEN. COMING TO A STOP CLUTCH WOULD NOT DISENGAGE. HAS ALSO TRIED TO ENGAGE ON ITS OWN AT LIGHTS. WENT TO DEALER THEY SAID NO RECALLS ARE OPEN ON CAR AND RECALL FOR SAME PROBLEM WAS ALREADY DONE SO YOU ARE ON YOUR OWN. SEEMS LIKE NEWER OF THE SAME PART WAS INSTALLED. CAR IS OFF THE ROAD AND I HAVE SAID MY SORRIES TO MY WIFE. PLEASE ADVISE. THANK YOU. *TR

WITH 59,000 FREEWAY MILES, AT 65 MPH VEHICLE DOWNSHIFTED ABRUPTLY AND UNEXPECTEDLY. VEHICLE WOULD ONLY LURCH ALONG AT A SLOW SPEED AND UNABLE TO GO INTO REVERSE. IT HAD TO BE TOWED. TRANSMISSION OVERHAUL REQUIRED COSTING OVER $2,000 TO REPAIR. *TR

I SAW A STORY ON ABC NEWS CONCERNING DECELERATION ON BMW VEHICLES AND I HAD A SIMILAR EXPERIENCE IN A CHRYSLER PT CRUISER. I WAS TRAVELING AT INTERSTATE SPEED AND EXPERIENCED A SUDDEN DECELERATION OF MY VEHICLE. IF SOMEONE WAS BEHIND ME I WOULD HAVE BEEN HIT. I HAD THE VEHICLE TOWED TO A CHRYSLER DEALERSHIP AND WAS TOLD IT WAS A SENSOR IN THE TRANSMISSION. *TR

03 PT CRUISER. SUDDEN LOSS HYDRAULIC PRESSURE AT SHIFTDOWN. WITHIN 7/70,000 POWERTRAIN WARRANTY. CHRYSLER REFUSES TO STAND BEHIND WARRANTY. THIS IS A KNOWN PROBLEM. *TR

I HAVE A 2003 PT CRUISER WITH 82000 MILES ON IT. IN MARCH OF 2005 WITH 47765 MILES ON IT, I TOOK THE VEHICLE TO A CHRYSLER DEALER TO REPAIR A VIBRATION WHILE BRAKING. THE CHRYSLER DEALER NOTED THERE WAS A GRINDING NOISE COMING FROM THE TRANSMISSION AND STATED THE COMPRESSOR WAS RUBBING AGAINST THE FRONT FRAME DUE TO SOME KIND OF COLLISION AND STATED THERE WAS A BROKEN MOTOR MOUNT. WE TOOK THE VEHICLE TO THE DEALER WHERE WE PURCHASED THE VEHICLE TO ADDRESS THIS DIAGNOSIS SINCE THIS WAS A NEW VEHICLE WHEN WE PURCHASED IT. THE DEALER CLAIMS THEY FOUND NO BROKEN MOTOR MOUNTS, NO SIGNS OF ACCIDENT AND DID NOT EVEN ADDRESS THE TRANSMISSION NOISE. ON 11/17/2006 I WAS TRAVELING ON A TWO LANE HIGHWAY WITH MY 3 YEAR OLD DAUGHTER AT NIGHT, AND WITHOUT WARNING,NOISE, HESITATION, OR LACK OF POWER, MY TRANSMISSION WENT OUT. I WAS NOT ABLE TO MOVE IN ANY GEAR. THE VEHICLE WAS TOWED TO THE DEALERSHIP WHERE I PURCHASED IT AND THEY TOLD ME IT HAS MAJOR TRANSMISSION DAMAGE AND THE TRANSMISSION NEEDS TO BE REPLACED. THE COST OF THE TRANSMISSION REPLACEMENT IS $2715.00 AND THE DEALER WILL NOT COVER ANY OF THE COST. *JB

DT*: THE CONTACT STATED WHEN THE CLUTCH WAS ENGAGED AT ANY SPEED, THE TRANSMISSION DID NOT SHIFT INTO GEAR EFFECTIVELY. THE VEHICLE WAS TAKEN TO A SERVICE DEALER, WHO WAS UNABLE TO DETERMINE THE PROBLEM. THE VEHICLE WAS SUBSEQUENTLY TAKEN TO A PRIVATE REPAIR SHOP, WHO DETERMINED THAT THE CLUTCH ASSEMBLY HAD COME APART. THERE WAS A NHTSA RECALL# 03V076000, WHICH PERTAINED TO THE CLUTCH ASSEMBLY. THE VEHICLE WAS NOT INCLUDED IN THE RECALL DUE TO THE VIN.

2003 CHRYSLER PT CRUISER VEHICLE WITH AN AUTOMATIC TRANSMISSION WITH 56,414 MILES ON IT BEGAN LURCHING WHEN ACCELERATING OR SLOWING DOWN ON INTERSTATE. PROBLEM STARTED WITH NO PRIOR WARNING OF TRANSMISSION PROBLEMS. VEHICLE LATER DIED IN THE MIDDLE OF A SIDE STREET. COULD NOT GET VEHICLE TO MOVE IN ANY GEAR, AND CHECK ENGINE LIGHT CAME ON AND STAYED ON. FINALLY GOT VEHICLE TO LIMP AROUND THE CORNER IN DRIVE, THEN VEHICLE DIED. NO TRANSMISSION FLUID FOUND IN RESERVOIR. FLUID NOTED ON GROUND UNDER VEHICLE. HAD TO TOW VEHICLE 30 MILES TO DEALERSHIP, WHO COULD NOT REPAIR IT AFTER THREE DAYS OF WAITING, DUE TO LACK OF TRANSMISSION SERVICE TECHNICIAN. VEHICLE WAS ULTIMATELY REPAIRED AT AAMCO TRANSMISSION, REQUIRING ANOTHER 20 MILE TOW. VEHICLE HAD TO HAVE TRANSMISSION REPLACED. TOTAL COST OF REPAIRS WAS $2222.73 BETWEEN CHRYSLER DEALERSHIP AND AAMCO TRANSMISSION - NOT COVERED UNDER WARRANTY WHICH RAN OUT AT 36000 MILES. *JB

DT*: THE CONTACT STATED WHILE DRIVING 55 MPH ON A HIGHWAY ON-RAMP, THE TRANSMISSION SEIZED UP STALLING THE VEHICLE. THE VEHICLE HAD TO BE TOWED TO A REPAIR FACILITY. ALSO, THE SEAT BELT BUCKLE CONSTANTLY FAILED TO REMAIN SECURE. THE VEHICLE WAS TOWED TO AN INDEPENDENT TRANSMISSION SHOP FOR SERVICE. THE MANUFACTURER WAS NOTIFIED, BUT THE SERVICE DEALER WAS NOT. UPDATED 10/25/2006 - THE TECH FOUND THAT THE TRANSMISSION GEARS HAD SLOWLY BEEN GRINDING AWAY, THROWING METAL SHAVINGS INTO THE CONVERTER AND THE PUMP. *NM

2003 PT CRUISER CLUTCH DOES NOT DISENGAGE. *TS THE CLUTCH WOULD NOT DISENGAGE AND AS A RESULT THE VEHICLE JUMP BACKWARDS ABOUT 6 FEET IN THE CONSUMER'S DRIVEWAY. THE FLYWHEEL AND CLUTCH ASSEMBLY WERE RECALLED, RECALL 03V076000. THE CONSUMER CONTINUE TO HAVE CLUTCH PROBLEM AFTER THE RECALL REPAIRS WERE MADE. THE VEHICLE HAS BEEN TAKE TO THREE DIFFERENT DEALERS ON FOUR DIFFERENT OCCASIONS. THE TRANSMISSION HAS BEEN PULLED OUT OF THE VEHICLE THREE TIMES. *NM

I HAVE A 2003 PT CRUISER WITH ABOUT 30,800 MILES ON IT. THIS CAR WHEN STOPPED IN GEAR AND YOUR FOOT ON THE BREAK SUDDENLY GOES INTO GEAR AND IT TAKES TWO FEET ON THE BREAK PAD TO HOLD IT. THIS ONLY LASTS ABOUT 3 SECONDS AND THEN STOPS. ON 03-28-06 I WAS DROPPING OFF MY DAUGHTER AND AS SHE WENT TO CROSS IN FRONT OF THIS CAR IT JUMPED INTO GEAR AND I ALMOST HIT MY DAUGHTER. I TOOK IT TO THE LOCAL DEALERSHIP AND TOLD THEM ABOUT THIS PROBLEM. THEY SAID THEY DID A ROAD TEST AND DRB TEST AND SHOWED NO CODES. THEY SAID WAIT UNTIL IT GETS MORE REGULAR AND BRING IT BACK IN. I DID EMAIL CHRYSLER CORP. ON THIS AND HAVE NOT HEARD BACK FROM THEM YET. I DON'T FEEL THIS CAR IS SAFE TO DRIVE UNTIL THIS GET FIXED. IT SEAMS THEY COULD REBUILD THE TRANSMISSION INSTEAD OF WAITING FOR ME TO RUN SOMEONE OVER. MY 3 YEAR/36,000 WILL BE UP SOMETIME THIS APRIL. I DON'T FEEL ITS FARE FOR ME TO WAIT TILL IT GETS WORSE AND THEN DIG ME $1500.00 TO REBUILD THE TRANSMISSION ESPECIAL AFTER IT HAS BEEN BROUGHT TO CHRYSLER ATTENTION DURING THE WARRANTY PERIOD. VERY FRUSTRATED RIGHT NOW WITH ALL THIS. *NM

MY 2003 CHRYSLER PT CRUISER, GT MODEL, HAS HAD PROBLEMS SINCE I HAVE HAD IT. FIRST, THE ENGINE LIGHT CAME ON AND THEY REPLACED A HOSE, THEN IT CAME ON AGAIN, AND THEY SAID THEY DIDN'T KNOW WHAT WAS WRONG WITH, AND THEY WOULD HAVE TO WAIT UNTIL IT WENT COMPLETELY OUT. IT DID, AT 28,000 MILES, IT WAS THE TURBO CHARGER. SECONDLY, THE AIRBAG MALFUNCTIONED, THEY HAD TO REPLACE THE SEAT, TOOK THREE TIMES TO GET THE RIGHT SEAT. THIRD, NOW, I WOULD PUT THE CAR IN DRIVE OR REVERSE, AND IT JUST SIT THERE, THEN JERKS INTO GEAR. SOMETIMES IF YOU GIVE IT GAS IT WOULD JUST REV UP. THEY SAID IT WAS THE PUMP IN THE TRANSMISSION, THEY TOOK 4 PLUS DAYS TO REPLACE IT. WHEN I PICKED IT UP I HEARD A NOISE AND SMELL SOMETHING BURNING. WHEN I TOOK IT OUT THERE THEY DIDN'T HEAR OR SMELL ANYTHING SO I WAS SENT ON MY WAY. THEN IT STARTED DOING THE SAME THING IT DID WHEN YOU PUT IT IN REVERSE OR DRIVE. I TOOK IT IN, HE SAID IT NEEDED A BATTERY. I PUT A DIEHARD BATTERY IN IT, BUT SEARS SAID THAT WAS NOT THE PROBLEM. THEN THE CHECK THE ENGINE LIGHT CAME ON, THEY SAID IT WAS THE EVAC PUMP. THEY FIXED THAT. THEY CLAIMED THAT WAS NOT COVERED UNDER THE WARRANTY I HAD WHEN I BROUGHT IT IN TWO WEEKS BEFORE. NOW, I HEAR A GRINDING WHEN I START THE CAR UP, SOMEONE SAID IT SOUNDS LIKE THE FLYWHEEL AND THEY DIDN'T ASSEMBLE THE TRANSMISSION CORRECTLY, AND THAT WAS PROBABLY WHERE THE BURNING SMELL WAS COMING FROM. I AM TAKING IT IN TO THE SHOP TODAY FOR THIS. *NM

THERE IS NO ONE SPECIFIC INCIDENT DATE. (SEE RELATED CORRESPONDENCE 10161568.) DATE UNKNOWN: REMEDY FOR RECALL 03V-076 PROVIDED BY GOEKE DODGE. NO TRANSMISSION PROBLEMS NOTICED PRIOR TO THIS DATE. 07/20/05: CLUTCH FAILED TO DISENGAGE DURING UNRELATED WARRANTY WORK AT GOEKE DODGE. RECALL REMEDY PROVIDED FOR THE SECOND TIME, AT NO COST TO OWNER. 05/01/06: CLUTCH INTERMITTENTLY FAILING TO DISENGAGE. CLUTCH FLUID FOUND LEAKING AT IMPROPERLY CONNECTED QUICK DISCONNECT BY KAHLO CHRYSLER, FLUID AND LABOR $91.98. 06/07/06: CLUTCH INTERMITTENTLY FAILING TO DISENGAGE. CLUTCH KIT AND INPUT SHAFT REPLACED UNDER EXTENDED PT WARRANTY BY CHAMPION CHRYSLER. DATE UNKNOWN: CLUTCH FAILING TO DISENGAGE. CLUTCH LINE SLAVE CYLINDER REPLACED BY CHAMPION CHRYSLER. *JB

AUTOMATIC TRANSMISSION WENT OUT AFTER 42,000 MILES, MOSTLY HIGHWAY MILES.

2003 PT CRUISER GT PURCHASED BRAND NEW APRIL 29, 2003. CLUTCH HAS FAILED 3 TIMES OVER 10 CONSECUTIVE MONTHS. MARCH 8, 2004 MILEAGE ? 19,842: DRIVING HOME AT NIGHT ENTERED ONTO THE 60 FWY EAST THE CLUTCH GOES OUT ON THE FREEWAY IN TRAFFIC! HAVE TRUCK TOWED TO JAMMIN DODGE CHRYSLER THAT NIGHT. THE CAR IS ALMOST 12 MONTHS OLD! MARCH 12, 2004 REMOVED AND REPLACED CLUTCH MODULE ASSEMBLY. CAR PICKED UP. DECEMBER 17, 2004 MILEAGE ? 35,930: THIS IS JUST 9 MONTHS AFTER THE CLUTCH WAS FIRST REPAIRED! CLUTCH GOES OUT. WHILE ATTEMPTING TO START THE CAR; IT LAUNCHED FORWARD BECAUSE IT WAS IN FIRST GEAR. IT MISSES THE CONCRETE WALKWAY TO MY OFFICE BUILDING BY LESS THAN A INCH. DECEMBER 21, 2004 STAR CHRYSLER REPAIRS CLUTCH JANUARY 22, 2005. MILEAGE ? 37,275: JUST ONE MONTH SINCE LAST REPAIR TO CLUTCH! I AM DRIVING TO BANK IN MORNING. I COME TO STOP AT THE END OF MY STREET AT THE STOP LIGHT. MY CAR CLUTCH IS MALFUNCTIONING. I STOP THE CAR. I TRY TURNING IT OFF AND THEN BACK ON. THE CAR LAUNCHES FORWARD HITTING THE BOTTOM OF THE TRUCK IN FRONT OF ME. THE MAN GETS OUT OF THE TRUCK. HE LOOKS AND THERE IS NOT DAMAGE TO HIS TRUCK. HE ASKS ME DID I SEE HIM? I TOLD HIM THAT MY CLUTCH WENT OUT AND HE CAME OVER AND SAW HOW THE CLUTCH JUST WENT TO THE FLOOR. HE SHRUGGED HIS SHOULDERS WISHED ME LUCK AND TOOK OFF. MY GRILL IN THE FRONT IS BULGING. MY LICENSE PLATE FRAME CRACKS. AND THE TOP OF MY BUMPER IS SCRATCHED. I CALL AAA. HAVE THE CAR TOWED TO JAMMIN DODGE IN POMONA. I REQUEST NO WORK TO BE DONE. I WILL CALL CHRYSLER CORPORATE MONDAY MORNING. I WILL NO LONGER DRIVE THIS VEHICLE AS IT IS NOT SAFE. *AK

CONSUMER'S VEHICLE EXPERIENCED THE SAME PROBLEM AS STATED IN NHTSA RECALL 03V076000: ON CERTAIN PASSENGER VEHICLES, MANUAL TRANSMISSION MODELS ONLY, A WELDED PIN INTERNAL TO THE DUAL-MASS FLYWHEEL (DMF) ASSEMBLY CAN UNSEAT AND BECOME LODGED BETWEEN THE FLYWHEEL AND THE CLUTCH DISC. THE DEALERSHIP INDICATED THIS VEHICLE WAS NOT PART OF THE RECALL DUE TO VIN. *AK *TC

CONSUMER HAS BEEN EXPERIENCING PROBLEMS WITH THE 2003 TURBO CHARGED CHRYSLER PT CRUISER. CLUTCH WHEN DEPRESSED TO START THE VEHICLE IT FEELS LIKE IT DOES NOT HAVE ANY PRESSURE AND DROPS TO THE FLOORBOARD. *TS THE MECHANIC REPLACED PORTIONS OF THE CLUTCH. *JB *NM