Chrysler · PT Cruiser · 2003
4
Recalls
257
Complaints
-
Not Rated
The 2003 Chrysler PT Cruiser has 4 recalls and 257 owner-reported complaints on file with NHTSA. Most reported issue: power train (26 reports).
Source: NHTSA Public Records · Updated Apr 28, 2026
The 2003 Chrysler PT Cruiser page works best as a research starting point. Complaint totals show how much owner-reported activity exists, while recalls and investigations help show whether any of that activity turned into formal safety action.
Because this is a newer-era vehicle page, it usually helps to compare this year against nearby model years before deciding whether a complaint pattern looks isolated or persistent. On this page, the most prominent complaint area is power train with 26 reported complaints.
This page combines three types of NHTSA data: recall campaigns (official manufacturer or government actions), owner complaints (unverified consumer reports), and crash test ratings (where available). A vehicle with many complaints is not necessarily less reliable — complaint volume correlates with sales volume and vehicle age. Recalls indicate identified defects, not overall quality. To compare this model year with others, use the year navigation in the sidebar or return to the model overview page.
If you are researching a used vehicle, start with the complaint categories, compare them against the recall list, and then check nearby model years to see whether the same issue profile repeats. That usually produces a better buying or research signal than treating the raw complaint total as a standalone safety ranking.
SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
Remedy Status
SABERSPORT WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON MAY 11, 2009. OWNERS MAY CONTACT SABERSPORT AT 1-909-598-7589.
FEDERAL MOGUL IS RECALLING 6,903 AFTERMARKET BALL JOINT ASSEMBLIES SHIPPED BETWEEN NOVEMBER 9, 2007 AND MARCH 26, 2008, WHICH MAY HAVE BEEN PACKAGED WITH INCORRECT NUTS. THE PART NUMBERS PACKAGED WITH INCORRECT NUTS ARE: K7147, K7329, K8683, AND 104353. THESE PARTS WERE MADE FOR USE ON THE VARIOUS VEHICLES LISTED ABOVE.
Remedy Status
FEDERAL MOGUL WILL NOTIFY OWNERS AND REPLACE THE PARTS FREE OF CHARGE. THE RECALL BEGAN ON MAY 22, 2008. OWNERS CAN CONTACT FEDERAL MOGUL AT 877-489-6659.
ON CERTAIN PASSENGER VEHICLES EQUIPPED WITH 2.4L NON-TURBOCHARGED ENGINES AND AUTOMATIC TRANSAXLES, THE POWER STEERING PRESSURE HOSE MAY CONTACT THE AUTOMATIC TRANSAXLE DIFFERENTIAL COVER, POTENTIALLY DAMAGING THE HOSE.
Remedy Status
DEALERS WILL INSPECT AND RELOCATE, OR REPLACE AS NECESSARY, THE POWER STEERING HOSE AND CONFIRM TORQUE OF THE HOSE FASTENER AT THE STEERING GEAR END. THE RECALL BEGAN ON SEPTEMBER 20, 2004. OWNERS SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
ON CERTAIN PASSENGER VEHICLES, MANUAL TRANSMISSION MODELS ONLY, A WELDED PIN INTERNAL TO THE DUAL-MASS FLYWHEEL (DMF) ASSEMBLY CAN UNSEAT AND BECOME LODGED BETWEEN THE FLYWHEEL AND THE CLUTCH DISC.
Remedy Status
DEALERS WILL REPLACE THE FLYWHEEL AND CLUTCH ASSEMBLIES WITH THE UPDATED DESIGN PARTS. OWNER NOTIFICATION BEGAN ON APRIL 14, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
Front seat belt doesn't engage after many attempts.
The clutch will not disengage every time and never fully disengages. I noticed my car had a recall for this problem in the past, so before doing the work, I called a dealer for Chrysler and was informed that the recall had already been performed. So I took it upon myself at my ow...
Preview excerpt
The contact owns a 2003 Chrysler equipped with Douglas, Tire line: Dug Xtra-Trac II, Tire size: 205/55R/16 91T and DOT number: N60FN11R. The contact stated that while driving at an undisclosed speed, the contact noticed that the vehicle started to perform slowly when the front pa...
Preview excerpt
WHen the fog lights are engaged, smoke and burning smell appears to be coming inside the steering wheel on the left side.
Was warming my car up and drove 2 miles to my mom's house and turned it off. Came out about 30 minutes later and the car was full of smoke. Aired out the car and noticed a burnt hole in the middle of the passenger seat. The seat warmer had malfunction and started the seat on fire...
Preview excerpt
I REPLACED MY VEHICLES BATTERY 2 DAYS AGO(NOV 12, 2019)(VERY OLD BATTERY AND WITH THE COLD IN MASSACHUSETTS IT NEEDED TO BE CHANGED). NOW WITH A PROPERLY FUNCTIONING BATTERY THE VOLTAGE REGULATOR IN PCM (NOT ALTERNATOR) IS SIGNALING ALTERNATOR TO RAISE CHARGING VOLTAGE INTERMITTE...
Preview excerpt
THERE WAS AN ELECTRICAL FIRE WHERE THE RADIO CUP HOLDERS AND THE SHIFTER. CAR IS UNDRIVEABLE DUE TO THE DAMAGE. MY CAR WAS STATIONARY AT THE TIME. THE RADIO KEPT TURN ON AND OFF. I HEARD CRACKING WHEN I WENT INTO WORK. WHEN I CAME OUT I SAY THERE WAS A WHOLE LOT OF DAMAGE. I D...
Preview excerpt
MY EXTERIOR FRONT LIGHTS ARE VERY DULL AND AREN'T BRIGHT WHEN TURN THEM ON.
I DON'T TRULY KNOW WHAT'S HAPPEN TO IT N IF IT'S BEEN FIXED BUT I DO KNOW THAT PRIOR IT WOULD HAVE UNCONTROLLABLE SPEED CONTROL N STEERING PROBLEMS N GPS N VIDEO N AUTO RECORDING N RADIO FREQUENCIES.
VEHICLE IS LEAKING POWER STEERING FLUID. FOUND RECALL NOTICE FOR MY YEAR MODEL BUT CHRYSLER SAYS MY VIN IS NOT INCLUDED IN THE RECALL. ADDED FLUID ABOUT 3 MONTHS AGO AND STEERING WAS FINE UNTIL A WEEK AGO. SINCE THEN, FLUID ONLY LASTS A DAY BEFORE IT HAS TO BE REFILLED.
Showing 10 recent complaints from 257 total
View Full Complaint LogThe strongest comparison flow is usually: exact vehicle-year page, then nearby years of the same model, then other 2003 Chrysler models. That sequence helps separate one-off year spikes from broader make-wide patterns.
The 2003 Chrysler PT Cruiser has 4 recalls recorded by NHTSA.
NHTSA has received 257 owner-reported complaints for the 2003 Chrysler PT Cruiser.
NHTSA has not published a safety rating for the 2003 Chrysler PT Cruiser.
The most commonly reported complaint categories for the 2003 Chrysler PT Cruiser are power train (26 reports), suspension (24 reports), electrical system (19 reports).
Yes. NHTSA has 4 recalls on record for the 2003 Chrysler PT Cruiser. Scroll up to review the published recall summaries, consequences, and remedies. To check for unrepaired recalls on your specific vehicle, use your VIN at nhtsa.gov/recalls.
Look up recalls and complaints for any year, make, and model.
This page summarizes publicly available data from the National Highway Traffic Safety Administration (NHTSA). Complaint counts reflect reports submitted to NHTSA by vehicle owners and do not by themselves prove defect severity or vehicle safety. Safety ratings may not be available for all vehicle-years. This site is not affiliated with NHTSA or any vehicle manufacturer. For official information, visit the official NHTSA page for this vehicle.