2006 Dodge Charger Fuel System Problems

when i refuel start out in highway car stalls almost results in getting rear ended i found dodge knew about this but i did not get recall i bought car new this just started bout 12 months ago car only has around 65000 miles on it .it happened today 3/20/24

When I fill my car with gasoline, it starts to putter and shuts off. I have replaced the fuel pump and fuel transfer unit over 4 times since I have owned this vehicle. I had the same issue with my Chrysler 300. It is very frustrating and cost full. I just dropped my car at the shop to be looked at again. I just had a fuel/transfer pump done less than a year ago

After filling up with gas my car stalled 3 times within 30 minutes. One time while making a turn and my power steering locked up almost making me crash, another time at a red light and also while idling in my driveway.

I FUEL MY CAR UP AND IT STALLS AND I CAN'T CONTROLL WHERE I AM GOING, THIS IS HAPPENING MORE AND MORE. ALMOST GOT HIT FROM BEHIND.

The fuel tank with this car have issues when filled up. This issue started about 3-4 years ago. The gas tank haven't been inspected but I've changed literally every component associated with the fueling system. I wish I would've done research before hand and would've just saved money and known that there are issues with the fuel tank. The car when filled up or sometimes just putting a little gas it will either sputter or shut off. No check engine light comes on or nothing. However after doing research I found out that my VIN isn't in the recall listing. This makes absolutely no sense for the investigation into a broader VIN listing to be closed with the amount of complaints these year model cars fuel tank.

After filling up with gas car shut off 1/2 mile causing loss of power steering. Restarted and did the same thing about 1/2 mile again

After filling up my gas tank I went to start driving again and my vehicle stalled out. It did this several more times.

When you fill the gas tank the vehicle cuts off and stalls in the middle of traffic and cannot restart. This has happened every time the tank was filled. Multiple times and every time

Every time I get gas, my Charger stalls at stops and while driving. Not good!!! I have had several close calls! I do not top off and I always use premium. Something has to be done this is not safe for anyone on the road.

Usually after I fill my car up with premium gas and start to drive it around it will stall out of nowhere especially when stopped or low idle.

The contact owns a 2006 Dodge Charger. The contact stated that on various occasions after refueling the vehicle over half tank, the vehicle would stall and then lose motive power while driving at slower speeds or while coming to a stop. No warning lights were illuminated. The contact stated that she was only able to restart the vehicle after refueling again. The vehicle was then taken to an independent mechanic to be diagnosed. The contact was informed that the passenger’s side fuel pump needed to be replaced. The vehicle was repaired; however, the failure recurred. The contact stated that she was unable to refuel the vehicle past half tank without the failure recurring. The local dealer was then made aware of the failure and confirmed that the VIN was not included in a recall. The manufacturer was made aware and also confirmed the VIN was not included in a recall and a case was opened. The approximate failure mileage was 190,000.

Car will shut off and or stall after filling up.

My 2006 Dodge Charger has approximately 51,000 miles on it. Last fall when I filled it up with gas and left the station to go home, my car stalled 5 times on a very busy road just trying to go home. It always restarted. It now does the same thing every time I fill it up with gas. It will either stall once I leave the station (sometimes multiple times) or jerk back and forth when trying to drive it. So far it has always restarted, but I am very concerned about my safety if it happens to stall when driving or turning at an intersection and there is an accident because of it. I understand that their is a lifetime warranty on this problem on these vehicles (Extended Warranty X53); and I would like to get this problem taken care of before I get in an accident. I have read up on this problem on Dodge Forums and will be calling Dodge in the next few days to see about having this problem taken care of. This is a definite SAFETY issue and needs to be handled ASAP.

Since owning this car everytime I fill up the gas (not over filling) or even going above 7/8 of a tank, my car stalls 3-10 times and chuggs while driving. I have already replaced the purge valve with no luck. After doing much research it has come to my attention that there has been a recall on cars just like mine. But when I look up my Vin it says no recall available. I am terrified to drive my car after putting gas in because I don't want to get into an accident.

Filled my gas up. Drove down road and it stalled in the dark on a busy road. Had my kids in car too.

The failing component is the same one that only "some" 2006 Dodge Chargers were covered. Even though my failed parts match the failed parts of the recall, I don't qualify because Chrysler didn't pick my VIN as one to replace. So after filling my vehilce with gas I went to turn and in the middle of the intersection my car shut off and all systems went down, meaning I lost power steering and the engine stalled. It would not restart. Four people nearly died, because we were almost hit by a gravel train truck. In the middle of the intersection, and could do nothing..If you win the Chrysler VIN lotterey, yours gets fixed and if you don't have that VIN, too bad for you. So I have a car that has the potential to kill many people because. of a known safety issue that Chrysler fixed on some cars but not all cars. NHTSA allows a huge safety problem as one that impacts the entire operation of the vehicle to still be on the road without the recall applying to it? One second difference and I and 3 occupants would have been dead. ONE SECOND. No warning lights, no codes, the problem has been seen by every dealer in the USA according to the technicians that looked at my car. They said it's sad that money means more to Chrysler than Safety. It first started happening just a few weeks ago, I only drive in the summer with this car, so it is low miles also. According to the recall the fuel tank and it's system fail. QUOTE from CHRYSLER " a condition where the fuel shut-off float, in the multifunction control valve sticks, which may result in the vehicle stalling after fueling." According to the dealer, my part numbers match the recall, just not my VIN.

AFTER FILLING THE GAS TANK I CAN DRIVE A FEW BLOCKS AND I'D SPUTTERS AND DIES THE FUEL PUMPS ARE FAIRLY NEW. IT STARTS BACK UP AND IT SPUTTERS. IT HAPPENS EVERY TIME WE FILL THE TANK.IT HAS BEEN ONGOING SINCE WE BOUGHT THE CAR

CAR CONTINUES TO STALL AT LOW SPEED, STOP SIGN, LIGHT, ETC. IM VERY CAUTIOUS WHEN I TURN ONTO TRAFFIC FOR FEAR OF CAR STALLING AND ME GETTING HIT. HAD IT TO NUMEROUS MECHANICS AND NO ONE CAN PIN POINT IT. USUALLY STALLS OUT 5-10 TIMES ON WAY TO AND FROM WORK EVERYDAY. I LIVE ABOUT 4 MILES FROM MY JOB.

CAR SHUT OFF AFTER FILL UP

I FILLED MY GAS TANK UP AND WHEN I DID AS I WAS DRIVING AT AROUND 15-20MPH MY CAR STALLED ON ME AND LATER ON IT SHUT OFF AS I WAS COMING TO A STOP THIS HAPPENS EVERY TIME I FILL MY GAS TANK UP.