2015 Fiat 500 Complaint Log

The contact owns a 2015 Fiat 500. The contact stated that while driving at 35 MPH and attempting to downshift, the vehicle failed to respond as intended while the RPM continued to rev. There was no warning light illuminated. The contact stated that the gear shifter was significantly difficult to move up or down, causing difficulty in engaging the brake as needed. The vehicle was taken to an independent mechanic, where it was diagnosed that the manual transmission gear pin had failed and needed to be replaced. The vehicle was not repaired. The dealer was contacted and confirmed that the VIN was not included in NHTSA Campaign Numbers: 16V302000(Power Train) nor 19E044000 (Power Train). The manufacturer was not notified of the failure. The failure mileage was approximately 42,000.

The contact owns a 2015 Fiat 500. The contact stated that while driving at an undisclosed speed, the manual transmission was unable to shift into gear. The contact was able to pull over to the shoulder of the roadway, where the failure persisted. No warning lights were illuminated. The vehicle was towed to an independent mechanic. The contact was informed that the clutch diaphragm spring and clutch assembly needed to be replaced. The vehicle was not repaired. After investigating the failure, the contact related the failure to NHTSA Campaign Number: 16V302000 (Power Train); but the VIN was not included. The manufacturer was notified of the failure, a case was opened, and the contact was referred to the NHTSA Hotline for assistance. The failure mileage was 54,000.

The contact owns a 2015 Fiat 500 Pop Hatchback. The contact received notification NHTSA Campaign Number: 16V302000 (Power Train) however, the parts to repair were not available. The contact stated that the manufacturer exceeded a reasonable amount of time for the recall repairs. The local dealer was notified of the recall notice and confirmed that the parts were not available. The contact stated while driving 30 MPH, the manual clutch failed and the contact was unable to steer the vehicle. The manufacturer was notified of the failure and the contact was provided with a customer care case number 89214492. The failure mileage was approximately 48,000.

In March 2023 my wife was driving our Fiat 500 on the freeway and the sunroof exploded with a loud bang. Small pieces of glass shattered everywhere and fell all over here. The sound and glass caused her to swerve, luckily no other cars were around. We got insurance involved and sent the car to a body shop to get fixed. No one really knew what caused the problem, though they all suspected a pebble. There was no other evidence to suggest a pebble. In August 2023 when entering the freeway (speed was less than 45 mph) the sunroof exploded again with a loud bang. My wife and I were both in the car. Once again we got insurance involved and the car was sent to a different body shop. The body shop did not find and evidence that a rock or pebble did the damage and were not sure how it could have been caused. This is our family car and we need to drive it daily. It puts everyone’s safety at risk when driving since the shock of falling glass and the sound of the sunroof exploding can cause knee jerk reactions. Therefore, not only is our safety at risk but also the other drivers were we to swerve unintentionally into someone. This happened twice in a span of 6 months.

A recall has been open on this vehicle for over 5 years. I have been waiting for a year and 2 Fiat dealerships cannot complete the recall because the manufacturer has failed to manufacture a spring part for the repair. The spring has been back ordered since May 2023 for my order, but according to the Madison dealership, owners before me were waiting for 8+ months with no parts available. Recall info: Manufacturer Recall NumberS34 NHTSA Recall Number16V-302 Recall Status: Recall Incomplete Summary THE CLUTCH COVER DIAPHRAGM SPRING MAY FATIGUE AND/OR FRACTURE. Safety Risk A FAILED CLUTCH COVER DIAPHRAGM SPRING MAY RESULT IN THE INABILITY TO DISENGAGE THE CLUTCH, SHIFT GEARS AND THE POTENTIAL FOR A LOSS OF MOTIVE POWER WHICH COULD CAUSE A CRASH WITHOUT WARNING.

The contact owns a 2015 Fiat 500. The contact stated that upon having the vehicle inspected, the mechanic noticed that the front driver’s and passenger’s side headlamps had failed to operate. The brake warning light and the headlamp warning lights were illuminated. The contact stated that the mechanic reconnected the front driver’s and passenger’s side headlamp connector. The vehicle was repaired; however, the failure recurred. The contact stated that after the vehicle was started, the contact noticed that the headlamps failed to illuminate. The contact then stated that the rear driver’s and passenger’s side brake lights failed to operate as needed. The vehicle was taken back the independent mechanic where it was diagnosed that the lighting wirings had burned out and the connectors needed to be replaced. The vehicle was not repaired. The dealer was notified of the failure. The vehicle was not repaired. The manufacturer was notified of the failure and the contact was advised to call the NHTSA Hotline. The failure mileage was approximately 52,000.

The contact owns a 2015 Fiat 500. The contact stated that after driving at low speeds, upon parking the vehicle, the brake pedal was depressed, but the vehicle was slow to respond while stopping. There were no warning lights illuminated. The vehicle was taken to the local dealer where it was diagnosed and determined that the clutch needed to be replaced. The vehicle was repaired but the failure recurred. The vehicle was towed to the local dealer again to be diagnosed. The contact was informed that the clutch and clutch cord needed to be replaced. The dealer informed the contact that the failure was due to her driving style. On another occasion while driving at an undisclosed speed, the failure recurred. The manufacturer was not contacted. The failure mileage was approximately 48,204.

After bringing vehicle to a complete stop at a traffic light, it died and gave a propulsion system warning. After about 20 attempts to turn off and reboot the vehicle, it restarted and behaved as if nothing had happened. This was a very dangerous situation with the vehicle stuck in the middle of the road. There have been two recalls on this very specific issue (and this vehicle has had that related software updates). Vehicle did the exact same behavior for no reason. (NHTSA campaign: 16V303000 & 15V179000). And because the vehicle wasn't sold in Georgia, no local dealers know how to work on it.

Driver side seat belt has worn prematurely, no longer retractable or locking in place. Seat belt is often wet during rainy weather, the vehicle is only 6yrs old to already have a safety belt malfunction. It is unknown to me why the seat belt has malfunctioned.

I was driving our Fiat 500e (31K miles) in late June, when suddenly the HV Battery System (and primarily the PIM/Power Inverter Module that controls the HV battery system and propulsion system) failed, causing my moving vehicle to lose it's ability to use power steering. I was on a steep hill and was barely able to control the car. I contacted my local Fiat dealer, had the car towed there, and it has sat there for 3.5 months, while the dealership and Fiat USA have argued over how to repair it. In the meantime, the 8 year warranty on the HV battery system has winnowed down and will go out of warranty this month. It is my belief that Fiat USA has purposely delayed a resolution so they could not have to pay to repair the car under warranty. The PIM controls the HV system and propulsion and yet Fiat claims that the PIM is not their responsibility to repair. This is an otherwise perfect car with only 31K miles and the idea that it would be junked and sent to landfill over a bad PIM controller (a small component the size of a football) is a tragedy. Via online messaging boards, I have spoken to numerous other owners of Fiat 500e autos who have suffered a similar PIM failure and whom Fiat also refused to help. Fiat should stand behind the cars they sold to us and should pay to repair the PIM controller so the car runs. Barring that, they should pay the market value of the car. I have specific engine error codes and reports that I would be happy to provide. Thank you in advance for your help.

Bought the vehicle used and it had zero issues. I bought 4 new tires and immediately after the RBS and ESC warning lights appeared but disappeared one day later. Fives days after the new tires the RBS & ESC warning lights reappeared but remained. I took it to the FIAT Dealership for a diagnostic and they stated that after following the flow chart it states to replace ABS Module due to internal failure. I held off on replacing the ABS module because a separate mechanic stated that it’s common with Fiats for the RBS & ECA warnings to appear after changing all tires. One month later the BRAKE warning light turned on (without the emergency brake in use) and the car began to jerk when in drive or when using the brakes (as I was driving). I had to drive slow with little pressure on the gas so that I would not have to use the brakes as every time I did the car would jerk very roughly and felt as if it was going to break.

FIAT 500E VEHICLE BRAKING BEHAVIOR IS UNEXPECTEDLY HARD, SUDDEN, OR UNPREDICTABLE UNTIL THE USER USES AN OBD SCAN TOOL WITH APPROPRIATE DIAGNOSTIC SOFTWARE- AND INITIATES BRAKE CONTROLLER SENSOR RE-CALIBRATION. THIS OPTION IS FOUND UNDER THE DIAGNOSTIC MENU UNDER: ABS>RENENERATIVE BRAKE CONTROLLER>ACTIVE DIAGNOSTICS, AND THEN SELECTING THE PROCEDURE TO START (RBC SENSOR CALIBRATION). ONLINE FORUM USERS (PLEASE SEE LINK BELOW) ARE CURRENTLY USING 3RD PARTY SOFTWARE, AT THEIR OWN EXPENSE, TO CORRECT THE BRAKING DEFICIENCY (APPROXIMATELY $49). MY PERSONAL VEHICLE WAS PURCHASED USED AND WAS EXHIBITING SUDDEN AND UNEXPECTED BRAKING ISSUES AT APPROXIMATELY 8,500 MILES; THIS IS IN MY OPINION A VERY LOW NUMBER OF MILES TO BE EXPERIENCING REGENERATE BRAKING AND CONTROL ISSUES. PLEASE REFERENCE THE ONGOING DISCUSSION THREAD AT FIAT 500E ONLINE FORUMS: HTTPS://WWW.FIAT500OWNERS.COM/THREADS/FIX-GRABBY-BRAKES-FOR-70.149282/#POST-1292483

Our FIAT was rear-ended on October 20. My wife suffered multiple critical injuries. The accident occurred in Manatee County Florida. I have the accident report, a picture of the vehicle, and a reported recall of the vehicle for a seat problem that took place in Australia. There has been no recall in the U.S. I will upload the relevant documents. The company reports the front seat’s guide tracks may not comply to safety standards do to a manufacturing fault. If the guide tracks are faulty, the seat could suddenly shift backwards or forwards during a crash, which poses an increased risk of injury.

Rear end car crash. Seat back collapsed and threw me into back seat where I sufferred brain injury.

What component or system failed or malfunctioned, and is it available for inspection upon request: High voltage battery system, the vehicle is available for viewing. How was your safety or the safety of others put at risk?: Long time garage storage of vehicle and limited owners manual description on procedure to maintain high voltage battery during extended non use of vehicle. Has the problem been reproduced or confirmed by a dealer or independent service center?: The problem has been reproduced and the vehicle is currently at a Fiat/Chrysler dealership. Has the vehicle or component been inspected by the manufacturer, police, insurance representatives or others?: The component is currently under inspection, the vehicle has been at the Fiat/Chrysler since 8/11/2021, it is now 9/18/2021. Were there any warning lamps, messages or other symptoms of the problem prior to the failure, and when did they first appear?: Error message display on cluster stating HV battery unable to be charged. General Description: Fiat 500e parked in closed garage for a year after following Fiat's Vehicle Storage instructions instruction shown pages 321 & 322 of the owners manual for the Fiat's electrical system. Returned after one year found Fiat's electric system a car went in fail mode. The instructions are limited and do not long term issues of fire danger in a enclosed space like a garage and power outages or brown outs. Fiat will not honor the vehicles warranty as the milage is a 42,625 and the warranty is only good up to 40,000 miles. The California Lemon Law does not cover this as well as it's as well. I need help!

I am a retired master certified automotive technician. Ever since I bought this 2015 Fiat 500e [it is battery electric] in 2017 with NO warning all kinds of trouble/service lights will go on as the car shuts down & stops as if it was thrown into Park, & most of the time it does this it is at highway speeds on crowded L.A. freeways, which has become very close to getting me killed several times I have taken it to local dealers for this problem since shortly after I bought it in 2017, long before the bumper to bumper warranty expired. Most of the time the dealer reads/clears the codes, then parks it in a back lot for days, weeks, & months, then after a while tells me it's done & I can pick it up, but normally within 100 miles the exact same thing happens so I have to take it back to the dealer. Most recently it did not even make it off the dealers lot before it did it. The latest dealer I have been taking it to for this problems, [5 times in a few months] clearly doesn't know the car or what they are doing & is now brazenly lying on repair orders. They have also been claiming it had no problems or trouble codes when I brought it in, after the service writer read & printed out dozens of codes, which they promised to give me a copy of but then refused to give to me. Because this is the exact same problem covered by previous recalls on this car I believe dealers have charged for services & doing recalls that they did not do, because I marked the parts & see NO indication they changed the parts required or did the procedures required to perform the services claimed. This car has had the exact same dangerous problems covered by the recalls since I bought it & I must now pay dealers to service it even though the propulsion system is under warranty. At this point I believe this is brazen dangerous widespread fraud with the factories participation

the problem is: I can not charging, light indicator is red plug , charger indicate (charging) I can not shift gear to D or R , just accept shift to P and N message warning : 1-service electric vehicle system , (yellow car) indicator lamp 2-service charging system (red plug) 3-service propulsion system

Fiat made their 500e vehicles (electric) and sold them off as a tax relief. Unfortunately, many who have purchased this vehicles are experiencing similar issues. The car dies and the main battery is dead (not the small battery that you can replace/charge - the big one). Upon calling Fiat, they said it was covered under warranty - BUT- there is one part that is crucial to the install and the part costs $7,000. Our car is not worth 7k. We bought it for 10k four years ago and it has depreciated value. When we appealed with Fiat - they would not budge. We filed a claim for loss damages and it goes denied - twice. This is a known problem - many insurance companies and mechanics do not know how to process electric vehicles.

2 Recalls R20 and S26

BEGAN LOSING CLUTCH, CLUTCH/BRAKE ASSEMBLY HAD THE 2 CONNECTING BOLTS BROKEN IN HALF. HAVE PICTURES. CLUTCH INTERLOCK ARRIVED BAD, BYPASSED IT; NOW THE POWER STEERING, ENGINE LIGHT AND EOS LIGHTS STAY ON. CAR ENGINE DIED THEN CRANKED UP ON ITS OWN WHILE DRIVING 60MPH STATING HIGH TEMP (PULL OVER, TURN ENGINE OFF) - HAD BEEN IN THE CAR LESS THAN 1 MINUTE, JUST LONG ENOUGH TO GET TO 60 ON THE HIGHWAY. NOW CLUTCH INTERLOCK, AND BRAKE INTERLOCK MUST BE REPLACED.

The quality of the exterior door handle is an issue. My passenger side door handle has snapped completely off and my drivers side door handle has partially broken, but still functions. The rear door hatch also stopped working. The arm rests both broke rather easily as well. My last car was a 2013 fiat 500 pop and the exterior door handles both broke, the rear latch stopped working, and both arm rests broke. I live in Iowa and it gets extremely cold, but I'm unsure if that's related. I have not been aggressive with any of these parts so I don't know what the issue is.

WHILE USING CRUISE CONTROL AND RESUMING OR INCREASING THE SPEED TO A HIGHER SPEED, THE TRANSMISSION SLAMS INTO GEAR INSTEAD OF TRANSITIONING.

MY VEHICLE HAS 37,000 MILES WHEN DRIVING ON THE FREEWAY VEHICLE GOT STUCK IN GEAR CAUSING A SAFETY CONCERN, LUCKILY I WAS ABLE TO MAKE IT HOME SAFELY WITH THE VEHICLE STUCK IN GEAR. THERE IS A RECALL ON MY VEHICLE THAT SAYS VEHICLE MAY GET STUCK IN GEAR, I WAS NEVER NOTIFIED OF THE RECALL BY FIAT, TOOK VEHICLE TO FIAT DEALERSHIP AND WAS TOLD IT HAS AN INTERNAL GEAR FAILURE INSIDE THE TRANSMISSION THAT IS NOT ASSOCIATED WITH THE RECALL AND THEY WILL NOT REPAIR IT EVEN THOUGH IN THE RECALL IT STATES VEHICLE CAN BECOME STUCK IN GEAR, FAILURE TO TAKE CARE OF THE RECALL CAN CAUSE TRANSMISSION FAILURE AND THE DEALERSHIP IS AWARE OF THIS HOWEVER THEY WILL NOT REPAIR THE VEHICLE THAT STILL RUNS BUT IS STUCK IN GEAR.

I WORK AT AN INDEPENDENT AUTO REPAIR FACILITY. WE HAVE SEEN SEVERAL HEADLIGHT BULB CONNECTOR FAILURES WHERE THE CONNECTOR MELTS. WHEN THE CONNECTOR MELTS, THE LIGHT STOPS FUNCTIONING. THE REPAIR REQUIRES REPLACEMENT OF THE CONNECTOR AND THE BULB.

TL* THE CONTACT OWNS A 2015 FIAT 500. THE CONTACT STATED THAT WHILE DRIVING AT AN UNKNOWN SPEED, THE FRONT DRIVER'S SIDE WINDOW DETACHED AND FELL INSIDE OF THE DOOR PANEL. THE VEHICLE WAS TAKEN TO FIAT OF SCOTTSDALE LOCATED AT 16301 N. 78TH ST, SCOTTSDALE, AZ 85260, TO BE DIAGNOSED. THE CONTACT WAS INFORMED THAT THE WINDOW REGULATOR FAILED AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 44,000.

TL* THE CONTACT OWNS A 2015 FIAT 500. THE CONTACT STATED THAT WHILE DRIVING AT VARIOUS SPEEDS, THE VEHICLE STALLED WITHOUT WARNING. THE VEHICLE WAS TAKEN TO BROWNS FIAT LOCATED AT 483 NEW YORK-112, EAST PATCHOGUE, NY 11772, TO BE DIAGNOSED. THE CONTACT WAS INFORMED THAT THE BATTERY WAS DEFECTIVE AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE CONTACT WAS INFORMED THAT THE VIN WAS NOT INCLUDED IN THE NHTSA CAMPAIGN NUMBER 16V303000 (ELECTRICAL SYSTEM). THE FAILURE MILEAGE WAS 39,483.

ON 2/5/2020, I LEFT MY HOME TO GO TO WORK. IT WAS A COLD MORNING IN SOUTHERN CALIFORNIA AND WHEN I GOT IN THE CAR AND TURNED IT ON A YELLOW SNOWFLAKE/ROAD APPEARED. IN THE 5 YEARS THAT I HAVE HAD THIS CAR, I HAVE NEVER SEEN THIS IMAGE APPEAR ON THE DASHBORD. I STARTED TO DRIVE THE CAR AND CALLED FIAT CHRYSLER TO INQUIRE ABOUT THE WARNING LIGHT. I SPOKE WITH A REPRESENTATIVE NAMED ASHLEY IN THE CALL CENTER. I TOLD ASHLEYT ABOUT THE WARNING AND SHE PLACED ME ON HOLD TO RESEARCH IT. SHE CAME BACK ON THE LINE AND THE WARNING MEANT I NEEDED TO PUT SNOW TIRES ON MY CAR BECAUSE OF THE WEATHER. I TOLD HER IN SOUTHERN CALIFORNIA WHERE I LIVE WE DON'T NEED SNOW TIRES BECAUSE IT DOES NOT SNOW. SHE THEN TOLD ME MY TIRES WERE COLD ALONG WITH THE OUTSIDE OF THE CAR AND UNDERCARRIAGE THEREFORE THE CAR WAS NOT SAFE TO DRIVE. I TOLD HER THE TIRES WERE LESS THAN A YEAR OLD AND NOTHING WAS WRONG WITH THEM. SHE THEN SAID IT WAS A SAFETY ISSUE. I SAID OK AND END THE CALL. AFTER THINKING FOR A BIT IT WAS UNSETTLING THAT I WAS DRIVING A CAR THAT WAS UNSAFE AS A FIAT REP INFORMED ME OF THIS SO I CALLED BACK TO START A BUY BACK WITH FIAT. I THEN SPOKE TO ANOTHER WHO INFORMED ME ASHLEY WAS NOT A MECHANIC AND SHOULD NOT HAVE TOLD ME THIS. I COULD NOT GET HER TO ACKNOWLEDGE IF THE CAR WAS SAFE TO DRIVE SO I ASKED HER TO HAVE A SUPERVISOR REVIEW THE CALL AND CALL ME BACK. I RECEIVED A CALL FROM MELISSA THE SUPERVISOR WHO ADVISED SHE REVIEWED THE CALL ASHLEY DID IN FACT TELL ME THIS BUT SHOUDL NOT HAVE THEREFORE IT'S A COACHING OPPORTUNITY FOR HER. I ASKED MELISSA TO SEND ME A LETTER CONFIRMING THE SAFETY OF THE CAR AND SHE WOULD NOT. I THEN INFORMED HER I WOULD CONTACT THE CALIFORNIA DEPT. OF CONSUMER AFFAIRS. THE SENSOR EVENTUALLY WENT AWAY ONCE THE CAR WARMED UP.

TL* THE CONTACT OWNS A 2015 FIAT 500E. WHILE DRIVING AT 55 MPH, THE VEHICLE LOST MOTIVE POWER WITHOUT WARNING. THE VEHICLE WAS TOWED TO RENTON CHRYSLER DODGE JEEP RAM LOCATED AT 585 RAINIER AVE S, RENTON, WA 98057, (425) 430-1000 TO BE DIAGNOSED. THE CONTACT WAS INFORMED THAT THERE WAS A LOSS OF POWER IN THE POWER INVERTER WHICH CAUSED THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE VEHICLE WAS TOWED BACK TO THE RESIDENCE. THE VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 16V303000 (ELECTRICAL SYSTEM). THE MANUFACTURER WAS CONTACTED AND INFORMED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 23,000.

I STOPPED IN A DRIVEWAY AND TRIED TO SHIFT INTO REVERSE. THE CAR HAS A MANUAL 5 SPEED TRANSMISSION. THE CAR WOULD NOT SHIFT INTO REVERSE. THE ONLY 2 GEARS AVAILABLE WERE 3RD, NEUTRAL, AND 4TH. INVESTIGATION FOUND THAT ONE OF THE 2 SHIFT CABLES CAME OFF THE SHIFT LEVER ON THE TRANSMISSION. THIS HAPPENED IN A DRIVEWAY, BUT COULD HAVE HAPPENED IN TRAFFIC, RESULTING IN NOT BEING ABLE TO MOVE THE VEHICLE.

2015 FIAT 500. DRIVER SIDE WINDOW FAILED DUE TO BROKEN LIFT PLATE AT 37,561 MILES. NOW THE PASSENGER SIDE FAILS AT 40,001 MILES. DEALER CLAIMS NOT UNDER WARRANTY, NO TSB, 'SILENT WARRANTY' AND SAYS THE WINDOWS TYPICALLY FAIL ON A 4 TO 5 YEAR OLD CAR.

WE HAVE RAN INTO TWO ISSUES WITH THE CAR. THE FIRST ISSUE WAS LAST YEAR THERE WAS AN ISSUE WITH THE COMPUTER INSIDE NOT WORKING WHICH IN TURN CAUSE ISSUES WITH THE BLUETOOTH, LIGHTING, AND DASHBOARD. THE MECHANIC SAID IT COULD IN TURN RESULT IN OTHER ISSUES AS WELL. WE RECENTLY STARTED THE CAR AND IT STARTED SHAKING, THE DASHBOARD WENT OUT, THE CHECK ENGINE LIGHT CAME ON, AND THEN THE POWER STEERING WENT OUT.

A FEW DAYS AFTER NORMANDIN CHRYSLER DID A RECALL CLUTCH REPAIR, THE PASSENGER SIDE CONTROL ARM CAME LOOSE AT THE WHEEL CAUSING VEHICLE TO BE UNCONTROLLABLE AND RIGHT TIRE TO JAM INTO WHEEL WELL. I HAD JUST TURNED LEFT ONTO A ROAD FROM A DRIVEWAY. I HEARD A GRINDING SOUND AND PULLED THE CAR OVER. CV FLUIDS ON ROAD. AXEL DISCONNECTED AT BOTH ENDS.

2015 FIAT 500. CONSUMER WRITES IN REGARDS TO CRACKED AND DRY ROTTED TIRES ON VEHICLE. *LD THE CONSUMER STATED THE DEALERSHIP KNOWINGLY SOLD A VEHICLE WITH POORLY WORN TIRES. *JS

2015 FIAT 500 ABARTH. CONSUMER WRITES IN REGARD TO TIRE SAFETY ISSUES. CONSUMER STATES TIRES PRE-DATE MANUFACTURE DATE OF VEHICLE WITH VEHICLE BEING SOLD WITH TIRES IN THIS CONDITION (SEVERE CRACKING, DRY ROT). *AS *JS

THE SHIFT CABLE FOR THE TRANSMISSION BROKE LEAVING ME UNABLE TO ACCELERATE WHILE IN MOVING TRAFFIC ON A 4 LANE STATE HIGHWAY. THE PART IS ON BACK ORDER AND I HAVE NOT HAD USE OF MY CAR FOR OVER A WEEK AND POSSIBLY UP TO A MONTH.

I WAS DRIVING ON A 4 LANE PARKWAY, WITH MY CHILDREN, AND THE CAR SUDDENLY WOULDN'T GO INTO ANY GEAR. UPON INSPECTION, THE CLUTCH WILL NEED TO BE REPLACED. THE CAR ONLY HAS 70,000 MILES ON IT AND HAS HAD ROUTINE MAINTENANCE.

THE RECALL WAS STOPPED AT 74 000 MILES AND NOW I NEED TO BUY A NEW CARE I HAVE AN OIL LEAK ON THE DRIVERS SIDE OF\ENGINE BY THE CAM SEAL, ACTUATOR

WHENEVER I TURN THE HEADLIGHTS ON, THEY GO OFF. WHENEVER I TURN THE HEADLIGHTS OFF, THEY GO ON. BECAUSE OF THIS, THE BREAK LIGHTS DON'T WORK. WHEN DRIVING AT NIGHT I HAVE TO CHOOSE BETWEEN BREAK LIGHTS OR HEADLIGHTS. FIAT WANTS OVER $1000 TO FIX ONE MONTH AFTER WARRANTY.

WHILE DRIVING TO WORK THE MANUAL TRANSMISSION WOULD ONLY GO INTO 3RD AND 4TH GEAR. NO WARNING LIGHT, NO PROBLEM LIGHT, NOTHING. JUST STOPPED AT THE ATOP SIGN AND WILL NOT GO INTO ANY GEAR OTHER THAN 3RD AND 4TH GEAR. THE CAR ONLY HAS 50,650 MILES.

The contact owns a 2015 Fiat 500. The contact stated that the interior door handles on the driver’s and passenger’s side front doors fractured making it difficult to open the door from the inside or outside of the vehicle. The local dealer was notified of the failure. The manufacturer was not yet contacted. The VIN was not available. The failure mileage was 55,000. Consumer stated handles break too often causing allot of inconvenience and expense. Appointment to get both handles on the car fixed again for Jan 3, 2022.

WHILE DRIVING, ONE OF THE SHIFT CONTROL CABLES CAME DETACHED FROM THE TRANSMISSION. (MANUAL TRANSMISSION) THIS LEFT ME WITH ONLY 3RD AND 4TH GEAR.

RADIO AND OTHER ELECTRONICS WENT BLANK, WE CAME TO LOCAL DEALER TO FIX IT. THEY CHANGED IT AND IT STILL NOT WORKING,VERY WENT BACK THEY CHANGED IT AGAIN, STILL NOT WORKING, MADE 3 RD APPOINTMENT TO FIVE IT, LOOSING A FAITH THAT THEY EVER WILL FIX IT RIGHT.

I WAS DRIVING A TOTAL OF 4 AND A HALF HOURS BACK HOME FROM A TRIP. MOST OF THE TRIP WAS VIA STRAIGHT FREEWAY. I WAS 2 HOURS IN WHEN THE CHECK ENGINE LIGHT STARTED BLINKING. I CALLED MY DAD WHO SAID TO PULL OVER IMMEDIATELY. I LET MY CAR GLIDE THROUGH THE EXIT THAT WAS COMING UP AND I NOTICED SMOKE FLOWING BEHIND MY CAR. I PULLED OVER AND GOT OUT TO SEE SMOKE COMING OUT OF THE HOOD. I OPENED THE HOOD AND DISCUSSED WHAT WAS HAPPENING WITH MY DAD. ALL OF A SUDDEN I HEARD A NOISE THAT SOUNDED LIKE A BLOW TORCH AND FLAMES CAME UP OUT OF THE ENGINE. I RAN ABOUT 50-100 METERS AWAY AND CALLED 911. QUICKLY, THE WHOLE HOOD WAS ON FIRE. THANKFULLY THE FIRE DEPARTMENT MUST HAVE BEEN CLOSE BY BECAUSE THEY WERE ABLE TO PUT OUT THE FIRE BEFORE IT GOT TOO FAR INSIDE THE CAR. THE WINDSHIELD MELTED AND SHATTERED. I FOUND GLASS STUCK ON MY PURSE AND HAT SITTING IN THE PASSENGER SEAT. I HAD TO THROW THEM AWAY AS I COULD NOT GET THE GLASS OFF. THE CAR WAS TAKEN TO A TOW YARD WHERE MY INSURANCE COMPANY INSPECTED IT. THEY COULD NOT FIND THE CAUSE FOR THE DAMAGE. SINCE THE CAR WAS A 2015 MODEL THAT I HAD PURCHASED NEW AND IT WAS 2018, I THOUGHT IT WAS STRANGE THAT THIS WOULD HAPPEN SO I HAD FIAT PICK UP THE VEHICLE AND INSPECT IT. THEY SAID THEY DID NOT FIND THAT THE FIRE WAS ASSOCIATED WITH MANUFACTURING OR ASSEMBLY ERROR. I THEN HAD MY INSURANCE COMPANY TAKE IT AND CLOSE THE CLAIM. STILL FIND IT STRANGE THAT A 3 YEAR OLD CAR SUDDENLY CAUGHT ON FIRE WITH NO WARNING. I'M GLAD I WAS ABLE TO MOVE OFF TO THE SIDE AND THAT I WASN'T IN THE CAR WHEN IT CAUGHT ON FIRE FULLY. THE CAUSE OF THE FIRE THOUGH IS STILL UNKNOWN. *TR

2015 FIAT 500 POP. CONSUMER WRITES IN REGARDS TO PROBLEMS COMPUTER SYSTEM AND ACCELERATION. *LD THE CONSUMER STATED THE CD PLAYER WAS INOPERABLE, THE REAR WIPERS STICK, THE GAUGES FLUCTUATE, AND THE FLOOR MATS WERE MISSING FROM THE VEHICLE. *JS

TL* THE CONTACT OWNS A 2015 FIAT 500. THE CONTACT STATED THAT THE VEHICLE FAILED TO START INTERMITTENTLY WITHOUT WARNING. EVER SINCE THE VEHICLE WAS TAKEN TO ORANGE COAST ALFA ROMEO AND FIAT (LOCATED AT 2524 HARBOR BLVD, COSTA MESA, CA 92626, (714) 546-4511) TO BE REPAIRED PER NHTSA CAMPAIGN NUMBER: 16V302000 (POWER TRAIN), THE VEHICLE FAILED TO START NUMEROUS TIMES. THE VEHICLE WAS TAKEN BACK TO THE DEALER TO BE DIAGNOSED, BUT A FAILURE CODE COULD NOT BE LOCATED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 58,700.

TL* THE CONTACT OWNS A 2015 FIAT 500. WHILE DRIVING APPROXIMATELY 25 MPH, THE ABILITY TO SWITCH GEARS BECAME VERY DIFFICULT. THE CONTACT STATED THAT THE FAILURE OCCURRED FOR APPROXIMATELY ONE YEAR AND NINE MONTHS, AND HAD WORSENED. ADDITIONALLY, THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 16V302000 (POWER TRAIN) AND STATED THAT THE MANUFACTURER FAILED TO REPAIR THE VEHICLE WITHIN A REASONABLE AMOUNT OF TIME. THE DEALER (BOB BAKER CHRYSLER JEEP DODGE RAM, 5555 CAR COUNTRY DRIVE, CARLSBAD, CALIFORNIA 92008) CONFIRMED THAT PARTS WERE NOT AVAILABLE TO PERFORM THE RECALL REPAIR. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE CONTACT WAS AFRAID TO DRIVE THE VEHICLE BECAUSE THE GEARS DID NOT ENGAGE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 60,000. PARTS DISTRIBUTION DISCONNECT.

WAS IN MOTION ON A SURFACE STREET AFTER JUST LEAVING A 4-WAY STOP INTERSECTION. THE CAR AUTOMATICALLY LEFT DRIVE AND WENT TO PARK. THE MESSAGE ON THE THE DASH SAID "BRAKING SYSTEM NEEDS MAINTENANCE." EVERY TIME THE CAR WAS PUT INTO NEUTRAL IT SHIFTED ITSELF TO PARK. ELECTRIC CAR, I THINK IT IS THE ENGINE (POWER INVERTER).

TL* THE CONTACT OWNS A 2015 FIAT 500. WHILE DRIVING 60 MPH, THE CONTACT DETECTED AN ABNORMAL BURNING ODOR AND SMOKE COMING FROM UNDER THE HOOD. THE VEHICLE STALLED WITHOUT WARNING AND WAS TOWED TO CLASSIC CHRYSLER DODGE JEEP (111 I-20 EAST FRONTAGE RD, ARLINGTON, TX 76018, 682-226-6400). THE DEALER DIAGNOSED THAT THE CLUTCH BEARING NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED AND OPENED CASE NUMBER: 32948895. THE CONTACT WAS INFORMED THAT THE VEHICLE WAS NOT UNDER A WARRANTY OR RECALL. THE FAILURE MILEAGE WAS 84,191.

THE CAR DASH GOES CRAZY TURNING ALL LIGHTS. OVER HEATING AND ESC RIGHT AFTERS IT TURNS OFF WHILE THE CAR IS ON THE GO LESS THEN 50 MILERS PER HOUR. I HAVE ALMOST CRASH TWICE DUE TO THE CAR STOPS COMPLETELY ON THE FREEWAY. DEALERSHIP HAS CHECK THE CAR 4 TIMES AND THEY CAN NOT GET IT TO BE FIX YET IN THE LAST PAST 2 MONTH. 11/30/17 FIAT SAYS IS CHECKING WHAT THEY CAN DO STILL I HAVE NOT RECEIVE AN ANSWER AND CHRYSLER HAS MY CAR FOR ALMOST 3 WEEKS AND STILL NOT DIAGNOSE AGAIN.

MANY DIFFERENT THINGS HAVE GONE WRONG WITH THIS CAR STARTING AT THE FIRST 900 MILES. THE CLUSTER THAT SHOWS YOU SPEED AND RPM WENT OUT AT 900 MILES WHILE DRIVING HOME FROM WORK MAKING IT HARD TO DRIVE. IT TOOK THE DEALERSHIP TWO WEEKS TO FIX THIS PROBLEM. A COUPLE MONTHS AFTER THIS THE CHECK ENGINE LIGHT CAME ON FOR NO REASON, THE DEALERSHIP TOLD ME THAT THERE WAS NOTHING WRONG AND GAVE IT BACK TO ME. TWO WEEKS LATER THE CHECK ENGINE LIGHT CAME ON AGAIN AND THEN THEY SAID THAT THERE WAS A PROBLEM WITH SOMETHING RELATED TO THE CLUSTER. THEY HAD MY CAR FOR A WEEK THIS TIME WHILE THEY REPAIRED THIS PROBLEM. SIX MONTHS LATER A GENERIC LIGHT CAME ON THAT SOMETHING WAS WRONG WITH THE CAR, I BROUGHT IT IN AND AGAIN THEY SAID THERE WAS NOTHING WRONG WITH MY CAR. A YEAR AFTER I PURCHASED IT THE DAYTIME RUNNING LIGHTS WENT OUT AND I STARTED GETTING A WARNING TO CHECK THEM, THEY SAID THIS WASN'T COVERED AND WOULD NOT REPLACE THEM. AT ABOUT 65,000 MILES MY HEAD LIGHTS BURNED OUT WHILE I WAS DRIVING AND I HAD TO DRIVE 70 MILES AT NIGHT WITH NO HEADLIGHTS ON THE FREEWAY. I REPLACED THESE MYSELF FOR $60. THEN THREE MONTHS LATER MY HEADLIGHTS STOPPED WORKING AGAIN. THE LIGHTS WEREN'T BURNT OUT BUT THEY WERE LOOSE AND I HAD TO JIGGLE THEM TO GET THEM BACK. AT THE SAME TIME THEY HAD A RECALL ON THE CLUTCH AND IT TOOK THEM A YEAR TO GET THE PARTS AND REPAIR THE RECALL AT 66,751 MILES. NOW AT 74,500 MILES THE CLUTCH HAS COMPLETELY GONE OUT WHILE I WAS DRIVING. LUCKILY I HAD JUST GOT TO MY DESTINATION AND LEFT IT PARKED IN A PARKING LOT. THE DEALERSHIP WANTS TO CHARGE ME $3,300 TO FIX THE CLUTCH. THE CAR IS ONLY WORTH $6600 AND I OWE $13000. ALSO I HAVE TRIED TO TRADE IT IN AND NO ONE WILL TAKE IT DUE TO ALL THE PROBLEMS THESE CARS HAVE. FIAT SHOULD BE BANNED FROM SELLING THESE CARS UNTIL THEY STOP TURNING OUT CRAPPY CARS.