2013 Ford Escape Suspension Problems

Purchased this ford escape for our granddaughter with in the last 2 years as a used vehicle and during a recent visit to a local ford dealer for another issue, they noticed the rear subframe crossmember had rust holes across it. Not sure if it is unsafe to drive due to the main structure looks solid. The front and back of the subframe has the rust holes. No other warning signs except a visual inspection. My question is: has there been an issue with this subframe or any other complaints. or is it normal for this part of the vehicle to wear or without warning. PS: I have a photo

The contact owns a 2013 Ford Escape. The contact stated that while driving at 55 MPH, the rear driver’s side control arm detached from the vehicle. The contact lost control of the vehicle momentarily. However, the contact was able to control the vehicle and pulled over to the side of the road. The vehicle was towed to an independent mechanic where it was diagnosed that the subframe had corroded and needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure, and a case was opened. The manufacturer advised the contact to file a complaint with the NHTSA Hotline. The failure mileage was approximately 83,000.

While driving on a city street at low speeds and good road conditions the rear torsion(stabilizer) bar cracked and broke off its mount and flipped the rear wheel sideways. This was extremely providential in that had this occurred at high speeds the results would have been disastrous for all around and in the vehicle. The incident occurred fortunately right at a location where there was a service to fix it. I want this incident to register with you because it may save someone's life. Please take this seriously. THIS WAS MY VEHICLE AND NOW IT IS MY DAUGHTER'S VEHICLE.

A wheel bearing is unsafe to drive on. Yes my safety and those in the car with me has been at risk. The problem was confirmed by a Ford Dealership and has been inspected by a suspension tech. There was no light in the dashboard or anything to notify me of this issue.

I would like to alert you to a "near miss" situation regarding my 2013 Ford Escape Titanium automobile which very nearly resulted in a car rollover while driving at 65 mph on the freeway. My wife was driving our 2013 Escape on the freeway. Suddenly, the left rear lower control arm cross support arm assembly Ford Part No. CV6Z*5500*L broke into two pieces. When this happened, the car immediately darted to the right because the left rear tire was no longer pointing straight ahead. Her reaction was to compensate by steering to the left. At that point in time, the car came up on two wheels and very nearly rolled over. After that, the car swerved back and forth until she could stop. It was extremely fortunate that she was in the center lane of a three lane wide freeway when this happened and there were no cars to her immediate right or left. After getting the car stopped she saw that the left rear wheel was clearly pointing in the wrong direction. We had the car towed home and since I generally handle all of my own automotive repairs in my home garage, I jacked the car up and noticed the broken cross support arm assembly. I removed the broken part and examined the failure surfaces. I happen to be a mechanical engineer with 40 years of mechanical design experience and I immediately recognized the classic symptoms of a metal fatigue failure. I have attached a series of photographs documenting the failure. The fracture surface consists of rust along the cracked surface about 2/3 the width of the part and then shinny material where the ultimate failure occurred when the crack propagated across the part on a single load cycle. The vehicle is admittedly 11 years old and it has 177k miles, but it is still in very good condition with very minimal rust. You can see from the photos that the failed part was not the result of rust and other than the fracture surface, the part is generally not rusted. I still have the failed part in my possession.

Due to leaking coolant and overheating. I had to get engine and transmission work done that totaled over $10,000 worth mechanical work. I also had to get suspension work which is also include it the total of being over $10,000.

OVER HEATING ,LEAKING ANTIFREEZE .

VEHICLE REPEATEDLY MAKES NOISES WHEN MAKING LOW SPEED TURNS, DRIVING OVER BUMPS, OR PRESSING ON THE BRAKES. THE SOUND COMES FROM THE FRONT SUSPENSION.

WHEN DRIVING THIS VEHICLE, IT SER ME LIKE IT IS NOT RUNNING RIGHT, AND THINK IT IS GOING TO DIE ON US IN TRAFFIC. THE FRONT SEAT BELT DOES NOT GO BACK IN THE AREA WHERE IT BELONGS AND SITS ON THE FRONT SEAT. THE PASSENGER DRIVER SIDE DOOR DOES NOT CLOSE RIGHT WHEN YOU OPEN IT. IT WILL STAY OPEN UNTIL YOU PUSH THE HANDLE DOWN AND THEN IT WILL CLOSE AND LOCK. WE ARE AFRAID TO TRAVEL LONG DISTANCE WITH THE VEHICLE BECAUSE OF THE WAY THE CAR ACTS AND RUN. WE JUST WANT IT FIX OR REPLACE VEHICLE.

TL* THE CONTACT OWNS A 2013 FORD ESCAPE. WHILE DRIVING AT UNKNOWN SPEEDS, THE ACCELERATOR PEDAL WAS APPLIED, BUT THE VEHICLE FAILED TO RESPOND AND THEN SPONTANEOUSLY ACCELERATED. THERE WERE NO WARNING INDICATORS ILLUMINATED. THE "HILL CLIMB ASSISTANCE NOT AVAILABLE" AND "FOUR WHEEL DRIVE NOT AVAILABLE" MESSAGES WERE DISPLAYED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO STATED THAT THE TONE RING NEEDED TO BE REPLACED. THE LOCAL DEALER WAS NOT CONTACTED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT CONTACTED. THE FAILURE MILEAGE WAS 57,000.

WHEN I FIRST PURCHASED THE ESCAPE THE TRUNK HANDLE FELL OFF INTO MY HAND, IT WAS REPLACED. THE PASSENGER DOOR OPENER HANDLE APPARENTLY IS WRAPPEND IN SILVER PLASTIC, THAT CUT A PASSENGER, I HAVE SPENT YEARS ASKING THEM TO REPLACE IT, THEY FINALLY DID LAST MONTH, OF COURSE NOW OUT OF WARRANTY SO I HAD TO PAY FOR IT. I HAVE HAD A RECURRING ISSUE WITH MY REAR PASSENGER DOOR INTERIOR PANEL SEPARATING FROM THE METAL EXTERIOR PANEL, RENDERING THE DOOR USELESS. MY 7 YEAR OLD DAUGHTER CANNOT GET INTO OR OUT OF THE VEHICLE ON HER SIDE. THE CLIPS HAVE BEEN REPLACED 3 TIMES AT THE DEALERSHIP AND THEY ARE SUGGESTING REPLACING THE INTERIOR BECAUSE IT IS "WARPED" HOW DOES A GARAGED VEHICLE'S INTERIOR BECOME "WARPED" TO AN EXTENT WHERE THE CLIPS CANNOT HOLD THE PART IN PLACE AND REPEATEDLY SNAP? THE CLIPS ARE PLASTIC AND SIMILAR TO THE INTERIOR OF THIS MODEL PLASTIC IS WEARABLE, AND FORD SHOULD BE REPLACING THIS ITEM, NOT ME. I HAD A 2001 EXPLORER FOR 14 YEARS THAT I NEVER HAD ISSUES WITH, PRIMARILY BECAUSE IT WASN'T CONSTRUCTED WITH PLASTIC.THIS IS A SERIOUS SAFTEY ISSUE AND MY CHILD SHOULD NOT BE TRAPPED IN A VEHICLE. I HAVE ALSO HAD A RECURRING ISSUE WITH THE FRONT SUSPENSION, THE SHOCKS WERE REPLACED AND THE MATTER HAS GOTTEN WORSE. THIS ISSUE TOOK PLACE AFTER THE TIRE WAS REPLACED BECUASE OF A NAIL PUNCTURE. I AM RESPONDING TO THE DEALERSHIP TODAY 10/16/2018 TO SEE WHAT THEY ARE GOING TO DO ABOUT THIS PROBLEM, THAT I DID NOT CREATE AND HAVE ATEMPTED TO HAVE REPAIRED SINCE JULY 2018. WHEN THE CAR IS IN MOTION THE PASSENGER SIDE SIMPLY SEEMS AS IF IT GOING TO FALL OFF, A LOUD CLANKING SOUND AND THE STABILITY IS THEN OFF AFTER THE VEHICLE GOES OVER ANYTHING, MAN HOLE OVERS SMALL FISSURES IN THE GROUND OR LARGE BUMPS. THIS CAN'T BE SAFE AND IT NEEDS TO BE FIXED.

TL* THE CONTACT OWNS A 2013 FORD ESCAPE. WHILE IDLING AT A DRIVE THRU WINDOW AT A RESTAURANT, THE VEHICLE JERKED FORWARD AND ALMOST CRASHED INTO THE PRECEDING VEHICLE. THE CONTACT ATTEMPTED TO DRIVE OFF, BUT THE VEHICLE STALLED AND THE CHECK ENGINE INDICATOR ILLUMINATED. THE VEHICLE WAS TOWED TO NORTH HILLS AUTOMOTIVE (1428 AUGUSTA ST, GREENVILLE, SC 29605, (864) 233-9002) WHERE IT WAS DIAGNOSED THAT NEW BUSHINGS NEEDED TO BE INSTALLED ALONG WITH A NEW TRANSMISSION. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND DID NOT ASSIST. THE FAILURE MILEAGE WAS 153,300.

SHOCK MOUNT BROKE AND SHAFT ON SHOCK PUNCHED THRU WHEEL WELL.

TL* THE CONTACT OWNS A 2013 FORD ESCAPE. WHILE ATTEMPTING TO AVOID CRASHING INTO ANOTHER VEHICLE AT APPROXIMATELY 30 MPH, THE CONTACT CRASHED INTO A CURB AND SEVERAL STREET SIGNS. A POLICE REPORT WAS FILED. NO INJURIES WERE SUSTAINED. THE VEHICLE WAS DRIVEN TO THE CONTACT'S RESIDENCE AND THEN TO THE DEALER WHERE IT WAS DIAGNOSED THAT THE FRONT END SUSPENSION FAILED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 19,300.

VEHICLE POWERS DOWN, LEAKS COOLANT , HAS ROUGH RIDE, VIBRATES AND HAS COMPLETELY SHUT DOWN ATLEAST TWICE REQUIRING A TOW. ENGINE HAS HOT SMELL TO IT, AS IF IT IS COMING FROM HOT COOLANT . FORD SAYS "CAN'T FIND A LEAK." THEY REPLACED A PART ON IT, HOWEVER I CAN NOT RECALL WHAT IT WAS BECAUSE THEY WERE ONLY GUESSING THEMSELVES AS FAR AS LOW COOLANT. HOWEVER IT DID NOT FIX IT ANYWAY. I HAVE CALLED FORD MANY TIMES, BUT THEY SHOW NO RECALLS TO ANY OF THE PROBLEMS I HAVE MENTIONED. I AM A SINGLE MOM & NURSE, I NEED A RELIABLE VEHICLE. IT IS SO DEPRESSING TO MAKE PAYMENTS ON VEHICLE. BY THE WAY I HAVE NO WARRANTY. THE ISSUES OCCUR AT ANY TIME ON ANY ROADS.

2013 SEL AND HAVE FRONT END NOISE. WHEN TURNING TO THE LEFT AND SOMETIMES TO THE RIGHT, THE FRONT END WILL MAKE A LOUD POPPING NOISE. IT FEELS LIKE THE FRONT WHEEL IS FALLING OFF. BEEN TO FORD OVER 6 TIMES AND PROBLEM IS BACK FOUR MONTH LATER.

TL* THE CONTACT OWNS A 2013 FORD ESCAPE. WHILE DRIVING AT 40 MPH, THE VEHICLE BEGAN TO VIBRATE. THE VEHICLE WAS TAKEN TO A DEALER WHO DIAGNOSED THAT THE SHAFT AND JOINT ASSEMBLY, BUSHING, SEALS, RIGHT FRONT AXLE, AND SHAFT JOINT FORWARD NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. FIVE MONTHS LATER WHILE DRIVING AT 65 MPH, THE CONTACT NOTICED STRONG FUEL FUMES EMITTING IN AND AROUND THE VEHICLE. THE VEHICLE WAS TAKEN BACK TO THE DEALER, WHO DIAGNOSED THAT THE FUEL LINES NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE CONTACT WAS AWARE OF NHTSA CAMPAIGN NUMBER: 13V584000 (FUEL SYSTEM, GASOLINE) HOWEVER, THE VIN WAS NOT INCLUDED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 54,000.

TL* THE CONTACT OWNS A 2013 FORD ESCAPE. WHILE DRIVING 45 MPH, THE REAR OF THE VEHICLE SHOOK WHEN THE BRAKES WERE APPLIED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE REAR CONTROL ARM NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE FAILURE MILEAGE WAS 44,196.

TL* THE CONTACT OWNS A 2013 FORD ESCAPE. WHILE DRIVING 15 MPH, THE FRONT PASSENGER SIDE TIRE SUDDENLY FRACTURED FROM THE VEHICLE. A POLICE REPORT WAS FILED. THE VEHICLE WAS TOWED TO THE CONTACT'S RESIDENCE. THE CONTACT DISCOVERED THAT THE SUSPENSION SHOCKS WERE FRACTURED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 7,500. THE VIN WAS NOT AVAILABLE. MA 10/8 *BF *CN *JB 3/28/18 *TR

I HAD A TIRE REPAIR FOR A NAIL IN AUG AT THE DEALERSHIP. SEPT 20TH RAN OVER A ROCK~ 8-10 IN ON THE DIRT ROAD AND SUSTAINED A FLAT TIRE. I HAD THE CAR TOED. SPARE APPLIED, BOUGHT 2 NEW FRONT TIRES AND WAS TOLD THAT THE LEFT REAR SHOCK WAS TOTALLY TORN OFF NEAR THE TOP, THIS WORK WAS DONE AT BELLE TIRE WHO ADVISED ME TO TAKE TO THE DEALERSHIP AS IT APPEARED TO HAVE FROZEN UP TO HAVE CAUSED THAT MUCH DAMAGE AND SHOULD BE UNDER MY WARRANTY. ALSO, I HAD NOT BEEN IN ANY ACCIDENTS. FORD TOLD ME THAT THE TECHNICIAN DID NOT FEEL THAT IT WAS DEFECTIVE. READING THAT THERE HAVE BEEN PROBLEMS WITH REAR SUSPENSION MOUNTS I QUESTION WHETHER THE MOUNT PROBLEM COULD HAVE CONTRIBUTED TO THE SHOCK BRAKING. *TR